2018 Autocar XPEDITOR: complaints, problems and recalls

Reported: 2017-12-07 (December 7, 2017)

Autocar, LLC (Autocar) is recalling certain 2017-2018 Xpeditor vehicles. These vehicles are equipped with an HVAC defrost door actuator system mechanism that may overheat due to inadequate circuit protection.

Consequence: Overheating of the defrost actuator increases the risk of a fire.

Remedy: Autocar will notify owners, and dealers will install an additional harness with a one amp fuse to the circuit, free of charge. The recall began on January 12, 2018. Owners may contact Autocar customer service at 1-888-218-3611. Autocar's number for this recall is ACX-1704.

Reported: 2018-03-12 (March 12, 2018)

Autocar, LLC (Autocar) is recalling certain 2014-2018 Xpeditor vehicles equipped with a factory installed methane detection system. The circuit protection for the methane detector may be inadequate, and the harness may be improperly routed.

Consequence: In the event that the wiring harness carries excessive current, the harness may overheat, increasing the risk of a fire.

Remedy: Autocar will notify owners, and dealers will replace the ten amp fuse with a three amp fuse, free of charge. The recall began on April 13, 2018. Owners may contact Autocar customer service at 1-888-218-3611 or 1-877-973-3486. Autocar's number for this recall is ACX-1801.

Reported: 2018-04-09 (April 9, 2018)

Autocar, LLC (Autocar) is recalling certain 2018-2019 Autocar Xpeditor vehicles. The pinch bolt on the clamp for the adjustable length drag link may not have been properly tightened.

Consequence: If the pinch bolt loosens, there may be a loss of steering control, increasing the risk of a crash.

Remedy: Autocar will notify owners, and dealers will inspect the drag link pinch bolt, tightening it as necessary, free of charge. The recall began on May 25, 2018. Owners may contact Autocar customer service at 1-888-218-3611 or 1-877-973-3486. Autocar's number for this recall is ACX-1802.

Reported: 2019-02-15 (February 15, 2019)

Autocar, LLC (Autocar) is recalling certain 2008-2019 Xpeditor vehicles. The affected vehicles are equipped with undersized brake chambers, possibly allowing the truck to roll when parked. As a result, the vehicles fail to comply with Federal Motor Vehicle Safety Standard (FMVSS) number 121, "Air brake systems."

Consequence: Unexpected movement when parked can increase the risk of crash.

Remedy: Autocar will notify owners, and dealers will replace the parking brake chambers with ones of the proper size, free of charge. The recall began April 16, 2019. Owners may contact Autocar customer service at 1-888-218-3611 or 1-877-973-3486. Autocar's number for this recall is ACX-1903.

Reported: 2019-06-14 (June 14, 2019)

Autocar, LLC (Autocar) is recalling certain 2013-2018 Autocar Xpeditor vehicles. The drive shaft support cross member may fail.

Consequence: If the cross member fails, the components that it supports may come loose from the vehicle, increasing the risk of crash.

Remedy: Autocar will notify owners, and dealers will install additional support brackets and cross members and replace any damaged components, free of charge. Autocar issued owners an interim notification on August 7, 2019. The recall began October 13, 2020. Owners may contact Autocar customer service at 1-888-218-3611 or 1-877-973-3486. Autocar's number for this recall is ACX-1906.

Reported: 2020-01-15 (January 15, 2020)

Autocar, LLC (Autocar) is recalling certain 2013-2020 Xpeditor vehicles. The ignition relay may fail without warning, causing the vehicle to stall.

Consequence: A vehicle stall can increase the risk of crash.

Remedy: Autocar will notify owners, and dealers will replace the ignition relay, free of charge. Autocar issued owners an interim notification on March 12, 2020. Owners may contact Autocar customer service at 1-888-218-3611 or 1-877-973-3486. Autocar's number for this recall is ACX-2001.

Reported: 2020-05-07 (May 7, 2020)

Autocar, LLC (Autocar) is recalling certain 2016-2020 Autocar Xpeditor vehicles equipped with Wabco Automatic Traction Control (ATC) electronic control units (ECU). The ATC ECUs may not be programmed correctly and may malfunction without warning.

Consequence: An ATC ECU malfunction may increase the risk of a crash.

Remedy: Autocar will notify owners, and dealers will reprogram the ATC ECU, free of charge. Owners may contact Autocar customer service at 1-888-218-3611 or 1-877-973-3486. The recall began July 6, 2020. Autocar's number for this recall is ACX-2002.

Reported: 2020-07-20 (July 20, 2020)

Autocar, LLC. (Autocar) is recalling certain 2014-2018 Xpeditor vehicles manufactured with a single cross-member behind the engine and equipped with a front engine power take off (FEPTO). The mounting brackets of the first cross member behind the engine may fail prematurely due to strain caused by improper spacing between the cross members, causing the supportive cross member to become loose and detach from the frame rails.

Consequence: If the cross member fails, the components that it supports may come loose from the vehicle, increasing the risk of crash.

