2011 Bmw 528I: complaints, problems and recalls

THE VEHICLE HAS AN ACCELERATION PROBLEM AND HESITATES AND PAUSES WHEN STARTING FROM A STOP OR WHILE IN LOW SPEED CONDITIONS. IT IS DANGEROUS TO, FOR EXAMPLE, PULL OUT IN TRAFFIC WHEN ONE DOES NOT KNOW IF YOUR VEHICLE IS GOING TO ACCELERATE PROPERLY. THERE IS A DEFINITE LAG AND PAUSE THAT IS A PROBLEM WHEN ACCELERATING. *TR

Owner-reported narrative. 35,000 miles reported. Look up ODI 10457980 at NHTSA ↗

WHEN ACCELERATING FROM A COMPLETE STOP OR DRIVING AT HIGHER SPEEDS (50-80MPH), THE VEHICLE CONSISTENTLY PULLS TO THE RIGHT. I'VE HAD ALIGNMENTS PERFORMED, BUT THE PROBLEM PERSISTS. THE DEALER SAID IT'S WITHIN SPECIFICATION, AND THEY COULDN'T DO ANYTHING ELSE ABOUT IT. AFTER MORE PERSISTENCE, MY SERVICE ADVISER CAME BACK WITH: THE STOCK CAMBER SETTINGS ON BMW'S ARE PRETTY AGGRESSIVE, AND THEY CAN'T ADJUST THE CAMBER ANYMORE ON MY CAR TO RESOLVE THE PULLING TO THE RIGHT ISSUE. HE SAID THERE IS ANOTHER BMW SUSPENSION PART (CONTROL ARM) THE…

Owner-reported narrative. 35,036 miles reported. Look up ODI 10499723 at NHTSA ↗

FROM A COMPLETE STOP, WHEN ACCELERATING, THERE IS A LAG OR HESITATION BEFORE THE CAR TAKES OFF. WHEN IT DOES TAKE OFF, THERE IS A HARD JERK. IT MAKES IT VERY HARD TO GAUGE THE DISTANCE BETWEEN YOU AND OTHER CARS WHEN IT LUNGES VERY QUICKLY. IF YOU'RE PULLING INTO TRAFFIC, AS IN MY CASE, IT CAN BE VERY DANGEROUS. ALSO IF IT'S WET, AND THIS HAPPENS, IT COULD CAUSE YOU TO LOSE CONTROL OF YOUR VEHICLE. THIS NEEDS TO BE INVESTIGATED, AS IT CAN BE A MAJOR SAFETY ISSUE. *TR

Owner-reported narrative. 33,000 miles reported. Look up ODI 10499724 at NHTSA ↗

AFTER PURCHASING MY 2011 528I I NOTICED THE CAR WOULD NOT ACCELERATE SMOOTHLY FROM A STOP OR AFTER SLOWING DOWN TO MAKE A TURN, IT ACTUALLY FELT LIKE IT WAS APPLYING THE BREAKS UNTIL YOU APPLIED CLOSE TO HALF THROTTLE THEN IT WOULD LURCH FORWARD. THE CAR WAS TAKEN TO DEALER AND RECEIVED A PATCH AND PROGRAMMING WHICH MADE NO CHANGE. TO TOP ALL OF THIS OFF IT PICKS AND CHOOSES WHEN ITS GOING TO DRIVE "NORMAL" SO YOU DON'T KNOW WHAT TO EXPECT....THIS IS UNSAFE...... ON THE FREEWAY IT WONT DOWNSHIFT TO PASS UNLESS PRESSED TO THE FLOOR, THE MOTOR J…

