2000 Dodge GRAND CARAVAN: complaints, problems and recalls

TRANSMISSION FAILURE OCCURRED AT 58,822 MILES ON THE 2000 DODGE GRAND CARAVAN I OWN. THE PROBLEM WITH MY TRANSMISSION WAS THAT THE SPLINES OF THE FRONT PLANETARY STRIPPED BECAUSE THEY WERE MADE WITH A SOFTER METAL THAN THE UNDERDRIVE CLUTCH HUB. I FEEL THIS IS A DESIGN FLAW THAT DAIMLER CHRYSLER SHOULD ADDRESS. WHEN I CONTACTED DAIMLER CHRYSLER, I WAS TOLD THE PROBLEM WAS MY FAULT, BECAUSE I HAD NOT CHANGED THE TRANSMISSION FLUID AT THE RECOMMENDED SERVICE INTERVAL, AND I WAS 22,000 MILES OUTSIDE OF WARRANTY. HOWEVER, THERE IS NOT A TRANSMIS…

Owner-reported narrative. 58,822 miles reported. Look up ODI 10000438 at NHTSA ↗

MY 7 YEAR-OLD SON WAS KILLED ON 12/21/02 BECAUSE MY 2000 DODGE GRAND CARAVAN WENT INTO GEAR WITH OUT STEPPING ON THE BREAK. THE VAN ROLLED DOWN A DRIVEWAY AND MY SON HAD HIS HEAD OUT THE WINDOW AND HE HIT A TREE AND WAS KILLED. GRANTED I AM PARTIALLY AT FAULT FOR LEAVING CHILDREN UNATTENDED FOR LESS THAN 2 MINUTES BUT THE VAN SHOULD HAVE NEVER BEEN ABLE TO GO OUT OF GEAR WITH OUT STEPPING ON THE BREAK. THIS IS NOT A FAMILY SAFE VEHICLE. I KNOW FOR A FACT I AM NOT THE ONLY PERSON THAT HAS RAN INSIDE BECAUSE THEY FORGOT SOMETHING AND THE CHILDREN…

Owner-reported narrative. Look up ODI 10000634 at NHTSA ↗

TRANSMISSION FAILURE - WHEN PLACED INTO DRIVE THE GEARS FAILED TO ENGAGE (ESPECIALLY WHEN COLD). THIS VAN IS 2+YEARS OLD WITH ~62,000 MILES. FIXED AT SMITH BROTHERS IN OLD SAYBROOK, CT AND REQUIRED NEW PART DUE TO THE FAILURE OF THE CLUTCH HUB IMPUT WHICH BROKE DOWN SENDING METAL PARTS THROUGHOUT THE TRANSMISSION. (VERY EXPENSIVE FOR A CAR THIS NEW!). I CAUGHT THIS PROBLEM EARLY ENOUGH TO AVOID THE POTENTIAL DISASTER OF A HIGH SPEED FAILURE. IN ADDITION, THIS VEHICLE DOES NOT APPEAR TO BE ABLE TO MAINTAIN IT'S FRONT END ALIGNMENT. SINCE PUR…

Owner-reported narrative. 62,215 miles reported. Look up ODI 10000679 at NHTSA ↗

MY 2000 DODGE GRAND CARAVAN SPORT ALL WHEEL DRIVE DEVELOPED A THUMPING NOISE IN THE FRONT DRIVE TRAIN. I TOOK IT TO COUNTY CHRYSLER, HAMBURG, PA - A 5 STAR CHRYSLER DEALERSHIP. THE SERVICE DEPT. THERE TOLD ME THAT IT WAS THE RESULT OF A WORN OUT POWER TRANSFER UNIT. THE COST TO REPLACE IT INCLUDING THE DIAGNOSTIC AND REPAIR LABOR WILL APPROACH $3,000. SINCE THE VAN IS ONLY 3 YEARS OLD AND HAS ONLY 67 THOUSAND MILES ON IT, IT SEEMS LIKE THE POWER TRANSFER UNIT MUST BE EITHER CHEAP OR DEFECTIVE. WITH ONLY THIS MUCH MILEAGE TO HAVE TO REPLACE…

