1994 Ford E-250: complaints, problems and recalls

OUR 1994 15 PASSENGER FORD VAN RIGHT SIDE VAN DOOR HAS THE STANDARD LOCK KNOB WHICH CAN BE PLAYED WITH BY OCCUPANT. IF THE KNOB IS SCREWED OFF , THE CONNECTING LOCKING MECHANISM WILL DROP INTO THE DOOR BEHIND THE INTERIOR PANEL. WHEN THIS HAPPENS, THE DOOR IS LOCKED AND CAN NOT BE UNLOCK WITH KEY, KNOB OR ELECTRIC OPENER. THE OCCUPANTS ONLY WAY OUT IS OVER THE FRONT SEAT OR OVER THE REAR SEATS AND OUT THE TAIL GATE DOOR. THIS HAS HAPPENED TWICE AND THE DOOR PANEL HAS TO BE REMOVED TO UNLOCK. VERY DANGEROUS AND IS NOT CHILD PROOF. *NLM

Owner-reported narrative. Look up ODI 10023300 at NHTSA ↗

ALB ARE A DANGER TO DRIVER IN WET ROADS WHEN YOU GO TO STOP AND SLIDE BRAKES COME OFF IT TAKES TO LONG TO COME BACK ON . WHEN YOU NEED TO STOP TO AVOID A ACCIDENT YOU CAN STOP FASTER WITH OUT THEM BY PUMPING BRAKES WHEN THEY COME OFF THERE IS NOTHING YOU CAN DO. WAIT TO HIT SOMEONE TILL BRAKE COME BACK. NOTHING SHOULD TAKE THE DRIVER AWAY FROM HIS CAR THEY WILL GET SOME ONE KILLED. *NM

Owner-reported narrative. Look up ODI 10171867 at NHTSA ↗

TL* THE CONTACT OWNS A 1994 FORD E250. THE TRANSMISSION SLIPS GEARS WHEN DRIVING BETWEEN 0-55 MPH. ALSO WHEN DRIVING UP- HILL OR DOWN- HILL, THE TRANSMISSION WILL SHIFT INTO NEUTRAL. THE VEHICLE WAS TAKEN TO THE DEALER FIVE TIMES FOR INSPECTION. THE TORQUE CONVERTER WAS REPLACED, AND THE TRANSMISSION WAS REBUILT. NONE OF THE REPAIRS HAVE REMEDIED THE FAILURE. THE FAILURE MILEAGE WAS 75,000 THE CURRENT MILEAGE WAS OVER 300,000.

Owner-reported narrative. 75,000 miles reported. Look up ODI 10292269 at NHTSA ↗

REAR ABS MODULE FAILED. CAUSING OVER PRESSURIZATION OF FRONT BRAKES RESULTING IN PASSENGER SIDE BRAKE HOSE SEPARATION. SO NO REAR OR FRONT BRAKES! THANK GOD IT HAPPENED NEAR MY DRIVEWAY OTHERWISE PEOPLE COULD DIE. I HAD JUST REENTERED DRIVERS SEAT AND RELEASED PARKING BRAKE AND ENGAGED BRAKE PEDAL WITH 1 FOOT. VEHICLE WAS STATIONARY POINTED IN A STRAIGHT LINE.

Owner-reported narrative. 105,025 miles reported. Look up ODI 11185736 at NHTSA ↗

RIGHT FRONT TIRE FAILED DAMAGED FENDER AND SIDE VIEW MIRROR (DOT NUMBER: W2CO1PX037 TIRESIZE: 255/70/R16)

Owner-reported narrative. Look up ODI 735813 at NHTSA ↗

WHEN KEY IS IN IGNITION BUILT-IN INTERLOCK CAUSES VEHICLE NOT TO START. ACCOURDING TO MANUFACTURER'S CARD, WOULD NEED TO PRESS ON BRAKES/ SHIFT INTO NEUTRAL, AND PLAY OR JIGGLE KEY IN IGNITION TO GET VEHICLE STARTED. VEHICLE AT TIMES CAN STALL IN TRAFFIC, AND IS A SAFETY HAZARD. NOT AT DEALERSHIP.*AK

Owner-reported narrative. Look up ODI 897207 at NHTSA ↗

THREE MICHELIN TIRES HAD TREAD SEPERATION, REPLACE ALL 4 TIRES, MILES LATER 1 BLEW AT 70MPH, THE TIRE WAS BADLY DAMANGED AND COULD NOT DETERMINE THE CAUSE. AGAIN AT 24,849 ANOTHER TIRE BLEW.

