Thomas Built Buses HDX recalls by model year

Reported: 2007-11-29 (November 29, 2007) · Model years: 2001, 2002, 2003, 2004, 2005, 2006, 2007, 2008

CERTAIN 2001 THROUGH 2008 THOMAS BUILT FS-56, ER, MVP ER, HDX, AND MVP EF SCHOOL BUSES MANUFACTURED FROM OCTOBER 23, 2000, THROUGH JANUARY 24, 2006, EQUIPPED WITH TYCO PC BOARD AND TYPE II AUTO RESET CIRCUIT BREAKERS. TYPE II AUTO RESET CIRCUIT BREAKER TEMPERATURES MAY EXCEED THE RATING OF THE TYCO PC BOARD CAUSING THE BOARDS TO MELT POTENTIALLY RESULTING IN A VEHICLE FIRE.

Consequence: A VEHICLE FIRE CAN OCCUR POSSIBLY RESULTING IN A CRASH.

Remedy: THOMAS BUILT WILL NOTIFY OWNERS AND REPAIR THE BUSES BY REPLACING THE TYPE II AUTO RESET CIRCUIT BREAKERS WITH MANUAL CIRCUIT BREAKERS, AND THE JUMPER CABLE. THE RECALL BEGAN ON MARCH 28, 2008. OWNERS MAY CONTACT THOMAS BUILT CUSTOMER SUPPORT OFFICE AT 336-889-4871.

Reported: 2008-02-26 (February 26, 2008) · Model years: 2001, 2002, 2003, 2004, 2005, 2006, 2007, 2008

DAIMLER TRUCKS IS RECALLING 243,435 MY 1995-2008 THOMAS BUILT SCHOOL BUSES MANUFACTURED BETWEEN JANUARY 1994, AND MARCH 10, 2008. (ADDITIONAL BUSES HAVE BEEN ADDED TO THIS RECALL CAMPAIGN. PLEASE SEE SUPPLEMENTAL REPORT NO. 4) THE EMERGENCY EXIT DOOR HANDLE BEGINS CORRODING AROUND THE SECURING ROLL PIN AND SQUARE DRIVE MECHANISM CAUSING THE PROTECTIVE FINISH TO CHIP AND FLAKE. CONTINUED CORROSION AND PITTING WEAKENS THE HANDLE. HANDLES WEAKENED BY CORROSION MAY BREAK WHILE TRYING TO OPEN THE DOOR FROM THE EXTERIOR.

Consequence: IN THE EVENT OF AN EMERGENCY, A PERSON ON THE OUTSIDE OF THE BUS MAY BREAK THE DOOR HANDLE TRYING TO OPEN THE EMERGENCY EXIT POTENTIALLY DELAYING EVACUATION AND INCREASING THE RISK OF PERSONAL INJURY TO THE VEHICLE'S OCCUPANTS.

Remedy: DAIMLER TRUCKS WILL NOTIFY OWNERS AND WILL REPLACE THE HANDLES WITH A MORE ROBUST HANDLE FREE OF CHARGE. REPAIRS WILL BE PERFORMED BY THOMAS BUILT BUSES DEALERSHIPS. THE RECALL BEGAN ON AUGUST 18, 2008, AND NOTIFICATION FOR THE REVISED POPULATION IS EXPECTED TO BEGIN ON OR ABOUT APRIL 29, 2009. OWNERS MAY CONTACT THOMAS BUILT AT 336-889-4871.

Reported: 2008-02-26 (February 26, 2008) · Model years: 2003, 2004, 2005, 2006, 2007

DAIMLER TRUCKS IS RECALLING 760 MY 2003-2007 THOMAS BUILT SCHOOL BUSES MANUFACTURED BETWEEN JULY 6, 2005 AND JULY 19, 2006, EQUIPPED WITH BRAUN WHEELCHAIR LIFTS, MODELS NL, NCL, OR NVL. THE THRESHOLD WARNING SYSTEMS OF THE SUBJECT MODEL WHEELCHAIR LIFTS FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 403, PLATFORM LIFT SYSTEMS FOR MOTOR VEHICLES.

Consequence: SHOULD THE THRESHOLD WARNING SYSTEM FAIL TO OPERATE, THE LIFT USER CAN FALL FROM THE VEHICLE AND BE SERIOUSLY INJURED.

