2006 Chevrolet COBALT: complaints, problems and recalls

I AM WRITING THIS LETTER BECAUSE OF CONCERNS I HAVE WITH MY 2006 COBALT I PURCHASED 31 AUGUST 2005. (VIN#1G1AK55F767633 614) MY FIRST CONCERN IS THE SAFETY OF THE CAR. ON THE 25 OF OCTOBER WHILE DRIVING THE CAR THE TRANSMISSION STARTED TO GO OUT OF GEAR AND BACK IN CAUSING A JERKING MOTION AND WHEN I PULLED OVER THE MOTOR STOPPED. I HAD 675 MILES ON IT AT THAT TIME. YESTERDAY I TOOK THE CAR TO THE DEALER AND THEY DROVE IT FOR A FEW MILES WITH NO PROBLEM. NO OTHER CHECK WAS MADE BY THE DEALER ON THE CAR. *NM

Owner-reported narrative. 675 miles reported. Look up ODI 10141164 at NHTSA ↗

2-INCIDENTS OF SUDDEN ACCELERATION AT FREEWAY SPEEDS: THE FIRST TIME THE CRUISE WAS ACTIVATED AND ON HITTING RESUME THE CAR TOOK OFF ON IT'S OWN. THE COAST FUNCTION DID NOT SLOW THE CAR AND TURNING OFF THE CRUISE DID NOT SLOW THE CAR. I WAS IN FAIRLY LIGHT TRAFFIC AND WAS ABLE TO STEER AND BRAKE OUT OF TROUBLE UNTIL THE ACCELERATOR RETURNED TO NORMAL[THE BRAKES ONLY PARTIALLY SLOWED THE CAR BECAUSE OF THE HIGH SPEED INVOLVED]. ABOUT AN HOUR LATER I WAS ENTERING A FREEWAY AND AT ABOUT 40-45 MPH THE ACCELERATOR WENT TO THE FLOOR ON ITS OWN AGAIN …

Owner-reported narrative. 300 miles reported. Look up ODI 10146741 at NHTSA ↗

DT*: THE CONTACT STATED THE VEHICLE STALLED 3 TIMES WITHOUT WARNING. THE FIRST 2 TIMES, AFTER WAITING FOR AN HOUR THE VEHICLE STARTED. THE DEALERSHIP WAS UNABLE TO DUPLICATE THE PROBLEM. THE THIRD TIME THE VEHICLE WOULD NOT START AND WAS TOWED TO THE DEALERSHIP. THE DEALERSHIP DETERMINED THE CRANKSHAFT SENSOR NEEDS TO BE REPLACED. *AK

Owner-reported narrative. 4,460 miles reported. Look up ODI 10147423 at NHTSA ↗

BRAKES FAILED. HIT ANOTHER CAR AT STOP LIGHT. CAR SLOWED BUT WOULD NOT STOP. FELT ABS KICK IN BUT BRAKES ONLY SLOWED CAR DOWN. LESS THAN 5 MPH. NO AIB BAG INFLATION. CAR WAS A LOANER FROM DEALER, WHILE MY CAR WAS BEING WORKED ON. HAD CAR TOWED BACK TO DEALER AND THEY SAID THEY FOUND NO PROBLEM WITH BRAKES. I KNOW HOW TO DRIVE AND I FIND IT HARD TO BELIEVE THAT BRAKES DON'T WORK WHEN YOU USE THEM.*AK

Owner-reported narrative. 2,700 miles reported. Look up ODI 10148860 at NHTSA ↗

DT*: THE CONTACT STATED UNLESS THE AUTOMATIC ON SENSOR DETERMINES IT NECESSARY THE DASH LIGHTS FAIL TO ILLUMINATE. THERE IS NO SWITCH ALLOWING THE CONTACT TO TURN ON THE DASH LIGHTS. ON PAGE 3-14 OF THE OWNER'S MANUAL IT STATES THE DASH LIGHTS ARE SUPPOSE TO ILLUMINATE WHEN THE LIGHTS ARE TURNED ON. ACCORDING TO TITLE 49 OF THE U. S. CODE PART 571.101, PARAGRAPHS S5.3.3 AND S5.3.1 UPDATED 03/15/05

Owner-reported narrative. 90 miles reported. Look up ODI 10151353 at NHTSA ↗

11/24/05 CLUTCH BURNING ODOR, WAS TOLD IT WAS NORMAL EXHAUST COATING BURNING OFF 12/27/05 CLUTCH SLIPPING WHILE ON HIGHWAY, PROCEEDED TO THE DEALERSHIP, WHERE IT TOOK ALMOST 3 WEEKS AND COST ME 1600 DOLLARS TO REPLACE A FAILING CLUTCH. LATER CONFIRMED FOR A PRIVATE MECHANIC THAT THE CLUTCH WAS TOO WEAK FOR THE CARS HP RATING. I AM NOT THE ONLY COBALT SS/SC TO HAVE THIS FAILURE. *NM

