1991 Dodge DYNASTY: complaints, problems and recalls

WHILE DRIVING AT ANY SPEED AND WITHOUT WARNING, THE TRANSMISSION FAILED. *AK *TT *JB

Owner-reported narrative. 106,000 miles reported. Look up ODI 10022197 at NHTSA ↗

I OWN A 1991 DODGE DYNASTY, 3.3 LITER. THE FUEL RAIL STARTED LEAKING AT THE JOINT ON THE FRONT, BEHIND THE VALVE COVER.*AK

Owner-reported narrative. Look up ODI 10104553 at NHTSA ↗

1991 DODGE DYNASTY, 3.3L ENGINE. FUEL RAIL LEAKING, AT CROSSOVER TUBE CONNECTION. FUEL LEAKING DOWN ONTO VAVLE COVER, WHICH THEN LEAKED ONTO HOT EXHAUST MANIFOLD. MINOR FIRE, BUT THANK GOD I WAS IN MY DRIVEWAY WHEN I SMELLED THE FUEL. OPENING THE HOOD REVEALED THE SMALL FIRE THAT STARTED. THE DODGE DEALER WANTS 300.00 FOR THE PART, AND I FEEL CHRYSLER SHOULD PAY FOR THIS PART SINCE IT IS NOT A "WEAR" ITEM, NOR IS IT A MOVING PART, OR IN A LOCATION PRONE TO WEAR. HAD MY WIFE OR MYSELF BEEN DRIVING AND THE FIRE OCCURED, THIS COULD HAVE BEEN A VE…

Owner-reported narrative. 185,000 miles reported. Look up ODI 10108304 at NHTSA ↗

PURCHASED VEHICLE USED OCT. 2006. NEAR MINT CONDITION. POWER EVERYTHING & EVERYTHING FUNCTIONS PERFECT. VEHICLE EMISSIONS PERFECT. APPROX. 4 DAYS AFTER FINAL REGISTRATION WAS SWITCHED, PLATED, & INSURED, I HOPPED ONTO THE FREEWAY, DOING ABOUT 65 MPH. WHEN SUDDENLY IN A MATTER OF SECONDS, I WAS TOTALLY OVERWHELMED BY THE SMELL OF GAS. I BECAME SERIOUSLY NAUSEOUS AND LIGHT HEADED AND HAD TO IMMEDIATELY EXIT THE FREEWAY TO FIND SOMEWHERE TO PULL OVER AS FAST AS I POSSIBLE COULD WITHOUT CAUSING AN ACCIDENT OR MORE SERIOUS A FATALITY. ON…

Owner-reported narrative. 87,000 miles reported. Look up ODI 10171857 at NHTSA ↗

BOTH REAR SET BELTS HAVE TROUBLE BEING PULLED OUT. THEY SEEM TO GET STUCK AND CANNOT BE USED. THIS COULD RESULT IN SERIOUS INJURY OR DEATH TO REAR PASSENGERS. I HAVE YET TO FIX THE PROBLEM. *JB

Owner-reported narrative. 86,000 miles reported. Look up ODI 10175929 at NHTSA ↗

FOR THE THIRD TIME WITHIN A 3 YEAR PERIOD MY CAR WILL START AND RUN FOR ABOUT 2 SECONDS AND TURN OFF, I HAD IT TOWED AND THE MECHANICS WOULD REPLACED THE MAIN COMPUTER, OR SAY THEY DID, AND CHARGE ME A GREAT DEAL OF MONEY. I SEARCHED RECENTLY ON THE INTERNET TO SEE IF OTHERS HAVE HAD THE SAME PROBLEM, AND I FOUND THAT IT IS A DEFECTIVE PART PROBLEM FOUND AT THIS SITE---HTTP://AUTOREPAIR.ABOUT.COM/LIBRARY/A/1F/BL111F.HTM I SHOULD NOT HAVE TO PAY FOR A DEFECTIVE PART WHICH IS TIED IN TO AN ANTI THEFT FEATURE. *JB

Owner-reported narrative. 140,263 miles reported. Look up ODI 10180605 at NHTSA ↗

PURCHASED SAID VEHICLE IN SEPT. 2006 USED. WAS JUST DRIVING AT POSTED SPEED LIMITS IN A COMMUNITY AREA OF PHOENIX, WHEN ALL OF A SUDDEN A LOUD CLACKING NOISE STARTED AS I PULLED UP TO MY DESIGNATION, SO I TURNED OFF THE MOTOR, LIFTED THE HOOD AND IMMEDIATELY NOTICED THAT THE TENSION PULLEY HAD NEARLY COMPLETELY CAME OFF THE MOTOR. IT DID CAUSE THE SERPINTINE BELT TO COME OFF OF ALL THE PULLIES OF THE MOTOR. I HAD TO HAVE THE VEHICLE TOWED HOME, AGAIN FOR THE SECOND TIME SINCE SEPT. 2006. HEN THE VEHICLE WAS AT MY HOME I FINISHED REMOVING THE…