Owner-reported narrative. 150 miles reported. Look up ODI 10504064 at NHTSA ↗

THE VEHICLE HAS A SIGNIFICANT DELAY IN ACCELERATION THAT OCCURS PRIMARILY AFTER (I) THE VEHICLE HAS SLOWED DOWN TO A SPEED BETWEEN 18 MPH AND 24 MPH; (II) A FULL STOP (ALTHOUGH IT IS INTERMITTENT FOLLOWING A FULL STOP) AND (III) SUDDEN SURGES OF ACCELERATION. THE ACCELERATION DELAY IS MOST NOTICEABLE WHEN MODERATE ACCELERATION IS DESIRED. THE PEDAL CAN BE DEPRESSED NEARLY FULLY WITH NO NOTICEABLE ACCELERATION FOR A SHORT PERIOD. AFTER THE DELAY THE CAR WILL ACCELERATE, OFTEN IN A SURGE. FROM A FULL STOP ACCELERATION IS OFTEN A JERKY AFFAIR…

Owner-reported narrative. 2,000 miles reported. Look up ODI 10504194 at NHTSA ↗

VEHICLE DID NOT ACCELERATE AS I WAS PULLING OUT OF A GAS STATION. THIS IS NORMAL FOR THIS CAR (THROTTLE DELAY). I USUALLY PLAN FOR THE POOR PERFORMANCE, HOWEVER, BECAUSE OF HEAVY TRAFFIC I PULLED OUT IN WHAT SHOULD HAVE BEEN AMPLE TIME TO MERGE IN. NO ACCIDENT OCCURRED BUT IF I DID NOT KNOW HOW TO REACT IT VERY EASILY COULD HAVE. I DO NOT LET OTHER FAMILY MEMBERS DRIVE THIS VEHICLE DUE TO THIS ISSUE VERY UNSAFE!! THANKS FOR YOUR TIME. *TR

Owner-reported narrative. 11,380 miles reported. Look up ODI 10516077 at NHTSA ↗

AS MY CAR WAS STOPPED AT A RED LIGHT, I FELT A QUICK JERK FORWARD AND THOUGHT I WAS REAR-ENDED. I LOOKED BACK AND THERE WASN'T A CAR. AS I PULLED INTO MY PARKING SPACE, I WAS SWITCHING FROM REVERSE TO DRIVE, THE CAR JERKED AGAIN, LIKE I WAS BEING REAR ENDED. IT FELT LIKE THE CAR WAS SKIPPING A GEAR (I DRIVE AN AUTOMATIC). THEN AS I WAS LEAVING THE PARKING LOT, I PUSHED THE GAS DOWN AND FOR ALMOST 2 SECONDS THE CAR DID NOTHING, THEN JERKED HARD FORWARD AND STARTED TO DRIVE. *TR

Owner-reported narrative. 39,000 miles reported. Look up ODI 10520213 at NHTSA ↗

WHEN I PRESS THE ACCELERATOR TO START DRIVING, THERE IS A VERY DISTINCT AND UNCOMFORTABLE LAG OF ABOUT 2 SECONDS. THIS HAPPENED WHEN I WAS MAKING A RIGHT TURN INTO A TWO-WAY DIVIDED ROAD FROM A RESIDENTIAL COMPLEX. THE VISIBILITY TO THE LEFT IS LIMITED TO ABOUT 200 FT DUE TO A CURVE IN THE DIVIDED ROAD. WHEN I START MOVING FROM THE STOP SIGN, I HAVE TO ACCELERATE QUICKLY IN ORDER TO AVOID ANY TRAFFIC THAT MAY BE COMING AT SPEED BEHIND ME. THIS ACCELERATOR LAG MAKES FOR A SAFETY CONCERN. I IMAGINE THIS CAN ALSO BE A SAFETY CONCERN DURING M…

Owner-reported narrative. 44,740 miles reported. Look up ODI 10552900 at NHTSA ↗

Reported: 2014-04-10 (April 10, 2014)

BMW of North America, LLC (BMW) is recalling certain model year 2010-2011 128i Coupe, 128i Convertible, 328i Sedan, 328i xDrive Sedan, 328i Coupe, 328i Convertible, 328i Sports Wagon and Z4 sDrive 30i, 2011-2012 135i Coupe, 135i Convertible, 335i Sedan, X5 xDrive 35i, and X6 xDrive 35i, 2011 335i xDrive Sedan, 335i Coupe, 335i Convertible, 528i Sedan, 535i Sedan, 535i xDrive Sedan, X3 xDrive 28i, and X3 xDrive 35i, 2010 X3 xDrive 30i, and X5 xDrive 30i, 2012 640i Coupe, and 640i Convertible and 2010-2012 535i Gran Turismo vehicles. In the affected vehicles, the bolts that secure the housing for the variable camshaft timing adjustment (VANOS) unit can loosen over time and may possibly break.