Owner-reported narrative. 2,400 miles reported. Look up ODI 10151429 at NHTSA ↗

DT*: THE CONTACT STATED WHILE DRIVING 75 MPH THE CRUISE CONTROL WOULD NOT DEACTIVATE. TO DEACTIVATE THE CRUISE CONTROL THE BRAKES WERE APPLIED AT LEAST 4 TIMES EACH TIME HARDER THAN THE TIME BEFORE IN COMBINATION WITH TURNING THE CRUISE CONTROL OFF. WHEN IT DEACTIVATED THERE WAS A LOUD GRINDING NOISE THAT WAS HEARD. WITHIN THE NEXT 20 MINUTES OF DRIVING THE CRUISE CONTROL ACTIVATED WITHOUT BEING TURNED ON, THIS OCCURRED ON 2 OCCASIONS. IT WAS DEACTIVATED IN THE SAME MANOR AS STATED BEFORE. THE VEHICLE WAS TAKEN TO DEALER FOR INSPECTION. …

Owner-reported narrative. 4,250 miles reported. Look up ODI 10151469 at NHTSA ↗

DT*: THE CONTACT STATED WHILE ATTEMPTING TO APPLY BRAKE PRESSURE AT 40 MPH THE VEHICLE HIT ANOTHER VEHICLE FROM BEHIND AND THE AIRBAGS DID NOT DEPLOY. A POLICE REPORT WAS FILED AT THE SCENE AND THERE WERE NO INJURIES. THE VEHICLE SUSTAINED FRONT END DAMAGE. IT WAS TOWED TO THE DEALERSHIP AND THE FRONT END WAS REPLACED. THE MANUFACTURER WAS CONTACTED. *AK

Owner-reported narrative. 2,567 miles reported. Look up ODI 10152196 at NHTSA ↗

Reported: 2007-01-18 (January 18, 2007)

CERTAIN PASSENGER VEHICLES NOT EQUIPPED WITH OPTIONAL ROOF-MOUNTED SIDE IMPACT AIR BAGS FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 201, 'OCCUPANT PROTECTION IN INTERIOR IMPACT.'

Consequence: IN A CRASH, HEAD IMPACT PROTECTION MAY BE INADEQUATE.

Remedy: DEALERS WILL INSTALL ENERGY ABSORBING PLASTIC TO THE HEADLINER TRIM TO REDUCE THE SEVERITY OF HEAD IMPACTS IN A CRASH. THE RECALL BEGAN ON MARCH 21, 2007. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438.

Reported: 2009-10-29 (October 29, 2009)

GENERAL MOTORS IS RECALLING CERTAIN MODEL YEAR 2006 CHEVROLET COBALT AND SATURN ION VEHICLES ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN THE STATES OF ARIZONA AND NEVADA; AND MODEL YEAR 2007 CHEVROLET COBALT, PONTIAC G5 AND SATURN ION VEHICLES ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN THE STATES OF ARIZONA, CALIFORNIA, FLORIDA, NEVADA AND TEXAS. THE PLASTIC SUPPLY OR RETURN PORT ON THE MODULAR RESERVOIR ASSEMBLY MAY CRACK. IF EITHER OF THESE PORTS DEVELOPS A CRACK, FUEL WILL LEAK FROM THE AREA. IF THE CRACK BECOMES LARGE ENOUGH, FUEL MAY BE OBSERVED DRIPPING ONTO THE GROUND AND VEHICLE PERFORMANCE MAY BE AFFECTED.

Consequence: FUEL LEAKAGE, IN THE PRESENCE OF AN IGNITION SOURCE, COULD RESULT IN A FIRE.

Remedy: DEALERS WILL REPLACE THE FUEL PUMP MODULE FREE OF CHARGE. A SPECIAL COVERAGE WILL BE IMPLEMENTED IN THE SAME TIME FRAME FOR MODEL YEAR 2006 VEHICLES REGISTERED IN ALABAMA, ARKANSAS, CALIFORNIA, FLORIDA, GEORGIA, HAWAII, LOUISIANA, MISSISSIPPI, NORTH CAROLINA, NEW MEXICO, OKLAHOMA, SOUTH CAROLINA, TENNESSEE AND TEXAS AND MODEL YEAR 2007 VEHICLES REGISTERED IN: ALABAMA, ARKANSAS, GEORGIA, HAWAII, LOUISIANA, MISSISSIPPI, NORTH CAROLINA, NEW MEXICO, OKLAHOMA, SOUTH CAROLINA AND TENNESSEE. THE SAFETY RECALL IS EXPECTED TO BEGIN ON OR BEFORE FEBRUARY 4, 2010. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438, SATURN AT 1-800-972-8876 AND PONTIAC AT 1-800-620-7668 OR AT THE OWNER CENTER AT WWW.GMOWNERCENTER.COM.

