2003 Bmw 325I: complaints, problems and recalls

THE VEHICLE DOWN SHIFTED VERY HARD WHEN THE BRAKES WERE APPLIED, THE VEHICLE JERKED AND JUMPED FORWARD WHEN DECELERATING.*JB

Owner-reported narrative. 11 miles reported. Look up ODI 10009434 at NHTSA ↗

THE COMPUTER FIRST FAILED ON MY 2003 BMW 325I ON JUNE 15, 2003, (THREE WEEKS AFTER I PICKED IT UP FROM THE DEALERSHIP, BMW OF MANHATTAN), CAUSING ME TO LOSE ACCELERATION WITHOUT WARNING. I WAS TRAVELLING AT 60-65 MILES PER HOUR IN THE FAR LEFT LANE OF THE GARDEN STATE PARKWAY. I WAS BARELY ABLE TO MANUEVER THE CAR TO THE SHOULDER OF THE ROAD AND I WAS LUCKY THAT THERE HAPPENED TO BE A VERY SMALL SHOULDER ON THE LEFT SIDE OF THE ROAD, AS I WOULD HAVE NEVER BEEN ABLE TO MAKE IT TO THE SHOULDER ON THE RIGHT HAND SIDE OF THE ROAD AND TRAFFIC WAS …

Owner-reported narrative. 1,143 miles reported. Look up ODI 10023814 at NHTSA ↗

LEFT/REAR AND RIGHT FRONT TIRES HAD DEVELOPED A LARGE "BUBBLE" IN THE SIDEWALL. THE TIRES HAD LESS THAN 2000 MILES AT TIME OF FAILURE. BRIDGESTONE TURANZA, ER30 225/45ZR17, DOT NO. K9701ER3OU2, ORIGINAL TIRES. *AK *JB

Owner-reported narrative. 2,200 miles reported. Look up ODI 10024110 at NHTSA ↗

1. TRANSMISSION: AFTER TRANSMISSION REPAIR, CONSTANT HARD DOWNSHIFTING OF AUTOMATIC TRANSMISSION WHEN COMING TO A STOP IN D AND S D MODES. VEHICLE JERKS FORWARD WHEN DECELERATING BETWEEN SPEEDS OF 42 TO 35 MPH (USUALLY WHEN DRIVEN BEFORE WITH SPEEDS IN EXCESS OF 50 MILES AN HOUR). ALSO, AFTER TRANSMISSION REPAIR, CONSTANT LOUD THUMPING NOISE WHEN COMING TO A STOP 2. ENGINE:INTERMITTENT LOUD ENGINE REVVING AND IMMEDIATE TORQUE LOSS OCCURRING WHEN TAKING OFF FROM A STOP.INTERMITTENT DELAYED ENGINE START OF UP TO 3 SECONDS AFTER TURNING KEY…

Owner-reported narrative. 1,600 miles reported. Look up ODI 10025336 at NHTSA ↗

AUTOMATIC TRANSMISSION ON 2003 325I JERKS WHEN DOWNSHIFTS WHILE BRAKING. A LAUD THUD CAN BE HEARD ON LOWER SPEEDS.

Owner-reported narrative. 13,000 miles reported. Look up ODI 10028771 at NHTSA ↗

I PURCHASED A NEW 2003 BMW 325 IN JULY, 2003 FROM PERFORMANCE BMW IN CHAPEL HILL, NC. THE IGNITION COIL HAD TO BE REPLACED TODAY ON THE #2 CYLINDER. THE VEHICLE CURRENTLY HAS 8,000 MILES ON IT. I WAS TOLD BY MEL, THE SERVICE TECH AT PERFORMANCE BMW IN CHAPEL HILL, NC, THAT BMW HAS HAD PROBLEMS WITH THE IGNITION COILS ON THE 2003 AND 2004 MODELS AND THAT BECAUSE OF THESE PROBLEMS BMW HAS SWITCHED VENDORS FOR THESE IGNITION COILS AND NO LONGER USES THE VENDOR THAT SUPPLIED THE PARTS FOR MY CAR. SINCE THERE A 6 IGNITION COILS IN MY CAR, THAT …