Remedy: Autocar will notify owners, and dealers will replace any damaged components as well as install additional support brackets and an additional cross member, free of charge. Autocar issued owners an interim notification on September 18, 2020. Owners may contact Autocar's customer service at 1-888-218-3611 or 1-877-973-3486. Autocar's number for this recall is ACX-2003. Note: These vehicles were separated out of the previous Autocar recall (19V-456) due to their unique configuration.

Reported: 2020-07-31 (July 31, 2020)

Autocar, LLC (Autocar) is recalling certain 2018-2021 Xpeditor trucks with a right-hand drive cab configuration equipped with a park brake valve (button) located to the right of the steering wheel. The parking brake synchronization valve plumbing may be improperly assembled, causing the parking brake to apply unexpectedly without warning.

Consequence: Unexpected parking brake application can increase the risk of a crash.

Remedy: Autocar will notify owners, and dealers will correct the plumbing to allow the system to operate as designed. The recall began September 28, 2020. Owners may contact Autocar customer service at 1-888-218-3611 or 1-877-973-3488. Autocar's number for this recall is ACX-2004.

Reported: 2021-01-28 (January 28, 2021)

Autocar, LLC (Autocar) is recalling certain 2018-2021 Xpeditor vehicles. These vehicles may have a seat belt harness routing located too close to the seat mechanism. If the harness chafes and short circuits, the circuit protection fuse will open, and the engine will shut off and not restart.

Consequence: The vehicle may stall and not restart, without warning, increasing the risk of a crash, personal injury or property damage.

Remedy: Autocar will notify owners, and dealers will route and secure the seatbelt wiring clear of the seat mechanism, free of charge. The recall began on March 25, 2021. Owners may contact Autocar customer service at 1-888-218-3611 or 1-877-973-3486. Autocar's number for this recall is ACX-2101.

Reported: 2021-02-18 (February 18, 2021)

Autocar, LLC (Autocar) is recalling certain 2018-2021 Xpeditor vehicles. The turbocharger heat shield may fail and detach from the vehicle.

Consequence: A detached heat shield can become a road hazard, increasing the risk of a crash or injury.

Remedy: Autocar will notify owners, and dealers will replace the turbocharger heat shield, free of charge. Owner notification letters were mailed on June 24, 2021. Owners may contact Autocar customer service at 1-888-218-3611 or 1-877-973-3486. Autocar's number for this recall is ACX-2103.

Reported: 2023-01-23 (January 23, 2023)

Autocar, LLC (Autocar) is recalling certain 2012-2016 Xpert, 2010-2020 Xspotter, 2008-2020 Xpeditor, 2008-2010 WXLL and WX vehicles. A worn parking brake control valve can leak air into the vent line, creating excessive back pressure and causing the parking brake to release unexpectedly.

Consequence: The unexpected release of the parking brake may allow the vehicle to rollaway, increasing the risk of a crash.

Remedy: Dealers will remove the vent line and fitting from the valve, free of charge. Owner notification letters were mailed March 23, 2023. Owners may contact Autocar customer service at 1-888-218-3611. Autocar's number for this recall is ACX-2023 ACTT-2301.

Reported: 2023-06-02 (June 2, 2023)

Autocar, LLC (Autocar) is recalling certain 2016-2023 ACX (Xpeditor) and 2020-2023 DC (Legend) vehicles. The park brake warning light may incorrectly illuminate during an air loss event. As such, these trucks fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 101, "Control and Displays."

Consequence: A park brake warning light that illuminates incorrectly increases the risk of a crash.

Remedy: Dealers will replace the pressure switch, free of charge. Owner notification letters were mailed July 31, 2023. Owners may contact Autocar customer service at 1-888-218-3611. Autocar's numbers for this recall is ACX-2307 and DC-2303.

Reported: 2023-10-17 (October 17, 2023)

Autocar, LLC (Autocar) is recalling certain 2016-2023 ACX (Xpeditor) and 2021-2023 DC (Legend) vehicles. The park brake warning light may incorrectly illuminate during an air loss event. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 101, "Control and Displays."

Consequence: A park brake warning light that illuminates incorrectly increases the risk of a crash.

Remedy: Dealers will replace the pressure switch, free of charge. Owner notification letters were mailed January 2, 2024. Owners may contact Autocar customer service at 1-888-218-3611. Autocar's numbers for this recall are ACX-2311 and DC-2306. This recall is an expansion of recall number 23V-400.

Reported: 2025-07-03 (July 3, 2025)

Autocar, LLC (Autocar) is recalling certain 2015-2022 ACTT (Xspotter) and ACX (Xpeditor) vehicles. The air tanks have an insufficient volume of air for the brake system. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 121, "Air Brake Systems."

Consequence: Insufficient air volume can reduce brake function, extending the distance required to stop and increasing the risk of a crash.

Remedy: Dealers will inspect and replace or add additional air tanks as necessary, free of charge. Interim owner notification letters explaining the safety risk were mailed August 29, 2025. Owners will receive a second notice once remedy parts become available, anticipated September 2026. Owners may contact Autocar customer service at 1-888-218-3611. Autocar's numbers for this recall are ACTT-2503 and ACX-2503.