2005 Damon CHALLENGER: complaints, problems and recalls

I ATTEMPTED TO DO A NARRATIVE HERE BEFORE, BUT IT WAS TO LONG FOR YOUR WEB SITE TO ACCEPT. I HAVE THE NARRATIVE TYPED UP AND WILL CONTINUE HERE AND SEE AT THE END HOW I CAN GET THE NARRATIVE TO YOU BUY OTHER MEANS. *NM WHILE DRIVING THE VEHICLE SUFFERED A ENGINE COOLANT LEAK. THE CONSUMER WAS ABLE TO PULL THE VEHICLE OVER ONTO THE SIDE OF THE ROAD. THE SMELL OF THE COOLANT MADE THE CONSUMERS SICK. THE CONSUMER SUFFERED FROM LABORED BREATHING, COUGHING AND THEIR EYES WERE STINGING AND TEARING. THE WARNING LIGHT ILLUMINATED ON THE DASH BUT…

Owner-reported narrative. 1,984 miles reported. Look up ODI 10171307 at NHTSA ↗

TL* THE CONTACT OWNS A 2005 DAMON CHALLENGER RV WITH A WORKHORSE W22 CHASSIS. THE CONTACT STATED RECEIVED NOTIFICATION OF NHTSA CAMPAIGN ID NUMBER: 09V225000 (SERVICE BRAKES, HYDRAULIC) AND THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER FOR REPAIRS. AFTER REPAIRS WHILE DRIVING 55-60 MPH, THE ABS WARNING LIGHT ILLUMINATED AND THE BRAKES FAILED. A LOCAL MECHANIC WAS CONTACTED WHO ADVISED THAT THE PREVIOUS TECHNICIAN HAD NOT PROPERLY TIGHTENED THE BRAKE LINE DOWN TO THE CALIBER. THE AUTHORIZED DEALER WAS CONTACTED AND ADVISED THAT HE WOULD COVER P…

Owner-reported narrative. 14,523 miles reported. Look up ODI 10390069 at NHTSA ↗

Reported: 2006-04-24 (April 24, 2006)

CERTAIN MOTOR HOMES BUILT ON WORKHORSE CHASSIS AND EQUIPPED WITH ACTIA CORPORATE INSTRUMENT CLUSTERS FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 101, "CONTROLS AND DISPLAYS" AND NO. 105, "HYDRAULIC AND ELECTRIC BRAKE SYSTEMS." IF THE BRAKE FAIL INPUT FALLS BELOW A VOLTAGE OF 1.5V, THE BRAKE FAILURE LAMP AND ALARM WILL BE ACTIVATED. ALSO ACTIVATION OF THE ABS TELLTALE WHEN THE ABS IS NOT PROPERLY FUNCTIONING DOES NOT ALWAYS OCCUR.

Consequence: AT NIGHT THE INSTRUMENT CLUSTER LIGHTS MAY FAIL AND THE DRIVER MAY NOT BE ABLE TO SEE THE INSTRUMENT PANEL GAUGES AND THE BRAKE WARNING LIGHT INDICATOR WHICH COULD INCREASING THE RISK OF A CRASH.

Remedy: DAMON IS WORKING WITH WORKHORSE TO CONTACT THE OWNERS AND REMEDY THIS CAMPAIGN . WORKHORSE WILL REPROGRAM THE INSTRUMENT PANEL CLUSTER FREE OF CHARGE. OWNERS MAY CONTACT WORKHORSE AT 1-877-246-7731 OR DAMON AT 1-800-860-3812.

Reported: 2006-06-30 (June 30, 2006)

CERTAIN MOTOR HOMES BUILT ON WORKHORSE CHASSIS MAY HAVE BEEN EQUIPPED WITH INCORRECT STEERING INTERMEDIATE SHAFTS. THE SPLINE CAN STRIP WHILE THE STEERING WHEEL IS BEING TURNED.

Consequence: THIS STEERING CONDITION COULD RESULT IN A LOSS OF STEERING CONTROL, INCREASING THE RISK OF A CRASH.

Remedy: WORKHORSE IS CONDUCTING THIS RECALL (PLEASE SEE 06V148000) AND WILL INSPECT AND, IF NECESSARY, REPLACE THE STEERING INTERMEDIATE SHAFT. OWNERS MAY CONTACT WORKHORSE AT 1-877-294-6773 OR DAMON AT 574-264-2900.

