Prevost XLII-45 ENTERTAINER recalls by model year

Reported: 2003-03-07 (March 7, 2003) · Model years: 2000, 2001, 2002, 2003

ON CERTAIN MOTOR COACHES AND MOTOR HOMES, THE STEERING COLUMNS MAY BE MISSING THE LOWER BOLT AND NUT. A REPLACEMENT BOLT AND NUT WAS INSTALLED TO CORRECT THIS SITUATION ON THE PRODUCTION LINE. IF A REPLACEMENT BOLT HAS BEEN USED AND NOT TIGHTENED PROPERLY, THE COLUMN MAY COME OUT OF THE INPUT SHAFT WHEN THE STEERING COLUMN ADJUSTMENT MECHANISM IS USED.

Consequence: IN SUCH A CASE, A LOSS OF STEERING WOULD OCCUR.

Remedy: DEALERS WILL VERIFY THE SIZE OF THE BOLT AND NUT AND REPLACE THEM IF NEEDED. OWNER NOTIFICATION BEGAN APRIL 4, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT PREVOST AT 1-418-831-5432.

Reported: 2005-03-23 (March 23, 2005) · Model years: 2001, 2002, 2003, 2004, 2005

ON CERTAIN MOTOR COACHES AND MOTOR HOMES, THE POWER STEERING HOSE CAN RUB IN THE ENGINE COMPARTMENT AND IN THE SPARE TIRE COMPARTMENT WHICH WILL CAUSE A POWER STEERING HOSE BREAK DOWN.

Consequence: LOSS OF STEERING CONTROL CAN CAUSE A VEHICLE CRASH WITHOUT PRIOR NOTICE.

Remedy: DEALERS WILL INSPECT THE HOSES AND REPLACE THEM IF THERE IS EVIDENCE OF WEAR FREE OF CHARGE. THE RECALL BEGAN ON MARCH 30, 2005. OWNERS MAY CONTACT PREVOST AT 418-831-5432.

Reported: 2006-06-14 (June 14, 2006) · Model years: 2004, 2005

ON CERTAIN MOTOR HOMES EQUIPPED WITH FRONT INDEPENDENT SUSPENSION, TWO SPINDLE SHAFTS WERE IMPROPERLY PROCESSED DURING MANUFACTURING WHICH WEAKENED THE SHAFTS.

Consequence: THE SHAFTS CAN BREAK CAUSING A LOSS OF STEERING CONTROL INCREASING THE RISK OF A CRASH.

Remedy: DEALERS WILL REPLACE THE TWO SPINDLE SHAFTS AND SURROUNDING PARTS FREE OF CHARGE. THE RECALL BEGAN ON OCTOBER 12, 2006. OWNERS MAY CONTACT PREVOST AT 418-831-5432.

Reported: 2004-09-07 (September 7, 2004) · Model years: 2005

ON CERTAIN MOTOR COACHES AND MOTOR HOMES, CRACKS WERE FOUND IN THE MATERIAL USED TO MAKE SUSPENSION RADIUS ROD PINS.

Consequence: BROKEN ROD PINS CAN CAUSE A LOSS OF CONTROL OF THE VEHICLE, WHICH COULD RESULT IN A CRASH.

Remedy: DEALERS WILL INSPECT ALL PARTS AND, IF NECESSARY, REPLACE THE ROD PINS. THE RECALL IS EXPECTED TO BEGIN DURING SEPTEMBER 2004. CUSTOMERS MAY ALSO CONTACT PREVOST AT 1-418-831-5432.

Reported: 2007-08-20 (August 20, 2007) · Model years: 2006

ON CERTAIN MOTOR COACHES EQUIPPED WITH BENDIX SR-7 SPRING BRAKE MODULATING VALVES, THE INTERNAL RUBBER CHECK VALVE MAY LEAK CAUSING A DELAY IN THE APPLICATION OF THE SPRING BRAKES TO PARK THE VEHICLE AFTER THE OPERATOR PULLS THE DASH VALVE BUTTON.

Consequence: THIS COULD CAUSE DELAY OR FAILURE IN APPLYING THE PARKING BRAKES WHICH COULD RESULT IN A VEHICLE ROLL AWAY, INCREASING THE RISK OF A CRASH.

