2008 Mini COOPER problems and owner complaints

TL*THE CONTACT OWNS A 2008 BMW MINI COOPER. WHILE DRIVING APPROXIMATELY 35 MPH, THE TRANSMISSION MONITOR LIGHT ILLUMINATED ON THE INSTRUMENT CONTROL PANEL. THE CONTACT TOOK THE VEHICLE TO THE DEALER AND THEY REPLACED THE MONITOR. IMMEDIATELY AFTER THE REPAIR, THE FAILURE RECURRED AND THE VEHICLE WAS TAKEN BACK TO THE DEALER. THE TECHNICIAN PERFORMED THE SAME REPAIR. THREE DAYS LATER, THE FAILURE RECURRED AGAIN AND THE VEHICLE WAS TAKEN BACK TO THE DEALER A THIRD TIME. THE VEHICLE HAS BEEN AT THE DEALER FOR THE PAST TWO WEEKS BECAUSE THE C…

Owner-reported narrative. 539 miles reported. Look up ODI 10229299 at NHTSA ↗

DEAR [XXX], I AM WRITING TO YOU IN REGARDS TO MY MINI COOPER VIN# [XXX]. FIRSTLY, I AM AWARE OF TWO RECALL NOTICES, ID# [XXX] AND ID #[XXX]. I BELIEVE I SHOULD HAVE BEEN NOTIFIED OF THESE RECALLS BUT TO DATE HAVE NOT RECEIVED A LETTER. SEVERAL TIMES I INDICATED THE SENSORY WARNING CAME ON WITH ENGINE MALFUNCTION. THIS CONCERNS ME, BECAUSE SINCE I PURCHASED THIS VEHICLE, I HAVE HAD CATASTROPHIC FAILURES BEFORE 45,000MILES. I HAVE BROUGHT IT TO THE MINI SERVICE CENTER FOR THESE FAILURES, INCLUDING: REPLACING SPARK PLUGS, FAULTY COIL PACK, FAU…

Owner-reported narrative. 46,000 miles reported. Look up ODI 10515648 at NHTSA ↗

TL*THE CONTACT OWNS A 2008 MINI COOPER WHICH WAS PURCHASED IN AUGUST 2008. HE STATED THAT THE VEHICLE WOULD NOT START. THE CHECK ENGINE LIGHT ILLUMINATED ON THE INSTRUMENT CONTROL PANEL. PREVIOUSLY, THE VEHICLE BEGAN STALLING AND LOSING POWER. HE ALSO OBSERVED SMOKE EMITTING FROM THE ENGINE COMPARTMENT AND SMELLED OIL BURNING. THE VEHICLE WAS TAKEN TO THE DEALER WHERE THE VEHICLE WAS DIAGNOSED WITH A LOSS IN PRESSURE AND ONE OF THE FOUR CYLINDERS HAD FAILED. THEY ALSO FOUND A DILAPIDATED TIMING CHAIN AND POSSIBLE EMISSIONS FAILURES. THE DEALER…

Owner-reported narrative. 29,335 miles reported. Look up ODI 10298966 at NHTSA ↗

TL* THE CONTACT OWNS A 2008 MINI COOPER. THE CONTACT STATED THAT WHEN DRIVING APPROXIMATELY 45 MPH THE VEHICLE SUDDENLY STALLED. THE VEHICLE WAS TOWED TO A DEALER AND THEY ADVISED HIM THAT HE NEEDED A NEW ENGINE DUE TO THE VACCUUM PUMP FAILING. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS CONTACTED AND THEY OFFERED NO ASSISTANCE. THE FAILURE AND CURRENT MILEAGES WERE APPROXIMATELY 64,000.

Owner-reported narrative. 64,000 miles reported. Look up ODI 10427474 at NHTSA ↗

I PURCHASED A NEW 2008 MINI COOPER FROM AUTOHAUS WEST/MINI OF ST LOUIS. THE MINI COOPER WAS DESIGNED, MANUFACTURED, ASSEMBLED, DISTRIBUTED AND SOLD BY BMW OF NORTH AMERICA, BMW (U.S.) HOLDING CORP., AND BAYERISCHE MOTOREN WERKE AKTIENGELLSCHAFT. I EXPERIENCED A PROGRESSIVE FAILURE OF THE TIMING CHAIN, TIMING CHAIN TENSIONER AND RELATED TENSIONER RAIL, GUIDE RAIL AND SUPPORT RAIL. THE TIMING CHAIN HAD PREVIOUSLY BEEN REPRESENTED TO HAVE A USEFUL LIFE EQUAL TO THE LIFE OF THE CAR. THE TIMING CHAIN IS LOCATED WITHIN THE ENGINE, CONSISTS OF A M…

