2006 Dodge MAGNUM: complaints, problems and recalls

I HAVE A 2005 DODGE HEMI MAGNUM. JUST RECENTLY EVERYTIME I DRIVE IT WITH THE WINDOWS UP OR DOWN YOU CAN SMELL AN ENGULFING AMOUNT OF EXHAUST FUMES. I TOOK IT INTO UNDERWOOD DODGE (WOOSTER, OHIO), MADE THEM DRIVE WITH ME SO THEY COULD SMELL IT, AND THEY DID. THEY CALLED TODAY AND SAID THERE IS NOTHING WRONG WITH IT. WELL THAT'S NICE I'M DRIVING AROUND WITH MYSELF, MY WIFE AND KIDS. ARE WE SOMEDAY GOING TO ARRIVE AT OUR DESTINATION WITH SOMEONE DEAD FROM THESE FUMES? WHEN THEY SMELLED THE SMELL HOW CAN THEY SAY THERE IS NOTHING WRONG? *JB

Owner-reported narrative. 2,000 miles reported. Look up ODI 10137624 at NHTSA ↗

I PURCHASED A 2005 DODGE MAGNUM RT IN MARCH OF 05. THE DASH/INSTRUMENT LIGHTS DIMMED NORMALLY TO A LEVEL SAFE FOR NIGHT TIME DRIVING. THEN I PURCHASED A 2006 MAGNUM IN OCT. 05. THE DASH LIGHTS DO NOT DIM TO THE SAME LEVEL AS THE 05 CAR. IN FACT, THEY DON'T DIM ANYWHERE CLOSE. THEY ARE SO BRIGHT ON THE LOWEST SETTING THAT I HAVE TO PUT A TOWEL OVER THE INSTRUMENT CLUSTER AT NIGHT WHICH THEN MAKES THE SPEEDOMETER (A REQUIRED PIECE OF EQUIPMENT) USELESS. THE DODGE COMPANY AND THE DEALER HAVE REFUSED TO ACKNOWLEDGE A PROBLEM AND OR FIX IT. DODGE NE…

Owner-reported narrative. 9 miles reported. Look up ODI 10147079 at NHTSA ↗

DT*: THE CONTACT STATED WHILE DRIVING AT NO PARTICULAR SPEED, THE THROTTLE CONTROL LIGHT ILLUMINATED AND THE VEHICLE LOST POWER. THE VEHICLE DID NOT STALL, HOWEVER THE RPM'S NEVER EXCEEDED 1800. THE VEHICLE WAS TAKEN TO THE LOCAL DEALERSHIP FOR INSPECTION. THE DEALER DETERMINED THE ACCELERATOR PEDAL SENSOR NEEDED REPLACED. AFTER THE SENSOR WAS REPLACED, ANOTHER PROBLEM AROSE. DRIVING AT NO SPECIFIC SPEEDS, A LOUD BANG WAS HEARD COMING FROM THE REAR OF THE VEHICLE IN THE EXHAUST SYSTEM. THE CONTACT DESCRIBED THE SOUND AS A MUFFLED EXPLOSI…

Owner-reported narrative. 1,800 miles reported. Look up ODI 10149529 at NHTSA ↗

THE VEHICLE SURGES BETWEEN 1500-3500 RPM'S AND SOMETIMES AT IDLE. THE PROBLEM COMES AND GOES AND IS OFTEN ACCOMPANIED BY PROBLEMS WITH THE TRANSMISSION SHIFTING. SOMETHIMES AT A STOP THE TRANS WILL NOT DOWN SHIFT AND WHEN I ACCELERATE AGAIN IT IS STUCK IN A HIGH GEAR WHICH HAS MANY TIMES CAUSED ME TO BE PUT IN DANGER WHILE PULLING INTO TRAFFIC, THE CAR WON'T ACCELERATE TO SPEED PROPERLY. IT IS UNERVING TO NEVER KNOW IF IT WILL DRIVE PROPERLY WITHOUT SHIFTING OR SURGING PROBLEMS. IT HAS BEEN DOING THIS FOR 15,000 MILES AND I HAVE TAKEN IT INO…

