2006 Dodge SPRINTER 2500: complaints, problems and recalls

TL*THE CONTACT OWNS A 2006 DODGE SPRINTER. THE CONTACT STATED THAT THERE WAS A FUEL LEAK IN THE FUEL FILTER. THE FAILURE CAUSED DIESEL FUEL TO LEAK ONTO THE ENGINE AND THE GROUND. THE DEALER ATTEMPTED TO REPAIR THE VEHICLE, BUT WAS UNSUCCESSFUL. THE CONTACT STATED THAT IF THE FUEL FILTER WERE CHANGED WITH O-RINGS SUPPLIED WITH THE FILTER, THE FAILURE WOULD STILL OCCUR. THE WATER SENSOR WAS CHANGED WITH O-RINGS, WHICH WERE SLIGHTLY DIFFERENT. THE CONTACT STATED THAT WITHOUT THIS SENSOR, ANY O-RINGS WOULD NOT BE SUFFICIENT ENOUGH TO REMEDY …

Owner-reported narrative. 36,000 miles reported. Look up ODI 10226013 at NHTSA ↗

2006 DODGE SPRINTER 2500 T1 EXTENDED PASSENGER APPROX. 23K MILES, 2 YEARS OLD, UNDER CHRYSLER FULL WARRANTY 1. VEHICLE STOPS RUNNING ALTOGETHER WHILE IN DRIVE, TOTAL ENGINE CUT-OUT, BATTERY LIGHT COMES ON UPON SLOWING AT AN INTERSECTION, TURNING A CORNER AT SLOW RATE OF SPEED. YOU CAN PUT VAN IN NEUTRAL AND IMMEDIATELY RE-START IT AND IT RUNS FINE. 2. THIS TENDS TO HAPPEN IN THE HEAT OF THE DAY WITH THE REAR A/C RUNNING FULL BLAST. THIS HAS BEEN HAPPENING RANDOMLY FOR 10 MONTHS OR MORE, BUT NEVER IN THE WINTER WHEN NOT RUNNING THE A/C. …

Owner-reported narrative. 23,000 miles reported. Look up ODI 10234929 at NHTSA ↗

2006 DODGE SPRINTER 2500 HC PASSENGER APPROX. 23K MILES, 2 YEARS OLD, UNDER CHRYSLER FULL WARRANTY 1. VEHICLE STOPS RUNNING ALTOGETHER WHILE IN DRIVE, TOTAL ENGINE CUT-OUT, BATTERY LIGHT COMES ON UPON SLOWING AT AN INTERSECTION, TURNING A CORNER AT SLOW RATE OF SPEED. YOU CAN PUT VAN IN NEUTRAL AND IMMEDIATELY RE-START IT AND IT RUNS FINE. 2. THIS TENDS TO HAPPEN ONLY IN HOT WEATHER, IN THE HEAT OF THE DAY WITH THE REAR A/C RUNNING FULL BLAST. THIS HAS BEEN HAPPENING RANDOMLY FOR 10 MONTHS OR MORE, BUT NEVER IN THE WINTER WHEN NOT RUNNING T…

Owner-reported narrative. 25,000 miles reported. Look up ODI 10240654 at NHTSA ↗

REPEATED ELECTRICAL PROBLEMS. HEADLIGHTS TAILLIGHTS ETC. DEALER STATES IT IS FUSES & BULBS. VEHICLE CHECKED BY AUTOMOTIVE ELECTRICIAN AND FUSES BULBS ETC OK. POSSIBLE DEFECTIVE WIRING. HAVE MADE NUMEROUS (5) ATTEMPTS TO CORRECT. RELATIVE ALSO OWNS SIMILAR VEHICLE WITH SAME PROBLEMS. *TR

Owner-reported narrative. 3,527 miles reported. Look up ODI 10244982 at NHTSA ↗

TURBO CHARGER RESONATOR FAILED X 2 VEHICLE TO GO NO FASTER THAN 30 MPH . THIS ON A SUPER HIGHWAY IS VERY DANGEROUS. *TR

Owner-reported narrative. 17,000 miles reported. Look up ODI 10260568 at NHTSA ↗

WE BOUGHT A BRAND NEW 2006 DODGE SPRINTER AND THE ENGINE JUST BLEW AT 115,000 MILES. THIS IS UNHEARD OF IN DIESEL ENGINES. THE VEHICLE WAS PLAGUED FROM THE START AND THE DEALERSHIP CLEARLY ADMITTED IT WAS "CURSED" AND WE SHOULD HAVE GOT MORE THAN 115,000 MILES OUT OF IT, YET NO ONE WANTS TO ASSUME RESPONSIBILITY FOR THE DEFECTS. *TR

