2000 Bmw 323I: complaints, problems and recalls

WHILE DRIVING THE VEHICLE AND APPLIED THE BRAKES THE ENGINE WILL SUFFER A SUDDENLY ACCELERATION. DEALER HAS INSPECTED THE VEHICLE AND COULD NOT DUPLICATE OR CORRECT THE PROBLEM. PLEASE PROVIDE FURTHER INFORMATION. TS

Owner-reported narrative. Look up ODI 10001158 at NHTSA ↗

WINDOW REGULATORS HAVE BEEN REPLACED TWO TO THREE TIMES ON ALL FOUR WINDOWS. ALL REPAIRS COMPLETE BY SOUTH MOTORS BMW SERVICE DEPARTMENT EXCEPT THIRD REPAIR ON FRONT PASSENGER WINDOW COMPLETED BY BRAMAN BMW. SERVICE ADVISOR ADMITS THAT THIS IS A KNOWN PROBLEM ON THIS MODEL DUE TO A BAD SUPPLIER. THE VEHICLE HAS BEEN SERVICED 5 TIMES FOR THIS PROBLEM.

Owner-reported narrative. Look up ODI 10005423 at NHTSA ↗

THE SUBFRAME CRACKED WHICH EXPOSED THE GAS TANK. THE CONSUMER FEELS AN IMPACT MY CAUSE AN EXPLOSION. *NLM

Owner-reported narrative. Look up ODI 10015909 at NHTSA ↗

THE SIDE AIRBAG RECALL 02V223000 WAS REMEDIED ON 11/4/02. ON 11/11/02, WHILE DRIVING, THE SIDE AIR BAG DEPLOYED WITHOUT WARNING. THE DEALER REPAIRED AND REPLACED. IN 06/03 THE AIR BAG WARNING LIGHT ILLUMINATED AGAIN. CONSUMER WAS VERY CONCERNED ABOUT THE INTEGRITY OF THE VEHICLE'S AIR BAG SYSTEM. *AK ON THREE SEPARATE OCCASIONS THE SRS LIGHT HAD COME. THE DEALER STATED IT WAS DEFECTIVE AND REPLACED IT. WHILE THE VEHICLE WAS IN MOTION, THE PASSENGER SIDE SRS AND HEAD PROTECTION AIRBAG DEPLOYED DUE TO THE CRASH SENSOR BEING TRIGGERED …

Owner-reported narrative. 47,948 miles reported. Look up ODI 10024877 at NHTSA ↗

CONSUMER STATES MOLDING INSIDE THE WINDOWS WAS FALLING DOWN. DEALER FIXED IT TWICE, AND PROBLEM STILL RECURRING. *AK

Owner-reported narrative. Look up ODI 10029656 at NHTSA ↗

BMW NOT HONORING FULL TERM OF NEW CAR WARRANTY. ALTHOUGH I BOUGHT THE CAR NEW AT A DEALER IN AUGUST 25 2000 AND THE CAR HAD UNDER THE MILEAGE LIMIT, THE DEALERS COMPUTERS LIST THE CAR AS BEING RETAILED IN APRIL 2000 NOT AUGUST 2000. HOWEVER I HAVE AND WAS GIVEN THE BILL OF SALE LISTING THE CAR AS NEW AND RETAILED ON AUGUST 25 2000. WHEN I WENT IN FOR SERVICE ON AUGUST 7 2003, A DEALER, PRESTIGE BMW IN RAMSEY TOLD ME THE INFORMATION BMW HAS LISTS THE CAR AS RETAILING TO ME IN APRIL. EVEN WHEN TOLD I HAD PAPERWORK PROVING OTHERWISE, THE SERVICE R…

Owner-reported narrative. 14,000 miles reported. Look up ODI 10030992 at NHTSA ↗

IN SPITE OF HARDLY EVER USING THE WINDOWS, I HAVE HAD TO REPLACE 2 WINDOW REGULATORS AT MY COST. DEALER STATES THAT THE REGULATORS ARE NOT COVERED BY THE CPO AND ALSO STATES THAT THE WINDOW REGULATORS IS A KNOWN PROBLEM IN THE 3 SERIES AND ALSO IN THE 5 SERIES. VERY UNSATISFIED WITH QUALITY OF VEHICLE.*AK

