2005 Ford E-SERIES: complaints, problems and recalls

THE VAN WOULD START LOSING POWER ON THE HIGHWAY, WHERE EVEN IF THE ACCELERATOR IS PUSHED DOWN, THE VAN CONTINUES TO LOSE SPEED. THE VAN EVENTUALLY REACHES A SPEED OF 0 MPH AND AT WHICH POINT THE ENGINE STALLS. AFTER WAITING 20 MINUTES ON THE SIDE OF THE HIGHWAY, TURNING THE ENGINE OFF FOR 20 MINUTES THEN STARTING IT SEEMS TO TEMPORARILY GET IT GOING, BUT ONLY FOR ANOTHER 30 MINUTES. SINCE THE FIRST TIME IT HAPPENED, IT WOULD REOCCUR ALMOST EVERY OTHER DAY. THIS IS VERY DANGEROUS DURING THE MORNING RUSH HOUR WHEN DRIVING ON THE NUMBER 2 LANE BEC…

Owner-reported narrative. 38,000 miles reported. Look up ODI 10243572 at NHTSA ↗

THE VEHICLE, A FORD E350 6.0L DIESEL WOULD LOSE POWER WHILE ON THE HIGHWAY AND COME TO A COMPLETE STOP IN THE MIDDLE OF THE ROAD. AFTER WAITING ABOUT 20 MINUTES, SOMETIMES WOULD START UP BUT MOST OF THE TIME WOULD HAVE TO BE TOWED. THIS WOULD OCCUR WHENEVER THE VEHICLE IS DRIVEN FOR MORE THAN 20-40 MILES WHEN THE ENGINE IS WARMED. THIS HAS OCCURRED A TOTAL OF OVER 15 TIMES, EACH FAILURE HAVING A SMALLER TIME IN BETWEEN THAN THE ONE PREVIOUS. VERY DANGEROUS. ALMOST HIT A CAR TRYING TO GET ON THE SHOULDER BEFORE A COMPLETE FAILURE. WHENEVER THE E…

Owner-reported narrative. 42,000 miles reported. Look up ODI 10246973 at NHTSA ↗

TL*THE CONTACT OWNS A 2005 FORD ECONOLINE VAN. WHILE DRIVING AT AN UNKNOWN SPEED, THE FUSES BEGAN TO SHORT OUT ELECTRICAL COMPONENTS IN THE VEHICLE. THE DEALER STATED THAT THERE WAS A PIECE OF METAL LOCATED IN THE FUSE RACK THAT TOUCHED THE WIRING HARNESS AND CAUSED THE ELECTRICAL WIRING TO SHORT. THE CONTACT WAS CONCERNED WITH THE SAFETY OF NOT HAVING THE WIRING HARNESS PROPERLY COVERED, WHICH COULD POTENTIALLY CAUSE MORE ELECTRICAL FAILURES OR A FIRE. THE MANUFACTURER INFORMED THE DEALER TO PLACE THE WIRING HARNESS BACK TO ITS ORIGINAL ST…

Owner-reported narrative. 50,000 miles reported. Look up ODI 10263128 at NHTSA ↗

OUR STREET NEEDS A SPEED BUMP ON 42ND AVE S BETWEEN FINDLEY AND ORCAS. THERE ARE MANY CHILDREN AND CARS GO TOO FAST. *TR

Owner-reported narrative. Look up ODI 10272446 at NHTSA ↗

TL*THE CONTACT OWNS A 2005 FORD EXCURSION. THE CONTACT STATED THAT INTERMITTENTLY THE VEHICLE WOULD STALL, AND THEN IMMEDIATELY RESTART. THE VEHICLE WAS TAKEN TO THE DEALER MULTIPLE TIMES TO DIAGNOSE THE FAILURE; HOWEVER, SINCE THE TECHNICIANS ARE UNABLE TO IDENTIFY THE CAUSE OF THE FAILURE, NO REPAIRS HAVE BEEN MADE. THE VEHICLE IDENTIFICATION NUMBER WAS UNAVAILABLE. THE FAILURE AND CURRENT MILEAGES WERE 52,800.

Owner-reported narrative. 52,800 miles reported. Look up ODI 10285480 at NHTSA ↗

TL*THE CONTACT OWNS A 2005 FORD ECONOLINE. THE CONTACT STATED THAT SHE COULD SMELL FUEL INSIDE THE VEHICLE AND SMOKE ESCAPED FROM THE TAILPIPE. THE DEALER REPLACED THE LINER ON THE FUEL TANK TWICE. THE DEALER STATED THAT THE DIESEL FUEL ATE THROUGH THE LINING. THE FAILURE MILEAGE WAS APPROXIMATELY 50,000 AND THE CURRENT MILEAGE WAS APPROXIMATELY 78,000.

