2001 Bmw 530IA: complaints, problems and recalls

ON OCTOBER 31, 2003 AT 9:30PM, AIRBAGS(FRONT, HEAD - DRIVER SIDE/FRONT, SIDE, HEAD - PASSENGER SIDE) DEPLOYED AS DRIVER WAS STARTING THE ENGINE OF A PARKED CAR. THE IMPACT SHATTERED THE FRONT WINDSHIELD AND DRIVER RECEIVED A CONCUSSION. DRIVER IS CURRENTLY SUFFERING FROM HEADACHES, RINGING IN THE EAR, SLEEP-DISORDER, SORE/STIFFNESS. *AK

Owner-reported narrative. Look up ODI 10047187 at NHTSA ↗

ON DECEMBER 19, 2004 I WAS DRIVING MY 2001 BMW 530I WITH THE DRIVER SIDE SEAT HEATER IN THE ON POSITION. I PARKED THE CAR IN A PARKING LOT, SHUT OFF THE ENGINE, AND WAS EXITING ON THE DRIVER SIDE, WHEN I NOTICED THAT THE BACK SUPPORT PORTION OF THE DRIVER SIDE SEAT HAD CAUGHT ON E AND BURNED A HOLE THROUGH THE LEATHER INTERIOR. IT ALSO SINGED MY WINTER COAT THAT I WAS WEARING AT THE TIME. I PUT OUT THE FIRE AND REALIZED THAT THE SEAT HEATER ELEMENT HAD MALFUNCTIONED AND CAUSED THE FIRE. TO DATE, I'VE BEEN WORKING TO HAVE THE SEAT REPLACED THRO…

Owner-reported narrative. Look up ODI 10133216 at NHTSA ↗

CAR FAILED TO OPERATE IN REVERSE WHEN AUTOMATIC TRANSMISSION WAS PLACED IN REVERSE. *TR

Owner-reported narrative. 112,300 miles reported. Look up ODI 10281388 at NHTSA ↗

2001 BMW 530IA REVERSE?!?! THE CAR HAS NEVER BEEN ABUSED AND ALWAYS SERVICED AS RECOMMENDED BY THE ON BOARD COMPUTER AND OWNERS MANUAL. REVERSE FOR NO REASON STOPPED WORKING AT THE WORST POSSIBLE TIME!!! IT HAS ENOUGH POWER TO ROLL VERY SLOWLY IF YOU REV THE MOTOR OUT OF A FLAT PARKING SPOT BUT IT DOESN'T HAVE ANY POWER TO BACK UP ANY INCLINE AT ALL. I HAVE NEVER ABUSED THE CAR OR HAD ANY PROBLEMS WITH THE DRIVE TRAIN. THE DEALERSHIP TOLD ME IT HAS A SEALED TRANSMISSION AND YOU CAN'T CHECK OR ADD FLUID. I GOT STUCK AGAINST A CURB WHILE TRY…

Owner-reported narrative. 97,000 miles reported. Look up ODI 10434352 at NHTSA ↗

TL* THE CONTACT OWNS A 2001 BMW 530IA. WHILE DRIVING 35 MPH, THE PASSENGER SIDE AIR BAG DEPLOYED WITHOUT WARNING. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 206,000.

Owner-reported narrative. 206,000 miles reported. Look up ODI 10934778 at NHTSA ↗

I PARKED MY CAR AND FOUND THAT THE ELECTRICAL SYSTEM HAD ALMOST CAUGHT FIRE, MELTING THE CARPET AND PLASTIC INTERIOR, GLOVEBOX AND MULTIPLE ELECTRICAL COMPONENTS AND WIRING HARNESS. THE AIRBAGS HAD DEPLOYED AND THERE WAS BLACK SOOT COVERING THE INTERIOR. I FOUND THAT THERE WAS WATER ACCUMULATED BENEATH THE PASSENGER FOOTWELL, WHERE THERE IS A MAJOR ELECTRICAL FUSE PANEL. THE CAR IS CURRENTLY IN FRONT OF MY HOME AND I'VE HAD TO FIND A REPLACEMENT VEHICLE DUE TO THE EXTENSIVE DAMAGE TO THE WIRING HARNESS AND MODULES. ALSO THE SMOKE DAMAGE WOU…

Owner-reported narrative. 130,000 miles reported. Look up ODI 10985482 at NHTSA ↗

VEHICLE WAS PARKED AT WALMART. LESS THEN 5 MINUTES AFTER WALKING INTO THE STORE THE VEHICLE BURST INTO FLAMES. THE FIRE STARTED IN THE FRONT OF THE ENGINE.