Remedy: PREVOST IS WORKING WITH BENDIX TO REPAIR THESE VEHICLES (PLEASE SEE 07E037). BENDIX WILL INSTALL A CHECK VALVE REPAIR KIT FOR THE AFFECTED SR-7 SPRING BRAKE MODULATING VALVE FREE OF CHARGE. THE RECALL BEGAN ON SEPTEMBER 14, 2007. OWNERS MAY CONTACT BENDIX AT 1-440-329-9000 OR PREVOST AT 1-418-831-2046.

Reported: 2013-04-19 (April 19, 2013) · Model years: 2006, 2007, 2008, 2009, 2010, 2011, 2012, 2013

Prevost is recalling certain model year 2012-2013 X3-45 VIP, 2006-2013 H3-45 VIP, and 2006-2011 XLII-45 coach buses equipped with window part numbers: 790612, 790613, and 790614. These vehicles were manufactured between October 31, 2003, through April 10, 2013. On the vehicles involved, the decals explaining how to open the emergency windows does not contain a step required to open the window in case of an emergency. Specifically, the latch must be held down while the window is pushed outward to release the window; this is not stated on the decal.

Consequence: In the event of a crash, the incorrect label may result in difficulty opening the emergency windows. This could increase the risk of personal injury.

Remedy: Prevost will notify owners, and dealers will replace the emergency window decals, free of charge. An interim notice was mailed to owners on August 1, 2013. Owners were notified that the replacement decals are available on August 30, 2013. Owners may contact Prevost at 1-418-883-2888 x 6558. Prevost's campaign recall number is SR13-26.

Reported: 2013-09-26 (September 26, 2013) · Model years: 2006, 2007, 2008, 2009, 2010, 2011

Prevost Cars, Inc. (Prevost) is recalling certain model year 2013 X3-45, 2012-2014 H3-45, 2008 H3-45 VIP, 2005 XL2, and 2006-2011 XL2-45 Entertainer buses equipped with super single tires. The cold inflation pressure shown on the certification plate is higher than the specification for the super single tires installed on the rear axle, which may lead to tire overinflation. Thus, these vehicles fail to conform to the requirements of Federal Motor Vehicle Safety Standard Part 567, "Certification Regulation."

Consequence: Tire overinflation may reduce traction, braking ability and handling, increasing the the risk of a crash.

Remedy: Prevost will notify owners, and dealers will replace the certification plate, free of charge. The recallbegan on November 22, 2013. Owners may contact Prevost at 1-418-883-2888. Prevost's recall number is SR13-61.

Reported: 2013-10-29 (October 29, 2013) · Model years: 2008, 2009

Prevost is recalling certain model year 2008-2009 X3-45 and X3-45 Entertainer coach buses manufactured November 2, 2006, through November 27, 2008. In the affected buses there are two battery cables. One of cables may have been inadvertently installed in a p-clamp. As a result, the cable that is not run through the p-clamp may rub against the p-clamp causing a short circuit.

Consequence: A short may result in a vehicle fire.

Remedy: Prevost will notify owners, and dealers will remove the p-clamp, inspect, and replace the affected battery cable as necessary, free of charge. The recall began on December 16, 2013. Owners may contact Prevost at 1-418-883-2888. Prevost's recall number is SR13-73.

Reported: 2013-02-07 (February 7, 2013) · Model years: 2009, 2010, 2011, 2012, 2013

Prevost is recalling certain model year 2008-2013 X3-45, H3-41 and H3-45 coaches, model year 2011-2013 H3-45 VIP coaches, model year 2012-2013 X3-45 VIP coaches, and model year 2009-2013 XLII-45 Entertainer coaches manufactured from May 16, 2007, through March 14, 2013 and equipped with Volvo engines. Certain conditions may cause the affected coaches to go into a software mode that would result in the throttle signal being fixed at 1700rpms regardless of throttle pedal input from the driver.

Consequence: Uncontrollable throttle position may lead to a loss of vehicle control, increasing the risk of a crash.

Remedy: Prevost will notify owners and dealers will remedy will the affected coaches, free of charge. The recall began on May 2, 2013. Owners may contact Prevost at 1-418-831-2046.