Reported: 2006-11-28 (November 28, 2006)

ON CERTAIN MOTOR HOMES BUILT ON WORKHORSE CHASSIS AND EQUIPPED WITH GM 8.1L V8 ENGINES, IMPROPER HARDENING DURING THE HEAT TREATMENT PROCESS CAN CAUSE THE FUEL RAIL PULSE DAMPER RETAINER CLIP TO FRACTURE, RESULTING IN INADEQUATE RETENTION OF THE DAMPER. IF THE DAMPER BECOMES LOOSE, FUEL COULD BE PUMPED BY THE FUEL PUMP INTO THE UNDER HOOD AREA.

Consequence: IN THE PRESENCE OF AN IGNITION SOURCE, A FIRE COULD RESULT.

Remedy: CHEVROLET AND WORKHORSE ARE HANDLING THE OWNER NOTIFICATION AND REMEDY FOR THIS CAMPAIGN (PLEASE SEE 06V225 AND 06V289). DEALERS WILL REPLACE THE FUEL RAIL PULSE DAMPER RETAINER CLIPS ON THESE ENGINES FREE OF CHARGE. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438, WORKHORSE AT 877-294-6773, OR DAMON AT 1-574-264-5517.

Reported: 2008-10-09 (October 9, 2008)

DAMON IS RECALLING 4,677 MY 2004-2006 CHALLENGER, DAYBREAK, INTRUDER, MY 2004-2005 ESCAPER, ULTRASPORT, AND MY 2005 ASTORIA AND ASTORIA WALDORF MOTOR HOMES EQUIPPED WITH A TWO-DOOR REFRIGERATOR MANUFACTURED BY THE DOMETIC CORPORATION. THE REFRIGERATOR MAY HAVE A DEFECT IN THE BOILER TUBE. PRESSURIZED COOLANT SOLUTION COULD BE RELEASED INTO AN AREA WHERE AN IGNITION SOURCE (GAS FLAME) IS PRESENT.

Consequence: RELEASE OF COOLANT UNDER CERTAIN CONDITIONS COULD IGNITE AND RESULT IN A FIRE.

Remedy: DAMON WILL BE WORKING WITH DOMETIC IN ORDER TO REPAIR THESE REFRIGERATORS (PLEASE SEE 08E032). DOMETIC WILL REPAIR THESE REFRIGERATORS BY INSTALLING A SECONDARY BURN HOUSING, A THERMAL FUSE, AND A MELT FUSE FREE OF CHARGE. DOMETIC HAS RETAINED STERICYCLE INC. TO MANAGE THIS CAMPAIGN. STERICYCLE WILL ASSIST THE OWNER IN LOCATING DEALERSHIPS OR SERVICE CENTERS AND WILL PROVIDE ASSISTANCE WITH SCHEDULING OF APPOINTMENTS. OWNERS MAY CONTACT DOMETIC/STERICYCLE AT 1-888-446-5157 OR DAMON AT

Reported: 2009-06-16 (June 16, 2009)

DAMON IS RECALLING 2,415 MOTORHOMES EQUIPPED WITH AXLES THAT INCLUDE BOSCH ZOPS OR ZOHT PIN SLIDE HYDRAULIC DISC BRAKES. WHEN COMBINED WITH OCCASIONAL OR SEASONAL VEHICLE OPERATION MAY EXPERIENCE CALIPERS STICKING IN THE APPLIED POSITION. THIS CAN RESULT IN ABNORMAL HEAT GENERATION AT THE WHEEL END CAUSING BRAKE DRAG.

Consequence: THE DRIVER WOULD NORMALLY DETECT THE BRAKE DRAG BUT IF UNDETECTED THE TEMPERATURE INCREASE AT THE WHEEL END CAN EVENTUALLY LEAD TO SOFT PEDAL CONDITIONS DUE TO BRAKE FLUID BOIL, AND POSSIBLE EXTENDED STOPPING DISTANCE INCREASING THE RISK OF A CRASH.

Remedy: DEALERS WILL INSPECT AND REPLACE THE NECESSARY COMPONENTS FREE OF CHARGE. WORKHORSE IS HANDLING THE REMEDY AND OWNER NOTIFICATION FOR THIS CAMPAIGN PLEASE SEE 09V-110. OWNERS MAY CONTACT WORKHORSE AT 1-877-246-7731.