Remedy: DAIMLER TRUCKS WILL NOTIFY OWNERS AND PROVIDE A FREE REMEDY WHICH WILL BE PERFORMED BY THOMAS BUILT DEALERSHIPS. THE RECALL BEGAN ON AUGUST 8, 2008. OWNERS MAY CONTACT THOMAS BUILT AT 336-889-4871.

Reported: 2008-11-26 (November 26, 2008) · Model years: 2003, 2004, 2005, 2006, 2007, 2008, 2009

DAIMLER TRUCKS IS RECALLING 18,198 MY 2003-2009 THOMAS BUILT ER, MVP-ER, HDX, AND MVP-EF SCHOOL AND TRANSIT BUSES EQUIPPED WITH A DUAL POWER SWITCH AND MANUFACTURED FROM FEBRUARY 1, 2002 THROUGH OCTOBER 17, 2008. SOLID STATE CIRCUIT BREAKERS MAY TRIP UNNECESSARILY POTENTIALLY RESULTING IN A LOSS OF POWER TO THE BUS CHASSIS AND BODY ELECTRICAL CIRCUITS CAUSING AN UNEXPECTED LOSS OF ENGINE POWER AND EXTERIOR LIGHTING.

Consequence: UNEXPECTED LOSS OF ENGINE POWER AND EXTERIOR LIGHTING COULD RESULT IN A VEHICLE CRASH.

Remedy: THOMAS BUILT BUS DEALERS WILL REPLACE THE SOLID STATE DUAL POWER SWITCH WITH A MECHANICAL CIRCUIT PRODUCTION (MEGA FUSE). THE RECALL IS EXPECTED TO BEGIN DURING APRIL 2009. OWNERS MAY CONTACT THOMAS BUILT AT 1-336-889-4871.

Reported: 2006-04-25 (April 25, 2006) · Model years: 2004, 2005, 2006

CERTAIN MY 2004 THROUGH 2006 THOMAS BUILT HDX, EF, AND FS-65 SCHOOL BUSES MANUFACTURED BETWEEN OCTOBER 4, 2004, AND FEBRUARY 14, 2006. THE BODY POWER DISTRIBUTION MODULE (PDM) WAS MANUFACTURED WITH COPPER CIRCUITS THAT ARE TOO THIN FOR THE ELECTRICAL LOADS ENCOUNTERED, POSSIBLY CAUSING THE BOARD TO OVERHEAT.

Consequence: IF THE PDM OVERHEATS IT MAY GENERATE SMOKE AND COULD RESULT IN A FIRE.

Remedy: THOMAS BUILT WILL NOTIFY OWNERS AND WILL REPLACE THE PDM'S THIN COPPER CIRCUITS WITH THICKER COPPER CIRCUITS. THE RECALL BEGAN ON JUNE 30, 2006. OWNERS MAY CONTACT THOMAS BUILT AT 1-877-660-4938.

Reported: 2006-05-03 (May 3, 2006) · Model years: 2004, 2005, 2006, 2007

CERTAIN MY 2004-2007 THOMAS BUILT MINOTOUR, FS65, MVP-EF, AND HDX MODEL SCHOOL BUSES, MANUFACTURED BETWEEN JUNE 16 AND JULY 1, 2005, EQUIPPED WITH RICON WHEELCHAIR LIFTS. CRACKS IN THE LIFT ARMS MAY ALLOW THE MECHANISM TO TWIST DURING STOWAGE, PREVENTING CLOSURE OF THE SAFETY INTERLOCK SWITCHES.

Consequence: IN THE EVENT THIS CONDITION OCCURS DURING PASSENGER OPERATIONS IT MAY NOT BE POSSIBLE TO CLOSE THE LIFT DOOR CAUSING THE VEHICLE INTERLOCKS TO REMAIN ENGAGED PREVENTING MOVEMENT OF THE VEHICLE OR THE ABILITY TO LOAD OR UNLOAD PASSENGERS WITH DISABILITIES FROM THE VEHICLE.

Remedy: RICON IS CONDUCTING THIS RECALL (PLEASE SEE 06E008000) AND WILL REPLACE THE TWO VERTICAL ARMS EVEN IF ONLY ONE ARM IS CRACKED FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN ON MAY 30, 2006. OWNERS MAY CONTACT RICON CUSTOMER SUPPORT DEPT. AT 800-322-2884 OR OWNERS MAY CONTACT THOMAS BUS CUSTOMER SUPPORT OFFICE AT 336-889-4871.