Owner-reported narrative. 50,000 miles reported. Look up ODI 10368297 at NHTSA ↗

TL*THE CONTACT OWNS A 2005 FORD ECONOLINE 350. WHILE DRIVING APPROXIMATELY 65 MPH UP A HILL THE VEHICLE LOST POWER AND IT BECAME DIFFICULT TO ACCELERATE. THE FAILURE OCCURRED EVERY TIME THE VEHICLE WAS DRIVEN IN THE LAST TWO WEEKS. THE VEHICLE WAS TAKEN TO THE DEALER WHERE THE TECHNICIANS STATED THAT THE FAILURE WAS DUE TO DELAMINATION IN THE GASOLINE TANK AND THAT THE FUEL PUMP, OIL AND FUEL FILTERS WOULD HAVE TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE VIN WAS UNAVAILABLE. THE APPROXIMATE FAILURE MILEAGE WAS 69,000.

Owner-reported narrative. 69,000 miles reported. Look up ODI 10376216 at NHTSA ↗

TL*THE CONTACT OWNS A 2005 FORD ECONOLINE 350 VAN. THE CONTACT STATED THAT THE SEATBELTS WERE DEFECTIVE (SECOND ROW CAPTAIN SEAT BEHIND THE PASSENGER SIDE/CAPTAIN CHAIR BEHIND THE DRIVERS SEAT). THE CONTACT SAID THE SEATBELT DISLODGED FROM THE HINGE AND WOULD NOT LOCK IN PLACE. THE DEALERSHIP AND MANUFACTURER WERE CONTACTED AND ADVISED THE CONTACT THAT SHE HAD TO PAY OUT OF POCKET TO REPAIR THE DEFECT. THE FAILURE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 40,000 AND THE CURRENT MILEAGE WAS 58,000. THE CONTACT ALSO STATED THAT THE BENCH SEAT (T…

Owner-reported narrative. 40,000 miles reported. Look up ODI 10405748 at NHTSA ↗

Reported: 2008-12-23 (December 23, 2008)

NEW ENGLAND WHEELS IS RECALLING 513 MY 2005-2007 FORD E-SERIES VEHICLES EQUIPPED WITH RICON PLATFORM STYLE WHEELCHAIR LIFTS. THESE LIFTS FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 403, "PLATFORM LIFT SYSTEMS FOR MOTOR VEHICLES." THE ANTI-STOW INTERLOCK MAY NOT DETECT THE PRESENCE OF A WHEELCHAIR OR MOBILITY AID USER. THE PRESSURE SENSING SWITCH THAT DETECTS THE PRESENCE OF WEIGHT ON THE PLATFORM WAS NOT ADJUSTED TO THE NECESSARY SENSITIVITY LEVEL. THE LIFT COULD STOW EVEN THOUGH SOMEONE OR SOMETHING IS STILL ON THE LIFT.

Consequence: A LIFT OCCUPANT CAN BE INJURED SHOULD THE LIFT BEGIN TO STOW UNINTENTIONALLY.

Remedy: NEW ENGLAND WHEELS IS WORKING WITH RICON TO CORRECT THE WHEELCHAIR LIFTS FREE OF CHARGE (PLEASE SEE 07E097). OWNERS MAY CONTACT RICON AT 1-818-267-3000 OR NEW ENGLAND WHEELS AT 1-800-886-9247.

Reported: 2009-01-12 (January 12, 2009)

AMERICAN EMERGENCY VEHICLES IS RECALLING 8 MY 2005-2006 E-SERIES VANS BUILT ON FORD CHASSIS AND EQUIPPED WITH RICON PLATFORM STYLE WHEELCHAIR LIFTS. THESE LIFTS FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 403, "PLATFORM LIFT SYSTEM ACCESSIBLE FOR MOTOR VEHICLES." THE ANTI-STOW INTERLOCK MAY NOT DETECT THE PRESENCE OF A WHEELCHAIR OR MOBILITY AID USER. THE PRESSURE SENSING SWITCH THAT DETECTS THE PRESENCE OF WEIGHT ON THE PLATFORM WAS NOT ADJUSTED TO THE NECESSARY SENSITIVITY LEVEL. THE LIFT COULD STOW EVEN THOUGH SOMEONE OR SOMETHING IS STILL ON THE LIFT.

Consequence: A LIFT OCCUPANT CAN BE INJURED SHOULD THE LIFT BEGIN TO STOW UNINTENTIONALLY.

Remedy: AMERICAN EMERGENCY VEHICLES IS WORKING WITH RICON TO CORRECT THE WHEELCHAIR LIFTS FREE OF CHARGE (PLEASE SEE 07E097). OWNERS MAY CONTACT RICON AT 1-818-267-3000 OR AMERICAN EMERGENCY VEHICLES AT 1-336-982-9824.