Owner-reported narrative. 21,000 miles reported. Look up ODI 10170854 at NHTSA ↗

I PURCHASED A 2006 MAGNUM FROM LITHIA OF FAIRFIELD IN MAY OF THIS YEAR, 2006. THE VEHICLE WAS RUNNING FINE FOR THE FIRST FIVE MONTHS (MAY-OCT) WITH THE ONLY DISTRACTION BEING ONE OF THE REAR WINDOWS OPERATED FINE FROM BOTH POWER SWITCHES FOR 90% OF THE TIME. I TOOK IT IN DURING ROUTINE WARRANTY SERVICE AND EXPLAINED TO ONE OF THE SERVICE MANAGERS BUT BECAUSE THE POWER WINDOW SWITCHES WERE OPERABLE THAT DAY I WAS TOLD THERE WAS NOTHING THEY COULD DO (THAT DIDN'T SIT TO WELL WITH ME, BUT I SHRUGGED IT OFF AND SAID OK). IN OCTOBER, A FEW OT…

Owner-reported narrative. 12,500 miles reported. Look up ODI 10173757 at NHTSA ↗

TL*- THE CONTACT STATED THAT WHILE DRIVING HIS 2006 DODGE MAGNUM IF THE VEHICLE GOES OVER 30 MPH THE VEHICLE PULLS TO THE RIGHT EXCESSIVELY. THE CONTACT HAS TAKEN THE VEHICLE TO THE DEALERSHIP(LUMS AUTO CENTER) TEN TIMES AND THEY HAVE ATTEMPTED TO RE-ALIGN THE VEHICLES FRONT END, AS WELL AS, CHANGING THE VEHICLES TIRES. THE CONTACT STATED THAT THE SERVICE MANAGER CONTACTED THE MANUFACTURED ON 01/03/07 TOLD THE MANUFACTURER THAT WERE NOT ABLE TO REPAIR THE VEHICLE AND THEY NEEDED GUIDANCE. THE MANUFACTURER STATED THAT THEY WILL GET BACK TO DEAL…

Owner-reported narrative. Look up ODI 10178418 at NHTSA ↗

TL* - THE CONTACT OWNS A 2006 DODGE. THE ESP, ELECTRONIC STABILIZATION PACKAGE FAILED WHEN DRIVING AT 5 MPH. WHENTHE TIRE SLIPPED A LITTLE WHEN ACCELERATING, THE THROTTLE FAILED AND THE VEHICLE DID NOT MOVE FORWARD, BUT THE ENGINE CONTINUED TO RUN. FOR APPROXIMATELY 3 TO 5 SECONDS THE THROTTLE WOULD NOT RELEASE GAS AND THE VEHICLE WOULD NOT MOVE FORWARD. THE MECHANIC AND THE STAR ENGINEER STATED THAT THE VEHICLE WAS OPERATING NORMALLY. THE FAILURE HAS OCCURRED APPROXIMATELY 50 TIMES, AND OCCURRED EVERY TIME THE VEHICLEWAS DRIVEN. THE …

Owner-reported narrative. 15,000 miles reported. Look up ODI 10183476 at NHTSA ↗

WHEN THE ESP (ELECTRONIC STABILIZATION PACKAGE) IS ENGAGED AND I AM PULLING OUT INTO TRAFFIC AND THE TIRES SLIP, AT ALL, THE THROTTLE RELEASES AND THE CAR GETS NO POWER AND WILL NOT ACCELERATE. THIS LASTS FOR APPROXIMATELY 3-5 SECOND. I HAVE TO TURN THE ESP OFF AS NOT TO GET HIT BY ONCOMING TRAFFIC. THE DEALERSHIP SAID THIS WAS NORMAL EVEN THOUGH WILL I HAD IT IN TO BE CHECKED I DROVE A CHRYSLER 300 WITH ESP AND IT DID THIS BUT THE THROTTLE CONTROL CAME BACK WITHIN FRACTIONS OF A SECOND. NM

Owner-reported narrative. Look up ODI 10183482 at NHTSA ↗

Reported: 2005-10-06 (October 6, 2005)

ON CERTAIN PICKUP TRUCKS, SPORT UTILITY AND PASSENGER VEHICLES EQUIPPED WITH 42RLE AUTOMATIC TRANSMISSIONS, THE CUP PLUG THAT RETAINS THE PARK PAWL ANCHOR SHAFT MAY BE IMPROPERLY INSTALLED. IF THE SHAFT MOVES OUT OF POSITION, THE VEHICLE MAY NOT BE ABLE TO ACHIEVE 'PARK' POSITION.