Reported: 2008-12-17 (December 17, 2008) · Model years: 2004, 2005, 2006

DAIMLER TRUCKS NORTH AMERICA (DTNA) IS RECALLING 24,650 SCHOOL AND NON-SCHOOL BUSES, MOTOR HOME CHASSIS, AND TRUCKS MANUFACTURED FROM MARCH 9, 2004 THROUGH AUGUST 18, 2006, EQUIPPED WITH EPA04 CERTIFIED MBE900 ENGINES, MANUFACTURED BY DETROIT DIESEL BETWEEN MARCH 1, 2004, AND JULY 31, 2006. THE HIGH PRESSURE FUEL LINES AND TRANSFER TUBES MAY FATIGUE AND FRACTURE.

Consequence: A FRACTURED FUEL LINE MAY LEAK DIESEL FUEL POSSIBLY RESULTING IN A FIRE OR FUEL MAY BE SPILLED ON THE ROAD CAUSING A SLIPPERY SURFACE, POSSIBLY RESULTING IN A VEHICLE CRASH.

Remedy: DETROIT DIESEL WILL NOTIFY OWNERS AND THE VEHICLES WILL BE REPAIRED WITH MORE ROBUST LINES AND VIBRATION DAMPERS FREE OF CHARGE. REPAIRS WILL BE PERFORMED BY AUTHORIZED DETROIT DIESEL DISTRIBUTORSHIPS. THE RECALL BEGAN ON MARCH 9, 2009. OWNERS MAY CONTACT DETROIT DIESEL 1-313-592-3708 OR DTNA TOLL-FREE AT 1-800-547-0712 FOR MORE INFORMATION.

Reported: 2011-08-31 (August 31, 2011) · Model years: 2005, 2006, 2007, 2008, 2009, 2010, 2011, 2012

DAIMLER TRUCKS NORTH AMERICA IS RECALLING CERTAIN MODEL YEAR 2005 THROUGH 2012 FREIGHTLINER M2, STERLING ACTERRA, 7500 & 8500, AND THOMAS BUILT HDX VEHICLES MANUFACTURED FROM JUNE 23, 2004, THROUGH MARCH 15, 2011, EQUIPPED WITH SPECIFIC MBE900 EPA04 AND EPA07 MODEL ENGINES. THE INTAKE AIR GRID HEATER MAY SHORT CIRCUIT AND FAIL DUE TO EXCESSIVE INTERNAL TEMPERATURES.

Consequence: A SHORT CIRCUITED GRID HEATER COULD RESULT IN A VEHICLE FIRE AND INJURY TO VEHICLE OCCUPANTS.

Remedy: DAIMLER TRUCKS WILL NOTIFY OWNERS, AND DEALERS WILL REPAIR THE VEHICLES FREE OF CHARGE. REPAIRS WILL BE PERFORMED BY DETROIT DIESEL CORPORATION AUTHORIZED REPAIR FACILITIES. THE SAFETY RECALL BEGAN ON SEPTEMBER 12, 2011. OWNERS MAY CONTACT DAIMLER TRUCKS TOLL-FREE AT 1-800-547-0712. THIS RECALL IS AN EXPANSION OF A PREVIOUS RECALL, CAMPAIGN NUMBER 10V-341.

Reported: 2006-01-18 (January 18, 2006) · Model years: 2006

CERTAIN 2006 THOMAS BUILT HDX SCHOOL BUSES MANUFACTURED BETWEEN JULY AND NOVEMBER 2005. THE FRONT SPRING EYES MAY CRACK FROM EMBRITTLEMENT DUE TO AN IMPROPER HEAT TREAT PROCESS.

Consequence: VEHICLE STEERING CONTROL MAY BE REDUCED IF ABNORMAL FRONT SUSPENSION NOISES ARE IGNORED, POSSIBLY RESULTING IN A CRASH AND PERSONAL INJURY.

Remedy: THOMAS BUILT WILL NOTIFY ITS OWNERS AND REPAIR THE STEERING SUSPENSIONS FREE OF CHARGE. THE RECALL BEGAN ON APRIL 10, 2006.

Reported: 2007-03-23 (March 23, 2007) · Model years: 2006, 2007

CERTAIN MY 2006 AND 2007 THOMAS BUILT MINOTOUR, FS-65, C2, HDX, AND EF SCHOOL BUSES MANUFACTURED BETWEEN JANUARY 6 AND SEPTEMBER 6, 2006, EQUIPPED WITH RICON WHEELCHAIR PLATFORM LIFT MODELS S2003, S2005, S2010, S5503, S5505, S5510, K2003, K2005, K2010, K5503, K5505, K5510. THE LIFTS INTERLOCK SWITCH SYSTEM MAY NOT DETECT THE PRESENCE OF A PASSENGER (EITHER WHEELCHAIR OR STANDEE) ON THE PLATFORM LIFT WHICH FAILS TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 404, PLATFORM LIFT SYSTEMS FOR MOTOR VEHICLES.

