2007 Bmw R 1200 GS: complaints, problems and recalls

CRACKS IN THE PLASTIC TOP FLANGE OF THE FUEL PUMP ASSEMBLY RESULTED IS A SPRAY OF FUEL WHEN SYSTEM UNDER OPERATING PRESSURE (IE. ENGINE RUNNING). THIS 4 YEAR OLD MOTORCYCLE IS CURRENTLY NOT TO SAFE TO OPERATE AND IS OUT OF COMMISSION UNTIL TRAILERED TO A REPAIR FACILITY. THE FUEL SPRAY SOURCE APPEARS AROUND THE FEMALE THREADED 'HUB' OF THE FLANGE THAT ACCEPTS THE MALE THREADED 'QUICK DISCONNECT' OF THE FUEL LINE. THE FAILURE (OR CRACKING) APPEARS TO BE SPONTANEOUS, AS NO PRIOR EVIDENCE (GASOLINE ODOR) WAS NOTICED. THIS MOTORCYCLE HAS BEEN DEA…

Owner-reported narrative. 14,944 miles reported. Look up ODI 10420291 at NHTSA ↗

WHILE RIDING DURING NORMAL OPERATIONS MY FRONT BRAKES ENGAGE AND LOCK UP THE FRONT TIRE, STOPPING THE MOTORCYCLE IN PLACE. THIS HAS HAPPENED ON MULTIPLE OCCASIONS. WHEN THIS HAPPENS WHILE MAKING A TURN I DROPPED THE MOTORCYCLE, LEFT THE TIRE LOCKED UP, UNABLE TO MOVE THE MOTORCYCLE IN TRAFFIC. *TR

Owner-reported narrative. 13,000 miles reported. Look up ODI 10450888 at NHTSA ↗

TL* THE CONTACT OWNS A 2007 BMW GSR1200 MOTORCYCLE. THE CONTACT STATED THAT THE REAR WHEEL SEIZED ABNORMALLY. THE CONTACT OPENED THE RESERVOIR FOR THE BRAKE CHAMBER AND FOUND THAT THE RUBBER WAS SEVERELY WORN. THE CONTACT ALLOWED THE VEHICLE TO COOL DOWN AND THE FAILURE WAS CORRECTED TEMPORARILY. THE FAILURE RECURRED LATER WHILE THE CONTACT WAS DRIVING AT HIGHWAY SPEEDS. THE STEERING WHEEL SEIZED ABNORMALLY AND THE VEHICLE WAS FLIPPED OVER. THE CONTACT SUSTAINED INJURIES TO THE KNEES. THE CONTACT LATER DISCONNECTED THE ABS BRAKE SYSTEM AND THE …

Owner-reported narrative. 46,000 miles reported. Look up ODI 10453832 at NHTSA ↗

FUEL PRESSURE CONTROL MODULE FAILED WITHOUT WARNING LEAVING ME STRANDED IN THE MIDDLE OF THE FREEWAY. PART WAS REPLACED UNDER WARRANTY BUT FAILED AGAIN, LEAVING ME STRANDED AGAIN, ON JUNE 7, 2011. WAS TOLD BY THE DEALER THAT THIS WAS 'RARE'. SEEMS LIKE AN UNSAFE CONDITION TO ME. *TR

Owner-reported narrative. 14,202 miles reported. Look up ODI 10454396 at NHTSA ↗

THE BRAKE FAILURE LIGHT CAME ON AT THE BEGINNING OF AN EXTENDED TRIP. I PULLED OVER, SHUT THE MOTORCYCLE OFF, RESTARTED THE MOTORCYCLE, AND THE BRAKE FAILURE LIGHT CONTINUED. BMW SERVICE SAID THE ABS CONTROL MODULE HAD FAILED, AND AS A RESULT NO ABS BRAKES WERE AVAILABLE ON THE MOTORCYCLE, WHICH COULD HAVE RESULTED IN A CRASH. BMW CHARGED $1000 FOR THE PART, PLUS LABOR, AND HAS ON TWO OCCASIONS SINCE THE REPLACEMENT, REFUSED TO PARTIALLY REIMBURSE FOR THIS PART OR ACKNOWLEDGE THAT THEY MAY HAVE A SERIOUS SAFETY ISSUE. *TR

Owner-reported narrative. 7,800 miles reported. Look up ODI 10467998 at NHTSA ↗

TL* THE CONTACT OWNS A 2007 BMW R1200 GS MOTORCYCLE. THE CONTACT STATED THAT THE LOW BEAM RUNNING LIGHTS BURNED OUT EXTREMELY QUICK. THE CONTACT WAS UNABLE TO SEE THE ROADWAY BECAUSE THE FAILURE WOULD OCCUR SPORADICALLY. THE VEHICLE WAS TAKEN TO THE DEALER WHO ADVISED THAT THE FAILURE WAS CAUSED BY THE BULBS, WHICH THEY RECOMMENDED THE CONTACT REPLACE. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 7,000 AND THE CURRENT MILEAGE WAS 43,000.