Owner-reported narrative. 70,000 miles reported. Look up ODI 10033471 at NHTSA ↗

CONSUMER'S VEHICLE WAS HAVING THE SAME PROBLEMS AS MENTIONED IN RECALL 02V223000 CONCERNINT AIR BAGS. DEALER WOULD NOT REPAIR BECAUSE VIN WAS NOT INCLUDED. *AK

Owner-reported narrative. Look up ODI 10037845 at NHTSA ↗

Reported: 2000-02-17 (February 17, 2000)

VEHICLE DESCRIPTION: PASSENGER VEHICLES. THE BRAKE LAMPS IN THESE VEHICLES ARE CONTROLLED BY A SWITCH ACTIVATED BY THE MOVEMENT OF THE BRAKE PEDAL. THIS SWITCH COULD FAIL INTERNALLY, CAUSING IT TO REMAIN EITHER IN THE "BRAKE LAMPS OFF" POSITION OR IN THE "BRAKE LAMPS ON" POSITION.

Consequence: IF THIS HAPPENS, THE BRAKE LAMPS EITHER WILL NOT OPERATE OR WILL BE CONTINUOUSLY ILLUMINATED, REGARDLESS OF BRAKE PEDAL POSITION.

Remedy: DEALERS WILL INSPECT AND, IF NECESSARY, REPLACE THE EXISTING BRAKE LAMP SWITCH WITH AN IMPROVED SWITCH.

Reported: 2002-08-09 (August 9, 2002)

ON CERTAIN 4-DOOR PASSENGER VEHICLES, THE SIDE AIR BAG SYSTEM COULD DEPLOY IN CERTAIN NON-CRASH IMPACTS, SUCH AS WHEN CONTACTING LARGE POTHOLES OR CURBS AT SUBSTANTIAL SPEEDS.

Consequence: THIS COULD CAUSE THE SIDE AIR BAG AND HEAD PROTECTION SYSTEM TO DEPLOY WITHOUT AN ACTUAL SIDE CRASH OR IMPACT SEVERE ENOUGH TO CAUSE SIGNIFICANT VISIBLE DAMAGE TO THE VEHICLE. UNEXPECTED DEPLOYMENT OF THE SIDE AIR BAG COULD CAUSE SERIOUS INJURY IF THE OCCUPANT'S HEAD IS RESTING NEAR THE SIDE AIR BAG.

Remedy: DEALERS WILL RECALIBRATE THE CENTRAL AIR BAG CONTROL MODULE TO REDUCE THE POSSIBILITY OF SUCH A NON-CRASH DEPLOYMENT. OWNER NOTIFICATION BEGAN OCTOBER 25, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT BMW AT 1-800-831-1117.

Reported: 2018-06-11 (June 11, 2018)

BMW of North America, LLC (BMW) is recalling certain model year 2000 323i sedans, coupes, convertibles, and Sports Wagons; 2000 328i sedans and coupes; 2001-2005 325i sedans, coupes, convertibles, and Sport Wagons; 2001-2005 325xi sedans and Sports Wagons; 2006 325i coupes and convertibles; 2001-2006 330i sedans, coupes, and convertibles; 2001-2005 330xi sedans; and 2001-2006 M3 coupes and convertibles to address a safety defect in the passenger side frontal air bag which may produce excessive internal pressure that could cause the air bag inflator to rupture upon deployment of the air bag.

Consequence: In the event of a crash necessitating deployment of the passenger's frontal air bag, excessive internal pressure could cause rupturing of the inflator resulting in metal fragments striking and potentially seriously injuring the passenger seat occupant or other occupants.

Remedy: Owners are advised not to drive their vehicles until they have been repaired. BMW will notify owners, and dealers will replace the passenger side frontal air bag, free of charge. An interim notice was mailed to owners in September 2014. A second notice was mailed when an adequate supply of parts became available, on December 1, 2014. Owners may contact BMW customer service at 1-800-525-7417 or email BMW at CustomerRelations@bmwusa.com.