Owner-reported narrative. Look up ODI 9005158 at NHTSA ↗

FRONT LEFT WHEEL FELL OFF, UPPER SPINDLE BOLT BROKE. TT

Owner-reported narrative. Look up ODI 976280 at NHTSA ↗

Reported: 2006-08-01 (August 1, 2006)

ON CERTAIN TRUCKS EQUIPPED WITH SPEED CONTROL, GASOLINE OR NATURAL GAS ENGINES, THE SPEED CONTROL DEACTIVATION SWITCH MAY OVERHEAT.

Consequence: OVERHEATING COULD RESULT IN SMOKE OR BURN AND AN UNDERHOOD FIRE.

Remedy: DEALERS WILL INSTALL A FUSED WIRING HARNESS INTO THE SPEED CONTROL SYSTEM FREE OF CHARGE. THE RECALL BEGAN ON AUGUST 7, 2006. OWNERS MAY CONTACT FORD AT 1-866-436-7332. (NOTE: ALSO SEE RECALLS 05V017 AND 05V388)

Reported: 2008-02-04 (February 4, 2008)

FORD IS RECALLING 225,000 MY 1992-2003 ECONOLINE, MY 1993-1995 TAURUS SHO, MY 1992-1998 CROWN VICTORIA, MY 1993 BRONCO, F-SERIES, MY 1995-1997 F-SERIES SUPER DUTY STRIPPED CHASSIS, MY 1992-1998 MERCURY GRAND MARQUIS, AND MY 1992-1995 LINCOLN TOWN CAR VEHICLES. THE AFFECTED VEHICLES WERE PREVIOUSLY REPAIRED USING A WIRING HARNESS THAT IS NOT COMPATIBLE WITH THE VEHICLE CIRCUIT POLARITY.

Consequence: AS A RESULT, THE FUSE IS LOCATED IN THE OUTPUT CIRCUIT RATHER THAN IN THE INTENDED INPUT POWER FEED CIRCUIT, AND MAY NOT OFFER THE INTENDED PROTECTION IN THE EVENT OF AN ELECTRICAL SHORT TO GROUND.

Remedy: DEALERS WILL INSTALL A NEW WIRING HARNESS, OR REPLACE THE MATING ELECTRICAL COMPONENT. THE RECALL BEGAN ON FEBRUARY 18, 2008. OWNERS MAY CONTACT FORD AT 1-800-392-3673.

Reported: 2009-10-13 (October 13, 2009)

FORD IS RECALLING MODEL YEARS 1995-2003 WINDSTAR, 2000-2003 EXCURSION DIESEL, 1993-1997 AND 1999-2003 F-250 SD THROUGH F-550 SD DIESEL, 1992-2003 E-150 THROUGH E-550, 1995-2002 EXPLORER, 1997 AND 2002 MERCURY MOUNTAINEER, 1995-1997 AND 2001-2003 RANGER, AND 1994 F53 VEHICLES EQUIPPED WITH THE TEXAS INSTRUMENTS SPEED CONTROL DEACTIVATION SWITCH (SCDS). THE SCDS MAY LEAK INTERNALLY AND THEN OVERHEAT, SMOKE, OR BURN.

Consequence: A VEHICLE FIRE COULD OCCUR WITH OR WITHOUT THE ENGINE RUNNING.

Remedy: FORD WILL NOTIFY OWNERS THAT DEALERS WILL INSTALL A FUSED WIRING HARNESS IN LINE WITH THE SCDS. ON 1999-2003 WINDSTAR VEHICLES WITH A LEAKING SCDS, DEALERS WILL ALSO INSPECT THE ABS CONTROL MODULE CONNECTOR AND REPAIR AS NECESSARY. REPAIRS WILL BE COMPLETED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON OCTOBER 27, 2009. OWNERS MAY CONTACT FORD AT 1-888-222-2751.