1999 Ford E-350: complaints, problems and recalls

DIESEL FUEL TANK FILLER NECK FAILURE. WHEN FILLING WITH FUEL FILLER NECK LEAKS FUEL. THIS WAS INITIALLY DIAGNOSED IN 2000. FILLER NECK REPLACED. SEPTEMBER 2001 TANK MOUNTS REPLACED IN RECALL. THIS IS THE SECOND FAILURE OF THE FUEL TANK FILLER NECK. FORD REFUSES TO MAKE REPAIRS UNDER WARRANTY.

Owner-reported narrative. 58,540 miles reported. Look up ODI 10000381 at NHTSA ↗

THE SPARK PLUGS BLEW OUT. *JB *TS

Owner-reported narrative. 140,000 miles reported. Look up ODI 10014653 at NHTSA ↗

WHILE DRIVING THE VEHICLE PULLED TO THE RIGHT. THE VEHICLE WAS TAKEN TO FORD AND FORD STATED THAT ALL 4 TIRES WERE BAD. *NLM

Owner-reported narrative. 34,000 miles reported. Look up ODI 10017280 at NHTSA ↗

WHILE DRIVING 65 MPH VEHICLE STARTED TO VIOLENTLY SHAKE. DRIVER IMMEDIATELY PULLED OVER. DRIVER SIDE REAR TIRE WAS VERY HOT AND THE TREAD LOOKED LIKE IT WAS ABOUT TO SEPARATE.*AK

Owner-reported narrative. Look up ODI 10022911 at NHTSA ↗

GOODYEAR TIRE RECALL. I OWN A 15 PASSENGER FORD VAN, APPROX ONE YEAR AGO I RECEIVED A LETTER FROM GOODYEAR, TO TAKE MY VAN TO A GOODYEAR DEALER AND HAVE THE TIRES INSPECTED FOR SOME REPLACEMENT CAMPAIGN. IT WAS DETERMINED THAT MY TIRES WERE TO BE REPLACED AT NO CHARGE. RECENTLY FOUR OF THE FIVE REPLACEMENT TIRES HAVE SEPARATED AND HAD TO BE REPLACED. THE FIFTH HAS NOT SEPARATED BECAUSE IT IS THE NEW SPARE. ONE OF THE CENTER TREADS IS LETTING GO AND ARE RISING HIGHER THEN THE REST OF THE TREADS CAUSING THE TIRE TO BOUNCE DRASTICALLY. THES…

Owner-reported narrative. 72,000 miles reported. Look up ODI 10039311 at NHTSA ↗

BRAKE FAILURE. THIS HAS BEEN REPORTED PREVIOUSLY AND I HAVE MADE NUMEROUS ATTEMPTS TO GET IT REPAIRED AT THE DEALER AND TO CONVEY THE PROBLEM TO THE MANUFACTURER. THE PROBLEM IS INTERMITTENT AND IMPOSSIBLE TO PREDICT. ONE OF THE FRONT WHEELS LOCK UP AND SERVE AS THE ONLY BRAKING FORCE. IN DRY WEATHER IT WILL "PULL" TO ONE SIDE AND IN WET WEATHER IT WILL SKID RESULTING IN NO BRAKING FORCE. ON 10/08/03 THIS OCCURRED IN A RAIN SHOWER AS I PULLED INTO AN INTERSTATE REST AREA (20-25MPH). I FIRST APPLIED THE BRAKES @ 100 - 125 FEET FROM THE REA…

Owner-reported narrative. Look up ODI 10041720 at NHTSA ↗

THE ORIGINAL TIRES OVERHEATED AND SMOKED,CAUSING THE VEHICLE TO SHAKE. THE TIRES WERE IN THE PROCESS OF BLOWING OUT WHICH COULD HAVE RESULTED IN A COLLISION OR SERIOUS DAMAGE. FIRESTONE, STEEL TEX TIRES.*AK

Owner-reported narrative. 24,000 miles reported. Look up ODI 10042507 at NHTSA ↗

FRONT PASSENGER/ DRIVER'S PASSENGER, AND REAR TIRES LOST AIR. CONSUMER WAS CONSTANTLY PUTTING AIR INTO THE TIRES. *AK

Owner-reported narrative. Look up ODI 10050572 at NHTSA ↗

Reported: 2000-04-19 (April 19, 2000)

VEHICLE DESCRIPTION: CUTAWAYS AND STRIPPED CHASSIS WITH SINGLE REAR WHEELS. THE LUG NUTS CAN POTENTIALLY BOTTOM OUT ON A SHOULDER ON THE STUDS.

