2000 Ford F-550 SD: complaints, problems and recalls

THE TIRE EXPERIENCED THE SAME DEFECT AS STATED IN RECALL NO. 01 V 046 000, HOWEVER THE VEHICLE IDENTIFICATION NUMBER WAS NOT INCLUDED IN THE RECALL. *JB THE VALVE COVER HAD COME OUT OF THE RIM, IT WAS LOOSE, AND LEAKED AIR. THE TIRES LOST ALL AIR AND HAD RUN FLAT, CAUSING THEM TO BE TOO DANGEROUS TO RE-INFLATE. (BROKEN DOWN SIDEWALLS) THE DEALER THOUGHT NOTHING WAS WRONG WITH THE VALVES. SCC

Owner-reported narrative. 17,000 miles reported. Look up ODI 10007344 at NHTSA ↗

2000 F 550 THE OIL PAN HAS ROTTED FROM THE VEHICLE. DEALER STATES THIS IS A BIG PROBLEM ON THIS MODEL. REPLACEMENT OF THE PART REQUIRES THIS REMOVAL OF THE ENGINE. THIS IS NOT A WARRANTY COVERED ITEM.*JB

Owner-reported narrative. 70,000 miles reported. Look up ODI 10008352 at NHTSA ↗

I THINK METAL VALVE STEMS ARE NEEDED IN THESE H.D. TRUCKS. HAS ANY FAILED? ****DIMSII IVOQ ENTRY POSTED AFTER 12/12/02 CUT-OVER TO ARTEMIS*****769357. *AK *JB

Owner-reported narrative. Look up ODI 10008527 at NHTSA ↗

THE WHEEL LUG NUTS HAD UNFASTENED WHILE DRIVING, WHICH CAUSED THE WHEEL TO SEPARATE.*JB

Owner-reported narrative. 8,600 miles reported. Look up ODI 10009672 at NHTSA ↗

THE VEHICLE WAS PURCHASED WITH ALL TERRAIN TIRES. THE VEHICLE HAS BEEN INVOLVED IN TWO TIRE RELATED ACCIDENTS WITHIN A 2 YEAR PERIOD. THE CONSUMER BELIEVES THE TIRES INSTALLED ARE NOT ALL TERRAIN TIRES. PH *NLM

Owner-reported narrative. Look up ODI 10011483 at NHTSA ↗

THE VALVE STEMS FAILED ON 3 TIRES, WHICH CAUSED THE TIRES TO FAIL, HOWEVER THE WARRANTY TIRE CENTER INDICATED A NAIL WAS EMBEDDED IN THE TIRE. *PH *JB *CB

Owner-reported narrative. Look up ODI 10011778 at NHTSA ↗

GENERAL TIRES WERE NOT ALL TERRAIN WHICH WAS SUPPOSED TO BE THE TIRE EQUIPMENT FOR THE VEHICLE. MR THE TIRES INABILITY TO HOLD THE ROAD CAUSED THE CONSUMER TO LOSE CONTROL AND HIT A POLE. MODEL/LT SCC *JB

Owner-reported narrative. Look up ODI 10014834 at NHTSA ↗

WHILE DRIVING THE BRAKE LINE DEVELOPED A HOLE WHICH CAUSED THE VEHICLE TO EXPERIENCE EXTENDED STOPPING DISTANCE. *NLM THE DRIVER APPLIED THE BRAKE AS HE WAS GOING OFF RAMP AND THE PEDAL HAD GONE TO THE FLOOR. THE CONSUMER NOTICED A HOLE HAD BLOWN THROUGH THE METAL FLEX LINE. *SCC *JB

Owner-reported narrative. 89,991 miles reported. Look up ODI 10020144 at NHTSA ↗

Reported: 2001-02-14 (February 14, 2001)

VEHICLE DESCRIPTION: TRUCKS EQUIPPED WITH COMMERCIAL TRUCK TIRES THAT HAVE STEEL CORDS IN THE TIRE SIDEWALL. THE VALVE STEMS MAY HAVE BEEN TORN OR DAMAGED DURING ASSEMBLY AND COULD LEAK CAUSING SIDEWALL DAMAGE.

Consequence: IF NOT MAINTAINED, COULD RESULT IN A SIDEWALL ZIPPER FAILURE. A ZIPPER FAILURE DURING INFLATION OF A DAMAGED TIRE COULD RESULT IN INJURY TO SOMEONE NEAR THE TIRE.

Remedy: DEALERS WILL INSPECT THE VALVE STEMS FOR LEAKAGE, AND WILL REPLACE BOTH THE VALVE STEM AND THE TIRE IF LEAKAGE IS PRESENT. OWNER NOTIFICATION BEGAN MARCH 28, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-800-392-3673.

