Thor Motor HURRICANE recalls by model year

Reported: 2015-05-07 (May 7, 2015) · Model years: 2016

Thor Motor Coach (TMC) is recalling certain model year 2016 Hurricane and Windsport motorhomes manufactured March 10, 2015, to March 24, 2015. In the affected motorhomes, the co-pilot seats may be attached to the floor of the motorhome in an area that is not properly reinforced.

Consequence: If the floor at the attachment point is not properly reinforced, the seat base mounting may loosen over time, increasing the risk of injury in the event of a crash.

Remedy: TMC will notify owners, and dealers will install a reinforcement plate at the co-pilot seat mounting bolt location, free of charge. The recall began on June 22, 2015. Owners may contact TMC customer service at 1-877-500-1020. TMC's number for this recall is RC000101.

Reported: 2015-10-23 (October 23, 2015) · Model years: 2016

Thor Motor Coach (TMC) is recalling certain model year 2016 Challenger, Hurricane and Windsport motorhomes manufactured July 31, 2015, to September 9, 2015. In the affected vehicles, the parking brake actuator may be out of calibration causing the parking brake system to not properly hold the vehicle even with the parking brake pedal fully depressed. Additionally, the parking brake may not disengage completely when the parking brake pedal is released.

Consequence: If the parking brake does not fully engage, the vehicle may unexpectedly roll, increasing the risk of personal injury or a crash. A parking brake that drags may result in a wheel end fire.

Remedy: TMC will notify owners, and dealers will replace the parking brake foot pedal assembly, free of charge. The recall began on November 16, 2015. Owners may contact TMC customer service at 1-877-855-2867. TMC's number for this recall is RC000107.

Reported: 2015-10-30 (October 30, 2015) · Model years: 2016

Thor Motor Coach (TMC) is recalling certain model year 2016 Ace, Challenger, Hurricane, Miramar, Outlaw, and Windsport vehicles manufactured July 14, 2015, to October 16, 2015. Due to an incorrect shift cable bracket and an improper shift cable adjustment, the affected vehicles can be shifted out of 'PARK' without applying the brakes.

Consequence: If the vehicle can be shifted into reverse without the brakes being applied, the vehicle may unintentionally move, increasing the risk of a crash.

Remedy: Ford will notify owners on TMC's behalf, and Ford dealers will replace the transmission shift control bracket and adjust the transmission shift cable, free of charge. The recall began on November 12, 2015. Owners may contact TMC customer service at 1-877-500-1020. TMC's number for this recall is RC000110.

Reported: 2015-11-10 (November 10, 2015) · Model years: 2016

Thor Motor Coach (Thor) is recalling certain model year 2011-2016 Thor Challenger, Thor Citation, Thor Hurricane, Thor Tuscany, Thor Windsport, 2011-2012 Thor Astoria, Thor Avanti, Thor Chateau, 2011-2014 Thor Daybreak, 2011-2015 Thor Outlaw, Thor Siesta, 2014-2015 Thor Miramar, 2012 Thor Four Winds, 2008-2011 Damon Astoria, Damon Daybreak, Damon Outlaw, Damon Tuscany, 2008-2012, Damon Challenger, 2008-2010 Damon Essence, 2009-2011 Damon Avanti, Four Winds Chateau, Four Winds Citation, Four Winds Four Winds, Four Winds Hurricane, Four Winds Siesta, Four Winds Windsport, 2009-2010 Four Winds Dorado, Four Winds Dutchmen, Four Winds Magellan, Four Winds Mandalay and 2009 Four Winds Fun Mover, and Four Winds Presidio motorhomes. The affected vehicles are equipped with certain Lippert-brand Coachstep Double and Triple Electric Steps. These steps use a bolt to attach the fan gear assembly to the steps. This bolt may fracture allowing the fan gear to disengage from the steps. As a result, the steps may not remain in the expected position and may be unstable.

Consequence: Unstable entry and exit steps increase the risk of injury.

Remedy: Thor will notify owners, and dealers will install a retainer bracket to reinforce the operating mechanism and replace all of the affected bolts, free of charge. The recall began on January 6, 2016. Owners may contact Thor customer service at 1-877-855-2867. Thor's number for this recall is RC000111.

Reported: 2016-03-07 (March 7, 2016) · Model years: 2016

Thor Motor Coach (TMC) is recalling certain model year 2014-2016 Hurricane and Windsport motor homes manufactured January 30, 2013, to March 6, 2015. In the affected motor homes, the vehicle exhaust is located near a storage compartment where heat may build-up, causing the compartment to melt.