Consequence: IF THIS OCCURS AND THE PARKING BRAKE IS NOT APPLIED, THE VEHICLE MAY ROLL AWAY AND CAUSE A CRASH WITHOUT WARNING.

Remedy: DEALERS WILL INSPECT THE TRANSMISSIONS AND INSTALL A BRACKET TO ENSURE THE PARK PAWL ANCHOR SHAFT IS RETAINED IN THE PROPER POSITION. THE RECALL BEGAN ON NOVEMBER 28, 2005. OWNERS MAY CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.

Reported: 2006-05-03 (May 3, 2006)

CERTAIN PASSENGER VEHICLES EQUIPPED WITH 2.7 LITER ENGINES AND MK25E BRAKING SYSTEMS MAY EXHIBIT INADEQUATE CLEARANCE BETWEEN THE REAR BRAKE TUBES AND THE EXHAUST GAS RECIRCULATION TUBE. CONTACT BETWEEN THE BRAKE TUBES AND EXHAUST GAS RECIRCULATION TUBE OVER AN EXTENDED PERIOD OF TIME MAY CAUSE THE BRAKE TUBES TO WEAR THROUGH AND CAUSE A BRAKE FLUID LEAK.

Consequence: THIS CAN RESULT IN A DECREASE OF BRAKING FORCE AND THE POTENTIAL FOR AN ENGINE COMPARTMENT FIRE.

Remedy: DEALERS WILL INSPECT THE REAR BRAKE TUBES FOR DAMAGE AND REPLACE THEM FREE OF CHARGE. A CLIP WILL ALSO BE INSTALLED TO SECURE THE BRAKE TUBES TO THE RIGHT FRONT SHOCK TOWER TO MAINTAIN PROPER CLEARANCE TO THE EXHAUST GAS RECIRCULATION TUBE. THE RECALL BEGAN ON JUNE 26, 2006. OWNERS MAY CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.

Reported: 2008-11-06 (November 6, 2008)

CHRYSLER IS RECALLING 20,283 MY 2006-2009 CHARGER AND MAGNUM VEHICLES BUILT WITH THE POLICE PACKAGE AND EQUIPPED WITH A COLUMN SHIFTER. THE GEARSHIFT CABLE MAY BECOME DISENGAGED FROM THE STEERING COLUMN MOUNTING BRACKET AND CAUSE AN INCORRECT TRANSMISSION GEARSHIFT POSITION DISPLAY.

Consequence: THIS COULD ALLOW THE VEHICLE TO MOVE IN AN UNEXPECTED DIRECTION STARTLING THE DRIVER, AND CAUSE A CRASH WITHOUT WARNING.

Remedy: DEALERS WILL ADD A REDUNDANT LOCKING MECHANISM TO THE GEARSHIFT CABLE AT THE MOUNTING BRACKET TO ENSURE PROPER RETENTION AND SHIFT LINKAGE FUNCTION. THE RECALL BEGAN ON NOVEMBER 10, 2008. OWNERS MAY CONTACT CHRYSLER AT 1-800-853-1403.

Reported: 2015-05-26 (May 26, 2015)

Chrysler (FCA US LLC) is recalling certain model year 2005-2009 Dodge Ram 2500, 2004-2008 Dodge Ram 1500 and Durango, 2006-2009 Dodge Ram 3500, 2008-2010 Dodge Ram 4500 and 5500, 2007-2008 Chrysler Aspen, 2005-2010 Chrysler 300, 300C, 300S, and SRT8, 2006-2010 Dodge Charger, 2005-2008 Magnum, 2005-2011 Dodge Dakota, and 2006-2009 Mitsubishi Raider vehicles. The affected vehicles are equipped with a dual-stage driver frontal air bag that may be susceptible to moisture intrusion which, over time, could cause the inflator to rupture.

Consequence: In the event of a crash necessitating deployment of the driver's frontal air bag, the inflator could rupture with metal fragments striking the driver or other occupants resulting in serious injury or death.

