2004 Buick RENDEZVOUS: complaints, problems and recalls

INSTRUMENT PANEL READING OF THE NUMBERS IS NOT CLEAR FOR CONSUMER TO SEE, ESPECIALLY WHEN HE PUTS HIS GLASSES ON. DRIVER TOOK VEHICLE TO THE DEALER, AND THE MECHANIC DID NOT HAVE AN ANSWER AT THIS TIME. *AK THE PROBLEM IS THAT THE GRAY ON GRAY PANEL WAS IN A SIX INCH RECESS DASH WHICH SHADES PENCIL THIN NUMBERS AND SLASHES BETWEEN NUMBERS E.G., 55/60. THE MOST SERIOUS PROBLEM WAS THE CLARITY OF THE SPEEDOMETER READINGS GOING NORTH, SOUTH, EAST, OR WEST. (COULD NOT BE READ AT A GLANCE) *SC

Owner-reported narrative. 75 miles reported. Look up ODI 10042509 at NHTSA ↗

AIR BAG LIGHT ILLUMINATED AND REMAINED ON WHILE DRIVING 35 MPH. CONSUMER TOOK VEHICLE TO THE DEALER. THEN, DEALER INFORMED THE CONSUMER THAT FRONT DRIVER'S AIR BAG HAD TO BE REPLACED. DEALER WAS WAITING FOR THE PARTS. *AK

Owner-reported narrative. 1,432 miles reported. Look up ODI 10056125 at NHTSA ↗

GAS TANK NECK ON THE GAS TANK SNAPPED OFF WHEN HIT BY ROAD DEBRIS. AFTER DISCOVERING GAS SPILLING WHILE REFILLING , I NOTICED THE NECK ON THE GAS TANK WHERE THE FILLER HOSE CONNECTS TO THE GAS TANK (AT THE LOWEST POINT WHERE THE FILLER HOSE ENDS AND CONNECTS ONTO THE GAS TANK) HAD SNAPPED OFF. IT IS MY OPINION THE VEHICLE DESIGN LEAVES THE LOW HANGING HOSE (LIKE A RADIATOR HOSE) THAT CONNECTS TO THE NECK OF GAS TANK WAY OVER EXPOSED WITHOUT ANY SHEILDING FOR ROAD HAZARDS...IE DEBRIS...LUCKY FOR ME IT BROKE OF WHEN MY TANK WAS LOW. REPLACENT O…

Owner-reported narrative. 15,500 miles reported. Look up ODI 10062519 at NHTSA ↗

THE FOLLOWING ARE THE SYMPTOMS WHICH I EXPERIENCED WITHIN 1-3 MILES OF LEAVING YOUR DEALERSHIP: 1.TRANSMISSION DISENGAGED 2.ENGINE RACED 3.TRANSMISSION REENGAGED 4.THE VEHICLE LURCHED FORWARD, CAUSING ME TO HAVE TO BREAK TO AVOID AN ACCIDENT 5.SPEEDOMETER READINGS WERE ALL OVER THE DIAL AND NOT INDICATIVE OF SPEEDS ACTUALLY TRAVELED. WHEN THE ABOVE WAS NOT HAPPENING THE TRANSMISSION SHIFTED VERY UNEVENLY*AK

Owner-reported narrative. 1,800 miles reported. Look up ODI 10062524 at NHTSA ↗

WHILE DRIVING ON THE INTERSTATE DEBRIS HIT THE VEHICLE. CONSUMER STOPPED TO FUEL THE VEHICLE, AND GASOLINE LEAKED UNDER THE VEHICLE. CONSUMER FOUND THAT THE DEBRIS HIT THE FUEL TANK NECK AND CAUSED THE NECK TO BREAK. VEHICLE WAS TAKEN TO THE DEALER, WHO HAD TO REPLACE THE FUEL TANK. *AK

Owner-reported narrative. 16,000 miles reported. Look up ODI 10063433 at NHTSA ↗

WHILE DRIVING 65 MPH, THE REAR DRIVER SIDE TIRE BLEW OUT. THE CONSUMER MANAGED TO PULL OVER AND PUT ON A SPARE TIRE. *AK ALSO IN QUESTION TIRE AND OR DOT#F88DDP1156) *SC *JB

Owner-reported narrative. 1,700 miles reported. Look up ODI 10064615 at NHTSA ↗

WHILE TRAVELING AT 30 MPH ANOTHER VEHICLE THAT WAS TRAVELING AT 45 AND HIT CONSUMER'S VEHICLE ON THE PASSENGER'S SIDE. UPON IMPACT, NONE OF THE VEHICLES AIRBAGS DEPLOYED. *AK

Owner-reported narrative. Look up ODI 10072064 at NHTSA ↗

WHILE PRESSING DOWN ON THE HORN, IT FAILED. THE DEALER HAD INSPECTED THE VEHICLE SEVERAL TIMES AND COULD NOT DUPLICATE THE PROBLEM. *JB

Owner-reported narrative. Look up ODI 10074275 at NHTSA ↗

Reported: 2003-11-10 (November 10, 2003)

ON CERTAIN PASSENGER VEHICLES, A WELD BETWEEN THE FUEL TANK INLET CHECK VALVE AND THE FUEL TANK CAN FAIL.