Consequence: THE DEFECT INVOLVES THE INTERLOCK SWITCH SYSTEM IN THE LIFT NOT DETECTING THE PRESENCE OF A PASSENGER (EITHER WHEELCHAIR OR STANDEE) ON THE RICON WHEELCHAIR PLATFORM LIFT. IN THE EVENT THIS CONDITION OCCURS DURING PASSENGER OPERATIONS IT MAY BE POSSIBLE FOR THE WHEELCHAIR TO TIP BACKWARDS ONTO THE PLATFORM WHEN THE PLATFORM WAS LOWERED. THIS COULD RESULT IN INJURY TO THE WHEELCHAIR'S OCCUPANT. ALSO, ANYONE STANDING ON THE PLATFORM COULD LOSE HIS OR HER BALANCE AND FALL, RESULTING IN INJURY.

Remedy: FREIGHTLINER WILL NOTIFY OWNERS AND WILL REPAIR THE AFFECTED BUSES FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN ON AUGUST 6, 2007. OWNERS CAN CONTACT FREIGHTLINER'S CUSTOMER ASSISTANCE CENTER AT 800-385-4357 OR CONTACT RICON AT 800-322-2884.

Reported: 2008-08-25 (August 25, 2008) · Model years: 2006, 2007, 2008

DAIMLER TRUCKS IS RECALLING 1,419 MY 2006 THROUGH 2008 THOMAS BUILT SCHOOL BUSES AND RECREATIONAL VEHICLE CHASSIS MANUFACTURED BETWEEN MARCH 7, 2005 AND MAY 27, 2008, EQUIPPED WITH RICON PLATFORM STYLE WHEELCHAIR LIFTS. THESE BUSES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 404, "PLATFORM LIFT INSTALLATIONS IN MOTOR VEHICLES." THE THRESHOLD WARNING SYSTEM MAY NOT DETECT THE PRESENCE OF A WHEELCHAIR OR MOBILITY AID USER IN A CERTAIN SPOT WITHIN THE DEFINED THRESHOLD AREA.

Consequence: THE USER OF THE LIFT COULD BE INJURED SHOULD THE LIFT MOVE UNINTENTIONALLY.

Remedy: THOMAS BUILT IS WORKING WITH RICON TO CORRECT THE WHEELCHAIR LIFTS FREE OF CHARGE (PLEASE SEE 07E095). THE RECALL BEGAN ON NOVEMBER 26, 2008. OWNERS MAY CONTACT RICON AT 1-818-267-3000 OR THOMAS BUILT 1-336-889-4871.

Reported: 2008-08-25 (August 25, 2008) · Model years: 2006, 2007

DAIMLER TRUCKS IS RECALLING 2,250 MY 2006 AND 2007 THOMAS BUILT MINOTOUR, FS65, C2, HDX, AND MVP EF SCHOOL BUSES AND RECREATIONAL VEHICLE CHASSIS MANUFACTURED BETWEEN MARCH 9, 2005 AND FEBRUARY 23, 2007, EQUIPPED WITH RICON S OR K SERIES WHEELCHAIR LIFTS. THE ANTI-STOW INTERLOCK MAY NOT DETECT THE PRESENCE OF A WHEELCHAIR OR MOBILITY AID USER. THE PRESSURE SENSING SWITCH THAT DETECTS THE PRESENCE OF WEIGHT ON THE PLATFORM WAS NOT ADJUSTED TO THE NECESSARY SENSITIVITY LEVEL. THE LIFT COULD STOW EVEN THOUGH SOMEONE OR SOMETHING IS STILL ON THE LIFT WHICH FAILS TO COMPLY WITH FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 404, "PLATFORM LIFT INSTALLATIONS IN MOTOR VEHICLES."

Consequence: A LIFT OCCUPANT CAN BE INJURED SHOULD THE LIFT BEGIN TO STOW UNINTENTIONALLY.

Remedy: DAIMLER TRUCKS IS WORKING WITH RICON TO CORRECT THE WHEELCHAIR LIFTS (PLEASE SEE 07E097). THE RECALL BEGAN ON NOVEMBER 26, 2008. OWNERS MAY CONTACT RICON AT 1-800-322-2884 OR THOMAS BUILT AT 1-336-889-4871.

