2007 Suzuki V-STROM 650 problems and owner complaints

MOTORCYCLE SUZUKI 2004 DL 650. MOTORCYCLE WILL FIND "NEUTRAL" AT TIMES AND LOCATIONS WHEN RIDER IS INTENDING TO BE IN GEAR. THIS IS NOT SPECIFIC TO ANY GEAR OR CONDITION, ALTHOUGH IT MOST OFTEN OCCURS BETWEEN 1ST AND SECOND GEAR. THIS OCCURRENCE IS COMMON ONCE THE RIDER BEGINS TO SQUEEZE THE CLUTCH LEVER TO SHIFT TO 3RD GEAR, AND THE BIKE THEN IS FOUND TO BE IN NEUTRAL. AFTER A SHIFT TO SECOND AGAIN, WHEN INTENDING TO GO TO THIRD GEAR, THIS CAN BE A SIGNIFICANT PROBLEM AND SAFETY CONCERN. THIS ALSO HAPPENS REGULARLY IN BETWEEN OTHER GEARS A…

Look up ODI 10195096 at NHTSA ↗

TRANSMISSION WILL SHIFT INTO NEUTRAL BETWEEN 5TH AND 6TH GEARS. THIS HAPPENS DURING AN ACCELERATION PERIOD AND CAUSES AN ABRUPT LOSS OF ACCELERATION CAUSING A DANGEROUS SITUATION. *JB

Look up ODI 10184565 at NHTSA ↗

FALSE NEUTRAL ON MOTORCYCLE. *TR

Look up ODI 10195067 at NHTSA ↗

SUZUKI HAS RECALLED ALL 2012 THROUGH 2016 DL650 MOTORCYCLES FOR FAULTY CHARGING STATORS. RECALL 16V-878. SEE DESCRIPTION OF DEFECT. THE 2008 THROUGH 2011 SUZUKI DL650 MOTORCYCLES USE THE SAME CHARGING STATOR AS THE 2012 THROUGH 2016 MODELS AND HAVE EXPERIENCED A HIGH RATE OF FAILURES.. THE ALTERNATOR WAS CHANGED TO A CLAIMED 400 WATT OUTPUT MODEL BEGINNING WITH THE 2008 MODEL. MANY FAILURES, SOME MULTIPLE, HAVE BEEN REPORTED ON STROMTROOPER.COM. FOR THE 2008 TO 2011 MODELS. ONE POLL RESULT FROM STROMTROOPER.COM VIEW POLL RESULTS: PLEASE …

Look up ODI 11002602 at NHTSA ↗

TL* THE CONTACT OWNS A 2013 (N/A) SUZUKI DL650A V-STROM. THE CONTACT RECEIVED NHTSA CAMPAIGN NUMBER: 16V878000 (ELECTRICAL SYSTEM) HOWEVER, THE PARTS TO DO THE REPAIR WERE UNAVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE MANUFACTURER WAS NOTIFIED OF THE ISSUE. THE CONTACT HAD NOT EXPERIENCED A FAILURE. PARTS DISTRIBUTION DISCONNECT.

Look up ODI 10969511 at NHTSA ↗

FAILURE OF FRONT BRAKE LINE ABOVE JUNCTION THAT SPLITS TO GO TO THE TWO CALIPERS. EITHER THE HOSE CRIMP HAS FAILED OR, THE CASTING HAS BROKEN. NOT YET DETERMINED. THIS CAUSED COMPLETE FAILURE OF FRONT BRAKES. BRAKE FLUID LEAKING FROM THIS POINT. THE FACTORY INSTALLATION APPEARS TO BE CORRECT AND NO APPARENT CAUSE OF FAILURE CAN BE NOTED OTHER THAN THE FACT THAT I HAD JUST GONE OVER A FAIRLY SEVERE RUT AND HAD THE BRAKES APPLIED AT THE TIME. *JS

Look up ODI 10456843 at NHTSA ↗

ABS pump issue, very likely clogged valves, lead to rear brake pedal locked up in disengaged position while riding - no rear brakes. When I was riding at moderate speed, the ABS module engaged after the rear wheel slid a little on a patch of grass. Immediately afterwards I found the rear brake pedal became stiff, and one more test brake later the rear brake pedal became rock solid, and I cannot engage the rear brake anymore while riding. Upon further investigation with mechanics, what happened was the valves on the ABS module were clogged dur…