Consequence: IF THESE PARTS SEPARATE, THE DRIVER MAY NOTICE AN ODOR OF FUEL, THE SERVICE ENGINE SOON OR CHECK ENGINE LIGHT MAY ILLUMINATE, AND/OR FUEL MAY LEAK ONTO THE GROUND. FUEL LEAKAGE IN THE PRESENCE OF AN IGNITION SOURCE COULD RESULT IN A FIRE.

Remedy: DEALERS WILL INSPECT THE SERIAL NUMBER OF THE FUEL TANK TO SEE IF IT IS ON THE LIST OF AFFECTED TANKS. IF THE SERIAL NUMBER MATCHES, THE FUEL TANK WILL BE REPLACED. OWNER NOTIFICATION BEGAN NOVEMBER 4, 2003. OWNERS SHOULD CONTACT BUICK AT 1-866-608-8080 OR PONTIAC AT 1-800-620-7668.

Reported: 2004-03-29 (March 29, 2004)

ON CERTAIN SPORT UTILITY VEHICLES, A STRUCTURAL SUPPORT AT THE LATCH ATTACHMENT IN THE REAR LIFTGATE MAY BE INADEQUATE TO RETAIN THE LATCH TO THE LIFTGATE IN CERTAIN SEVERE VEHICLE CRASH EVENTS.

Consequence: IF THE LIFTGATE WERE TO OPEN IN A VEHICLE CRASH, AN OCCUPANT COULD BE EJECTED FROM THE VEHICLE RESULTING IN INCREASED RISK OF PERSONAL INJURY.

Remedy: DEALERS WILL ADD STRUCTURAL REINFORCEMENTS TO THE LIFTGATE IN THE AREA ADJOINING THE LATCH ASSEMBLY. OWNER NOTIFICATION SCHEDULE BEGAN ON JUNE 21, 2004. OWNERS SHOULD CONTACT BUICK AT 1-866-608-8080. THIS IS AN EXPANSION TO A PREVIOUS RECALL (03V211).

Reported: 2005-04-20 (April 20, 2005)

ON CERTAIN SPORT UTILITY VEHICLES, CONTAMINATION ON IGNITION RELAY CONTACTS CAN CAUSE HIGH RESISTANCE. THIS CAN AFFECT SIGNALS TO THE POWERTRAIN CONTROL MODULE AND, COULD CAUSE INTERMITTENT VEHICLE STALLS AT ANY TIME.

Consequence: THE VEHICLE CANNOT BE RESTARTED IMMEDIATELY. IF THIS WERE TO OCCUR, IT COULD RESULT IN A VEHICLE CRASH.

Remedy: DEALERS WILL REPLACE THE IGNITION RELAY FREE OF CHARGE. THE RECALL BEGAN ON MAY 4, 2005. OWNERS MAY CONTACT PONTIAC AT 1-800-620-7668 AND BUICK AT 1-866-608-8080.

Reported: 2007-08-08 (August 8, 2007)

ON CERTAIN VEHICLES, VARIATIONS IN THE MANUFACTURING PROCESS OR EXPOSURE TO HIGH AMBIENT TEMPERATURES MAY LEAD TO FRACTURE OF THE FUEL TANK INLET CHECK VALVE (ICV).

Consequence: A FRACTURE MAY ALLOW FUEL VAPORS TO PASS THROUGH AND ALLOW DROPLETS OF FUEL TO ACCUMULATE ON THE SIDE OF THE FUEL TANK. FUEL LEAKAGE, IN THE PRESENCE OF AN IGNITION SOURCE, COULD RESULT IN A FIRE.

Remedy: DEALERS WILL REPLACE THE FUEL TANK. THE RECALL WILL BE MAILED IN TWO PHASES WITH THE FIRST PHASE BEGINNING ON DECEMBER 4, 2007. THE SECOND PHASE WILL BE MAILED ON DECEMBER 13, 2007. OWNERS MAY CONTACT BUICK AT 1-866-608-8080; CHEVROLET AT 1-800-630-2438; OR PONTIAC AT 1-800-620-7668. THE VEHICLE POPULATION INCLUDES BUICK RENDEZVOUS AND PONTIAC AZTEK VEHICLE BUILT IN MAY 2003; CHEVROLET VENTURE AND PONTIAC MONTANA VEHICLES BUILT FROM JUNE THROUGH AUGUST 2002; AND ALL VEHICLES REGISTERED IN NEVADA, ARIZONA, VIRGIN ISLANDS, PUERTO RICO, AND HAWAII.