Consequence: Heat build-up in the vehicle storage compartment increases the risk of fire.

Remedy: TMC will notify owners, and dealers will install a heat shield to prevent heat build-up in the storage compartment. The recall began on April 20, 2016. Owners may contact TMC customer service at 1-877-855-2867. TMC's number for this recall is RC000112.

Reported: 2017-03-13 (March 13, 2017) · Model years: 2016

Thor Motor Coach (TMC) is recalling certain 2014-2015 ACE, Hurricane, Challenger, Daybreak, Miramar, Outlaw, and Windsport motorhomes. These vehicles have windshield wiper systems that may have been improperly installed and secured, possibly causing the wipers to fail during use.

Consequence: Failure of the windshield wipers may impair the driver's visibility, increasing the risk of a crash.

Remedy: TMC has notified owners, and dealers will inspect and tighten the wiper arm securing nuts, free of charge. The recall began on May 5, 2017. Owners may contact TMC customer service at 1-877-855-2867.

Reported: 2017-09-07 (September 7, 2017) · Model years: 2016

Thor Motor Coach (TMC) is recalling certain 2014-2016 Ace, Challenger, Daybreak, Hurricane, Miramar, Outlaw, Windsport, Palazzo, Tuscany, and Tuscany XTE motorhomes. The windshield wipers may fail due to the system being incorrectly installed or secured.

Consequence: If the windshield wipers cannot be used, driver visibility would be reduced, increasing the risk of a crash.

Remedy: TMC will notify owners, and dealers will inspect the wiper system to verify it is installed correctly, repairing or replacing the system as necessary, free of charge. The recall began on September 27, 2017. Owners may contact TMC customer service at 1-877-855-2867. TMC's number for this recall is RC000146. Note: Although some of the vehicles included in this recall have previously been remedied under recalls 17V-096 or 17V-162, the vehicles may need additional repairs under this campaign.

Reported: 2017-11-22 (November 22, 2017) · Model years: 2016, 2017

Thor Motor Coach (Thor) is recalling various 2003-2018 recreational vehicles, equipped with Kidde Plastic-Handle or Push Button 'Pindicator' Fire Extinguishers. See a list of the affected trailer models at: https://static.nhtsa.gov/odi/rcl/2017/RMISC-17V758-5764.pdf. These extinguishers may become clogged, preventing the extinguisher from discharging as expected or excessive force may be needed to activate the extinguisher. Additionally, in certain models, the nozzle may detach from the valve assembly with enough force that it could cause injury and also render the product inoperable. For a full list of the affected fire extinguisher models visit: https://static.nhtsa.gov/odi/rcl/2017/RMISC-17E062-5427.pdf

Consequence: In the event of a fire, if the fire extinguisher does not function properly, it can increase the risk of injury.

Remedy: Thor will notify owners, instructing them to contact Kidde for a replacement fire extinguisher, free of charge. The recall began on January 15, 2018. Owners may contact Thor customer service at 1-877-500-1020, or Kidde customer service toll-free at 1-855-262-3540, or online at www.kidde.com and click on "Product Safety Recall" for more information.

Reported: 2017-04-10 (April 10, 2017) · Model years: 2017

Thor Motor Coach (TMC) is recalling certain 2017 Ace, Hurricane, and Windsport motorhomes. The weight rating labels for the tow hitches on these vehicles indicate a 10,000lb weight capacity when the actual hitch capacity is 8,000lbs.

Consequence: If the hitch is loaded to the capacity on the label, the hitch may damage the motorhome or the hitch may disconnect from the tow vehicle, increasing the risk of the crash.

Remedy: TMC will notify owners and provide them corrected labels, free of charge. The recall began on May 22, 2017. Owner's may contact TMC customer service at 1-877-500-1020.

Reported: 2017-10-09 (October 9, 2017) · Model years: 2017

Thor Motor Coach (TMC) is recalling certain 2017-2018 Challenger, Axis, Chateau, Four Winds, Hurricane, Miramar, Palazzo, Tuscany, Vegas, Venetian, and Windsport motorhomes. The cargo carrying capacity (CCC) label on these vehicles may indicate an incorrect water capacity for the water heater/fresh water tank. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 120, "Tires and Rims for Motor vehicles over 10,000lbs."

Consequence: If the water capacity information is incorrect and it causes the vehicle to be over loaded, there would be an increased risk of a crash.

Remedy: TMC will notify owners and send them corrected labels, free of charge. The recall began on November 15, 2017. Owners may contact TMC customer service at 1-877-500-1020. TMC's number for this recall is RC000147.