1993 Dodge GRAND CARAVAN: complaints, problems and recalls

WHEN BRAKES WAS APPLIED WHILE DRIVING AT 45 MPH, VEHICLE LAUNCH FORWARD. CONSUMER TOOK VEHICLE TO THE DEALERSHIP WHO INDICATED THAT THE TRANSMISSION SENSOR NEED TO BE REPLACED. TS

Owner-reported narrative. 171,619 miles reported. Look up ODI 10001112 at NHTSA ↗

CONSUMER STATES THAT THERE VEHICLES' AIRBAG HAS THE SAME DEFECT STATED IN RECALL NUMBER 99 V 113 000, BUT THERE VIN NUMBER IS NOT INCLUDED. PLEASE PROVIDE MORE DETAILS. TS

Owner-reported narrative. Look up ODI 10001194 at NHTSA ↗

WHILE DRIVING THE TRANSMISSION SHIFTED ITSELF INTO NEUTRAL UNTIL THE SPEED DECREASED AND THEN IT AUTOMATICALLY DEFAULTED INTO 2ND GEAR. *NLM

Owner-reported narrative. Look up ODI 10020116 at NHTSA ↗

WHILE TRAVELING ON THE HIGHWAY ABS BRAKING LIGHT APPEARED ON THE DASHBOARD. *AK

Owner-reported narrative. Look up ODI 10027097 at NHTSA ↗

NO BRAKES AT TIMES WHEN THE BRAKE PUMP RUNS. *AK

Owner-reported narrative. 183,260 miles reported. Look up ODI 10028919 at NHTSA ↗

I HAVE A 1993 DODGE GRAND CARAVAN LE & 1994 DODGE GRAND CARAVAN. BOTH ARE DARK BLUE IN COLOR, AND BOTH VANS ARE LOSING THE PAINT FROM THE HOOD, AND TOP OF BOTH CARS, I HAVE FOUND, EVERY BLUE VAN I HAVE SEEN, HAS THIS SAME PROBLEM, HAS THEIR BEEN ANY RECALLS ON THIS PROBLEM! *PH

Owner-reported narrative. Look up ODI 10030984 at NHTSA ↗

VEHICLE IS EXPERIENCING MOMENTARY ABS FAILURE. THERE WAS A RECALL ON THE ABS SYSTEM ISSUED; HOWEVER THIS VEHICLE NOT INCLUDED DUE TO VIN. *AK

Owner-reported narrative. 87,059 miles reported. Look up ODI 10034298 at NHTSA ↗

THE JACK THAT CAME EQUIPPED WITH THE VEHICLE SUDDENLY COLLAPSED WHILE IN USE. CONSUMER BELIEVED THAT THE STATIONERY BOLT WAS DEFECTIVE. *AK UPON INSPECTION IT WAS EVIDENT THAT THE TREADS IN THE STATIONARY BOLT FAILED COMPLETELY. *TS *NLM

Owner-reported narrative. 130,000 miles reported. Look up ODI 10040328 at NHTSA ↗

Reported: 2000-10-12 (October 12, 2000)

VEHICLE DESCRIPTION: MINI VANS EQUIPPED WITH 2-SPOKE LUXURY WHEELS MANUFACTURED JULY 1992 THROUGH JUNE 1993; OR EQUIPPED WITH 4-SPOKE SPORT WHEELS MANUFACTURED FROM JULY 1992 THROUGH SEPTEMBER 1993. THE STEERING WHEEL ARMATURE STAMPING CAN CRACK AND SEPARATE FROM THE CENTER HUB ATTACHMENT TO THE STEERING COLUMN.

Consequence: IF THE STEERING WHEEL SEPARATES FROM THE CENTER HUB ATTACHMENT TO THE STEERING COLUMN, LOSS OF CONTROL CAN OCCUR INCREASING THE RISK OF AN ACCIDENT.

Remedy: DEALERS WILL INSPECT THE STEERING WHEEL FOR CRACKS AND ANY WHEELS WITH CRACKS WILL BE REPLACED. ALL OTHER VEHICLES WILL HAVE A REINFORCEMENT PLATE INSTALLED TO PREVENT STEERING WHEEL SEPARATION IN THE EVENT CRACKING OCCURS.

Reported: 1996-06-13 (June 13, 1996)

THE ABS HYDRAULIC CONTROL UNIT CAN EXPERIENCE EXCESSIVE BRAKE ACTUATOR PISTON SEAL WEAR CAUSING PUMP-MOTOR DETERIORATION.

Consequence: IF THIS CONDITION OCCURS, THE ABS FUNCTION COULD BE LOST AND REDUCED POWER ASSIST WOULD BE EXPERIENCED DURING VEHICLE BRAKING INCREASING THE POTENTIAL FOR A VEHICLE ACCIDENT.

