1994 Ford F-350: complaints, problems and recalls

LEFT REAR TIRE SEPARATED FROM AXLE. NAR 07/02/2003 *MR WHEN THE WHEEL AND RIM CAME OFF THE VEHICLE COLLAPSED TO THE GROUND AND SLIDE TO FINAL REST ON THE RIGHT BERM. *NM

Owner-reported narrative. Look up ODI 10026620 at NHTSA ↗

THE FUEL INJECTOR PUMP FOR MY 1994 FORD F350 PICKUP TRUCK HAS FAILED FOR THE OFURTH TIME IN FOUR YEARS. THE ENGINE IS A NAVISTAR 7.3 LITER TURBO DIESEL. I HAVE RESEARCHED THE ISSUE ON THE INTERNET AND FOUND THAT THIS ENGINE HAS A PROBLEM WITH THE TOLERANCES FOR THE CAM, WHCH DAMAGES THE PUMP.*AK

Owner-reported narrative. 100,000 miles reported. Look up ODI 10031174 at NHTSA ↗

PER OWNER MANUAL, ENGINE SHOULD HOLD 12 QUARTS OF OIL. A CHANGE WAS MADE TO THE DIP STICK BY THE MANUFACTURER, WHICH INCREASES THE OIL INTAKE TO 14 QUARTS. CONSUMER WASN'T NOTIFIED OF THE CHANGE. THIS RESULTED IN ENGINE FAILURE, DO TO INSIGNIFICANT OIL CONSUMPTION. *PH

Owner-reported narrative. Look up ODI 10031686 at NHTSA ↗

THE SIDE VIEW MIRRORS DO NOT STAY IN ADJUSTMENT AND CAUSE POOR VISIBILITY WHILE DRIVING. *AK SIDE VIEW MIRRORS WERE IN POOR CONDITION SINCE PURCHASE. *LA *JB

Owner-reported narrative. 14,000 miles reported. Look up ODI 10042017 at NHTSA ↗

WHILE PULLING A TRAILER LOADED WITH FIRE WOOD, THE BRAKES FAILED AT AN INTERSECTION. THE BRAKE PEDAL WENT NEARLY TO THE FLOOR. THE BRAKES WOULD NOT SLOW ME DOWN. THE EMERGENCY BRAKE WAS NOT STONG ENOUGH TO STOP ME WHILE LOADED. HAD TO DOWN SHIFT TO STOP. THE BRAKE LINE GOING TO THE REAR AXLE HAD A HOLE IN IT. THE HOLE WAS LOCATED AT ONE ON CLAMPS TO THE FRAME. *AK

Owner-reported narrative. 125,000 miles reported. Look up ODI 10061915 at NHTSA ↗

THE HOMESTEADER 820CT 2000 TRAILER IS BEING TOWED BY THE TRUCK CHAISE LISTED BELOW. THE TRAILERS TIRES ARE CAVING INWARDS AFTER ONLY BEING USED TWICE. THIS OCCURRED BECAUSE THE DOUBLE AXLES BENT. A DMV REPRESENTATIVE WEIGHED THE TRAILER LOADED AND FOUND THAT THE TRAILER WAS UNDER LOADED ,AND THE AXLES WEREN'T STRONG ENOUGH TO SUPPORT THE WEIGHT OF THE TRAILER. THE TRAILER AND THE AXLE MANUFACTURERS WERE CONTACTED, BUT PROVIDED NO SOLUTION TO THE PROBLEM. INSTEAD, THEY WERE BLAMING EACH OTHER.*AK

Owner-reported narrative. Look up ODI 10075864 at NHTSA ↗

ELECTRICAL FIRE ON GLOWPLUG WIRIES ENDS. *AK

Owner-reported narrative. Look up ODI 10096011 at NHTSA ↗

CRACKS HAVE ACCUMULATED ON THE FUEL TANK, CAUSING FUEL TO LEAK. DEALERSHIP WAS NOTIFIED, BUT DID NOT RESOLVE THE PROBLEM. *AK . SIME VEHICLES CAN EXPERIENCE A CROSS TANK FUEL CONDITION DUE TO ADAMAGED VALVE IN THE FUEL PUMP/SENDER ASSEMBLY. FUEL MAY BESUPPLIED FROM ONE TANK AND SOME OR ALL OF THE UNUSED FUEL MAY BE RETURNED TO THE OTHER TANK. SHOULD THIS OCCUR, THE CAPACITY OF THE RECEIVING TANK MAY OVERFLOW THE FILLER CAP. *AK

Owner-reported narrative. 137,000 miles reported. Look up ODI 10102025 at NHTSA ↗

Reported: 2006-08-01 (August 1, 2006)

ON CERTAIN TRUCKS EQUIPPED WITH SPEED CONTROL, GASOLINE OR NATURAL GAS ENGINES, THE SPEED CONTROL DEACTIVATION SWITCH MAY OVERHEAT.