Reported: 2001-08-08 (August 8, 2001)

VEHICLE DESCRIPTION: PASSENGER CARS, SPORT UTILITY VEHICLES, AND LIGHT AND MEDIUM DUTY PICKUP TRUCKS. A SWITCH LOCATED IN THE PLASTIC COVER OF THE WIPER MOTOR GEAR CASE COULD MALFUNCTION AND OVERHEAT, POTENTIALLY RESULTING IN LOSS OF INTERMITTENT WIPER FUNCTION, LOSS OF WIPER PARK FUNCTION, COMPLETE LOSS OF WIPER FUNCTION, OR IGNITION OF THE PLASTIC COVER MATERIAL. SWITCH MALFUNCTION IS MOST LIKELY TO OCCUR WHEN THE INTERMITTENT SETTING OF THE WIPERS IS BEING USED, OR WHEN SNOW OR ICE OBSTRUCTS THE BLADES FROM RETURNING TO THE "PARKED" POSITION AT THE BOTTOM OF THE WINDSHIELD. THESE VEHICLES WERE BUILT AT THE FOLLOWING ASSEMBLY PLANTS: ATLANTA PLANT FROM 2/11/00 THROUGH 7/31/00; CHICAGO PLANT FROM 2/14/00 THROUGH 8/4/00; KANSAS CITY PLANT FROM 2/26/00 TO 9/4/00; KENTUCKY TRUCK PLANT FROM 2/18/00 TO 8/31/00; MICHIGAN TRUCK PLANT FROM 2/23/00 THROUGH 8/3/00; NORFOLK PLANT FROM 2/21/00 THROUGH 7/27/00; WAYNE STAMPING AND ASSEMBLY PLANT FROM 2/25/00 THROUGH 8/15/00; AND WIXOM PLANT FROM 2/15/00 THROUGH 8/8/00.

Consequence: LOSS OF VISIBILITY WHILE DRIVING INCREASES THE RISK OF A CRASH.

Remedy: DEALERS WILL INSPECT THE DATE CODE ON THE WIPER MOTOR. MOTORS BUILT WITH THE SUSPECT TIME FRAME WILL HAVE THE WIPER MOTOR GEAR CASE COVER REPLACED. OWNER NOTIFICATION BEGAN AUGUST 20, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-866-436-7332.

Reported: 2006-08-01 (August 1, 2006)

ON CERTAIN TRUCKS EQUIPPED WITH SPEED CONTROL, GASOLINE OR NATURAL GAS ENGINES, THE SPEED CONTROL DEACTIVATION SWITCH MAY OVERHEAT.

Consequence: OVERHEATING COULD RESULT IN SMOKE OR BURN AND AN UNDERHOOD FIRE.

Remedy: DEALERS WILL INSTALL A FUSED WIRING HARNESS INTO THE SPEED CONTROL SYSTEM FREE OF CHARGE. THE RECALL BEGAN ON AUGUST 7, 2006. OWNERS MAY CONTACT FORD AT 1-866-436-7332. (NOTE: ALSO SEE RECALLS 05V017 AND 05V388)

Reported: 2007-12-05 (December 5, 2007)

ON CERTAIN HEAVY DUTY TRUCKS EQUIPPED WITH 7.3L DIESEL ENGINES, THE CAMSHAFT POSITION SENSOR LOCATED ON THE ENGINE OF THE VEHICLE MAY FUNCTION INTERMITTENTLY, POSSIBLY RESULTING IN AN ENGINE STALL.

Consequence: IN THE EVENT OF AN ENGINE STALL, A CRASH COULD RESULT WITHOUT WARNING.

Remedy: DEALERS WILL INSPECT THE SENSOR AND REPLACE IT WITH AN IMPROVED CAMSHAFT POSITION SENSOR FREE OF CHARGE. THE RECALL BEGAN ON DECEMBER 29, 2007. OWNERS MAY CONTACT FORD AT 1-866-436-7332.

Reported: 2009-10-13 (October 13, 2009)

FORD IS RECALLING MODEL YEARS 1995-2003 WINDSTAR, 2000-2003 EXCURSION DIESEL, 1993-1997 AND 1999-2003 F-250 SD THROUGH F-550 SD DIESEL, 1992-2003 E-150 THROUGH E-550, 1995-2002 EXPLORER, 1997 AND 2002 MERCURY MOUNTAINEER, 1995-1997 AND 2001-2003 RANGER, AND 1994 F53 VEHICLES EQUIPPED WITH THE TEXAS INSTRUMENTS SPEED CONTROL DEACTIVATION SWITCH (SCDS). THE SCDS MAY LEAK INTERNALLY AND THEN OVERHEAT, SMOKE, OR BURN.

Consequence: A VEHICLE FIRE COULD OCCUR WITH OR WITHOUT THE ENGINE RUNNING.

Remedy: FORD WILL NOTIFY OWNERS THAT DEALERS WILL INSTALL A FUSED WIRING HARNESS IN LINE WITH THE SCDS. ON 1999-2003 WINDSTAR VEHICLES WITH A LEAKING SCDS, DEALERS WILL ALSO INSPECT THE ABS CONTROL MODULE CONNECTOR AND REPAIR AS NECESSARY. REPAIRS WILL BE COMPLETED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON OCTOBER 27, 2009. OWNERS MAY CONTACT FORD AT 1-888-222-2751.