Owner-reported narrative. 125,000 miles reported. Look up ODI 11150794 at NHTSA ↗

AUXILLIARY COOLING FAN MOTOR CAUGHT FIRE AFTER VEHICLE ENGINE TURNED OFF.

Owner-reported narrative. Look up ODI 748207 at NHTSA ↗

Reported: 2001-06-21 (June 21, 2001)

VEHICLE DESCRIPTION: PASSENGER VEHICLES. THE ENGINE AUXILIARY/COOLING FAN OPERATION, INCLUDING VARIABLE SPEED, IS ELECTRONICALLY CONTROLLED. FAILURE OF THE FAN MOTOR CAN CAUSE THE ELECTRICAL CIRCUITRY OF THE FAN CONTROL UNIT TO OVERLOAD AND FAIL, CAUSING THE FAN TO STOP OPERATING.

Consequence: IF THIS WERE TO OCCUR, ENGINE OVERHEATING AND SUBSEQUENT ENGINE DAMAGE COULD RESULT. IN ADDITION, IT IS POSSIBLE FOR THE FAILURE OF THE ELECTRICAL CIRCUITRY TO CAUSE A FIRE IN THE FAN CONTROL UNIT LOCATED IN THE FRONT OF THE ENGINE COMPARTMENT.

Remedy: DEALERS WILL REPLACE THE FAN. OWNER NOTIFICATION BEGAN SEPTEMBER 28, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT BMW AT 1-800-831-1117.

Reported: 2002-05-16 (May 16, 2002)

ON CERTAIN PASSENGER VEHICLES, THE ENGINE AUXILIARY/COOLING FAN OPERATION, INCLUDING VARIABLE SPEED, IS ELECTRONICALLY CONTROLLED. FAILURE OF THE FAN MOTOR CAN CAUSE THE ELECTRICAL CIRCUITRY OF THE FAN CONTROL UNIT TO OVERLOAD AND FAIL, CAUSING THE FAN TO STOP OPERATING.

Consequence: IF THIS WERE TO OCCUR, ENGINE OVERHEATING AND SUBSEQUENT ENGINE DAMAGE COULD RESULT. IN ADDITION, IT IS POSSIBLE FOR THE FAILURE OF THE ELECTRICAL CIRCUITRY TO CAUSE A FIRE IN THE FAN CONTROL UNIT LOCATED IN THE FRONT OF THE ENGINE COMPARTMENT.

Remedy: DEALERS WILL REPLACE THE FAN. OWNER NOTIFICATION BEGAN SEPTEMBER 28, 2001. THIS IS A SUPPLEMENT TO A RECALL THAT BEGAN DURING SEPTEMBER 2001 (SEE RECALL CAMPAIGN 01V206). OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT BMW AT 1-800-831-1117.

Reported: 2003-10-24 (October 24, 2003)

ON CERTAIN PASSENGER VEHICLES, A MICROPROCESSOR IN THE AIR BAG CONTROL MODULE, WHICH ACTIVATES THE FRONT AIR BAGS, THE SIDE AIR BAGS, THE FRONT SEAT SAFETY BELT PRETENSIONERS, AND THE BATTERY SAFETY TERMINAL, MAY HAVE A MALFUNCTION THAT COULD LEAD TO AN UNINTENDED ACTIVATION OF ONE OR MORE OF THESE COMPONENTS.

Consequence: UNEXPECTED DEPLOYMENT OF THE AIR BAG(S) COULD CAUSE SERIOUS INJURY IF AN OCCUPANT IS TOO CLOSE TO THE DEPLOYING AIR BAG(S). IN ADDITION, THE BATTERY SAFETY TERMINAL MAY ALSO BE ACTIVATED. IF THAT HAPPENS, THE STARTER CABLE WOULD BECOME DISCONNECTED FROM THE BATTERY, AND THE ENGINE COULD NOT BE RESTARTED.

Remedy: DEALERS WILL REPLACE THE AIR BAG CONTROL MODULE. OWNER NOTIFICATION BEGAN NOVEMBER10, 2003. OWNERS SHOULD CONTACT BMW AT 1-800-831-1117.