Mercedes Benz S430 problems and owner complaints

TL* THE CONTACT OWNS A 2000 MERCEDES BENZ S430. WHILE THE CONTACT WAS DRIVING APPROXIMATELY 35 MPH WITH THE AIR CONDITIONER ACTIVATED, HE SMELLED A PLASTIC BURNING ODOR THEN SUDDENLY THE AIR CONDITIONED FAILED TO OPERATE. THE VEHICLE WAS MANEUVERED TO THE SIDE OF THE ROAD, WHERE THE CONTACT NOTICED THAT FAULTY BLOWER MOTOR REGULATOR WIRES MELTED. THE MANUFACTURER WAS NOTIFIED OF THE DEFECT AND THEY STATED THAT ON APRIL 20, 2005 THE VEHICLE WAS REPAIRED UNDER THE NHTSA CAMPAIGN ID NUMBER 00V141000 (EQUIPMENT:ELECTRICAL:AIR CONDITIONER). THE VEHI…

Owner-reported narrative. 246,000 miles reported. Look up ODI 10469367 at NHTSA ↗

DT*: THE CONTACT STATED THE DASHBOARD ELECTRICAL SYSTEM FAILED AND THE GAUGES NO LONGER REGISTER THE SPEED OR FUEL LEVEL. THERE IS A NHTSA RECALL, # 06V028000, REGARDING THE INTERIOR LIGHTING. THE VIN WAS NOT INCLUDED IN THE RECALL.

Owner-reported narrative. 92,000 miles reported. Look up ODI 10158159 at NHTSA ↗

DEFECT IN ACCELERATOR AND ELECTRONIC ATTACHMENTS, PART NO220 300 00 04. WHEN PART FAILED, INITIALLY, CAR ONLY POWERED TO LOW SPEED UNDER LOAD. HAD TO DRIVE IT OUT OF DESERT AND OVER MOUNTAIN AT LOW SPEED, BUT DOWN HILL OK. EVENTUALLY PARKED IT OFF ROAD. WHEN NEXT STARTING IT, IT REVVED TO 3500 RPM AND HELD. TRIED TO MOVE IT, IT DROPPED TO IDLE SPEED AND WOULD NOT ACCELERATE. I PARKED IT AND HAD MECHANIC CHECK IT. DETERMINED THE ACCELERATOR WAS FAULTY. GAS PEDDLE DID NOT AFFECT ENGINE SPEED. HE POUNDED ON PEDDLE WITH HAND. ENGINE JUMPED TO…

Owner-reported narrative. 165,000 miles reported. Look up ODI 11139238 at NHTSA ↗

DT: CONTACT STATES THE THERE WAS COMPLETE BRAKE FAILURE AT 23,000 MILES. THE VEHICLE WAS STILL UNDER WARRANTY. SERVICE DEALER STATED THEY COULDN'T FIND WHAT IS WRONG WITH THE BRAKES. *AK WHILE DRIVING AT SPEEDS ABOVE 40 MPH THE VEHICLE VIBRATED. ON SEVERAL OCCASION THE VEHICLE WOULD NOT STOP WHEN THE BRAKES WERE APPLIED. THIS RESULTED IN SEVERAL NEAR ACCIDENTS. THE DEALER/MANUFACTURER WERE NOTIFIED AND CONCLUDED THAT THE BRAKE WEAR WAS NORMAL WEAR AND TEAR AND THAT THEY JUST NEEDED TO BE REPLACED. THE CENTER CONSOLE WOULD NOT OPE…

Owner-reported narrative. 23,000 miles reported. Look up ODI 10124896 at NHTSA ↗

ON 11/18/16 I WAS DRIVING MY 2000 S430 WHEN WILE ACCELERATING TO MERGE ONTO THE FREEWAY MY TRANSMISSION SLIPPED CAUSING MY ENGINE TO REV. I RELEASED THE GAS PEDAL & TRIED TO PRESS IT AGAIN TO RE ENGAGE THE TRANSMISSION BUT IT DIDN'T WORK. I PULLED TO THE SIDE OF THE ROAD, PLACED THE CAR IN PARK, THEN BACK TO DRIVE. I CAUTIOUSLY DROVE BACK HOME & PARKED THE CAR UNTIL I WAS ABLE TO GET A SHOP APPOINTMENT. ON 11/21/16 I TOOK THE CAR TO THE SHOP, THEY SAID THE FLUID WAS FULL BUT THE TRANSMISSION WAS SLIPPING & NEEDED TO BE REPLACED? SO I TOOK IT HO…