Owner-reported narrative. 92,000 miles reported. Look up ODI 10851815 at NHTSA ↗

MY CAR ONLY HAS 47,000 MILES ON IT AND HAS THE SAME PASSENGER SIDE AIRBAG ISSUE. IT STARTED OFF AT TIMES HAVING THE PROBLEM, NOW IS ON ALL THE TIME. MINI WANTS $125 TO DIAGNOSE THE PROBLEM, WHICH SEEMS EVIDENT. ALSO PAID $425 TO FIX ELECTRICAL WIRING THAT CORRODED AND $1,700 2 MONTHS EARLIER THIS YEAR WHEN WHEEL SENSOR WENT BAD AND 3 LIGHTS WENT OFF IN THE CAR.

Owner-reported narrative. 46,000 miles reported. Look up ODI 10882134 at NHTSA ↗

MINI COOPER POWER STEERING PROBLEMS (2007 AND 2008 MODELS) - I NOTICED THE REPORTS ON POWER STEERING. I HAVE LEASED 2 MINIS AND FOUND THAT THIS WAS A PROBLEM WHEN TRYING TO PARALLEL PARK IN NEW YORK CITY. WHEN TRYING TO FIT INTO A SMALL SPACE--WHICH REQUIRES LOTS OF TWISTS, TURNS OF THE STEERING WHEEL REPEATEDLY UNTIL CAR IS SQUEEZED IN--THE POWER STEERING ON BOTH YEARS OF BOTH CARS THAT I HAD--AND THE 2007 I TEST DROVE AT THE DEALER--ALL POPPED OUT. IT SEEMS THAT REPEATED TURNING MAKES THE POWER STEERING TURN OFF. IF YOU WAIT A FEW SECONDS ON…

Owner-reported narrative. Look up ODI 10358619 at NHTSA ↗

TL* THE CONTACT OWNS A 2008 MINI COOPER. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 20 MPH THE STEERING WHEEL SUDDENLY LOCKED. THE VEHICLE WAS SHUT OFF, AND UPON RESTART THE FAILURE CONTINUED. THE VEHICLE WAS TOWED TO AN AUTHORIZED DEALER WHERE THE CONTACT WAS INFORMED THAT THE STEERING RACK NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED. THE FAILURE MILEAGE WAS APPROXIMATELY 74,000.

Owner-reported narrative. 74,000 miles reported. Look up ODI 10410254 at NHTSA ↗

IN SEPTEMBER, 2013, MY 2008 MINI COOPER HARDTOP, WITH THE N12 ENGINE, HAD THE TIMING CHAIN FAIL UNDER OPERATION. THIS CAUSED THE ENGINE TO STOP, AT HIGHWAY SPEED, AFFECTING STEERING, BRAKING AND ALL ABILITY TO MANEUVER THE VEHICLE OUT OF TRAFFIC. TWO VEHICLES BARELY AVOIDED MY DISABLED VEHICLE. I CONTACTED MINI USA AND THEY REFUSED TO ACKNOWLEDGE THE FACTORY DEFECT IN THE TIMING-CHAIN TENSIONER THAT CAUSES THE TIMING CHAIN TO FAIL. I PAID OVER $8000 FOR A REPLACEMENT N12 ENGINE. WITH LESS THAN 10,000 MILES ON THE REPLACEMENT ENGINE, IN JUL…

Owner-reported narrative. 64,000 miles reported. Look up ODI 10927273 at NHTSA ↗

WHILE DRIVING I NOTICED THE SMELL OF GASOLINE THAT BECAME INCREASINGLY STRONGER. AFTER I ARRIVED HOME I BEGAN LOOKING FOR THE SOURCE OF THE GASOLINE SMELL. WHAT I FOUND WAS THE HIGH PRESSURE FUEL LINE THAT SUPPLIES FUEL TO THE INJECTOR RAIL WAS LEAKING. THE WAY THE HOSE WAS ROUTED ON THE BACK OF THE ENGINE, ALLOWED THE HOSE TO REST ON A RETAINING CLIP FOR ANOTHER HOSE. THE RETAINING CLIP HAD WORN A GROOVE INTO THE HIGH PRESSURE LINE AND GASOLINE WAS SPRAYING ACROSS THE BACK OF THE ENGINE AND DOWN ONTO THE ENGINE EXHAUST. *TR

Owner-reported narrative. 83,000 miles reported. Look up ODI 10482772 at NHTSA ↗