Look up ODI 11562956 at NHTSA ↗

This motorcycle has been garage kept. It is in mint condition with 2114 miles on the odometer. It was purchased new in 2018. In 2024 the ABS light on the instrumentation illuminated. I tested the brakes to see if the ABS still worked, but it does not work. The rear tire can be locked up to skid, and the ABS does nothing. It used to work in years prior, as I had tested it in the past by applying heavy rear brakes. According to the manual, the error code #35 indicates a faulty ABS unit. The trouble-shooting is to test for 12 volts a…

Look up ODI 11679824 at NHTSA ↗

My VIN number is [XXX]. A recall was issued for Suzuki Vstrom. The recall was issued for 2012-2016 Suzuki V-Strom 650 stator due to a wiring issue. The wire burns. The problem is that the 2008 model has the same stator rectifier system. The part numbers are identical and feature the same wiring. My stator currently went bad at 42,000 miles. K8, 32101-17G12, 32800-47H00 K12, 32101-17G12, 32800-47H00 INFORMATION Redacted PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6).

Look up ODI 11476826 at NHTSA ↗

MOTORCYCLE IS 2 WEEKS OLD / 1,900 MILES TOTAL: THE MOTORCYCLE HAS BEEN STALLING UNDER CERTAIN SPECIFIC CONDITIONS. ONCE THE ENGINE IS WARM, AND I ATTEMPT TO DOWNSHIFT MULTIPLE GEARS AT A TIME, THE BIKE MAY STALL WHILE THE CLUTCH IS PULLED IN. AS AN EXAMPLE, I MAY BE RIDING IN 6TH GEAR AND WILL SLOW USING MY BRAKES ONLY (NOT ENGINE BRAKING). I WILL CLOSE THE THROTTLE COMPLETELY, CLUTCH IN, AND THEN DOWNSHIFT TO 5TH, 4TH, 3RD SEQUENTIALLY WITHOUT RELEASING THE CLUTCH BETWEEN GEARS. THERE WILL BE A POP COMING FROM UNDER THE SEAT, AND THE BIKE…

Look up ODI 10200704 at NHTSA ↗

THE BIKE HAS A SEVERE FRONT END VIBRATION AND SHAKE ON DECELERATION BETWEEN 45-35 MPH. THE VIBRATION STARTS OUT MILD AND ESCALATES TO THE POINT THAT YOU CAN LOOSE CONTROL OF THE BIKE UNLESS YOU ACCELERATE ABOVE 45 MPH, OR QUICKLY BRAKE AND SIGNIFICANTLY REDUCE YOUR SPEED. THE PROBLEM IS YOU ARE NOT ALWAYS IN A SAFE POSITION ON THE ROAD AND IN TRAFFIC TO KEEP THE BIKE OUTSIDE OF THE DANGEROUS RANGE. AS A RESULT, I FEEL THE VEHICLE IS UNSAFE TO OPERATE. IF YOU ARE CONSCIOUSLY AWARE OF THE RANGE OF SPEED IN WHICH IT OCCURS, YOU CAN TRY TO AVOI…

Look up ODI 10715815 at NHTSA ↗

THE BIKE HAS A SEVERE FRONT END VIBRATION AND SHAKE ON DECELERATION BETWEEN 45-35 MPH. THE VIBRATION STARTS OUT MILD AND ESCALATES TO THE POINT THAT YOU CAN LOOSE CONTROL OF THE BIKE UNLESS YOU ACCELERATE ABOVE 45 MPH, OR QUICKLY BRAKE AND SIGNIFICANTLY REDUCE YOUR SPEED. THE PROBLEM IS YOU ARE NOT ALWAYS IN A SAFE POSITION ON THE ROAD AND IN TRAFFIC TO KEEP THE BIKE OUTSIDE OF THE DANGEROUS RANGE. AS A RESULT, I FEEL THE VEHICLE IS UNSAFE TO OPERATE. IF YOU ARE CONSCIOUSLY AWARE OF THE RANGE OF SPEED IN WHICH IT OCCURS, YOU CAN TRY TO AVOI…

Look up ODI 10715815 at NHTSA ↗