1992 Bmw 525I: complaints, problems and recalls

WHILE DRIVING CONSUMER'S VEHICLE WAS HIT ON THE DRIVER SIDE FRONT QUARTER PANEL. THE AIR BAGS DEPLOYED. DRIVER WAS BURNED IN THE FACE AND CHEST. *AK

Owner-reported narrative. 103,000 miles reported. Look up ODI 10071399 at NHTSA ↗

I AM WONDERING HOW THE MANUFACTURE DETERMINES WHICH VEHICLES ARE AFFECTED BY A PARTICULIAR RECALL. A COUPLE OF EXAMPLES, I HAVE A 1992 BMW 525I AND HAVE EXPERIENCED TWO FAILURES RELATED TO RECALLS ONE CONCERNED THE RING IN THE STEERING COLUMN RELATED TO THE AIRBAG BROKE AND HAD TO BE REPLACED AND THE OTHER HAD TO DO WITH THE COOLING SYSTEM WHERE THE TERMOSTAT STUCK AND THE PRESSURE CRACKED THE RADIATOR. THESE FAILURE OCCURRED A FEW YEARS BACK AND I WOULD NED TO CHECK MY MAINTENANCE RECORDS TO GET THE EXACT DATES.

Owner-reported narrative. Look up ODI 10118557 at NHTSA ↗

DT: VEHICLE WAS INVOLVED IN AN FRONTAL IMPACT THE AIR BAGS DEPLOYED, HOWEVER THE CONSUMER SUSTAINED 3RD DEGREE BURNS TO THE CHIN AREA, AND HAD TO HAVE ROOT CANAL WORK ON A TOOTH. THE VEHICLE WAS TOTALED. NO REPAIRS WERE MADE. THERE WAS A SMALL DEPLOYMENT AND IT WAS LIKE IT WAS FIRE, RED FLAMING AREA ON THE AIR BAG THAT ACTUALLY IGNITED. *AK

Owner-reported narrative. 96,000 miles reported. Look up ODI 10127190 at NHTSA ↗

THE AIR BAG CONTACT RING LOCKING TAB LOCATED IN THE STEERING WHEEL ASSEMBLY BROKE WITHOUT WARNING. IT WAS NOTICEABLE, A CLICK OR GRAB TYPE FEEL, WHEREVER THE STEERING WHEEL WAS TURNED AND I IMMEDIATELY TOOK THE CAR TO MY BMW SHOP TO CORRECT. I AM NOT SURE WHAT WAS ACCOMPLISHED BUT THE CLICK WAS REMOVED. ON RECALLS FOR BMWS THIS FAULT WAS LIMITED TO THE 3 SERIES AND NOT A 5 SERIES WHICH I OWN. I HAD REPORTED THIS EARLIER BUT DIDN'T RECEIVE ANY RESPONSE FROM THE NTSB SO THEREFORE I AM RESUBMITTING. *NM

Owner-reported narrative. 90,000 miles reported. Look up ODI 10150229 at NHTSA ↗

DT*: THE CONTACT STATED THE ENGINE OVERHEATED WHILE DRIVING VARIOUS SPEEDS. THE VEHICLE WAS SEEN BY A DEALER. THE RADIATOR AND WATER PUMP WAS REPLACED. AFTERWARDS, THE ENGINE CONTINUED TO OVERHEAT. THE VEHICLE WAS TAKEN BACK TO THE DEALER FOR INSPECTION. THE SERVICE DEPARTMENT DETERMINED THE ENGINE'S OVERALL COOLING SYSTEM NEEDED TO BE REPLACED.

Owner-reported narrative. 142,000 miles reported. Look up ODI 10153617 at NHTSA ↗

BODY APPEARS TO BE DEFECTIVE. THE BODY LOOKS LIKE IT IS ABOUT TO FALL APART, IN THE REAR OF THE VEHICLE. VEHICLE IS UNSAFE TO DRIVE. FIELDS BMW NORTHFIELD 700 W FRONTAGE ROAD NORTHFIELD, IL 60093 MAY HAVE BEEN NEGLIGENT. THEY INSPECTED VEHICLE ON JUNE 11TH 2011 AND DID NOT MENTION THIS ISSUE AND THAT THE VEHICLE WAS UNSAFE TO DRIVE.

Owner-reported narrative. 286,508 miles reported. Look up ODI 10417229 at NHTSA ↗

TL* THE CONTACT OWNS A 1992 BMW 525I. THE CONTACT STATED THAT WHILE DRIVING AT AN UNKNOWN SPEED, ANOTHER VEHICLE CRASHED INTO THE VEHICLE. THE CONTACT STATED THAT THE AIR BAG DEPLOYED CAUSING SEVERE BURNS. THE CONTACT REQUIRED MEDICAL ATTENTION FOR THE THIRD DEGREE BURNS TO HER FACE AND NECK. A POLICE REPORT WAS FILED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE WAS 99,000. THE VIN WAS UNAVAILABLE.

