1995 Chevrolet SUBURBAN: complaints, problems and recalls

CONSUMER STATES WHILE BRAKING HAD EXTENDED STOPPING. PLEASE PROVIDE ANY ADDITIONAL INFORMATION. TS

Owner-reported narrative. Look up ODI 10001559 at NHTSA ↗

WHILE DRIVING, CONSUMER RODE OVER A SMALL POTHOLE AND A WELD BROKE IN THE STEERING COLUMN WHICH CAUSED THE STEERING WHEEL ASSEMBLY TO BREAK AND FALL INTO THE CONSUMER'S LAP. *JB *TS

Owner-reported narrative. Look up ODI 10003641 at NHTSA ↗

DRIVER SEAT FRAME IS BROKEN, CAUSING SEAT TO ROCK BACK AND FORTH.*JB *TS

Owner-reported narrative. Look up ODI 10007330 at NHTSA ↗

REAR CARGO WINDOW ON PASSENGER SIDE (NOT BACK DOOR GLASS) LEAKS WATER INTO THE "BULKHEAD" AREA. AS WATER BUILDS UP IT EVENTUALLY SPLASES OVER INTO THE CARGO AREA INSIDE THE VEHICLE THEREBY FLOODING THE CARPET, ETC. THIS OCCURS WHENEVER THERE IS RAIN OF ANY SUBSTANTIAL AMOUNT AND IS ONGOING CONTIUOUSLY. SEVERAL AREA SUBURBAN OWNERS ARE EXPERIENCING THIS PROBLEM ANDS NO ONE SEEMS TO HAVE A SOLUTION.*JB

Owner-reported narrative. Look up ODI 10008063 at NHTSA ↗

THE FRONT LEFT CORNER OF THE DRIVER'S SEAT BASE FAILED AT THE POINT WHERE THE SEAT BASE ATTACHES TO THE SLIDER. AS THE SECOND OWNER OF THE VEHICLE, I AM UNSURE OF THE HISTORY. REGARDLESS, HAVING THE DRIVER'S SEAT SO POORLY ATTACHED IS SURELY A SAFETY ISSUE THAT NEEDS SERIOUS ATTENTION. I HAVE READ OTHER COMPLAINTS AND I AM DISAPPOINTED WITH THE APPARENT LACK OF ATTENTION TO THIS MATTER. HOW MANY PEOPLE MUST COMPLAIN OF THE SAME FAILURE OF A SAFETY DEVICE BEFORE THE MANUFACTURER IS HELD ACCOUNTABLE FOR THE DEFECT. WE CANNOT ALL BE MAKING THIS UP…

Owner-reported narrative. 87,650 miles reported. Look up ODI 10010488 at NHTSA ↗

THE SEAT BRACKET ON THE DRIVERS SIDE SEAT BROKE AT THE WELD CAUSING THE SEAT TO SNAP BACKWARDS. THE DEALER HAD THE BRACKET PART ON HAND WHICH INDICATES TO ME THAT THIS IS A COMMON OCCURRENCE. IT IS POTENTIALLY CATASTROPHIC. *NLM

Owner-reported narrative. 80,000 miles reported. Look up ODI 10019234 at NHTSA ↗

METAL BODY OF DRIVER'S SEAT IS FATIGUED AND CRACKED NEAR POINT OF ATTACHMENT TO THE MOUNTING FRAME CONTAINING THE POWER SEAT ADJUSTMENT MOTORS. POINT OF FAILURE IS LEFT FRONT CORNER. *NLM

Owner-reported narrative. 130,000 miles reported. Look up ODI 10020519 at NHTSA ↗

THE DRIVER SIDE SEAT BOTTOM FRAME ASSEMBLY BROKE APART ON MY 1995 CHEV. SUBURBAN. THIS CAUSED THE SEAT TO TIP BACKWARDS. FORTUNATELY I WAS ABLE TO CATCH MYSELF USING THE STEERING WHEEL AND BALANCE IN THE SEAT AND GET THE CAR UNDER CONTROL. I DID NOT CRASH, BUT THIS IS A VERY UNSAFE DESIGN.

Owner-reported narrative. 100,833 miles reported. Look up ODI 10020718 at NHTSA ↗

Reported: 2003-04-28 (April 28, 2003)

ON CERTAIN MINIVANS, PICKUP TRUCKS, AND SPORT UTILITY VEHICLES WITH CERTAIN MODEL-ENGINE COMBINATIONS, THE WINDSHIELD WIPER MOTOR MAY FAIL DUE TO CRACKED SOLDER JOINTS ON THE CONTROLLER CIRCUIT BOARD. THE WINDSHIELD WIPERS COULD WORK INTERMITTENTLY OR NOT AT ALL.

