2000 Ford E-150: complaints, problems and recalls

IMPROPERLY INSTALLED WINDSHEILD. FORD REFUSES TO FIX IT.

Owner-reported narrative. 36,785 miles reported. Look up ODI 10000966 at NHTSA ↗

AIR BAG / AIR CONDITIONER.. THE AIR BAG LIGHT ILLUMINATED AND THE AIR CONDITION DID WORK. *JB

Owner-reported narrative. Look up ODI 10009445 at NHTSA ↗

WHILE DRIVING 55 MPH TRANSMISSION LOST POWER, CAUSING VEHICLE TO SLOW DOWN TO 35 MPH. MANUFACTURE RAND DEALER HAVE BEEN NOTIFIED.*AK

Owner-reported narrative. Look up ODI 10037852 at NHTSA ↗

DOOR METAL ON DRIVER'S SIDE IS CRACKING WHICH PRODUCES A SQUEAKY NOISE. *AK

Owner-reported narrative. Look up ODI 10038473 at NHTSA ↗

AT 35,500 MILES ON MY 2000 E-150 SERIES VAN, THE VEHICLE HAD A PROBLEM WITH PULLING OR "DRIFTING HARD" TO THE RIGHT. AFTER REQUESTING THAT THE VEHICLE HAVE A FRONT END ALIGNMENT CHECK, THE DEALERSHIP FOUND THAT THE BALL-JOINTS WERE IN NEED OF REPLACEMENT. JOINTS WERE REPLACED UNDER MANUFACTURERS WARRANTY ON 07/2002, BUT ALIGNMENT WAS CHARGED TO ME. NOW THE VEHICLE WAS JUST IN FOR THE SAME PROBLEM WITH HARD DRIFT TO RIGHT (AT 55MPH, THE VEHICLE WOULD MAKE ENOUGH OF DRIFT TO CHANGE ONE FULL LANE IN 5 SECONDS) WAS TOLD BY DEALER THAT THE BALL JOIN…

Owner-reported narrative. 56,886 miles reported. Look up ODI 10043544 at NHTSA ↗

THE TIRES ON MY FORD 2000 E150 ARE "PEELING" ... THE OUTSIDE RUBBER ON THE SIDE OF THE TIRES IS PEELING AWAY AND EXPOSING THE "FABRIC" BENEATH. (IT'S LIKE THE VENEER PEELING OFF A PIECE OF FURNITURE.) THIS IS REMINDING ME OF THE TIRE PROBLEMS FORD HAD SEVERAL YEARS AGO. THE TIRES ON MY FORD E-150 ARE MICHELINS.*AK

Owner-reported narrative. Look up ODI 10082613 at NHTSA ↗

ONGOING PROBLEMS WITH VEHICLE'S BRAKES AND SUSPENSION.*MR DUE TO THE VEHICLE BEING OVERWEIGHTED BY WITH THE MOBILITY CONVERSATIONS PACKAGE SYSTEM THE VEHICLE EXPERIENCED ABNORMAL WEAR OF THE DRIVETRAIN, BRAKE SYSTEM AND SUSPENSION COMPONENTS. THE VEHICLE WAS OVERWEIGHT WHEN THE CONSUMER ALONG WITH HIS WHEELCHAIR AND A FORTH OF A TANK OF GAS WHERE IN THE VEHICLE. *NM

Owner-reported narrative. Look up ODI 10083496 at NHTSA ↗

COMPLAINT REGARDING 2000 FORD 3-150 LIBERTY VMI VAN.*MR THE CONSUMER RECEIVED A NOTICE FROM FORD REGARDING THE GROSS VEHICLE WEIGHT RATINGS ON THE F150 VAN AND WAGON MODELS. THE CONSUMER CONTACTED THE MOBILITY MANUFACTURER ABOUT THIS PROBLEM BUT THEY HOLD HIM IT WAS HIS PROBLEM. THE CONSUMER REQUEST REIMBURSEMENT FOR THE COST OF REPAIRS, MILEAGE, FUEL, RENTAL COST AND LOSS OF TIME. *NM

Owner-reported narrative. Look up ODI 10089144 at NHTSA ↗

Reported: 2001-04-05 (April 5, 2001)

VEHICLE DESCRIPTION: ON CERTAIN VANS WITH AMBULANCE PREP PACKAGES OR OTHER SEVERE-DUTY APPLICATIONS INVOLVING OPERATION AT OR NEAR THE GROSS VEHICLE WEIGHT WITH FREQUENT TWISTING OF THE VEHICLE BODY, SUCH AS OFF-ROAD, ROUGH ROAD OR SPEED BUMP EVENTS, THE 35 GALLON MID-SHIP FUEL TANK COULD DEVELOP A CRACK WHERE IT CONTACTS THE FRAME CROSS MEMBER. IF THE FUEL TANK CRACKS, FUEL LEAKAGE COULD OCCUR.

Consequence: FUEL LEAKAGE IN THE PRESENCE OF AN IGNITION SOURCE COULD RESULT IN A FIRE.

Remedy: DEALERS WILL INSPECT THE FUEL TANK AND, IF CRACKED, WILL REPLACE THE TANK. INSULATOR PADS WILL BE INSTALLED ON ALL VEHICLES TO REDUCE THE STRESS LEVELS IN THE FUEL TANK. OWNER NOTIFICATION BEGAN APRIL 19, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-800-392-3673.