Owner-reported narrative. 8,000 miles reported. Look up ODI 10048997 at NHTSA ↗

2003 BOUGHT BRAND NEW. AUTOMATIC TRANSMISSION DOES NOT ENGAGE IN THE MORNINGS. AFTER PARKING CAR IN GARAGE OVERNIGHT, THE CAR IS PUT WENT INTO REVERSE AND BACKED OUT WITHOUT STEPPING ON THE GAS (DRIVEWAY IS SLOPED). AFTER SHIFTING INTO DRIVE, THE CAR LAGS ANYWHERE FROM 3 TO 10 SECONDS BEFORE THERE IS ANY POWER TO DRIVE. THIS IS SPECIALLY DANGEROUS WHEN THERE IS TRAFFIC.*AK

Owner-reported narrative. 75 miles reported. Look up ODI 10058439 at NHTSA ↗

WHEN DRIVING AT AN UNDETERMINED SPEED TRUNK WOULD OPEN WITHOUT WARNING. CONSUMER TOOK THE VEHICLE TO THE DEALERSHIP FOR INSPECTION, AND MECHANIC DETERMINED THAT VEHICLE HAD AN ELECTRICAL PROBLEM. *AK

Owner-reported narrative. Look up ODI 10059407 at NHTSA ↗

Reported: 2003-03-31 (March 31, 2003)

ON CERTAIN PASSENGER AND SPORT WAGON VEHICLES WITH AUTOMATIC TRANSMISSIONS, WITH THE ENGINE RUNNING, AND THE VEHICLE AT REST, AN INCREASE OF ENGINE IDLE SPEED (UP TO 1,300 RPM) MAY OCCUR.

Consequence: IF A GEAR IS SELECTED, THE DRIVER MAY FEEL AS IF THE VEHICLE IS BEING PUSHED.

Remedy: DEALERS WILL REPROGRAM THE DIGITAL ENGINE MANAGEMENT CONTROL UNIT. OWNER NOTIFICATION BEGAN MAY 5, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT BMW AT 1-800-831-1117.

Reported: 2003-04-29 (April 29, 2003)

ON CERTAIN PASSENGER VEHICLES, THE WINDOW LIFTING ANTI-PINCHING DEVICE MIGHT NOT FUNCTION PROPERLY.

Consequence: OCCUPANTS COULD BE PINCHED BY A WINDOW THAT IS BEING CLOSED.

Remedy: DEALERS WILL INSPECT, AND IF NECESSARY, REPLACE THE ELECTRONIC CONTROL UNIT FOR THE WINDOW LIFTING ANTI-PINCHING DEVICE. OWNER NOTIFICATION BEGAN MAY 27, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT BMW AT 1-800-831-1117.

Reported: 2011-08-26 (August 26, 2011)

BMW IS RECALLING CERTAIN MODEL YEAR 2002-2005 325I, 325XI, 330I, AND 330XI VEHICLES MANUFACTURED FROM SEPTEMBER 1, 2001, THROUGH MARCH 1, 2005. OVER TIME, RESISTANCE IN THE ELECTRICAL CONTACTS MAY CAUSE ONE OR MORE REAR LAMP FUNCTIONS (TAIL LIGHT, BRAKE LIGHT, AND/OR TURN-SIGNAL), WITHIN THE VEHICLE'S BODY PANEL, TO STOP WORKING.

Consequence: INTERMITTENT LIGHT OPERATION REDUCES THE ABILITY TO WARN OTHER MOTORISTS OF THE DRIVER'S INTENTIONS. THIS COULD CAUSE A VEHICLE CRASH WITHOUT WARNING.

Remedy: BMW WILL NOTIFY OWNERS, AND DEALERS WILL REPAIR THE VEHICLES FREE OF CHARGE. THE SAFETY RECALL BEGAN ON FEBRUARY 15, 2012. OWNERS MAY CONTACT BMW CUSTOMER RELATIONS AND SERVICES AT 1-800-525-7417.

Reported: 2013-05-02 (May 2, 2013)

BMW is recalling certain model year 2002-2003 325i, 325xi, 330i, 330xi sedans; 325Ci and 330Ci coupes and convertibles; 325iT and 325xiT Sports Wagons; and M3 coupes and convertibles to address a safety defect in the passenger side frontal air bag which may produce excessive internal pressure causing the inflator to rupture upon deployment of the air bag.

Consequence: In the event of a crash necessitating deployment of the passenger's frontal air bag, the inflator could rupture with metal fragments striking and potentially seriously injuring the passenger seat occupant or other occupants.

