2007 Bmw R 1200 GS ADVENTURE: complaints, problems and recalls

THE FUEL GAUGE HAS BEEN TO THE DEALER TWICE UNDER WARRANTY AND DOES NOT WORK CORRECTLY. MY BIGGEST COMPLAINT IS THAT THE "MASTER CAUTION" FLASHES FOR 3/4 OF A TANK WITH THE WORDS "FUEL" FLASHING ON THE INSTRUMENT CLUSTER TELLING ME I'M OUT OF GAS. I AM CONCERNED THAT I WILL GET SO USE TO A FLASHING YELLOW TRIANGLE THAT I WILL IGNORE IT. *TR

Owner-reported narrative. 17,000 miles reported. Look up ODI 10341946 at NHTSA ↗

PLASTIC QUICK CONNECT ON TOP OF GAS TANK FUEL PUMP PLATE CRACKED. FUEL UNDER PRESSURE SPRAYED OUT, RUNNING ONTO HOT EXHAUST PIPE. COULD RESULT IN MAJOR FIRE. PLASTIC SEEMS NOT SUITABLE FOR ETHANOL BLENDED FUEL WHICH CAUSES IT TO GET BRITTLE AND CRACK. *TR

Owner-reported narrative. 32,000 miles reported. Look up ODI 10354202 at NHTSA ↗

FINAL DRIVE FAILURE, COMMON TO THE SINGLE SIDED SWING ARM. REPLACED CROWN BEARING, NEEDLE SLEEVE, SEAL, AND O RING. THIS IS MY THIRD FAILURE ON THREE DIFFERENT BMW SINGLE SIDED SWING ARM MOTORCYCLES. $625.15 *KB

Owner-reported narrative. 46,789 miles reported. Look up ODI 10446648 at NHTSA ↗

CRACKS DEVELOPED IN THE FUEL PUMP FLANGE CAUSING FUEL TO LEAK ON THE ENGINE. *TR

Owner-reported narrative. 63,000 miles reported. Look up ODI 10492342 at NHTSA ↗

I WAS GETTING AT A STOP LIGHT AND THE REAR WHEEL LOCKED ABRUPTLY. *TR

Owner-reported narrative. 60,400 miles reported. Look up ODI 10501443 at NHTSA ↗

BIKE STARTED LEAKING FUEL.. WAS GETTING ON TO RIDER CLOTHING. WHEN DISASSEMBLED IT WAS DISCOVERED THAT THE FUEL WAS COMING FROM CRACK IN PLASTIC PIECE ON FUEL FLANGE. BMW REQUIRED A COMPLETE FUEL PUMP ASSEMBLY (2 PARTS FLANGE AND PUMP) TO BE PURCHASED TO THE AMOUNT OF $500.00.. BUT YOU CAN PURCHASE JUST THE PUMP WITHOUT THE FLANGE SEPARATELY. ACCORDING TO LOCAL BMW SHOP NUMEROUS BIKES ARE COMING IN WITH THIS PROBLEM.. YEARS 2005 TO 2010.. BMW REPLACED THE DEFECTIVE PART WITH METAL RING ON NEW BIKES BUT ARE NOT TAKING CARE OF EXISTING PR…

Owner-reported narrative. 45,000 miles reported. Look up ODI 10549250 at NHTSA ↗

UPON STARTING THE MOTORCYCLE GAS BEGIN SQUIRTING OUT THE RIGHT SIDE OF THE GAS TANK - APPROXIMATELY 1 QUART WITHIN A MINUTE OR TWO, COVERING MY PANT LEG AND FLOOR. UPON REMOVAL OF THE RIGHT SIDE TANK COVER IT WAS APPARENT THAT THE QUICK RELEASE COUPLING WAS SPLIT OR CRACKED AND WOULD SPEW GAS ANYTIME THE IGNITION WAS TURNED ON. THIS IS A VERY LOW MILEAGE HIGHLY MAINTAINED MOTORCYCLE KEPT IN A TEMPERATURE CONTROLLED GARAGE. THIS COULD HAVE BEEN A SERIOUS SITUATION HAD I BEEN RIDING AT SPEED AND THE GAS IGNITED. MY BMW REPAIR FACILITY INDICATED T…

Owner-reported narrative. 875 miles reported. Look up ODI 10568870 at NHTSA ↗

Reported: 2010-06-16 (June 16, 2010)

BMW IS RECALLING CERTAIN 2005 THROUGH 2007 R 1200 GS ADVENTURE MOTORCYCLES MANUFACTURED FROM DECEMBER 7, 2005 THROUGH SEPTEMBER 26, 2007. THE FUEL TANK FRONT ATTACHMENT BOLTS CAN WORK LOOSE ALLOWING THE BOLTS TO COME INTO CONTACT WITH THE FORK LEG IF THE HANDLEBAR IS TURNED A SIGNIFICANT AMOUNT.

