2006 Dodge DURANGO: complaints, problems and recalls

I PICKED UP MY BRAND NEW DODGE DURANGO ON JAN 31ST. A SHORT TIME AFTER, I RECEIVED A CALL FROM MY DEALER, PARAMUS DODGE, REGARDING A SAFETY RECALL FOR ABS. I WAS TOLD TO SCHEDULE AN APPOINTMENT TO HAVE THE DEFECT CORRECTED. I SCHEDULED AN APPOINTMENT FOR MONDAY, FEBRUARY 20TH AT 10 A.M. AFTER SITTING AT THE DEALERSHIP FOR APPROXIMATELY 1 1/2 HOURS, THEY INFORMED ME THAT THEY COULD NOT PERFORM THE PROCEDURE BECAUSE THEY DID NOT HAVE THE RIGHT SOFTWARE THAT WOULD ENABLE THEM TO CORRECT THE CONDITION. IT IS QUITE TROUBLING TO ME THAT I WASTED…

Owner-reported narrative. Look up ODI 10150663 at NHTSA ↗

COMPLETE FAILURE OF WINDSHIELD WIPER SYSTEM IN A NATIONAL RENT A CAR 2006 DODGE DURANGO DURING A TORRENTIAL RAINSTORM WHILE TRAVELING 60 MPH IN THE HOV LANE OF I-5 IN HEAVY TRAFFIC FROM LOS ANGELES TO SAN DIEGO. WE SUDDENLY COULD NOT SEE ANYTHING IN FRONT OF US, AND HAD TO CROSS 5 LANES OF TRAFFIC COMING FROM BEHIND AND BESIDE US TO GET TO THE SIDE OF THE ROAD (THERE WAS NO CURB ON THE INNER HOV LANE). WE NARROWLY AVOIDED GET HIT IN DOING SO, AND FEEL FORTUNATE THAT NO ONE WAS INJURED IN THE PROCESS. IT WAS WHAT YOU WOULD CALL THE "PERFECT STOR…

Owner-reported narrative. 9,900 miles reported. Look up ODI 10154345 at NHTSA ↗

DT*: THE CONTACT STATED THE ABS LIGHT ILLUMINATED AND A NOISE CAN BE HEARD FROM THE REAR END. THERE IS A NHTSA RECALL, #05V554000 ON THE VEHICLE REGARDING THE SERVICE BRAKES, HYDRAULIC: ANTILOCK: CONTROL UNIT/MODULE. THE PARTS NEEDED TO REPAIR THE VEHICLE ARE NOT AVAILABLE AT THE LOCAL DEALERSHIP. THE MANUFACTURER CONFIRMED THE PARTS ARE NOT AVAILABLE.

Owner-reported narrative. 4,433 miles reported. Look up ODI 10155789 at NHTSA ↗

MY ABS LIGHT & BRAKE LIGHT COME ON, AND MY PASSENGER AIR BAG TURNS OFF. WHEN THIS HAPPENS, THE VEHICLE BECOMES DIFFICULT TO NAVIGATE AND THE BACK END GET TIGHT. THIS HAS HAPPENED 4 TIMES, AND THE LAST TIME WAS ON A BUSY HIGHWAY, AND I WAS LUCKY TO MISS CAUSING AN ACCIDENT. WE TOOK THE VEHICLE IN ON 4/18/06 AND HAD ALL RECALL WORK DONE, AND THE VEHICLE STILL IS NOT WORKING PROPERLY. THIS LAST INSTANCE SCARED ME TO THE POINT I DO NOT FEEL SAFE DRIVING THE VEHIVLE.