Remedy: Owners are advised not to drive their vehicle until the recall repair is complete. Chrysler will notify the affected Chrysler and Dodge owners and Mitsubishi will notify the affected Raider owners. Dealers will replace the driver's frontal air bag inflator, free of charge. The recall began for Chrylser on June 8, 2015. The recall for Mitsubishi started on June 24, 2015. Chrysler and Dodge owners may contact Chrysler customer service at 1-800-853-1403. Mitsubishi owners may call 1-888-648-7820. Chrysler's number for this recall is R25. Note: This recall supersedes recall 14V817 in its entirety. Vehicles that have had their driver side frontal air bag replaced previously need to have their air bag replaced under this recall as well.

Reported: 2016-05-24 (May 24, 2016)

Chrysler (FCA US LLC) expanded the affected population to include 73,712 2005-2009 RAM 2500 trucks produced at the St. Louis North Assembly Plant. With this change, Chrysler is recalling certain model year 2004-2008 RAM 1500, 2005-2009 RAM 2500, 2006-2009 RAM 3500, 2007-2010 RAM 3500 Cab Chassis, 2008-2010 RAM 4500 and 5500 Cab Chassis, 2004-2009 Dodge Durango, 2007-2009 Chrysler Aspen, 2007-2012 Jeep Wrangler, 2008-2012 Dodge Challenger, 2005-2008 Dodge Magnum, 2005-2012 Chrysler 300, 2006-2012 Dodge Charger, 2005-2011 Dodge Dakota, and 2006-2009 Mitsubishi Raider vehicles originally sold, or ever registered, in AL, CA, FL, GA, HI, LA, MS, SC, TX, Puerto Rico, American Samoa, Guam, the Northern Mariana Islands (Saipan), and the U.S. Virgin Islands, or "Zone A." Additionally, unless included in "Zone A" above, Chrysler is also recalling 2004-2008 RAM 1500, 2005-2009 RAM 2500, 2006-2009 RAM 3500, 2007-2009 RAM 3500 Cab Chassis, 2008-2009 RAM 4500 and 5500 Cab Chassis, 2004-2009 Dodge Durango, 2007-2009 Chrysler Aspen, 2007-2009 Jeep Wrangler, 2008-2009 Dodge Challenger, 2005-2008 Dodge Magnum, 2005-2009 Chrysler 300, 2006-2009 Dodge Charger, 2005-2009 Dodge Dakota and 2006-2009 Mitsubishi Raider vehicles originally sold, or ever registered, in AZ, AR, DE, Washington D.C., IL, IN, KS, KY, MD, MO, NE, NV, NJ, NM, NC, OH, OK, PA, TN, VA, and WV, or "Zone B." Lastly, unless included in "Zone A" or "Zone B" above, Chrysler is recalling certain 2005-2008 RAM 2500, 2006-2008 RAM 3500, 2007-2008 RAM 3500 Cab Chassis, 2008 RAM 4500 and 5500 Cab Chassis, 2004-2008 Dodge Durango, 2007-2008 Chrysler Aspen, 2007-2008 Jeep Wrangler, 2008 Dodge Challenger, 2005-2008 Dodge Magnum, 2005-2008 Chrysler 300, 2006-2008 Dodge Charger, 2005-2008 Dodge Dakota, and 2006-2008 Mitsubishi Raider vehicles originally sold, or registered, in AK, CO, CT, ID, IA, ME, MA, MI, MN, MT, NH, NY, ND, OR, RI, SD, UT, VT, WA, WI, and WY.

Consequence: These vehicles are equipped with certain air bag inflators assembled as part of the passenger frontal air bag modules, and used as original equipment or replacement equipment. These inflators may rupture due to propellant degradation occurring after long-term exposure to absolute humidity and temperature cycling. An inflator rupture may result in metal fragments striking the vehicle occupants resulting in serious injury or death.

Remedy: Owners are advised not to drive their vehicle until the recall repair is complete. Chrysler will notify the Chrysler, Dodge, Jeep and RAM owners. Mitsubishi owners will be notified by their company. Dealers will replace the passenger frontal air bag inflator, free of charge. The recall began on March 27, 2017. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is S43. Note: This recall supersedes recall 14V-7700.