Reported: 2006-06-12 (June 12, 2006) · Model years: 2007

CERTAIN HEAVY TRUCKS, SHUTTLE BUSES, AND SCHOOL BUSES EQUIPPED WITH BENDIX MODULATED SPRING BRAKE VALVES. A DEFECT IN THE MODULATED SPRING BRAKE VALVE CASTING MAY CAUSE AN INTERMITTENT DELAY IN THE APPLICATION OF THE PARK BRAKE.

Consequence: THE VEHICLE MAY ROLLAWAY WITHOUT WARNING, POSSIBLY CAUSING PERSONAL INJURY.

Remedy: FREIGHTLINER WILL NOTIFY OWNERS AND REPLACE THE DEFECTIVE VALVES FREE OF CHARGE. THE RECALL BEGAN ON JUNE 28, 2006 TO FREIGHTLINER, STERLING, AND FCCC OWNERS. THOMAS BUILT MAILED LETTERS TO OWNERS BEGINNING JULY 27, 2006. THIS RECALL HAS BEEN SUPERSEDED (REPLACED) BY RECALL 07V302 (FL-504).

Reported: 2007-07-18 (July 18, 2007) · Model years: 2007, 2008

FREIGHTLINER IS RECALLING CERTAIN SCHOOL BUS CHASSIS, HEAVY TRUCKS, VAN CHASSIS, RV MOTORHOME CHASSIS MANUFACTURED FROM JANUARY 5 TO MAY 17, 2007, EQUIPPED WITH AXLE ALLIANCE COMPANY (AAC) FRONT AXLES. DURING THE FRONT AXLE ASSEMBLY, THE FASTENERS THAT ATTACH THE STEERING ARM OR TIE ROD ARMS TO THE SPINDLE MAY BE OVER OR UNDER TIGHTENED.

Consequence: INCORRECTLY TIGHTENED STEERING ARM FASTENERS MAY FATIGUE AND FRACTURE WHICH COULD CAUSE A CRASH WITHOUT WARNING.

Remedy: THOMAS BUILT WILL NOTIFY OWNERS, INSPECT THE FASTENERS, AND REPLACE THE STEERING ARM IF NECESSARY. THE RECALL BEGAN ON DECEMBER 21, 2007. OWNERS CAN CONTACT FREIGHTLINER AT 1-800-547-0712.

Reported: 2010-07-27 (July 27, 2010) · Model years: 2007, 2008, 2009, 2010, 2011

DAIMLER TRUCKS IS RECALLING CERTAIN MODEL YEAR 2007 THROUGH 2011 FCCC B2 106 CH AND THOMAS BUILT SAF-T-LINER C2 AND HDX SCHOOL BUSES MANUFACTURED FROM SEPTEMBER 5, 2006 THROUGH JUNE 30, 2010, EQUIPPED WITH SPECIFIC MBE900 EPA04 AND EPA07 MODEL ENGINES. THE INTAKE AIR GRID HEATER MAY SHORT CIRCUIT AND FAIL DUE TO EXCESSIVE INTERNAL TEMPERATURES.

Consequence: A SHORT CIRCUITED GRID HEATER COULD RESULT IN A VEHICLE FIRE AND INJURY TO VEHICLE OCCUPANTS.

Remedy: DAIMLER TRUCKS WILL NOTIFY OWNERS AND DEALERS WILL REPAIR THE BUSES FREE OF CHARGE. REPAIRS WILL BE PERFORMED BY DETROIT DIESEL CORPORATION AUTHORIZED REPAIR FACILITIES. THE SAFETY RECALL IS EXPECTED TO BEGIN ON OR ABOUT JULY 29, 2011. OWNERS MAY CONTACT DAIMLER TRUCKS TOLL-FREE AT 1-800-547-0712.

Reported: 2008-06-17 (June 17, 2008) · Model years: 2008

DAIMLER TRUCKS IS RECALLING 2,506 MY 2008 XC MOTOR HOME CHASSIS AND THOMAS BUILT HDX SCHOOL AND TRANSIT BUSES EQUIPPED WITH SAF-HOLLAND ADL SERIES REAR SUSPENSIONS. IN SOME INSTANCES THE TRANSVERSE BEAM WAS NOT PROPERLY WELDED WHICH COULD RESULT IN A FAILURE OF THE WELD.