Owner-reported narrative. Look up ODI 10000926 at NHTSA ↗

THE AUTOMATIC TRANSMISSION PAN WAS LEAKING. CONSUMER HAD VEHICLE CHECKED BY A MECHANIC, WHO INDICATED THAT THIS WAS A RESULT OF THE TRANSMISSION PAN BEING MADE WITH SILICONE. THE MECHANIC ALSO STATED THAT THIS IS A COMMON PROBLEM WITH THESE MAKE/MODEL VEHICLE. PLEASE PROVIDE MORE DETAILS.

Owner-reported narrative. 43,000 miles reported. Look up ODI 10001540 at NHTSA ↗

CONSUMER STATED THAT WHEN BUCKLING THE CHILD INTO THE INTEGRATED CHILD RESTRAINT IT WOULD NOT LATCH PROPERLY CAUSING THE CHILD NOT TO BE RESTRAINED PROPERLY. DEALER NOTIFIED. TS

Owner-reported narrative. Look up ODI 10002218 at NHTSA ↗

CONSUMER STATED WHIEL DRIVING, THE TRANSAXLE FAILED, WHICH CAUSED THE TRANSMISSION FLUID TO LEAK.*JB

Owner-reported narrative. Look up ODI 10002596 at NHTSA ↗

THE TRANSAXLE IN THE TRANSMISSION BLEW APART IN THE GEAR CASE AT 76,000 MILES ON OUR 2000 CARAVAN AND NINE DAYS AFTER THIS THE LEFT FRONT AXLE ASSEMBLE WAS SHOT AND HAD TO BE REPLACED.

Owner-reported narrative. 77,500 miles reported. Look up ODI 10003064 at NHTSA ↗

Reported: 2000-09-13 (September 13, 2000)

VEHICLE DESCRIPTION: MINI VANS BUILT WITH 3.3L AND 3.8L ENGINES HAVE FUEL RAILS WITH NITROLE RUBBER O-RING SEALS THAT CAN DEGRADE OVER TIME. FUEL LEAKAGE FROM THE UNDERHOOD FUEL INJECTION FUEL RAIL COULD RESULT, INCREASING THE LIKELIHOOD OF A VEHICLE FIRE.

Consequence: FUEL LEAKAGE IN THE PRESENCE OF AN IGNITION SOURCE CAN RESULT IN A FIRE.

Remedy: DEALERS WILL INSTALL A SEAL ON THE VEHICLE FUEL RAILS TO PREVENT EXTERNAL LEAKAGE OF FUEL FROM THE FUEL RAIL CROSSOVER TUBE, SHOULD THE EXISTING O-RINGS CONTINUE TO DEGRADE. OWNER NOTIFICATION BEGAN ON JANUARY 25, 2002. DUE TO THE LARGE QUANTITY OF VEHICLES INVOLVED IN THIS CAMPAIGN, THE OWNER NOTIFICATION WILL BE PHASED OVER THE NEXT SEVERAL MONTHS. HOWEVER, IF A VEHICLE IS LEAKING FUEL FROM THE O-RINGS, THE VEHICLE SHOULD BE TAKEN INTO A DEALER TO HAVE THIS REPAIRED AS SOON AS POSSIBLE. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.

Reported: 2003-03-07 (March 7, 2003)

CERTAIN PICKUP TRUCK, VAN, AND MINI VAN CONVERSIONS EQUIPPED WITH SOUTHERN COMFORT BUILT RUNNING BOARDS THAT CONTAIN CERTAIN COURTESY LIGHTS MANUFACTURED BY AMERICAN TECHNOLOGY COMPONENTS, INC. THESE UNITS CONTAIN A COURTESY LIGHT OR LIGHTS THAT MIGHT OVERHEAT WHEN THE WIRE HARNESS IS EXPOSED TO EXCESSIVE MOISTURE AND ROAD SALT.