Owner-reported narrative. 2,000 miles reported. Look up ODI 10155826 at NHTSA ↗

WHEN GOING TO RELEASE THE EMERGENCY BRAKE, THE HANDLE BROKE OFF FROM THE CABLE, WAS NOT ABLE TO RELEASE THE BRAKE. *NM

Owner-reported narrative. Look up ODI 10160336 at NHTSA ↗

INTERMITTENT AND SPONTANEOUS ACTIVATION OF THE WINDSHIELD WIPERS AND WASHERS DURING OPERATION OF THE STEERING WHEEL UNDER NORMAL DRIVING CONDITIONS. STEERING WHEEL SOUND SYSTEM CONTROLS WORK ERRATICALLY OR IN REVERSE OF NORMAL FUNCTION. IGNITION REMAINS ENGAGED UNTIL SWITCH IS RECYCLED. SEEMS TO BE LOW TEMPERATURE RELATED( HAPPENS MORE OFTEN IN THE COOLER AM). VEHICLE HAS BEEN TO THE DEALER MULTIPLE TIMES FOR REPAIR ATTEMPTS. CLOCK SPRING,MULTIFUNCTION SWITCH,INDIVIDUAL AUDIO CONTROLS, AND THE FRONT CONTROL MODULE HAVE BEEN REPLACED UNDER WARR…

Owner-reported narrative. 100 miles reported. Look up ODI 10161167 at NHTSA ↗

DT*: THE CONTACT STATED THE VEHICLE IS EQUIPPED WITH THE WRONG SPARE TIRE. WHEN THE DEALER WAS CONTACTED, THEY INDICATED THE SPARE WAS ADEQUATE.

Owner-reported narrative. 300 miles reported. Look up ODI 10164324 at NHTSA ↗

BOTH INNER BRAKE DRUMS OF THE REAR TIRES OF A 2005 DODGE DURANGO WITH APPROXIMATELY 13500 MILES ARE NOT FUNCTIONING PROPERLY. UPON INSPECTION, THE CONTACT SURFACES ARE TOTALLY CORRODED AND SHOW NO SIGNS OF WEAR. AFTER DRIVING A FEW MILES, THE REAR BRAKES SEEM TO SQUEAL AND GRIND WHEN APPLYING THE BRAKE. THE BRAKES CONTINUE TO SQUEAK WHEN ACCELERATING OR MAINTAINING A CONSTANT SPEED UP TO APPROXIMATELY 35 MPH. *JB

Owner-reported narrative. 8,000 miles reported. Look up ODI 10165099 at NHTSA ↗

Reported: 2005-10-06 (October 6, 2005)

ON CERTAIN PICKUP TRUCKS, SPORT UTILITY AND PASSENGER VEHICLES EQUIPPED WITH 42RLE AUTOMATIC TRANSMISSIONS, THE CUP PLUG THAT RETAINS THE PARK PAWL ANCHOR SHAFT MAY BE IMPROPERLY INSTALLED. IF THE SHAFT MOVES OUT OF POSITION, THE VEHICLE MAY NOT BE ABLE TO ACHIEVE 'PARK' POSITION.

Consequence: IF THIS OCCURS AND THE PARKING BRAKE IS NOT APPLIED, THE VEHICLE MAY ROLL AWAY AND CAUSE A CRASH WITHOUT WARNING.

Remedy: DEALERS WILL INSPECT THE TRANSMISSIONS AND INSTALL A BRACKET TO ENSURE THE PARK PAWL ANCHOR SHAFT IS RETAINED IN THE PROPER POSITION. THE RECALL BEGAN ON NOVEMBER 28, 2005. OWNERS MAY CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.

Reported: 2005-12-08 (December 8, 2005)

ON CERTAIN SPORT UTILITY VEHICLES WITH ANTI-LOCK BRAKE SYSTEM (ABS), THE ABS CONTROL MODULE SOFTWARE PROGRAM MAY CAUSE THE REAR BRAKES TO LOCK UP DURING CERTAIN BRAKING CONDITIONS.

Consequence: THIS COULD RESULT IN A LOSS OF VEHICLE CONTROL AND A CRASH COULD OCCUR WITHOUT WARNING.

Remedy: DEALERS WILL REPROGRAM THE ABS CONTROL MODULE. THE RECALL IS EXPECTED TO BEGIN ON DECEMBER 12, 2005. OWNERS MAY CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.

Reported: 2006-02-09 (February 9, 2006)

ON CERTAIN PICKUP TRUCKS AND SPORT UTILITY VEHICLES, A STATIC ELECTRICITY SPARK BETWEEN THE OPERATOR AND THE VEHICLE CAN CAUSE THE TURN SIGNAL, HEADLAMPS OR WINDSHIELD WIPERS TO MALFUNCTION WITHOUT WARNING.