Consequence: IF THE WELD FAILS, VEHICLE STABILITY WHILE CORNERING COULD BE AFFECTED RESULTING IN LOSS OF VEHICLE CONTROL, POSSIBLY RESULTING IN A CRASH. IN ADDITION, THE TRANSVERSE BEAM COULD DROP TO THE GROUND CAUSING SPARKS THAT COULD CAUSE A FIRE HAZARD.

Remedy: DAIMLER TRUCKS IS WORKING WITH SAF-HOLLAND TO HAVE A VISUAL INSPECTION OF THE ADL TRANSVERSE BEAM PERFORMED. IF A WELD DEFECT IS IDENTIFIED, SAF-HOLLAND WILL PROVIDE A SERVICE REPLACEMENT KIT THAT CONTAINS A NEW TRANSVERSE BEAM, ALL NECESSARY INSTALLATION HARDWARE, BEAM REPLACEMENT, AND INSTRUCTIONS FREE OF CHARGE (PLEASE SEE 08E031). THE RECALL RECALL BEGAN ON SEPTEMBER 12, 2008 (THOMAS BUILT BUSES) AND OCTOBER 8, 2008. OWNERS MAY CONTACT SAF-HOLLAND AT 1-231-773-3271 OR DAIMLER TRUCKS AT 1-800-547-0712.

Reported: 2009-10-02 (October 2, 2009) · Model years: 2009, 2010

DAIMLER TRUCKS IS RECALLING CERTAIN MODEL YEAR 2009-2010 THOMAS BUILT SCHOOL BUSES MANUFACTURED BETWEEN MARCH 31, 2008 AND FEBRUARY 18, 2009, EQUIPPED WITH SPECIALTY MANUFACTURING, INC. (SMI) 000290 LED LIGHT KITS. A CHANGE TO THE WIRE USED IN THE LED LIGHT KITS MAY REDUCE THE EFFECTIVE LIFE OF THE LIGHTS USED ON THE STOP ARMS. THE LIGHTS MAY STOP FUNCTIONING WITHOUT WARNING.

Consequence: SHOULD THE LED LIGHTS STOP FUNCTIONING, VISIBILITY OF A STOPPED BUS WOULD BE DECREASED, POSSIBLY ENDANGERING A CHILD OR PEDESTRIAN TO INJURY BY PASSING VEHICLES.

Remedy: THOMAS BUILT WILL NOTIFY OWNERS AND LIGHT KITS WILL BE REPLACED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON FEBRUARY 3, 2010. OWNERS MAY CONTACT THOMAS BUILT AT 1-800-547-0712.

Reported: 2010-05-03 (May 3, 2010) · Model years: 2009, 2010

DTNA IS RECALLING CERTAIN MODEL YEAR 2009 AND 2010 HDX SCHOOL BUSES MANUFACTURED ON NOVEMBER 15, 2007 THROUGH JUNE 15, 2009. THE HEATER COOLANT FLOW VALVE ACTUATOR 0-RING MAY ALLOW COOLANT LEAKAGE INTO THE HEATER CORE COMPARTMENT AND THE ACTUATOR PC BOARD AREA POTENTIALLY CAUSING THE ACTUATOR TO OVERHEAT AND/OR MELT.

Consequence: AN OVERHEATED AND/OR MELTED ACTUATOR MAY RESULT IN A VEHICLE FIRE.

Remedy: DTNA WILL NOTIFY OWNERS AND REPAIRS WILL BE PERFORMED BY THOMAS BUILT DEALERSHIPS FREE OF CHARGE. THE SAFETY RECALL BEGAN ON JULY 6, 2010. OWNERS MAY CONTACT THOMAS BUILT AT 1-336-889-4871.

Reported: 2010-05-03 (May 3, 2010) · Model years: 2009, 2010

DTNA IS RECALLING CERTAIN MODEL YEAR 2009 AND 2010 HDX NON SCHOOL BUSES MANUFACTURED BEGINNING NOVEMBER 20, 2007 THROUGH MAY 8, 2009. THE HEATER COOLANT FLOW VALVE ACTUATOR 0-RING MAY ALLOW COOLANT LEAKAGE INTO THE HEATER CORE COMPARTMENT AND THE ACTUATOR PC BOARD AREA POTENTIALLY CAUSING THE ACTUATOR TO OVERHEAT AND/OR MELT.

Consequence: AN OVERHEATED AND/OR MELTED ACTUATOR MAY RESULT IN A VEHICLE FIRE.