Consequence: OVERHEATING COULD RESULT IN SMOKE OR BURN AND AN UNDERHOOD FIRE.

Remedy: DEALERS WILL INSTALL A FUSED WIRING HARNESS INTO THE SPEED CONTROL SYSTEM FREE OF CHARGE. THE RECALL BEGAN ON AUGUST 7, 2006. OWNERS MAY CONTACT FORD AT 1-866-436-7332. (NOTE: ALSO SEE RECALLS 05V017 AND 05V388)

Reported: 1994-01-02 (January 2, 1994)

THE U-CLIP STYLE NUTS THAT RETAIN THE FRONT BUMPERS TO THE FRONT BUMPER INNER ARMS CAN FRACTURE.

Consequence: IF ONE OF THE U-CLIP NUTS FRACTURES, THE BUMPER WILL LOOSEN AND RATTLE CAUSING FRACTURE OF THE REMAINING U-CLIP NUTS, RESULTING IN SEPARATION OF THE BUMPER FROM THE VEHICLE. IF THE BUMPER WERE TO DETACH FROM THE VEHICLE WHILE IT IS BEING DRIVEN, A VEHICLE COLLISION COULD RESULT.

Remedy: INSPECTION AND REPLACEMENT OF THE FOUR U-CLIP NUTS AND THE ASSOCIATED BOLTS.

Reported: 1994-05-25 (May 25, 1994)

IN A HEAVILY LOADED VEHICLE, WHILE IN THE CRUISE CONTROL MODE, THE THROTTLE MAY NOT REDUCE IMMEDIATELY WHEN THE LOAD ON THE ENGINE IS DECREASED (SUCH AS WHEN THE VEHICLE CRESTS A HILL.) THIS CAN RESULT IN INCREASED VEHICLE SPEED WITHOUT PRIOR WARNING.

Consequence: THIS CAN RESULT IN LOSS OF SPEED CONTROL OF THE VEHICLE, AND A POSSIBLE ACCIDENT.

Remedy: DEALERS WILL REPLACE THE ELECTRONIC ENGINE CONTROL MODULE.

Reported: 1994-09-07 (September 7, 1994)

THE PARKING BRAKE CONTROL SELF-ADJUST PAWL DOES NOT LINE UP PROPERLY WITH THE SELF-ADJUST RACHET CAUSING THE PAWL TO SLIP OVER ONE OR MORE TEETH IN THE RACHET.

Consequence: WHEN THE ABOVE OCCURS, IT CAN RESULT IN PARKING BRAKE SYSTEM INEFFECTIVENESS. THE PARKING BRAKE WILL NOT HOLD THE VEHICLE, CAUSING THE VEHICLE TO ROLL FREELY, IF THE TRANSMISSION IS NOT LEFT IN GEAR.

Remedy: A WEDGE WILL BE INSTALLED WHICH WILL SERVE TO LOCK THE PARKING BRAKE SELF-ADJUST MECHANISM PAWL INTO ENGAGEMENT WITH THE RACHET. ALSO, OWNERS WILL BE ADVISED TO RELEASE AND REAPPLY THE PARKING BRAKE WHENEVER TOOTH SKIP OCCURS AND WILL BE REMINDED TO ALWAYS TURN OFF THE ENGINE AND LEAVE THE VEHICLE IN GEAR WHEN THE VEHICLE IS PARKED.

Reported: 1996-04-16 (April 16, 1996)

THE WIRE HARNESS FOR THE POWER LUMBAR FEATURE ON THE SEAT IS UNDERNEATH THE FRONT SEAT CUSHION SUPPORT WIRES. THE SUPPORT WIRES ON THE DRIVER SEAT CAN CONTACT AND DAMAGE THE INSULATION HARNESS RESULTING IN A HIGH RESISTANCE ELECTRICAL SHORT THROUGH THE SUPPORT WIRES.

Consequence: CONSEQUENCE OF DEFECT: OVER HEATING OF THE SUPPORT WIRES COULD RESULT, AND MELTING, SMOKE, OR POSSIBLE IGNTION OF THE SURROUNDING MATERIALS COULD OCCUR.

Remedy: DEALERS WILL INSPECT THE SEATS ON THE AFFECTED VEHICLES. IF NO DAMAGE IS FOUND, THE DRIVER SEAT WIRE HARNESS WILL BE COVERED WITH A PROTECTIVE CONVOLUTE TUBING, WRAPPED WITH ELECTRICAL TAPE AND THE HARNESS WILL BE REROUTED. IF DAMAGE IS FOUND, THE WIRE HARNESS WILL BE REPLACED.