Owner-reported narrative. 7,000 miles reported. Look up ODI 10474476 at NHTSA ↗

DURING ROUTINE SERVICE, IT WAS NOTED THAT THE REAR WHEEL FLANGE HAD DEVELOPED STRESS FRACTURES IN 3 OF 5 BRAKE ROTOR MOUNTING POINTS. INTERNET INVESTIGATION HAS REVEALED THAT THIS IS A COMMON OCCURRENCE FOR R1200 SERIES BMW MOTORCYCLES. THE REPLACEMENT OEM PART HAS BEEN REDESIGNED MULTIPLE TIMES IN AN APPARENT ATTEMPT TO PREVENT RECURRENCE. COMPLETE FAILURE OF THIS PART HAS BEEN DOCUMENTED BY OWNERS, LEADING TO VEHICLE DAMAGE AND RISK OF LOSS OF CONTROL. THERE HAVE BEEN INCIDENTS WHERE WHEEL MOUNTS HAVE EXPERIENCE SIMILAR STRESS CRACKS. *…

Owner-reported narrative. 48,000 miles reported. Look up ODI 10536113 at NHTSA ↗

TL* THE CONTACT OWNS A 2007 BMW R 1200 GS MOTORCYCLE. THE CONTACT STATED THAT THE FUEL PUMP WAS LEAKING. THE MANUFACTURER WAS CONTACTED ABOUT THE FAILURE. THE VEHICLE WAS NOT REPAIRED OR DIAGNOSED. THE FAILURE MILEAGE WAS APPROXIMATELY 47,000. UPDATED 10/29/13*LJ THE FLANG AT THE JOINT BETWEEN THE FUEL PUMP OUTPUT AND THE FUEL LINE, HAD A SPLIT, THUS ALLOWING FUEL TO LEAK AND RUN DOWN THE FRONT SIDE OF THE MOTORCYCLE THE EXHAUST HEADER. UPDATED 10/29/13

Owner-reported narrative. 47,000 miles reported. Look up ODI 10536530 at NHTSA ↗

Reported: 2010-06-18 (June 18, 2010)

BMW IS RECALLING CERTAIN MODEL YEAR 2007 THROUGH 2009 R 1200 AND K 1200 SERIES MOTORCYCLES MANUFACTURED FROM AUGUST 2006 THROUGH MAY 2009. DUE TO THE CURRENT ROUTING OF THE FRONT BRAKE LINES, IT IS POSSIBLE THAT DURING RIDING, AND THEREFORE ASSOCIATED VIBRATION. THE BRAKE LINES COULD BE UNDER STRAIN. IF THE VIBRATION/STRAIN IS SIGNIFICANT, THE BRAKE LINE COULD SPLIT AND START TO DEVELOP A LEAK.

Consequence: IF THIS GOES UNNOTICED, AND THE BRAKE FLUID RESERVOIR RUNS EMPTY, THE FRONT BRAKES COULD FAIL, INCREASING THE RISK OF A CRASH.

Remedy: BMW WILL NOTIFY OWNERS AND DEALERS WILL INSTALL NEW BRAKE LINES, CONTAINING A "SLEEVE" ALONG A PORTION OF THE LINES FREE OF CHARGE. THE SAFETY RECALL BEGAN ON SEPTEMBER 20, 2010. OWNERS MAY CONTACT BMW AT 1-800-525-7417.

Reported: 2013-12-12 (December 12, 2013)

BMW of North America, LLC (BMW) is recalling certain model year 2005-2011 model year R-model motorcycles, model year 2005-2012 K-model motorcycles, model year 2010-2011 S 1000 model motorcycles, and model year 2006-2010 HP2 motorcycles. In the affected motorcycles, the fuel pump flange (and the auxiliary fuel pump flange if equipped) could develop cracks and leak fuel.

Consequence: A fuel leak in the presence of an ignition source may result in a fire.

Remedy: BMW will notify owners, and dealers will either reinforce the fuel pump flange or replace the pump, as necessary, free of charge. The recall began on April 16, 2014. Owners may contact BMW customer relations at 1-800-525-7417 or email BMW at CustomerRelations@bmwusa.com.

Reported: 2015-03-11 (March 11, 2015)

BMW of North America, LLC (BMW) is recalling certain model year 2005-2010 R1200GS and R1200RT, 2006-2010 R1200GS Adventure, 2007-2010 R1200R, 2007 R1200S and K1200R Sport, 2005-2007 R1200ST, 2008-2009 HP2 Megamoto, 2006 HP2 Enduro, 2008-2010 HP2 Sport, 2005-2008 K1200S, 2006-2008 K1200R, K1200GT, 2009-2011 K1300S, 2010-2011 K1300R, and 2009-2010 K1300GT motorcycles. In the affected motorcycles, the rear wheel mounting flange may crack if the rear wheel mounting bolts are over tightened.

Consequence: If the rear wheel mounting flange cracks, the mounting bolts may loosen and the rear wheel may not remain secured to the motorcycle, causing a loss of stability and increasing the risk of a crash.

Remedy: BMW will notify owners, and dealers will replace the existing aluminum rear wheel flange with a steel one, free of charge. The recall began on May 7, 2015. Owners may contact BMW customer service at 1-800-525-7417.