Remedy: DTNA WILL NOTIFY OWNERS AND REPAIRS WILL BE PERFORMED BY THOMAS BUILT DEALERSHIPS FREE OF CHARGE. THE SAFETY RECALL BEGAN ON JULY 6, 2010. OWNERS MAY CONTACT THOMAS BUILT AT 1-336-889-4871.

Reported: 2009-07-23 (July 23, 2009) · Model years: 2010

DAIMLER TRUCKS IS RECALLING 35 MODEL YEAR 2010 MVP-EF AND HDX THOMAS BUILT TRANSIT BUSES MANUFACTURED FROM OCTOBER 22, 2008 THROUGH MARCH 25, 2009 THE EMERGENCY EXIT PUSH-OUT WINDOW MAY BE INSTALLED IMPROPERLY RESULTING IN BINDING OF THE WINDOW.

Consequence: IN THE EVENT OF AN EMERGENCY EVACUATION, BINDING EMERGENCY EXIT WINDOWS MAY DELAY EVACUATION AND MAY INCREASE THE RISK OF PERSONAL INJURY TO THE VEHICLE OCCUPANTS.

Remedy: DAIMLER TRUCKS WILL NOTIFY OWNERS AND REPAIR THE BUSES FREE OF CHARGE. REPAIRS WILL BE PERFORMED BY DAIMLER TRUCKS DEALERSHIPS. THE SAFETY RECALL BEGAN ON NOVEMBER 5, 2009. OWNERS MAY CONTACT DAIMLER TRUCKS TOLL-FREE AT 1-800-547-0712 OR THOMAS BUILT CUSTOMER SUPPORT OFFICE AT 1-336-889-4871.

Reported: 2010-10-14 (October 14, 2010) · Model years: 2010, 2011

DAIMLER TRUCKS IS RECALLING CERTAIN THOMAS BUILT MVP-EF, HDX, AND SAF-T-LINER C2 SCHOOL BUSES MANUFACTURED FROM MARCH 17, 2009, THROUGH DECEMBER 7, 2009, EQUIPPED WITH STABILUS BLOC-O-LIFT, P/N 5561ED, DRIVER SEATS. THE WELD WHICH HOLDS THE MOUNTING TAB TO THE SHOCK BODY WAS IMPROPERLY WELDED AND CAN BREAK.

Consequence: THE SEAT COULD DROP UNEXPECTEDLY WITHOUT PRIOR WARNING AND COULD CAUSE MOMENTARY LOSS OF STEERING CONTROL, POSSIBLY RESULTING IN A CRASH.

Remedy: DAIMLER TRUCKS WILL NOTIFY OWNERS AND REPAIRS WILL BE PERFORMED BY AUTHORIZED THOMAS BUILT BUSES SERVICE FACILITIES FREE OF CHARGE. THE SAFETY RECALL BEGAN ON NOVEMBER 24, 2010. OWNERS MAY CONTACT DAIMLER TRUCKS AT 1-800-547-0712.

Reported: 2010-10-14 (October 14, 2010) · Model years: 2010, 2011

DAIMLER TRUCKS IS RECALLING CERTAIN THOMAS BUILT MVP-EF AND HDX NON SCHOOL BUSES MANUFACTURED FROM MARCH 17, 2009, THROUGH DECEMBER 7, 2009, EQUIPPED WITH STABILUS BLOC-O-LIFT, P/N 5561ED, DRIVER SEATS. THE WELD WHICH HOLDS THE MOUNTING TAB TO THE SHOCK BODY WAS IMPROPERLY WELDED AND CAN BREAK.

Consequence: THE SEAT COULD DROP UNEXPECTEDLY WITH OUT PRIOR WARNING AND COULD CAUSE MOMENTARY LOSS OF STEERING CONTROL, POSSIBLY RESULTING IN A CRASH.

Remedy: DAIMLER TRUCKS WILL NOTIFY OWNERS AND REPAIRS WILL BE PERFORMED BY AUTHORIZED THOMAS BUILT BUSES SERVICE FACILITIES FREE OF CHARGE. THE SAFETY RECALL BEGAN ON NOVEMBER 24, 2010. OWNERS MAY CONTACT DAIMLER TRUCKS AT 1-800-547-0712.