Owner-reported narrative. 25 miles reported. Look up ODI 10186214 at NHTSA ↗

LEAKAGE OF FUEL AT THE FUEL RAIL CONNECTIONS, ABOVE THE VALVE COVERS, WHICH DRAINS ONTO THE MANIFOLD AND COULD START A FIRE. I AM TOLD IT WILL COST OVER $700 TO REPLACE THE PARTS WHICH CANNOT BE BOUGHT ANYWHERE ELSE. *TR

Owner-reported narrative. Look up ODI 10215553 at NHTSA ↗

Reported: 1990-09-04 (September 4, 1990)

FRONT DISC BRAKE CALIPER GUIDE PIN BOLTS MAY NOT HAVE BEEN ADEQUATELY TORQUED AND COULD LOOSEN.

Consequence: THIS COULD CAUSE REDUCED BRAKING EFFECTIVENESS AND COULDRESULT IN AN ACCIDENT.

Remedy: PROPERLY TORQUE FRONT BRAKE CALIPER GUIDE PIN BOLTS TO 250 POUNDS.

Reported: 1991-10-02 (October 2, 1991)

WATER LEAKING UNDER WINDSHIELD COWL IN AREA ABOVE HEATER BLOWER MOTOR RESISTOR BLOCK RESULTS IN CORROSION OF THE RESISTOR TERMINALS.

Consequence: CORROSION OF THE RESISTOR TERMINALS INCREASES ELECTRICALRESISTANCE, LEADING TO OVERHEATING AND POSSBLE IGNITION OF THE WIRING CONNECTORSAND INSULATION, CAUSING A FIRE IN THE COWL AREA.

Remedy: THE BLOWER MOTOR RESISTOR BLOCK WILL BE REPLACED, AND A MASTIC PATCH APPLIED TO SEAL THE COWL AGAINST WATER ENTRY. DAMAGED WIRE CONNECTORS WILL BE REPLACED.

Reported: 1991-07-11 (July 11, 1991)

FRONT OUTBOARD SAFETY BELT MAY BECOME DIFFICULT TO LATCH AND OR UNLATCH DUE TO A WEBBING STIFFENER ENTERING THE BUCKLE HOUSING AND DISLODGING THE BUCKLE LATCH GUIDE.

Consequence: LATCH MAY OPEN DURING ACCIDENT OR SUDDEN STOP, EXPOSINGSEAT OCCUPANT TO INCREASED RISK OF INJURY.

Remedy: REPLACE BUCKLE LATCH ENGAGEMENT.

Reported: 1991-11-01 (November 1, 1991)

THE ANTI-LOCK BRAKE SYSTEM HIGH PRESSURE HOSE MAY LEAK OR DETACH AT ITS CRIMPED END FITTING RESULTING IN THE DISCHARGE OF HYDRAULIC FLUID.

Consequence: FLUID DISCHARGE EVENTUALLY CAUSES THE LOSS OF BOTH THEANTI-LOCK BRAKE SYSTEM AND HYDRAULIC ASSIST FOR THE BRAKE SYSTEM, RESULTING ININCREASED LIKELIHOOD OF BRAKE LOCKUP AND INCREASED STOPPING DISTANCES, WHICHCOULD RESULT IN A VEHICLE ACCIDENT.

Remedy: REPLACE THE ABS HIGH PRESSURE HOSE WITH A HOSE OF DIFFERENT DESIGN AND CONSTRUCTION.

Reported: 1996-06-13 (June 13, 1996)

THE ABS HYDRAULIC CONTROL UNIT CAN EXPERIENCE EXCESSIVE BRAKE ACTUATOR PISTON SEAL WEAR CAUSING PUMP-MOTOR DETERIORATION.

Consequence: IF THIS CONDITION OCCURS, THE ABS FUNCTION COULD BE LOST AND REDUCED POWER ASSIST WOULD BE EXPERIENCED DURING VEHICLE BRAKING INCREASING THE POTENTIAL FOR A VEHICLE ACCIDENT.

Remedy: DEALERS WILL TEST THE VEHICLE'S ANTI-LOCK BRAKE SYSTEM AND REPAIR THE VEHICLES IF NECESSARY. ALSO THE WARRANTY ON ALL ABS COMPONENTS WILL BE EXTENDED TO 10 YEARS OR 100,000 MILES (EXCEPT FOR THE BRAKE ACTUATOR PISTON ASSEMBLY AND THE PUMP-MOTOR ASSEMBLY WHICH WILL HAVE A LIFETIME COVERAGE). OWNERS WILL ALSO BE REIMBURSED FOR PREVIOUS ABS COMPONENT REPAIR COSTS.