Reported: 2013-10-29 (October 29, 2013) · Model years: 2009

Prevost is recalling certain model year 2009-2010 H3-45 and model year 2009 H3-41, X3-45, XLII Converted Coach Shells and XLII-45 Entertainer Converted coach and model year 2008 H3-VIP coach shells. The mechanical springs used to return the accelerator pedal to idle after the driver lifts their foot off the pedal may break.

Consequence: If the springs break, the pedal may not return to idle once the driver lifts their foot off the pedal. This unintended acceleration increases the risk of a crash.

Remedy: Prevost will notify owners, and dealers will replace the affected accelerator pedals, free of charge. The recall began on December 17, 2013. Owners may contact Prevost at 1-418-883-2888. Prevost's recall number is SR13-72.

Reported: 2012-07-18 (July 18, 2012) · Model years: 2011, 2012, 2013

Prevost is recalling certain model year 2011-2013 X3-45 and XLII Entertainer Bus vehicles, manufactured from November 24, 2010, through July 3, 2012. The power cable may come in contact, or rub against sharp, abrasive edges.

Consequence: If this occurs, a short-circuit, or fire may result, increasing the risk of personal injury.

Remedy: Prevost will notify owners, and dealers will inspect and, as necessary, repair the power cables free of charge. The safety recall is expected to begin during August 2012. Owners may contact Prevost Car Inc., service department toll-free at 1-866-870-2046 or 1-418-831-2046.

Reported: 2012-10-18 (October 18, 2012) · Model years: 2012, 2013

Prevost is recalling certain model year 2012-2013 X3-45 and XLII-45 coach buses, manufactured between November 15, 2011, and August 14, 2012. The power cables may rub against sharp edges in both the rear junction box and the condenser compartment, resulting in a short-circuit.

Consequence: If the power cables short-circuit, a vehicle fire may result.

Remedy: Prevost will notify owners, and dealers will re-route and repair the affected power cables, as necessary, free of charge. The recall began on November 14, 2012. Owners may contact Prevost at 1-418-883-2888 x 6558.

Reported: 2013-12-26 (December 26, 2013) · Model years: 2012, 2013

Prevost Cars, Inc. (Prevost) is recalling certain model year 2012-2013 X3-45 VIP motorhomes, H3 VIP motorhomes and XLII-45 Entertainers and model year 2012-2014 model year X3-45, H3-41, H3-45 coaches manufactured June 6, 2011, through May 17, 2013, equipped with JAKO windshield wiper motors, model SWF403195. In the affected vehicles, the windshield wiper motor housing may crack resulting in a loss of windshield wiper function.

Consequence: Without functioning windshield wipers, the driver's visibility may be reduced, increasing the risk of a crash.

Remedy: Prevost will notify owners, and dealers will inspect the vehicles and any affected windshield wiper motor will be replaced, free of charge. The recall began on February 26, 2014. Owners may contact Prevost at 1-418-883-2888. Prevost's number for this recall is SR14-02.

Reported: 2012-09-06 (September 6, 2012) · Model years: 2013

Prevost is recalling certain model year 2013 X3-45 and MTH XLII-45E vehicles, all equipped with Volvo D13 engines and an automatic fire detection and suppression system (AFSS). The AFSS linear thermal detector wire may come in contact with or chafe against its supporting tie cables.

Consequence: If the detector wire chafes it may cause the AFSS to activate with no fire present and, as a result, the stop engine feature will be activated, bringing the vehicle to an unplanned stop and increasing the risk of a crash.

Remedy: Prevost will notify owners, and dealers will add a protection cloth to the linear thermal detector wire at the location of tie cable, free of charge. The safety recall began on September 27, 2012. Owners may contact Prevost Car Inc., service department toll-free at 1-866-870-2046 or 1-418-831-2046.

Reported: 2013-01-22 (January 22, 2013) · Model years: 2013

Prevost is recalling certain model year 2013 X3-45, H3-45, and XLII-45 Entertainer coach buses and coach bus shells manufactured September 25, 2012, through January 9, 2013, for failing to conform to the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 108, "Lamps, Reflective Devices, and Associated Equipment." The buses may have missing side reflectors.

Consequence: The absence of reflectors could reduce the ability for others to see the bus, increasing the risk that another vehicle may crash into the bus.

Remedy: Prevost will notify owners, and dealers will add side reflectors, free of charge. The recall began on February 5, 2013. Owners may contact Prevost at 1-418-883-2888 x 6558.