Consequence: THIS COULD LIMIT THE TRAVEL RANGE OF THE HANDLEBARS WHICH COULD AFFECT HANDLING AND MANEUVERABILITY OF THE MOTORCYCLE, INCREASING THE RISK OF A CRASH.

Remedy: BMW WILL NOTIFY OWNERS AND DEALERS WILL REPAIR MOTORCYCLES BY FURTHER SECURING THE BOLTS USING LOCTITE. THE REPAIR WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON AUGUST 30, 2010. OWNERS MAY CONTACT BMW AT 1-800-525-7417.

Reported: 2010-06-18 (June 18, 2010)

BMW IS RECALLING CERTAIN MODEL YEAR 2007 THROUGH 2009 R 1200 AND K 1200 SERIES MOTORCYCLES MANUFACTURED FROM AUGUST 2006 THROUGH MAY 2009. DUE TO THE CURRENT ROUTING OF THE FRONT BRAKE LINES, IT IS POSSIBLE THAT DURING RIDING, AND THEREFORE ASSOCIATED VIBRATION. THE BRAKE LINES COULD BE UNDER STRAIN. IF THE VIBRATION/STRAIN IS SIGNIFICANT, THE BRAKE LINE COULD SPLIT AND START TO DEVELOP A LEAK.

Consequence: IF THIS GOES UNNOTICED, AND THE BRAKE FLUID RESERVOIR RUNS EMPTY, THE FRONT BRAKES COULD FAIL, INCREASING THE RISK OF A CRASH.

Remedy: BMW WILL NOTIFY OWNERS AND DEALERS WILL INSTALL NEW BRAKE LINES, CONTAINING A "SLEEVE" ALONG A PORTION OF THE LINES FREE OF CHARGE. THE SAFETY RECALL BEGAN ON SEPTEMBER 20, 2010. OWNERS MAY CONTACT BMW AT 1-800-525-7417.

Reported: 2013-12-12 (December 12, 2013)

BMW of North America, LLC (BMW) is recalling certain model year 2005-2011 model year R-model motorcycles, model year 2005-2012 K-model motorcycles, model year 2010-2011 S 1000 model motorcycles, and model year 2006-2010 HP2 motorcycles. In the affected motorcycles, the fuel pump flange (and the auxiliary fuel pump flange if equipped) could develop cracks and leak fuel.

Consequence: A fuel leak in the presence of an ignition source may result in a fire.

Remedy: BMW will notify owners, and dealers will either reinforce the fuel pump flange or replace the pump, as necessary, free of charge. The recall began on April 16, 2014. Owners may contact BMW customer relations at 1-800-525-7417 or email BMW at CustomerRelations@bmwusa.com.

Reported: 2015-03-11 (March 11, 2015)

BMW of North America, LLC (BMW) is recalling certain model year 2005-2010 R1200GS and R1200RT, 2006-2010 R1200GS Adventure, 2007-2010 R1200R, 2007 R1200S and K1200R Sport, 2005-2007 R1200ST, 2008-2009 HP2 Megamoto, 2006 HP2 Enduro, 2008-2010 HP2 Sport, 2005-2008 K1200S, 2006-2008 K1200R, K1200GT, 2009-2011 K1300S, 2010-2011 K1300R, and 2009-2010 K1300GT motorcycles. In the affected motorcycles, the rear wheel mounting flange may crack if the rear wheel mounting bolts are over tightened.

Consequence: If the rear wheel mounting flange cracks, the mounting bolts may loosen and the rear wheel may not remain secured to the motorcycle, causing a loss of stability and increasing the risk of a crash.

Remedy: BMW will notify owners, and dealers will replace the existing aluminum rear wheel flange with a steel one, free of charge. The recall began on May 7, 2015. Owners may contact BMW customer service at 1-800-525-7417.