2009 Ford F-350: complaints, problems and recalls

WHEN MY TRUCK IS DRIVEN OVER A POTHOLE, ONTO A BRIDGE, OR ANY CHANGE IN ELEVATION IN THE DRIVING SURFACE, THE VEHICLE WILL SHAKE VIOLENTLY. THE SHAKING IS SO VIOLENT THE VEHICLE MUST BE STOPPED TO AVOID LOSING CONTROL. IT FEELS AS IF THE FRONT END WILL LITERALLY COME APART. THIS BEGAN NEAR THE END OF NOVEMBER AND HAS CONTINUED TO GET WORSE AND HAPPEN MORE FREQUENTLY. I HAVE CONTACTED FORD MOTOR COMPANY AND WAS TOLD THERE IS NO RECALL AND TO KEEP RECORDS OF MY REPAIRS IF THERE EVER IS ONE. THE PROBLEM IS THE TRACK BAR AND THE COST TO FIX TH…

Owner-reported narrative. 49,000 miles reported. Look up ODI 10442582 at NHTSA ↗

TL* THE CONTACT OWNS A 2009 FORD F-350. THE CONTACT STATED THAT THE BRAKES FAILED. IN ADDITION, THE CONTACT ATTEMPTED TO CHANGE THE TIRE BUT THE TIRE WOULD NOT TURN ONCE INSTALLED. THE CONTACT CALLED THE DEALER AND WAS ADVISED THAT THE BRAKE SYSTEM NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED AND STATED THAT THE BRAKES WERE MOST LIKELY RUSTED AS A RESULT OF NOT BEING USED FOR SOME TIME. THE FAILURE MILEAGE WAS 11,000. ..UPDATED 09-26-12 *BF THE CONSUMER STATED THE BRAKES ONLY SLOW THE VEHICLE DOWN. T…

Owner-reported narrative. 11,000 miles reported. Look up ODI 10472064 at NHTSA ↗

TL* THE CONTACT OWNS A 2009 FORD F-350 EQUIPPED WITH CAPITOL TIRES CL24757-245/70/R17. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 60 MPH, THE FRONT PASSENGER TIRE EXPLODED. THE VEHICLE WAS TAKEN TO THE DEALER WHERE THE TECHNICIAN ADVISED THAT NOTHING WAS FOUND THAT IMPACTED THE ORIGINAL TIRE. THE TECHNICIAN THEN REPLACED ALL OF THE TIRES WITH ANTHER BRAND. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND ADVISED THE CONTACT THAT THE TIRES WERE NOT INCLUDED IN ANY RECALLS AND HAD BEEN DISCONTINUED. THE APPROXIMATE FAILURE AND CURRENT …

Owner-reported narrative. 92,000 miles reported. Look up ODI 10483881 at NHTSA ↗

CAME UP TO STOPLIGHT, APPLIED BRAKE, ENGINE WOULD NOT SLOW DOWN. PUT TRUCK IN PARK, ENGINE CONTINUED AT 4KRPM. PRESSED ACCELERATOR AND ENGINE RETURNED TO NORMAL. 4TH TIME THIS HAPPENED SINCE I BOUGHT VEHICLE NEW. FORD DEALER SAYS CODE DOESN'T SHOW UP AND CAN'T DO ANYTHING. I HAVE DRIVEN 75,000 MILES AND THIS IS THIRD FORD VAN AND NEVER HAD PROBLEM LIKE THIS BEFORE. *TR

Owner-reported narrative. 45,000 miles reported. Look up ODI 10492358 at NHTSA ↗

TL* THE CONTACT OWNS A 2009 FORD F-350. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 30 MPH, HE NOTICED A LOUD NOISE COMING FROM THE FRONT. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE THE FRONT DRIVER AND PASSENGER'S SIDE U-JOINTS WERE REPLACED HOWEVER, THE FAILURE RECURRED AND CAUSED DAMAGE TO THE FRONT AXLE. THE VEHICLE WAS TAKEN BACK TO THE MECHANIC WHERE THE AXLE AND U-JOINTS WERE REPLACED A SECOND TIME. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE VEHICLE WAS REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 116,640.