Consequence: THIS CAN IMPAIR THE DRIVER'S VISION AND RESULT IN A CRASH.

Remedy: DEALERS WILL RE-FLASH THE INSTRUMENT CLUSTER. THE RECALL BEGAN ON MARCH 6, 2006. OWNERS MAY CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.

Reported: 2006-02-13 (February 13, 2006)

CERTAIN SPORT UTILITY VEHICLES FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 208, 'OCCUPANT CRASH PROTECTION.' THE WRONG OCCUPANT RESTRAINT CONTROLLER (ORC) WAS INSTALLED ON THESE VEHICLES.

Consequence: THIS CAN CAUSE INCREASED RISK OF INJURY TO THE DRIVER UNDER CERTAIN CRASH CONDITIONS.

Remedy: DEALERS WILL REPLACE THE OCCUPANT RESTRAINT CONTROL MODULE. THE RECALL BEGAN ON FEBRUARY 27, 2006. OWNERS MAY CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.

Reported: 2006-03-08 (March 8, 2006)

ON CERTAIN VANS AND SPORT UTILITY VEHICLES, THE FRONT WINDSHIELD WIPER MOTOR ARMATURE SHAFT MAY BREAK.

Consequence: DURING CERTAIN OPERATING CONDITIONS, LOSS OF FRONT WINDSHIELD WIPING CAPABILITY COULD OCCUR, AND THE DRIVER'S VISION COULD BE OBSCURED WHICH COULD RESULT IN A CRASH.

Remedy: DEALERS WILL INSPECT AND REPLACE THE WINDSHIELD WIPER MOTOR FREE OF CHARGE. THE RECALL BEGAN ON JUNE 19, 2006, TO DODGE DURANGO OWNERS. MINIVAN OWNERS WILL BE NOTIFIED DURING JULY 2006. OWNERS MAY CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.

Reported: 2006-07-07 (July 7, 2006)

ON CERTAIN SPORT UTILITY VEHICLES, THE LEFT REAR SUSPENSION WATTS LINK MAY HAVE BEEN DAMAGED DURING VEHICLE ASSEMBLY AND COULD FAIL.

Consequence: A FAILED WATTS LINK COULD ADVERSELY AFFECT VEHICLE HANDLING AND CAUSE A CRASH WITHOUT WARNING.

Remedy: DEALERS WILL REPLACE THE LEFT REAR SUSPENSION WATTS LINK FREE OF CHARGE. THE RECALL BEGAN ON JULY 19, 2006. OWNERS MAY CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.

Reported: 2007-03-09 (March 9, 2007)

ON SOME SPORT UTILITY VEHICLES, UNDER CERTAIN OPERATING CONDITIONS, AN INTEGRATED CIRCUIT IN THE INSTRUMENT CLUSTER THAT CONTROLS INTERIOR LIGHTING MAY OVERHEAT.

Consequence: THIS COULD POTENTIALLY CAUSE AN INSTRUMENT PANEL FIRE.

Remedy: DEALERS WILL INSPECT THE CLUSTER FOR DAMAGE AND REPLACE IT FREE OF CHARGE. THE RECALL BEGAN ON APRIL 2, 2007. OWNERS MAY CONTACT DAIMLERCHRYSLER AT 1-800-853-140.

Reported: 2015-05-26 (May 26, 2015)

Chrysler (FCA US LLC) is recalling certain model year 2005-2009 Dodge Ram 2500, 2004-2008 Dodge Ram 1500 and Durango, 2006-2009 Dodge Ram 3500, 2008-2010 Dodge Ram 4500 and 5500, 2007-2008 Chrysler Aspen, 2005-2010 Chrysler 300, 300C, 300S, and SRT8, 2006-2010 Dodge Charger, 2005-2008 Magnum, 2005-2011 Dodge Dakota, and 2006-2009 Mitsubishi Raider vehicles. The affected vehicles are equipped with a dual-stage driver frontal air bag that may be susceptible to moisture intrusion which, over time, could cause the inflator to rupture.

Consequence: In the event of a crash necessitating deployment of the driver's frontal air bag, the inflator could rupture with metal fragments striking the driver or other occupants resulting in serious injury or death.