Reported: 2010-03-03 (March 3, 2010)

GENERAL MOTORS IS RECALLING CERTAIN MODEL YEAR 2005-2010 CHEVROLET COBALT AND MODEL YEAR 2007-2010 PONTIAC G5 VEHICLES EQUIPPED WITH ELECTRIC POWER STEERING. THE DRIVER MAY EXPERIENCE A SUDDEN LOSS OF POWER STEERING ASSIST THAT COULD OCCUR AT ANY TIME WHILE DRIVING.

Consequence: IF POWER STEERING ASSIST IS LOST, IT WOULD REQUIRE GREATER DRIVER EFFORT AT LOW VEHICLE SPEEDS, INCREASING THE RISK OF A CRASH.

Remedy: DEALERS WILL REPLACE THE ELECTRIC POWER STEERING MOTOR FREE OF CHARGE. OWNERS ARE BEING NOTIFIED ON A ROLLING BASIS BETWEEN MARCH 29 THROUGH NOVEMBER 2010. A COPY OF THE MAILING SCHEDULE IS LOCATED IN THE RECALL FILE. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438 AND PONTIAC AT 1-800-620-7668 OR AT THE OWNER CENTER AT WWW.GMOWNERCENTER.COM.

Reported: 2014-02-10 (February 10, 2014)

This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on February 10, 2014 that they are recalling 619,122 model year 2005-2007 Chevrolet Cobalt, and 2007 Pontiac G5 vehicles. On February 25, 2014, GM increased the recall to include an additional 748,024 model year 2006-2007 Chevrolet HHR and Pontiac Solstice vehicles and 2003-2007 Saturn Ion vehicles and 2007 Saturn Sky vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine. On March 27, 2014, GM notified the agency that the defective ignition switches may have been used as service replacement parts on other vehicles, and as a result GM will be recalling certain model year 2008-2010 Chevrolet Cobalt, Saturn Sky, and Pontiac G5 and Solstice, and 2008-2011 Chevrolet HHR vehicles. The part numbers for the service parts are 10392423 (a/k/a ACDelco D1461F), 10392737, 15857948, 15854953, 15896640, and 25846762. This expansion represents an additional 823,788 vehicles.

Consequence: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.

Remedy: GM will notify owners, and dealers will replace the ignition switch, free of charge. An interim notification was issued to owners of 2007 and earlier models on March 10, 2014, informing them of the safety defect. Owners of 2008 and later vehicles will be mailed an interim letter on April 21, 2014. All affected owners will receive another letter once parts are available. The recall began on April 18, 2014. Owners may contact Chevrolet at 1-800-222-1020, Pontiac at 1-800-762-2737 or Saturn at 1-800-553-6000. GM's number for the initial recall is 13454 and 14063 for the expansion. GM’s recall number for the vehicles that may have received the replacement parts is 14092. Note: Until the recall repairs have been performed, it is very important that customers remove all items from their key rings, leaving only the vehicle key. The key fob (if applicable), should also be removed from the key ring. Always wear your seatbelt.

Reported: 2014-04-10 (April 10, 2014)

General Motors LLC (GM) is recalling certain model year 2005-2010 Chevrolet Cobalt, 2006-2011 Chevrolet HHR, 2007-2010 Pontiac G5, 2006-2010 Pontiac Solstice, 2003-2007 Saturn Ion, and 2007-2010 Saturn Sky vehicles. In the affected vehicles, the key can be removed from the ignition when the ignition is not in the "Off" position.

Consequence: If the key can be removed from the ignition when the ignition is not in the "off" position, the vehicle could roll away: (a) for an automatic transmission, if the transmission is not in the "Park" position; or (b) for a manual transmission, if the parking brake is not engaged and the transmission is not in the "Reverse" position. This potential for rollaway increases the risk for a crash and occupant or pedestrian injuries.

Remedy: General Motors will notify owners, and for vehicles that were built with the defective ignition cylinder and have not previously had the ignition cylinder replaced with the redesigned part, dealers will replace the ignition cylinder and cut and, if necessary, re-learn two ignition/door keys for each vehicle. For vehicles that were built with the redesigned ignition cylinder or had the ignition cylinder replaced with the redesigned part, dealers will cut and, if necessary, re-learn two ignition/door keys for each vehicle. The recall began on April 18, 2014. Chevrolet owners may contact General Motors at 1-800-222-1020, Pontiac owners at 1-800-762-2737, and Saturn owners at 1-800-553-6000. General Motors' number for this recall is 14113 for the ignition lock cylinder and key replacement, and 14133 for only key replacements. Note: Until a vehicle has been remedied, owners and operators are advised that when exiting, to be sure that the vehicle is in "Park," or in the case of a manual transmission, that the vehicle is in the "Reverse" position and the parking brake is engaged.