Toyota GR86 problems and owner complaints

COMPONENT/SYSTEM FAILURE: Engine - Catastrophic engine failure due to oil starvation on August 4, 2025. FA24 engine consumed excessive oil without triggering oil pressure warning light or low oil level indicator. Oil was changed at 500 miles after purchase and topped off on July 12, 2025. Engine failed 23 days later with no warning. Vehicle has been at dealership since August 4, 2025 (34+ business days). Component is available for inspection at [Dealer Name] Toyota. SAFETY RISK: Sudden engine failure without warning created immediate dangerous…

Owner-reported narrative. Look up ODI 11688386 at NHTSA ↗

The contact owned a 2023 Toyota GR86 Sport vehicle. The contact stated that while driving 139 MPH for a couple of minutes, the vehicle stalled. Several unknown warning lights were illuminated. The contact was able to pull to the side of the road. The vehicle failed to restart and was towed to the dealer, where it was diagnosed that the engine had failed and needed to be replaced. The contact stated that the vehicle was covered under warranty; however, the dealer informed the contact that the repair could not be covered under warranty because th…

Owner-reported narrative. 33,000 miles reported. Look up ODI 11666520 at NHTSA ↗

Engine blew around May, what caused this issue would be unknown even though the dealership said it was excessive RTV on the oil pan, there was no RTV on the oil pan (i have a picture). I was driving on the highway and slowing down to take my exit, it happened around 25mph, car got stuck on 3rd gear if im not mistaken (its an automatic transmission by the way). Ended up with 3 holes in the engine block, a missing valve, oil all over the engine bay which caused the car to release white smoke through exhaust and hood.

Owner-reported narrative. Look up ODI 11756294 at NHTSA ↗

The Cross- Caster Defect: "A comparative analysis of two alignment sheets proves a structural suspension failure. On June 4, 2026, the vehicle's left front caster was at a factory-healthy 5.9 Following a tire blow out/tire failure just three weeks later the left front caster dropped to 5.6. This creates a severe 0.5 cross-caster split between the left and right front wheels." The Unadjustable Failure: "Front caster is a non-adjustable factory setting on the Toyota GR86. This unadjustable 0.3 shift in geometry is absolute mathematical proof of …

Owner-reported narrative. Look up ODI 11754343 at NHTSA ↗

The dome light on the driver side has failed. This is not due to a dead bulb, but instead the circuit area seems to die if the car sits in the sun. This has been confirmed by a dealer but I haven't yet scheduled an appointment to replace the electrical parts. There were no safety warnings.

Owner-reported narrative. Look up ODI 11562530 at NHTSA ↗

The car began throwing alerts about SRS system failure, RAB failure and eyesight (safety system) being disabled suddenly while driving. Dealership said dashcam plugged into the 12v port in the car overloaded the fuse. Issue remains that the dashcam remained functional before and after and fuse for 12v is independent of the electrical wiring for the safety features. Dealership dismissed as it as a non warranty/safety issue as a third party device was connected to the car. Claimed this is applicable for any devices connected into the car incl…

Owner-reported narrative. Look up ODI 11487412 at NHTSA ↗

There are two fuel lines on each side of the engine bay, driver and passenger going into the injector rails. One of the fuel lines on the driver side is rubbing on the underside of the hood, when closed, causing marks, and potentially a burst on a fuel lines, causing fires. The fuel line on my car has rub marks, and visually “wearing it down”. No bursts, yet. There has been about 10-15 cases of GR86/BRZ (essentially the same car), with fires starting randomly from the engine bay on the driver side, rising the chances of this being a reality, an…

Owner-reported narrative. Look up ODI 11668417 at NHTSA ↗