Consequence: IF THIS OCCURS, THERE CAN BE AN INADEQUATE CLAMP LOAD TO ATTACH THE WHEEL TO THE AXLE, RESULTING IN NOISE, DAMAGE TO THE WHEEL AND HUB, OR IN EXTREME CASES, LOSS OF A REAR WHEEL WHILE THE VEHICLE IS BEING DRIVEN.

Remedy: DEALERS WILL REPLACE THE REAR WHEEL ATTACHING STUDS.

Reported: 2000-09-21 (September 21, 2000)

VEHICLE DESCRIPTION: BI-FUEL CNG PICKUP TRUCKS AND BI-FUEL CNG VANS, MODIFIED BY CFI CONTROL SYSTEMS, INC., FAIL TO CONFORM TO THE REQUIREMENTS OF FMVSS NO. 303, "FUEL SYSTEM INTEGRITY OF COMPRESSED NATURAL GAS VEHICLES." THE LABEL AFFIXED TO THE FUEL FILLER DOOR BY THE VEHICLE MODIFIER CONTAINS THE INSPECTION DATE AND EXPIRATION DATE OF THE CNG TANK. HOWEVER, IT DOES NOT CONTAIN THE STATEMENT "SEE INSTRUCTIONS ON THE FUEL CONTAINER FOR INSPECTION AND SERVICE LIFE."

Consequence: THESE VEHICLES DO NOT COMPLY WITH THE REQUIREMENTS.

Remedy: OWNERS WILL BE PROVIDED A LABEL WITH THE REQUIRED STATEMENT, ALONG WITH INSTRUCTIONS FOR AFFIXING THE LABEL AT THE FUEL FILLER DOOR. OWNER NOTIFICATION BEGAN NOVEMBER 2, 2000. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-800-392-3673.

Reported: 2001-04-05 (April 5, 2001)

VEHICLE DESCRIPTION: ON CERTAIN VANS WITH AMBULANCE PREP PACKAGES OR OTHER SEVERE-DUTY APPLICATIONS INVOLVING OPERATION AT OR NEAR THE GROSS VEHICLE WEIGHT WITH FREQUENT TWISTING OF THE VEHICLE BODY, SUCH AS OFF-ROAD, ROUGH ROAD OR SPEED BUMP EVENTS, THE 35 GALLON MID-SHIP FUEL TANK COULD DEVELOP A CRACK WHERE IT CONTACTS THE FRAME CROSS MEMBER. IF THE FUEL TANK CRACKS, FUEL LEAKAGE COULD OCCUR.

Consequence: FUEL LEAKAGE IN THE PRESENCE OF AN IGNITION SOURCE COULD RESULT IN A FIRE.

Remedy: DEALERS WILL INSPECT THE FUEL TANK AND, IF CRACKED, WILL REPLACE THE TANK. INSULATOR PADS WILL BE INSTALLED ON ALL VEHICLES TO REDUCE THE STRESS LEVELS IN THE FUEL TANK. OWNER NOTIFICATION BEGAN APRIL 19, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-800-392-3673.

Reported: 2007-08-03 (August 3, 2007)

ON CERTAIN PICKUP TRUCKS, PASSENGER VEHICLES, SPORT UTILITY VEHICLES, AND MOTOR HOMES CHASSIS, THE SPEED CONTROL DEACTIVATION SWITCH MAY, UNDER CERTAIN CONDITIONS, LEAK INTERNALLY AND THEN OVERHEAT, SMOKE, OR BURN.

Consequence: THIS COULD RESULT IN AN UNDERHOOD FIRE.

Remedy: DEALERS WILL INSTALL A FUSED WIRING HARNESS. OWNERS OF THE PASSENGER CARS INCLUDED IN THIS CAMPAIGN WILL BE INSTRUCTED TO RETURN THEIR VEHICLES TO THEIR DEALERS TO HAVE THE SPEED CONTROL DEACTIVATION SWITCH DISCONNECTED AS AN INTERIM REPAIR. AS SOON AS REPAIR PARTS ARE AVAILABLE (EXPECTED OCTOBER 2007), OWNERS WILL BE INSTRUCTED TO RETURN TO THE DEALERS FOR INSTALLATION OF A FUSED WIRING HARNESS. THE RECALL BEGAN ON AUGUST 13, 2007, AND MAILING COMPLETED BY SEPTEMBER 19, 2007. OWNERS MAY CONTACT FORD AT 1-888-222-2751.