Reported: 2019-11-26 (November 26, 2019)

BMW of North America, LLC (BMW) is recalling certain 1999-2000 323i and 328i and 2000 323Ci and 328Ci vehicles equipped with Non-Azide Driver air bag Inflators (NADI) manufactured by Takata. These inflators do not contain phase stabilized ammonium nitrate (PSAN) propellant. Due to a manufacturing issue, the NADI inflators may absorb moisture, causing the inflators to rupture or the air bag cushion to underinflate.

Consequence: In the event of a crash necessitating air bag deployment, an inflator rupture may result in metal fragments striking the driver or other occupants. An underinflated air bag may not properly protect the occupant. These scenarios increase the risk of serious injury or death.

Remedy: BMW will mail interim notices informing owners of the safety risk on January 17, 2020. Owners will receive a second notice when the remedy becomes available. Dealers will inspect the driver air bag inflators and replace them, as necessary, free of charge. BMW mailed interim notices informing owners of the safety risk on January 17, 2020. The recall began July 27, 2020. Owners may contact BMW customer service at 1-800-525-7417.

Reported: 2019-11-26 (November 26, 2019)

BMW of North America, LLC (BMW) is recalling certain 1999-2001 323i, 325i, 328i and 330i and 2000-2001 323Ci, 325Ci, 328Ci, 330Ci, 323iT, and 325iT vehicles equipped with Non-Azide Driver air bag Inflators (NADI) manufactured by Takata. These vehicles may have received a replacement driver air bag as part of a vehicle repair. Due to a manufacturing issue, the replacement NADI inflator may absorb moisture, causing the inflator to rupture or the air bag cushion to underinflate.

Consequence: In the event of a crash necessitating air bag deployment, an inflator rupture may result in metal fragments striking the driver or other occupants. An underinflated air bag may not properly protect the occupant. These scenarios increase the risk of serious injury or death.

Remedy: BMW notified owners, and Dealers will replace the driver air bag inflators, free of charge. The recall began November 10, 2020. Owners may contact BMW customer service at 1-800-525-7417.

Reported: 2020-01-15 (January 15, 2020)

BMW of North America, LLC (BMW) is recalling certain 2000-2005 323iT, 325iT, 325xiT, 320i, 323i, 325i, 325xi, 328i, 330i and 330xi and 2000-2006 323Ci, 325Ci, 328Ci, 330Ci, M3 Coupe, 323Cic, 325Cic, 330Cic, and M3 Convertible vehicles equipped with non-desiccated frontal Takata PSAN inflators and PSPI passenger frontal air bag inflators containing phase stabilized ammonium nitrate (PSAN) propellant that were used as interim remedy parts for previous Takata recalls. These inflators may explode due to propellant degradation occurring after long-term exposure to high absolute humidity, high temperatures, and high temperature cycling.

Consequence: An inflator explosion may result in sharp metal fragments striking the driver or other occupants resulting in serious injury or death.

Remedy: BMW will notify owners, and dealers will replace the passenger's front air bag, free of charge. The recall began February 13, 2020. Owners may contact BMW customer service at 1-800-525-7417.

Reported: 2021-05-27 (May 27, 2021)

BMW of North America, LLC (BMW) is recalling certain 2000-2001 BMW 3 Series (323Ci, 325Ci, 328Ci and 330Ci), 1999-2001 323i, 328i, 330i, 330xi, and 2000 323i, 328i stationwagon vehicles equipped with Non-Azide Driver air bag Inflators (NADI) manufactured by Takata. These vehicles are equipped with driver-side air bag inflators that were previously inspected, but not replaced under recall numbers 19V-851, 19V852, or 19V-853. Due to a manufacturing issue, the NADI inflator may absorb moisture, causing the inflator to explode or the air bag cushion to underinflate.

Consequence: The inflator could explode during air bag deployment, resulting in metal fragments striking the driver or other occupants. An underinflated air bag may not properly protect the occupant. These scenarios increase the risk of serious injury or death.

Remedy: Dealers will replace the driver-side air bag inflator with a newly designed inflator, free of charge. Owner notification letters were mailed on July 12, 2021. Owners may contact BMW customer service at 1-800-525-7417.