Reported: 2010-02-23 (February 23, 2010) · Model years: 2011

DAIMLER TRUCKS IS RECALLING CERTAIN MODEL YEAR 2011 SAF-T-LINER C2, HDX, MVP-EF, AND MINOTOUR SCHOOL BUSES MANUFACTURED FROM OCTOBER 21, 2009 THROUGH JANUARY 19, 2010. THE BUSES FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 222, "SCHOOL BUS PASSENGER SEATING AND CRASH PROTECTION." SEAT CUSHION HINGE TOLERANCE MAY ALLOW THE CUSHION TO SLIP LATERALLY CAUSING THE LATCH STRIKER TO BECOME DISENGAGED FROM THE SEAT FRAME. ONCE THE SEAT CUSHION BECOMES UNLATCHED IT CAN BE LIFTED WITH LESS FORCE THAN REQUIRED BY THE STANDARD.

Consequence: IN THE EVENT OF A CRASH OR SUDDEN MANEUVER, THE SEAT CUSHION MAY UNLATCH EXPOSING THE SEAT FRAME TO THE VEHICLE'S OCCUPANTS POSSIBLY RESULTING IN INJURY.

Remedy: DAIMLER TRUCKS WILL NOTIFY OWNERS AND REPAIRS WILL BE PERFORMED BY THOMAS BUILT BUSES DEALERSHIPS FREE OF CHARGE. THE SAFETY RECALL BEGAN ON FEBRUARY 15, , 2010. OWNERS MAY CONTACT DAIMLER TRUCKS AT 1-800-547-0712.

Reported: 2010-06-29 (June 29, 2010) · Model years: 2011

BUSWEST IS RECALLING CERTAIN MODEL YEAR 2011 HDX SCHOOL BUSES BUILT ON THOMAS BUILT CHASSIS FROM OCTOBER 6, 2009 THROUGH JANUARY 25, 2010 EQUIPPED WITH SEATS MANUFACTURED BY IMMI. THE SEAT CUSHION LOCKING MECHANISMS WERE MISALIGNED DURING VEHICLE ASSEMBLY. THIS ERROR RENDERS THE SCHOOL BUSES NONCOMPLIANT WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 222, "SCHOOL BUS PASSENGER SEATING AND CRASH PROTECTION."

Consequence: IN THE EVENT OF A CRASH, THE SEAT CUSHION COULD DETACH FROM THE SEAT, INCREASING THE RISK OF INJURY TO THE BUS OCCUPANTS.

Remedy: BUSWEST WILL NOTIFY OWNERS AND REPAIR THE BUSES FREE OF CHARGE. THE SAFETY RECALL IS EXPECTED TO BEGIN DURING JULY 2010. OWNERS MAY CONTACT BUSWEST AT 1-310-984-3900.

Reported: 2014-09-17 (September 17, 2014) · Model years: 2015

Daimler Trucks North America LLC (DTNA) is recalling certain model year 2015 Freightliner 108SD, 114SD, and M2 Business Class; Thomas Built Buses HDX; Western Star 4700; and FCCC MBC, MC, MT45, MT55, S2C 106CAB, Sport M2 106, XBR, XBS, XCL,XCM, XCR, and XCS vehicles manufactured May 2, 2014, to July 31, 2014. The Cummins ISB or ISL engines in these vehicles may have been equipped with Fleetguard UFF-XT fuel filters, part number FF63009, whose filter shell may separate from the fuel filter nut plate causing the engine to stall without warning.

Consequence: If the engine stalls unexpectedly there is an increased risk of a crash.

Remedy: Cummins will notify owners on behalf of DTNA, and dealers will replace the fuel filter with a non-defective one, free of charge. The recall began on September 29, 2014. Owners may contact DTNA customer service at 1-800-745-8000 or Cummins customer service at 1-800-223-4583. DTNA's number for this recall is FL-664.

Reported: 2023-04-07 (April 7, 2023) · Model years: 2023

Daimler Trucks North America, LLC (DTNA) is recalling certain 2023 Thomas Built Buses SAF-T-LINER SAF-T-LINER C2 Jouley, Thomas Built Buses SAF-T-LINER EFX, Thomas Built Buses SAF-T-Liner HDX, Thomas Built Buses Chassis and 2023-2024 School Bus Chassis school buses. The tie rod may be missing a fastener, allowing the steer arm to detach.

Consequence: A detached steering arm can result in a sudden loss of steering control, increasing the risk of a crash.

Remedy: DTNA will inspect and repair or replace the tie rod assembly as necessary, free of charge. Owner notification letters were mailed August 11, 2023. Owners may contact DTNA customer service at 1-800-547-0712. DTNA's number for this recall is FL970.