Reported: 2007-08-03 (August 3, 2007)

ON CERTAIN PICKUP TRUCKS, PASSENGER VEHICLES, SPORT UTILITY VEHICLES, AND MOTOR HOMES CHASSIS, THE SPEED CONTROL DEACTIVATION SWITCH MAY, UNDER CERTAIN CONDITIONS, LEAK INTERNALLY AND THEN OVERHEAT, SMOKE, OR BURN.

Consequence: THIS COULD RESULT IN AN UNDERHOOD FIRE.

Remedy: DEALERS WILL INSTALL A FUSED WIRING HARNESS. OWNERS OF THE PASSENGER CARS INCLUDED IN THIS CAMPAIGN WILL BE INSTRUCTED TO RETURN THEIR VEHICLES TO THEIR DEALERS TO HAVE THE SPEED CONTROL DEACTIVATION SWITCH DISCONNECTED AS AN INTERIM REPAIR. AS SOON AS REPAIR PARTS ARE AVAILABLE (EXPECTED OCTOBER 2007), OWNERS WILL BE INSTRUCTED TO RETURN TO THE DEALERS FOR INSTALLATION OF A FUSED WIRING HARNESS. THE RECALL BEGAN ON AUGUST 13, 2007, AND MAILING COMPLETED BY SEPTEMBER 19, 2007. OWNERS MAY CONTACT FORD AT 1-888-222-2751.

Reported: 2008-02-04 (February 4, 2008)

FORD IS RECALLING 225,000 MY 1992-2003 ECONOLINE, MY 1993-1995 TAURUS SHO, MY 1992-1998 CROWN VICTORIA, MY 1993 BRONCO, F-SERIES, MY 1995-1997 F-SERIES SUPER DUTY STRIPPED CHASSIS, MY 1992-1998 MERCURY GRAND MARQUIS, AND MY 1992-1995 LINCOLN TOWN CAR VEHICLES. THE AFFECTED VEHICLES WERE PREVIOUSLY REPAIRED USING A WIRING HARNESS THAT IS NOT COMPATIBLE WITH THE VEHICLE CIRCUIT POLARITY.

Consequence: AS A RESULT, THE FUSE IS LOCATED IN THE OUTPUT CIRCUIT RATHER THAN IN THE INTENDED INPUT POWER FEED CIRCUIT, AND MAY NOT OFFER THE INTENDED PROTECTION IN THE EVENT OF AN ELECTRICAL SHORT TO GROUND.

Remedy: DEALERS WILL INSTALL A NEW WIRING HARNESS, OR REPLACE THE MATING ELECTRICAL COMPONENT. THE RECALL BEGAN ON FEBRUARY 18, 2008. OWNERS MAY CONTACT FORD AT 1-800-392-3673.

Reported: 2009-10-13 (October 13, 2009)

FORD IS RECALLING MODEL YEARS 1995-2003 WINDSTAR, 2000-2003 EXCURSION DIESEL, 1993-1997 AND 1999-2003 F-250 SD THROUGH F-550 SD DIESEL, 1992-2003 E-150 THROUGH E-550, 1995-2002 EXPLORER, 1997 AND 2002 MERCURY MOUNTAINEER, 1995-1997 AND 2001-2003 RANGER, AND 1994 F53 VEHICLES EQUIPPED WITH THE TEXAS INSTRUMENTS SPEED CONTROL DEACTIVATION SWITCH (SCDS). THE SCDS MAY LEAK INTERNALLY AND THEN OVERHEAT, SMOKE, OR BURN.

Consequence: A VEHICLE FIRE COULD OCCUR WITH OR WITHOUT THE ENGINE RUNNING.

Remedy: FORD WILL NOTIFY OWNERS THAT DEALERS WILL INSTALL A FUSED WIRING HARNESS IN LINE WITH THE SCDS. ON 1999-2003 WINDSTAR VEHICLES WITH A LEAKING SCDS, DEALERS WILL ALSO INSPECT THE ABS CONTROL MODULE CONNECTOR AND REPAIR AS NECESSARY. REPAIRS WILL BE COMPLETED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON OCTOBER 27, 2009. OWNERS MAY CONTACT FORD AT 1-888-222-2751.

Reported: 2010-06-17 (June 17, 2010)

ACCESS OPTIONS IS RECALLING CERTAIN TRUCKS AND VANS BUILT ON FORD E150, E350, TOYOTA SIENNA, AND DODGE GRAND CARAVAN CHASSIS AND EQUIPPED WITH VMI/RICON 6-WAY POWER SEAT BASES. THE SIX WAY POWER SEAT BASE MAY HAVE A DEFECTIVE (COLD) WELD ON THE PIVOT PIN WHICH IS WELDED TO THE SWIVEL PLATE. THE WELD COULD FAIL.

Consequence: THE SEAT OCCUPANT MAY BE INJURED IF THE SEAT BASE PIN WERE TO BREAK.

Remedy: THE SWIVEL PLATE WILL BE REPLACED FREE OF CHARGE IF NECESSARY. THE RECALL BEGAN ON JUNE 8, 2010. OWNERS MAY CONTACT ACCESS OPTION AT 831-722-6804.