Consequence: THIS OVERHEATING CONDITION CAN CAUSE THE RUNNING BOARD TO MELT OR CAUSE A FIRE.

Remedy: DEALERS WILL REPLACE THE WIRING HARNESS ON THESE RUNNING BOARDS. OWNER NOTIFICATION BEGAN MARCH 7, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT SOUTHERN COMFORT AT 1-800-745-6096.

Reported: 2003-12-10 (December 10, 2003)

ON CERTAIN MINIVANS AND 4X2 PICKUP TRUCKS, THE VEHICLE CERTIFICATION LABEL MAY HAVE GROSS AXLE WEIGHT RATINGS (GAWR) THAT EXCEED THE MAXIMUM TIRE LOAD CAPACITY AS DEFINED IN FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 120, "TIRE SELECTION AND RIMS FOR MOTOR VEHICLES OTHER THAN PASSENGER CARS."

Consequence: IMPROPERLY LOADING YOUR VEHICLE CAN CAUSE TIRE FAILURE AND RESULT IN A CRASH.

Remedy: OWNERS WILL BE PROVIDED WITH VEHICLE CERTIFICATION LABEL OVERLAYS CONTAINING CORRECTED INFORMATION RELATIVE TO VEHICLE GAWR AND TIRE SIZE. OWNER NOTIFICATION BEGAN MARCH 1, 2004. OWNERS SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-992-1997.

Reported: 2004-10-06 (October 6, 2004)

ON CERTAIN MINIVANS, THE DRIVER'S AIR BAG MAY BECOME DISABLED DUE TO A FAILURE OF THE CLOCKSPRING, WHICH IS LOCATED IN THE HUB OF THE STEERING WHEEL.

Consequence: THIS CONDITION WILL MANIFEST ITSELF THROUGH ILLUMINATION OF THE AIR BAG WARNING LAMP, AND COULD EVENTUALLY RESULT IN A DRIVER'S AIR BAG OPEN CIRCUIT, IF THE PART IS NOT REPLACED IN A REASONABLE AMOUNT OF TIME.

Remedy: DEALERS WILL REPLACE THE CLOCKSPRING ASSEMBLY ON ALL COVERED VEHICLES WITH 70,000 MILES OR LESS. FOR THOSE VEHICLES WITH MORE THAN 70,000 MILES, DAIMLERCHRYSLER WILL OFFER AN EXTENDED LIFETIME WARRANTY UNDER WHICH IT WILL REPLACE THE CLOCKSPRING AT NO CHARGE IF IT FAILS. DAIMLERCHRYSLER WILL ALSO REIMBURSE OWNERS WHO HAVE PAID TO HAVE THE CLOCKSPRING REPLACED ON THEIR VEHICLES. THE RECALL BEGAN ON OCTOBER 12, 2004. OWNERS SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.

Reported: 2010-06-17 (June 17, 2010)

ACCESS OPTIONS IS RECALLING CERTAIN TRUCKS AND VANS BUILT ON FORD E150, E350, TOYOTA SIENNA, AND DODGE GRAND CARAVAN CHASSIS AND EQUIPPED WITH VMI/RICON 6-WAY POWER SEAT BASES. THE SIX WAY POWER SEAT BASE MAY HAVE A DEFECTIVE (COLD) WELD ON THE PIVOT PIN WHICH IS WELDED TO THE SWIVEL PLATE. THE WELD COULD FAIL.

Consequence: THE SEAT OCCUPANT MAY BE INJURED IF THE SEAT BASE PIN WERE TO BREAK.

Remedy: THE SWIVEL PLATE WILL BE REPLACED FREE OF CHARGE IF NECESSARY. THE RECALL BEGAN ON JUNE 8, 2010. OWNERS MAY CONTACT ACCESS OPTION AT 831-722-6804.