Consequence: IF THIS WERE TO OCCUR DURING BAD WEATHER, DRIVER VISIBILITY WOULD BE REDUCED, WHICH COULD RESULT IN A CRASH.

Remedy: DEALERS WILL REPLACE THE WIPER MOTOR CIRCUIT BOARD AND COVER. OWNER NOTIFICATION BEGAN ON JUNE 19, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020, GMC AT 1-800-462-8782, OR OLDSMOBILE AT 1-800-442-6537.

Reported: 1995-02-16 (February 16, 1995)

DUE TO A THIN CASE CASTING, AN EXTERNAL TRANSMISSION LEAK CAN OCCUR.

Consequence: THIS CONDITION CAN CAUSE TRANSMISSION OIL TO SPRAYONTO THE EXHAUST SYSTEM AND RESULT IN A POSSIBLE VEHICLE FIRE.

Remedy: DEALERS WILL INSPECT THE TRANSMISSION CASE ASSEMBLY FOR THE INVOLVED CASE CASTING. IF THE ASSEMBLY IS INVOLVED, THE TRANSMISSION WILL BE REPLACED.

Reported: 1995-07-26 (July 26, 1995)

THE TRANSMISSION SHIFT-CABLE LOCK CLIP CAN BACK OUT OF ITS INSTALLED POSITION RESULTING IN A LOSS OF CABLE ADJUSTMENT. WHEN THE SHIFT LEVER IS PLACED IN THE "PARK" POSITION, THE "PARK" INDICATOR LIGHT MAY NOT ILLUMINATE.

Consequence: THE VEHICLE CAN MOVE UNINTENTIONALLY IF THE DRIVER DOES NOT NOTICE THAT THE INDICATOR LIGHT IS NOT ON AND DOES NOT APPLY THE PARKING BRAKE.

Remedy: DEALERS WILL ADJUST THE SHIFT CABLE AND INSTALL A LOCK CLIP.

Reported: 1995-07-25 (July 25, 1995)

THE VEHICLES HAVE BOTH THE SUPPLEMENTAL INFLATABLE RESTRAINT (SIR) LABEL AND AN ENGINE START LABEL INSTALLED ON THE SAME SIDE OF THE SUN VISOR. THIS DOES NOT COMPLY WITH FMVSS NO.208, "OCCUPANT CRASH PROTECTION."

Consequence: CONSEQUENCE OF NON-COMPLIANCE: OPERATORS COULD FAIL TO NOTICE AND HEED THE WARNING LABEL.

Remedy: THE ENGINE START LABEL WILL BE REMOVED FROM THE STOWED SIDE OF THE SUN VISOR AND A NEW ENGINE START LABEL WILL BE INSTALLED ON THE HEADLINER IN THE SUN VISOR DEPRESSION. OWNERS WILL RECEIVE THE NEW LABEL AND CAN INSTALL THE LABEL THEMSELVES OR HAVE A DEALER INSTALL IT.

Reported: 1996-04-04 (April 4, 1996)

THESE VEHICLES WERE ASSEMBLED WITH THE THROTTLE CABLE CONTACTING THE DASH MAT WHICH COULD BIND THE THROTTLE. THIS DOES NOT MEET WITH THE MAXIMUM RETURN TIMES REQUIRED BY FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 124, "ACCELERATOR CONTROL SYSTEMS."

Consequence: CONSEQUENCE OF NON-COMPLIANCE: THE ENGINE SPEED MAY NOT RETURN TO IDLE INCREASING THE POTENTIAL FOR A VEHICLE ACCIDENT.

Remedy: DEALERS WILL INSPECT FOR ADEQUATE THROTTLE CABLE TO DASH MAT CLEARANCE, AND IF THERE IS INSUFFICIENT CLEARANCE, CUT OUT A PORTION OF THE DASH MAT TO PROVIDE PROPER CLEARANCE.

Reported: 1998-07-01 (July 1, 1998)

VEHICLE DESCRIPTION: LIGHT DUTY PICKUP TRUCKS AND SPORT UTILITY VEHICLES, 2 AND 4-WHEEL DRIVE. SOLDER JOINTS NEAR THE WIRING HARNESS CONNECTOR CAN CRACK CAUSING THE WINDSHIELD WIPERS TO WORK INTERMITTENTLY.

Consequence: THIS CONDITION CAN RESULT IN INOPERATIVE WIPERS, REDUCING A DRIVER'S VISIBILITY, AND INCREASING THE RISK OF A VEHICLE CRASH.

Remedy: DEALERS WILL REPLACE THE WIPER MOTOR CIRCUIT BOARD AND COVER.