Owner-reported narrative. 99,000 miles reported. Look up ODI 10653182 at NHTSA ↗

NO SUMMARY LISTED FOR ABOVE VEHICLE. *AK

Owner-reported narrative. Look up ODI 741534 at NHTSA ↗

Reported: 1996-07-01 (July 1, 1996)

THE AIR BAG CONTACT RING LOCKING TAB LOCATED IN THE STEERING WHEEL ASSEMBLY CAN BREAK WITHOUT WARNING.

Consequence: IF THIS HAPPENS, THE CONTACT RING WIRING COULD EVENTUALLY BREAK. THE AIR BAG READINESS INDICATOR LAMP (SRS OR AIRBAG) IN THE INSTRUMENT CLUSTER WILL ILLUMINATE, AND THE AIR BAG WOULD NOT DEPLOY IN THE EVENT OF A FRONTAL IMPACT VEHICLE COLLISION.

Remedy: DEALERS WILL REPLACE THE LOCKING TAB WITH ONE OF A DIFFERENT DESIGN.

Reported: 1996-07-01 (July 1, 1996)

THE BRAKE LIGHT SWITCH CAN FAIL ALLOWING THE SWITCH TO REMAIN IN THE "BRAKE LIGHTS OFF" POSITION OR IN THE "BRAKE LIGHTS ON" POSITION.

Consequence: IF THIS HAPPENS, THE BRAKE LIGHTS EITHER WILL NOT OPERATE OR WILL BE CONTINUOUSLY ON, REGARDLESS OF BRAKE PEDAL POSITION. FOLLOWING DRIVERS WOULD NOT BE ABLE TO DETERMINE WHETHER THE VEHICLE IS STOPPING, INCREASING THE POTENTIAL FOR A VEHICLE ACCIDENT.

Remedy: DEALERS WILL REPLACE THE EXISTING BRAKE LIGHT SWITCH WITH A NEWLY DESIGNED SWITCH.

Reported: 1997-08-19 (August 19, 1997)

THE CRUISE CONTROL AND THROTTLE CABLES ARE ATTACHED TO THE SAME THROTTLE VALVE ACTUATING LEVER AT THE THROTTLE HOUSING. IT IS POSSIBLE THAT THE PLASTIC BUSHING ON EITHER CABLE COULD BREAK DUE TO ENVIRONMENTAL INFLUENCES COUPLED WITH VIBRATION. IF THE BUSHING BREAKS, THE OUTER CABLE HOUSING CAN SEPARATE FROM THE BUSHING. IN THIS CASE, DURING APPLICATION OF THE THROTTLE PEDAL WITHOUT CRUISE CONTROL BEING ENGAGED, THE OUTER TUBE COULD CATCH ON THE EDGE OF THE BROKEN BUSHING.

Consequence: THIS COULD CAUSE THE THROTTLE VALVE TO REMAIN PARTIALLY OPEN. IT HIS WERE TO OCCUR, THE CAR MIGHT NOT DECELERATE AS EXPECTED INCREASING THE RISK OF A VEHICLE CRASH.

Remedy: DEALERS WILL INSTALL A SPRING STEEL CLIP ON THE OUTER TUBE OF EACH CABLE IN THE AREA OF THE ADJUSTING SCREW AND PLASTIC BUSHING. THE CLIP IS DESIGNED TO PREVENT THE OUTER TUBE FROM DISLODGING FROM THE BUSHING.

Reported: 1998-08-04 (August 4, 1998)

VEHICLE DESCRIPTION: PASSENGER VEHICLES. A MALFUNCTION OR FAILURE OF A COOLANT SYSTEM COMPONENT, SUCH AS A THERMOSTAT, WATER PUMP, OR FAN BELT, CAN RESULT IN SIGNIFICANTLY INCREASED COOLANT TEMPERATURE AND SYSTEM PRESSURE. IF THE INDICATIONS OF A CRITICAL OVERHEATING CONDITION IS NOT NOTICED BY THE DRIVER, IT IS POSSIBLE THAT DAMAGE TO, OR FAILURE OF, A COOLANT SYSTEM COMPONENT COULD OCCUR.

Consequence: IF A CRACK WERE TO FORM OR A SEAM WERE TO SEPARATE IN THE HEATER CORE END PIECE, HOT COOLANT COULD SUDDENLY BE EXPELLED, INCREASING THE RISK OF PERSONAL INJURY TO A VEHICLE OCCUPANT.

Remedy: DEALERS WILL INSTALL A NEW DESIGN RADIATOR CAP TO CONTROL PRESSURE AND PROVIDE GREATER COOLANT OVERFLOW IN THE EVENT OF OVERHEATING.