Owner-reported narrative. 116,640 miles reported. Look up ODI 10560211 at NHTSA ↗

CAR PULLED OUT OF SIDE ROAD CROSSING MY PATH. I STRUCK HIS CAR BROADSIDE IN DRIVER DOOR. MY AIR BAG RESTRAINTS DID NOT DEPLOY. I WAS TRAVELING APPROXIMATELY 45-50 AT POINT OF IMPACT. FORTUNATELY I WAS NOT INJURED, BUT MY AIR BAGS SHOULD HAVE DEPLOYED! *TR

Owner-reported narrative. 53,000 miles reported. Look up ODI 10567704 at NHTSA ↗

TL* THE CONTACT OWNS A 2009 FORD F-350. THE CONTACT STATED THAT WHILE DRIVING 70 MPH, THE VEHICLE ABNORMALLY DECELERATED TO 20 MPH AND THE CHECK ENGINE LIGHT ILLUMINATED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. A MECHANIC RECOMMENDED THAT THE VCT PHASERS BE REPLACED. THE VEHICLE WAS REPAIRED ON THREE OCCASIONS HOWEVER, THE FAILURE RECURRED. THE FAILURE MILEAGE WAS 3,635 AND THE CURRENT MILEAGE WAS 37,000. UPDATED 6/27/14*CN

Owner-reported narrative. 3,635 miles reported. Look up ODI 10586771 at NHTSA ↗

FORD DIESEL ENGINE BEGAN TO SPUTTER/MISS/BACKFIRE/ETC-LATER SHOWN TO HAVE 'BLOWN-UP' ... BASIS OF PROBLEM APPEARS TO BE IN THE 'CRANK-AREA' OF THE ENGINE. HAS TO BE REPLACED @ 116,000 MILES WITH A $20,000 PRICETAG. (NOTE: ANY DIESEL SHOULD BE GOOD FOR 250,000--300,000 MILES). WE ARE 2ND OWNER(1ST OWNER WAS A FORD DEALER) BUYING ON 5/31/12 47,276 MILES ON SPEEDO. *TR

Owner-reported narrative. 116,000 miles reported. Look up ODI 10587472 at NHTSA ↗

Reported: 2014-02-11 (February 11, 2014)

Monroe Truck Equipment (Monroe) is recalling certain model year 2006, 2008 and 2009 Chevrolet C7500 vehicles, 2005-2006 Chevrolet Tahoe vehicles, and 2009 Ford F-350, and F-450 vehicles, equipped with Sure Power-brand battery equalizers or DC-DC converters containing a particular epoxy sealing, aka 'potting', compound. The specific potting compound used in the subject products for insulation was found to be capable of conducting electricity after being exposed to heat.

Consequence: Once electrically conductive, the material is capable of melting and burning, increasing the risk of a fire.

Remedy: Monroe will notify owners, and Sure Power will replace the equalizers or converters, free of charge. The recall began on March 24, 2014. Owners may contact Monroe at 1-608-328-8127.

Reported: 2014-08-13 (August 13, 2014)

PJ's Truck Bodies & Equipment Co., (PJ's) is recalling certain 2009-2013 Ford F-350, F-450, and F-550 Super Duty chassis modified by PJ's and equipped with certain Muncie Power Products PTO Assemblies. In the affected vehicles, oil may leak from the PTO pressure switch onto a thermal blanket covering the exhaust.

Consequence: The leaking oil may soak into the thermal blanket covering the exhaust, which when combined with heat from exhaust, may result in an increased risk of fire.

Remedy: PJ's has notified owners and dealers will install a new pressure switch kit that moves the switch away from the exhaust system, free of charge. The recall began on August 28, 2014. Owners may contact PJ's customer service at 1-866-475-8782.