Reported: 2009-01-13 (January 13, 2009)

AMERICAN EMERGENCY VEHICLES IS RECALLING 8 MY 2005-2006 E-SERIES VANS BUILT ON FORD CHASSIS AND EQUIPPED WITH RICON PLATFORM STYLE WHEELCHAIR LIFTS. THESE LIFTS FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 404, "PLATFORM LIFT INSTALLATIONS ON MOTOR VEHICLES." THE THRESHOLD WARNING SYSTEM MAY NOT DETECT THE PRESENCE OF A WHEELCHAIR OR MOBILITY AID USER IN A CERTAIN SPOT WITHIN THE DEFINED THRESHOLD AREA.

Consequence: THE USER OF THE LIFT COULD BE INJURED SHOULD THE LIFT MOVE UNINTENTIONALLY.

Remedy: AMERICAN EMERGENCY VEHICLES IS WORKING WITH RICON TO CORRECT THE WHEELCHAIR LIFTS FREE OF CHARGE (PLEASE SEE 07E095). OWNERS MAY CONTACT RICON AT 1-818-267-3000 OR AMERICAN EMERGENCY VEHICLES AT 1-336-982-9824.

Reported: 2009-02-06 (February 6, 2009)

MOBILITY IS RECALLING 86 MY 2005-2006 FORD E-SERIES AND CHEVROLET EXPRESS VAN EQUIPPED WITH RICON PLATFORM STYLE WHEELCHAIR LIFTS. THESE VEHICLES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 404, "PLATFORM LIFT INSTALLATIONS ON MOTOR VEHICLES." THE THRESHOLD WARNING SYSTEM MAY NOT DETECT THE PRESENCE OF A WHEELCHAIR OR MOBILITY AID USER IN A CERTAIN SPOT WITHIN THE DEFINED THRESHOLD AREA.

Consequence: THE USER OF THE LIFT COULD BE INJURED SHOULD THE LIFT MOVE UNINTENTIONALLY.

Remedy: MOBILITY IS WORKING WITH RICON TO CORRECT THE WHEELCHAIR LIFTS FREE OF CHARGE (PLEASE SEE 07E095). OWNERS MAY CONTACT RICON AT 1-818-267-3000 OR MOBILITY AT 714-674-0480.

Reported: 2009-02-06 (February 6, 2009)

MOBILITY IS RECALLING 43 MY 2005-2006 FORD E-SERIES AND CHEVROLET EXPRESS VANS EQUIPPED WITH RICON PLATFORM STYLE WHEELCHAIR LIFTS. THESE LIFTS FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 403, "PLATFORM LIFT SYSTEM ACCESSIBLE FOR MOTOR VEHICLES." THE ANTI-STOW INTERLOCK MAY NOT DETECT THE PRESENCE OF A WHEELCHAIR OR MOBILITY AID USER. THE PRESSURE SENSING SWITCH THAT DETECTS THE PRESENCE OF WEIGHT ON THE PLATFORM WAS NOT ADJUSTED TO THE NECESSARY SENSITIVITY LEVEL. THE LIFT COULD STOW EVEN THOUGH SOMEONE OR SOMETHING IS STILL ON THE LIFT.

Consequence: A LIFT OCCUPANT CAN BE INJURED SHOULD THE LIFT BEGIN TO STOW UNINTENTIONALLY.

Remedy: MOBILITY IS WORKING WITH RICON TO CORRECT THE WHEELCHAIR LIFTS FREE OF CHARGE (PLEASE SEE 07E097). OWNERS MAY CONTACT RICON AT 1-818-267-3000 OR MOBILITY AT 714-674-0480.

Reported: 2009-03-24 (March 24, 2009)

NEW ENGLAND WHEELS, INC. IS RECALLING 513 RICON WHEELCHAIR LIFTS WHICH IT INSTALLED ON MY 2005 THROUGH 2007 FORD E-SERIES COMMERCIAL VANS. THESE VEHICLES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 404, "PLATFORM LIFT INSTALLATIONS IN MOTOR VEHICLES." THE THRESHOLD WARNING SYSTEM MAY NOT DETECT THE PRESENCE OF A WHEELCHAIR OR MOBILITY AID USER IN A CERTAIN SPOT WITHIN THE DEFINED THRESHOLD AREA.

Consequence: A LIFT OCCUPANT CAN BE INJURED SHOULD THE LIFT BEGIN TO STOW UNINTENTIONALLY.

Remedy: NEW ENGLAND WHEELS IS WORKING WITH RICON TO CORRECT THE WHEELCHAIR LIFTS FREE OF CHARGE (PLEASE SEE 07E095). OWNERS MAY CONTACT RICON AT 1-818-267-3000 OR NEW ENGLAND WHEELS AT 1-800-886-9247.