Consequence: If the bolts loosen or break the engine may have reduced power or stall. An engine stall increases the risk of a crash.

Remedy: BMW will notify owners, and dealers will replace the four VANOS housing bolts for both VANOS units (intake and exhaust), free of charge. In addition, owners of approximately 170,172 model year 2010-2012 BMW vehicles equipped with inline 6 cylinder engines not covered by this recall, will receive an extended warranty to address this condition. The recall began on September 24, 2014. Owners may contact BMW at 1-800-525-7417.

Reported: 2016-10-17 (October 17, 2016)

BMW of North America, LLC (BMW) is recalling certain model year 2007-2011 BMW X5 3.0si, X5 4.8i, X5 M, X5 xDrive30i, X5 xDrive35i, X5 xDrive48i and X5 xDrive50i, 2008-2011 X6 x Drive35i, X6 xDrive50i and X6 M, 2010-2011 X6 ActiveHybrid, 535i xDrive Gran Turismo, 535i Gran Turismo, 550i xDrive Gran Turismo and 550i Gran Turismo, 2011-2012 528i, 535i, 535i xDrive, 550i and 550i xDrive and 2012 535i ActiveHybrid, 640i Convertible, 650i Convertible, 650i xDrive Convertible, 650i Coupe and 650i Coupe xDrive vehicles. The affected vehicles have in-tank fuel pumps that may have insufficiently crimped wire contacts.

Consequence: The loose wires may cause the connector to melt, resulting in a fuel leak. Additionally, the fuel pump may stop working, possibly causing an engine stall and increase the risk of a crash.

Remedy: BMW will notify owners, and dealers will replace the fuel pump module, free of charge. The recall began February 2017. Owners may contact BMW customer service at 1-800-525-7417.

Reported: 2016-11-17 (November 17, 2016)

BMW of North America, LLC (BMW) is recalling certain model year 2011 BMW 528i, 528xi, 535i, 535xi, 550i and 550xi vehicles manufactured March 1, 2010, through August 31, 2011. The affected vehicles may have received a replacement Sensor Cluster Unit (SCU) during a service visit. These SCUs have an acceleration sensor that may have been incorrectly programmed and, as a result, the SCU may not accurately determine if activation and deployment of the air bags, safety belt pre-tensioners and head restraints is necessary in the event of a crash.

Consequence: Depending on the severity of the crash, inadequate activation of the driver and/or passenger air bags, safety belt pre-tensioners and active head restraints may increase the risk of injury.

Remedy: BMW will notify owners, and dealers will replace the SCU, free of charge. The recall began on December 16, 2016. Owners may contact BMW customer service at 1-800-525-7417.

Reported: 2017-10-30 (October 30, 2017)

BMW of North America, LLC (BMW) is recalling certain 2008-2011 128i and 2007-2011 328i, 328xi, 328i xDrive, 525i, 525xi, 528i, 528xi, 530i, 530xi, X3 3.0si, X3 xDrive30i, X5 xDrive30i, Z4 3.0i, Z4 3.0si and Z4 sDrive30i vehicles. The heater for the positive crankcase ventilation (PCV) valve may short circuit.

Consequence: An electrical short can cause the parts within the PCV valve to melt, increasing the risk of a fire, even when the vehicle is not in use.

Remedy: BMW will notify owners, and dealers will replace the PCV valve heater, free of charge. Interim letters were mailed on November 27, 2017. Owners will receive a second notification by the end of October 2018. Owners may contact BMW customer service at 1-800-525-7417.