Remedy: Owners are advised not to drive their vehicle until the recall repair is complete. Chrysler will notify the affected Chrysler and Dodge owners and Mitsubishi will notify the affected Raider owners. Dealers will replace the driver's frontal air bag inflator, free of charge. The recall began for Chrylser on June 8, 2015. The recall for Mitsubishi started on June 24, 2015. Chrysler and Dodge owners may contact Chrysler customer service at 1-800-853-1403. Mitsubishi owners may call 1-888-648-7820. Chrysler's number for this recall is R25. Note: This recall supersedes recall 14V817 in its entirety. Vehicles that have had their driver side frontal air bag replaced previously need to have their air bag replaced under this recall as well.

Reported: 2016-05-24 (May 24, 2016)

Chrysler (FCA US LLC) expanded the affected population to include 73,712 2005-2009 RAM 2500 trucks produced at the St. Louis North Assembly Plant. With this change, Chrysler is recalling certain model year 2004-2008 RAM 1500, 2005-2009 RAM 2500, 2006-2009 RAM 3500, 2007-2010 RAM 3500 Cab Chassis, 2008-2010 RAM 4500 and 5500 Cab Chassis, 2004-2009 Dodge Durango, 2007-2009 Chrysler Aspen, 2007-2012 Jeep Wrangler, 2008-2012 Dodge Challenger, 2005-2008 Dodge Magnum, 2005-2012 Chrysler 300, 2006-2012 Dodge Charger, 2005-2011 Dodge Dakota, and 2006-2009 Mitsubishi Raider vehicles originally sold, or ever registered, in AL, CA, FL, GA, HI, LA, MS, SC, TX, Puerto Rico, American Samoa, Guam, the Northern Mariana Islands (Saipan), and the U.S. Virgin Islands, or "Zone A." Additionally, unless included in "Zone A" above, Chrysler is also recalling 2004-2008 RAM 1500, 2005-2009 RAM 2500, 2006-2009 RAM 3500, 2007-2009 RAM 3500 Cab Chassis, 2008-2009 RAM 4500 and 5500 Cab Chassis, 2004-2009 Dodge Durango, 2007-2009 Chrysler Aspen, 2007-2009 Jeep Wrangler, 2008-2009 Dodge Challenger, 2005-2008 Dodge Magnum, 2005-2009 Chrysler 300, 2006-2009 Dodge Charger, 2005-2009 Dodge Dakota and 2006-2009 Mitsubishi Raider vehicles originally sold, or ever registered, in AZ, AR, DE, Washington D.C., IL, IN, KS, KY, MD, MO, NE, NV, NJ, NM, NC, OH, OK, PA, TN, VA, and WV, or "Zone B." Lastly, unless included in "Zone A" or "Zone B" above, Chrysler is recalling certain 2005-2008 RAM 2500, 2006-2008 RAM 3500, 2007-2008 RAM 3500 Cab Chassis, 2008 RAM 4500 and 5500 Cab Chassis, 2004-2008 Dodge Durango, 2007-2008 Chrysler Aspen, 2007-2008 Jeep Wrangler, 2008 Dodge Challenger, 2005-2008 Dodge Magnum, 2005-2008 Chrysler 300, 2006-2008 Dodge Charger, 2005-2008 Dodge Dakota, and 2006-2008 Mitsubishi Raider vehicles originally sold, or registered, in AK, CO, CT, ID, IA, ME, MA, MI, MN, MT, NH, NY, ND, OR, RI, SD, UT, VT, WA, WI, and WY.

Consequence: These vehicles are equipped with certain air bag inflators assembled as part of the passenger frontal air bag modules, and used as original equipment or replacement equipment. These inflators may rupture due to propellant degradation occurring after long-term exposure to absolute humidity and temperature cycling. An inflator rupture may result in metal fragments striking the vehicle occupants resulting in serious injury or death.

Remedy: Owners are advised not to drive their vehicle until the recall repair is complete. Chrysler will notify the Chrysler, Dodge, Jeep and RAM owners. Mitsubishi owners will be notified by their company. Dealers will replace the passenger frontal air bag inflator, free of charge. The recall began on March 27, 2017. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is S43. Note: This recall supersedes recall 14V-7700.