Remedy: Owners are advised not to drive their vehicles until they have been repaired. BMW intends to issue initial notifications to owners informing them of the safety defect in June 2013. Once replacement parts are available, estimated for July, BMW will notify owners again to contact their dealers and schedule a replacement of the passenger air bag, free of charge. Owners may contact BMW customer service at 1-800-525-7417 or email BMW at CustomerRelations@bmwusa.com.

Reported: 2018-06-11 (June 11, 2018)

BMW of North America, LLC (BMW) is recalling certain model year 2000 323i sedans, coupes, convertibles, and Sports Wagons; 2000 328i sedans and coupes; 2001-2005 325i sedans, coupes, convertibles, and Sport Wagons; 2001-2005 325xi sedans and Sports Wagons; 2006 325i coupes and convertibles; 2001-2006 330i sedans, coupes, and convertibles; 2001-2005 330xi sedans; and 2001-2006 M3 coupes and convertibles to address a safety defect in the passenger side frontal air bag which may produce excessive internal pressure that could cause the air bag inflator to rupture upon deployment of the air bag.

Consequence: In the event of a crash necessitating deployment of the passenger's frontal air bag, excessive internal pressure could cause rupturing of the inflator resulting in metal fragments striking and potentially seriously injuring the passenger seat occupant or other occupants.

Remedy: Owners are advised not to drive their vehicles until they have been repaired. BMW will notify owners, and dealers will replace the passenger side frontal air bag, free of charge. An interim notice was mailed to owners in September 2014. A second notice was mailed when an adequate supply of parts became available, on December 1, 2014. Owners may contact BMW customer service at 1-800-525-7417 or email BMW at CustomerRelations@bmwusa.com.

Reported: 2015-05-28 (May 28, 2015)

BMW of North America, LLC (BMW) is recalling certain model year 2002-2005 325i, 325xi, 330i, and 330xi Sedans, and 325xi and 325i Sportswagons, 2002-2006 330Ci, 325Ci, and M3 Convertibles and 325i, 330i, and M3 Coupes, 2002-2003 M5, 540i, 525i Sedan, and 530i Sedans, and 540i and 525i Sportswagons, and 2003 X5 3.0i and 4.4i Sports Activity Vehicles. Please note that the 5-series and X5 vehicles are only included if they are equipped with the optional sports steering wheel. The affected vehicles are equipped with a dual-stage driver frontal air bag that may be susceptible to moisture intrusion which, over time, could cause the inflator to rupture.

Consequence: In the event of a crash necessitating deployment of the driver's frontal air bag, the inflator could rupture with metal fragments striking the driver or other occupants resulting in serious injury or death.

Remedy: Owners are advised not to drive their vehicles until the vehicle has been remedied. BMW will notify owners, and dealers will replace the front driver air bag module, free of charge. The recall began Aug 2016. Owners may contact BMW customer service at 1-800-525-7417. Note: This recall supersedes recall 14V-348 in its entirety. Additionally, vehicles that have had their driver side frontal air bag replaced previously as part of a recall remedy need to have their air bag replaced under this recall as well. Note: On December 17, 2015 BMW removed the model year 2004 X5 3.0i and 4.4i Sports Activity vehicle from this recall. Those vehicles were mistakenly identified as including the air bags that are subject to this recall.

Reported: 2020-01-15 (January 15, 2020)

BMW of North America, LLC (BMW) is recalling certain 2000-2005 323iT, 325iT, 325xiT, 320i, 323i, 325i, 325xi, 328i, 330i and 330xi and 2000-2006 323Ci, 325Ci, 328Ci, 330Ci, M3 Coupe, 323Cic, 325Cic, 330Cic, and M3 Convertible vehicles equipped with non-desiccated frontal Takata PSAN inflators and PSPI passenger frontal air bag inflators containing phase stabilized ammonium nitrate (PSAN) propellant that were used as interim remedy parts for previous Takata recalls. These inflators may explode due to propellant degradation occurring after long-term exposure to high absolute humidity, high temperatures, and high temperature cycling.

Consequence: An inflator explosion may result in sharp metal fragments striking the driver or other occupants resulting in serious injury or death.

Remedy: BMW will notify owners, and dealers will replace the passenger's front air bag, free of charge. The recall began February 13, 2020. Owners may contact BMW customer service at 1-800-525-7417.