Owner-reported narrative. 115,000 miles reported. Look up ODI 10268494 at NHTSA ↗

I WAS ATTEMPTING TO PASS A BIG SLOW MOVING TRUCK GOING UPHILL WHEN MY VAN SUDDENLY LOST POWER. ANOTHER 18 WHEELED TRUCK WAS BEHIND ME ALSO TRYING TO PASS THE SAME SLOW MOVING TRUCK WHICH WAS ON THE RIGHT LANE. THE TRUCK BEHIND ME HAD TO SLAM ON HIS BRAKES TO AVOID REAR-ENDING ME. I HAD TO WAIT UNTIL THE TRUCK WHICH I WAS ATTEMPTING TO PASS, PASSED ME SO I COULD GO BACK TO THE LEFT LANE CAUSING IRATE MOTORISTS BEHIND ME AND CAUSING A LOT OF SAFETY CONCERNS. IT WAS EXTREMELY DANGEROUS AND I WAS TRAVELING WITH WIFE AND TWO KIDS. *TR

Owner-reported narrative. 24,500 miles reported. Look up ODI 10274065 at NHTSA ↗

I WAS ATTEMPTING TO PASS A BIG SLOW MOVING TRUCK GOING UPHILL WHEN MY VAN SUDDENLY LOST POWER. ANOTHER 18 WHEELED TRUCK WAS BEHIND ME ALSO TRYING TO PASS THE SAME SLOW MOVING TRUCK WHICH WAS ON THE RIGHT LANE. THE TRUCK BEHIND ME HAD TO SLAM ON HIS BRAKES TO AVOID REAR-ENDING ME. I HAD TO WAIT UNTIL THE TRUCK WHICH I WAS ATTEMPTING TO PASS, PASSED ME SO I COULD GO BACK TO THE RIGHT LANE CAUSING IRATE MOTORISTS BEHIND ME AND CAUSING A LOT OF SAFETY CONCERNS. IT WAS EXTREMELY DANGEROUS AND I WAS TRAVELING WITH WIFE AND TWO KIDS. *TR

Owner-reported narrative. 24,500 miles reported. Look up ODI 10274066 at NHTSA ↗

Reported: 2007-07-13 (July 13, 2007)

ON CERTAIN TRUCKS EQUIPPED WITH REAR AIR CONDITIONING SYSTEM, THE INTERIOR LAMP IS EQUIPPED WITH AN 18W LAMP AND A SCATTERING LENS. IN EXTREMELY HOT AND HUMID CONDITIONS, THE COMBINATION OF HEAT AND HUMIDITY, AND THE HEAT FROM THE LAMP DUE TO EXTREME LONG TERM OPERATION, CAN DISTORT THE SCATTERING LENS.

Consequence: THE SWITCHING CONTACTS OF THE LAMP MAY CAUSE A SHORT CIRCUIT OF THE REAR LAMP INCREASING THE RISK OF A FIRE.

Remedy: DEALERS WILL REPLACE THE REAR INTERIOR LAMPS FREE OF CHARGE WITH A MODIFIED VERSION WHICH IS NOT SUBJECT TO THE IMPACTS OF HEAT AND HUMIDITY. THE RECALL BEGAN ON DECEMBER 17, 2007. OWNERS MAY CONTACT DAIMLERCHRYSLER MANUFACTURING INTERNATIONAL AT 1-843-695-5041.

Reported: 2008-07-24 (July 24, 2008)

SPRINTER IS RECALLING 10 MY 2001-2006 DODGE AND FREIGHTLINER 2500 AND 3500 VEHICLES. THE WELDING SEAM BETWEEN THE BRACKET AND STEERING COLUMN OF AFFECTED SPARE PARTS DOES NOT MEET DESIGN SPECIFICATIONS. THE RESULT OF AN OUT OF SPECIFICATION WELDING SEAM IS THAT THE STEERING COLUMN MAY DETACH FROM ITS INTERIOR VEHICLE MOUNTING BRACKET.