Remedy: DEALERS WILL TEST THE VEHICLE'S ANTI-LOCK BRAKE SYSTEM AND REPAIR THE VEHICLES IF NECESSARY. ALSO THE WARRANTY ON ALL ABS COMPONENTS WILL BE EXTENDED TO 10 YEARS OR 100,000 MILES (EXCEPT FOR THE BRAKE ACTUATOR PISTON ASSEMBLY AND THE PUMP-MOTOR ASSEMBLY WHICH WILL HAVE A LIFETIME COVERAGE). OWNERS WILL ALSO BE REIMBURSED FOR PREVIOUS ABS COMPONENT REPAIR COSTS.

Reported: 1997-09-09 (September 9, 1997)

VEHICLE DESCRIPTION: PASSENGER MINI-VANS. COVERS ON THE SOLID STALK MOUNTED SEAT BELT BUCKLES CAN BECOME DISLODGED CAUSING THE RELEASE BUTTON TO STICK INSIDE THE COVER. THE BUCKLE WOULD THEN BE ONLY PARTIALLY LATCHED.

Consequence: IN THE EVENT OF A VEHICLE CRASH, THE OCCUPANT MAY NOT BE PROPERLY RESTRAINED INCREASING THE RISK OF PERSONAL INJURY.

Remedy: DEALERS WILL INSTALL A COVER RETAINING CLIP TO THE STALK MOUNTED BUCKLE COVER TO PREVENT DISLOCATION OF THE BUCKLE COVER.

Reported: 1997-09-09 (September 9, 1997)

VEHICLE DESCRIPTION: PASSENGER MINI-VANS. THE CENTER REAR SEAT, RIGHT OUTBOARD SIDE, SAFETY BELT ANCHOR HOOK CAN BECOME UNATTACHED FROM THE BODY ANCHOR POSITION.

Consequence: IN THE EVENT OF A VEHICLE CRASH, THE OCCUPANT MAY NOT BE PROPERLY RESTRAINED INCREASING THE RISK OF PERSONAL INJURY.

Remedy: DEALERS WILL REPLACE THE ANCHOR HOOK RETAINING CLIP WITH A REVISED PROFILE CLIP AND A COVER PLATE.

Reported: 1999-05-06 (May 6, 1999)

VEHICLE DESCRIPTION: MINI VANS. THE WIRING THAT INITIATES THE DRIVER AND/OR PASSENGER AIR BAG COULD ELECTRICALLY SHORT CIRCUIT TO GROUND. A SHORT CIRCUIT TO GROUND THAT EXISTS IMMEDIATELY AFTER TURNING THE IGNITION KEY TO THE "ON" OR "START" POSITION CAN CAUSE THE AIR BAG(S) TO INADVERTENTLY DEPLOY.

Consequence: INADVERTENT AIR BAG DEPLOYMENT CAN INJURE A FRONT SEAT OCCUPANT.

Remedy: DEALERS WILL PERFORM AN ELECTRONIC DIAGNOSTIC CHECK. ANY SHORT CIRCUITS IDENTIFIED IN EITHER THE DRIVER'S OR PASSENGER SIDE AIR BAG INITIATOR WIRE CIRCUIT WILL BE REPAIRED.

Reported: 1999-07-16 (July 16, 1999)

VEHICLE DESCRIPTION: MINIVANS. THE LEFT HAND WINDSHIELD WIPER PIVOT DRIVE ARM WAS NOT MECHANICALLY STAKED TO THE PIVOT SHAFT.

Consequence: THIS COULD ALLOW THE DRIVE ARM TO DISENGAGE FROM THE SHAFT LEADING TO A LOSS OF WIPER FUNCTION. THE DRIVER'S VISIBILITY WOULD BE IMPAIRED, INCREASING THE RISK OF A CRASH.

Remedy: DEALERS WILL REPLACE THE LEFT HAND SIDE WINDSHIELD WIPER PIVOT ASSEMBLY.

Reported: 1999-09-02 (September 2, 1999)

VEHICLE DESCRIPTION: MINI VANS. THE BOLTS USED TO ATTACH THE STRUT TO THE BODY AND THE REAR LIFTGATE CAN ACCUMULATE FATIGUE DAMAGE IF THREE FACTORS COMBINE. IF THE BOLT IS LOOSE, THE GAS STRUT IS OVER-PRESSURIZED, AND THE FREQUENCY OF OPENING AND CLOSING CYCLES IS HIGHER THAN FOR THE AVERAGE CUSTOMER, THE BOLT CAN FAIL.

Consequence: PERSONAL INJURY COULD OCCUR IF THE BOLTS BREAK ALLOWING THE LIFTGATE TO FALL SUDDENLY.

Remedy: DEALERS WILL INSPECT FOR LOOSE FASTENERS, IF THE FASTENERS ARE LOOSE, THE STRUT (AND INTEGRAL BOLTS) WILL BE REPLACED. IF THE BOLT SHOWS EVIDENCE OF TORQUE, THE BOLT WILL BE REMOVED, LARGER WASHERS WILL REPLACE THE EXISTING WASHER AND THE BOLT WILL BE REINSTALLED AND HAND TIGHTENED TO THE TARGET TORQUED.