Reported: 2008-02-04 (February 4, 2008)

FORD IS RECALLING 225,000 MY 1992-2003 ECONOLINE, MY 1993-1995 TAURUS SHO, MY 1992-1998 CROWN VICTORIA, MY 1993 BRONCO, F-SERIES, MY 1995-1997 F-SERIES SUPER DUTY STRIPPED CHASSIS, MY 1992-1998 MERCURY GRAND MARQUIS, AND MY 1992-1995 LINCOLN TOWN CAR VEHICLES. THE AFFECTED VEHICLES WERE PREVIOUSLY REPAIRED USING A WIRING HARNESS THAT IS NOT COMPATIBLE WITH THE VEHICLE CIRCUIT POLARITY.

Consequence: AS A RESULT, THE FUSE IS LOCATED IN THE OUTPUT CIRCUIT RATHER THAN IN THE INTENDED INPUT POWER FEED CIRCUIT, AND MAY NOT OFFER THE INTENDED PROTECTION IN THE EVENT OF AN ELECTRICAL SHORT TO GROUND.

Remedy: DEALERS WILL INSTALL A NEW WIRING HARNESS, OR REPLACE THE MATING ELECTRICAL COMPONENT. THE RECALL BEGAN ON FEBRUARY 18, 2008. OWNERS MAY CONTACT FORD AT 1-800-392-3673.

Reported: 2009-10-13 (October 13, 2009)

FORD IS RECALLING MODEL YEARS 1995-2003 WINDSTAR, 2000-2003 EXCURSION DIESEL, 1993-1997 AND 1999-2003 F-250 SD THROUGH F-550 SD DIESEL, 1992-2003 E-150 THROUGH E-550, 1995-2002 EXPLORER, 1997 AND 2002 MERCURY MOUNTAINEER, 1995-1997 AND 2001-2003 RANGER, AND 1994 F53 VEHICLES EQUIPPED WITH THE TEXAS INSTRUMENTS SPEED CONTROL DEACTIVATION SWITCH (SCDS). THE SCDS MAY LEAK INTERNALLY AND THEN OVERHEAT, SMOKE, OR BURN.

Consequence: A VEHICLE FIRE COULD OCCUR WITH OR WITHOUT THE ENGINE RUNNING.

Remedy: FORD WILL NOTIFY OWNERS THAT DEALERS WILL INSTALL A FUSED WIRING HARNESS IN LINE WITH THE SCDS. ON 1999-2003 WINDSTAR VEHICLES WITH A LEAKING SCDS, DEALERS WILL ALSO INSPECT THE ABS CONTROL MODULE CONNECTOR AND REPAIR AS NECESSARY. REPAIRS WILL BE COMPLETED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON OCTOBER 27, 2009. OWNERS MAY CONTACT FORD AT 1-888-222-2751.

Reported: 1998-10-14 (October 14, 1998)

VEHICLE DESCRIPTION: PICKUP TRUCKS BUILT WITH SINGLE REAR WHEELS AND EQUIPPED WITH 3.55:1 AND 3.73:1 AXLE RATIO. THESE VEHICLES WERE BUILT WITH INCORRECT SPEEDOMETER DRIVEN GEARS, RESULTING IN A LOWER SPEEDOMETER READING THAN THE ACTUAL VEHICLE SPEED BEING DRIVEN.

Consequence: THIS CAN RESULT IN THE VEHICLE BEING DRIVEN AT AN UNSAFE OR ILLEGAL SPEED SHOULD THE DRIVER NOT REALIZE THAT HIS VEHICLE ROAD SPEED IS GREATER THAN THE SPEEDOMETER INDICATION.

Remedy: DEALERS WILL INSTALL THE CORRECT SPEEDOMETER GEAR.

Reported: 1999-03-15 (March 15, 1999)

VEHICLE DESCRIPTION: UTILITY VANS EQUIPPED WITH THE "60/40" HINGED SIDE CARGO DOORS. THE STRIKERS FOR THE 60/40 DOOR SINGLE LATCH SYSTEM WERE FOUND TO CONTAIN STRESS CRACKS AT THE STRIKER WIRE LOWER STAKE JOINT. STRIKERS WITH STRESS CRACKS MAY NOT MEET THE REQUIREMENTS OF FMVSS NO. 206, "DOOR LOCKS AND DOOR RETENTION COMPONENTS."

Consequence: IN THE EVENT OF A CRASH, THE DOOR STRIKERS MAY NOT HOLD THE DOOR, INCREASING THE RISK OF PERSONAL INJURY OR PROPERTY DAMAGE.

Remedy: DEALERS WILL REPLACE THE DOOR STRIKER.