Consequence: THE OPERATOR MAY LOSE STEERING ABILITY OF THE VEHICLE INCREASING THE RISK OF A CRASH.

Remedy: DEALERS WILL INSPECT AND REPLACE THE STEERING COLUMNS FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN ON OR BEFORE FEBRUARY 16, 2009. OWNERS MAY CONTACT SPRINTER AT 843-695-5057.

Reported: 2008-12-10 (December 10, 2008)

ILDERTON CONVERSION IS RECALLING 3 MY 2006 SPRINTER DODGE 2500 VANS EQUIPPED WITH RICON PLATFORM STYLE WHEELCHAIR LIFTS. THESE VEHICLES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 404, "PLATFORM LIFT INSTALLATIONS IN MOTOR VEHICLES." THE THRESHOLD WARNING SYSTEM MAY NOT DETECT THE PRESENCE OF A WHEELCHAIR OR MOBILITY AID USER IN A CERTAIN SPOT WITHIN THE DEFINED THRESHOLD AREA.

Consequence: THE USER OF THE LIFT COULD BE INJURED SHOULD THE LIFT MOVE UNINTENTIONALLY.

Remedy: ILDERTON CONVERSION IS WORKING WITH RICON TO CORRECT THE WHEELCHAIR LIFTS FREE OF CHARGE (PLEASE SEE 07E095). OWNERS MAY CONTACT RICON AT 1-818-267-3000 OR ILDERTON CONVERSION AT 1-800-859-6066.

Reported: 2008-12-10 (December 10, 2008)

ILDERTON CONVERSION IS RECALLING 3 MY 2006 DODGE SPRINTER 2500 VANS EQUIPPED WITH RICON PLATFORM STYLE WHEELCHAIR LIFTS. THESE LIFTS FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 403, "PLATFORM LIFT SYSTEM ACCESSIBLE FOR MOTOR VEHICLES." THE ANTI-STOW INTERLOCK MAY NOT DETECT THE PRESENCE OF A WHEELCHAIR OR MOBILITY AID USER. THE PRESSURE SENSING SWITCH THAT DETECTS THE PRESENCE OF WEIGHT ON THE PLATFORM WAS NOT ADJUSTED TO THE NECESSARY SENSITIVITY LEVEL. THE LIFT COULD STOW EVEN THOUGH SOMEONE OR SOMETHING IS STILL ON THE LIFT.

Consequence: A LIFT OCCUPANT CAN BE INJURED SHOULD THE LIFT BEGIN TO STOW UNINTENTIONALLY.

Remedy: ILDERTON CONVERSION IS WORKING WITH RICON TO CORRECT THE WHEELCHAIR LIFTS FREE OF CHARGE (PLEASE SEE 07E097). OWNERS MAY CONTACT RICON AT 1-818-267-3000 OR ILDERTON CONVERSION AT 1-800-859-6066.

Reported: 2016-11-17 (November 17, 2016)

Daimler Vans USA, LLC (DVUSA) is recalling certain model year 2003-2006 Dodge and Freightliner Sprinter 2500 and 3500 vans manufactured June 30, 2003, to August 31, 2006. The instrument cluster on the affected vehicles fails to illuminate the BRAKE warning lamp in the instrument cluster during the vehicle start up bulb-function check. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 105, "Hydraulic and Electric Brake Systems."

Consequence: Without the BRAKE lamp illuminating during the vehicle start up bulb-function check, the driver has no confirmation that the lamp is working and therefore may not know whether or not the lamp will illuminate if the brake fluid level is low. If the operator is unaware that the vehicle has low brake fluid, there would be an increased risk of a crash.

Remedy: DVUSA will notify owners, and DVUSA and Dodge dealers will correct the instrument cluster software, as necessary, free of charge. An interim notification was sent to owners on January 6, 2017. A second notice will be mailed to owners once the remedy becomes available. The recall began on July 27, 2017. Owners may contact DVUSA customer service at 1-770-705-2070.