Owner-reported narrative. Look up ODI 10937111 at NHTSA ↗

CONSUMER OF A 2001 S430 V FAULTY SUNROOF, LED SIDE MIRRORS, AND TURN SIGNALS. CUSTOMER STATES THE VEHICLE HAS COST HIM A LOT OF MONEY TO REPAIR AND WOULD LIKE IT TO BE FIXED AND BE REPAID IN SOMEWAY. **NAR**KB THE CONSUMER STATED THE VEHICLE HAS HAD NUMEROUS PROBLEMS SUCH AS PERSISTENT TAIL LIGHT AND HEAD LIGHT ASSEMBLY FAILURES, ENGINE, FUEL, ACCELERATOR PEDAL ASSEMBLY, ALTERNATOR, BATTERY, INSTRUMENT CLUSTER, VACUUM DOOR PUMP, ELECTRICAL, FRONT SUSPENSION FAILURES SUCH AS THE AIRMATIC SHOCKS, THE THRUST ARMS, BALL JOINTS AND THE AIRMATIC…

Owner-reported narrative. Look up ODI 10202668 at NHTSA ↗

MY WIFE WAS DRIVING OUR MERCEDES 2001 S430 AND THE FRONT SUSPENSION DROPPED ALL OF A SUDDEN ON A BACK ROAD IN THE MIDDLE OF NOWHERE. FIRST IT HAD DROPPED SO LOW IT PREVENTED STEERING AND WAS DIFFICULT TO PUT VEHICLE ON THE SHOULDER WITHOUT DAMAGING CAR. THEN WE HAD THREE TOWING COMPANIES WHICH WOULD NOT TOW THE VEHICLE BECAUSE OF LIABILITY TO FRONT END DAMAGE. I CHANGED THE RELAY THROUGH RESEARCH AND WAS ABLE TO GET IT UP ENOUGH TO BE TOWED. TAKE INTO CONSIDERATION THIS WAS TAKEN FOUR DAYS TO EXECUTE. THEN I HAVE NEVER BEEN SO HAPPY TO HAVE A V…

Owner-reported narrative. Look up ODI 10219195 at NHTSA ↗

TL* THE CONTACT OWNS A 2000 MERCEDES BENZ S430. THE CONTACT STATED THAT WHILE DRIVING AT 25 MPH, THE VEHICLE STALLED WITHOUT WARNING. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE IT WAS UNABLE TO BE DIAGNOSED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 142,000. THE VIN WAS NOT AVAILABLE.

Owner-reported narrative. 142,000 miles reported. Look up ODI 10810049 at NHTSA ↗

A FEW DAYS BEFORE THE MAIN INCIDENT, MY 2003 MERCEDES S430 WOULD STALL FOR NO APPARENT REASON. I CALLED MERCEDES ROADSIDE ASSISTANCE, AND THEY TOLD ME THAT I SHOULD LET THE CAR RESET, AND THIS WOULD FIX THE PROBLEM. THIS HAPPENED TWO TIMES AND BOTH TIMES THERE WAS A TEMPORARY FIX AFTER THE CAR RESET. A DAY AFTER THE SECOND RESET, MY CAR COMPLETELY STALLED AND ENGINE SHUT OFF COMPLETELY WHILE I WAS DRIVING ON THE FREEWAY CAUSING ME TO ALMOST GET INTO A FEW CRASHES. MERCEDES ROADSIDE ASSISTANCE CALLED THE TOW COMPANY, AND THEY TOOK OVER AN HO…

Owner-reported narrative. 54,943 miles reported. Look up ODI 10415380 at NHTSA ↗

WHEN FILLING UP TANK GAS PUMP DOES NOT SHUT OFF. CONSUMER FEELS THERE'S A DEFECT IN FUEL TANK. CAUSE IS UNKNOWN. PLEASE PROVIDE ANY FURTHER INFORMATION.*AK

Owner-reported narrative. Look up ODI 8008650 at NHTSA ↗

THE BATTERY LOCATED IN THE TRUNK OF THE VEHICLE IS SITUATED NEXT TO THE GAS TANK. THERE ARE NO COVERS ON THE METAL PARTS ON THE TOP OF THE BATTERY LOCATED IN THE TRUNK OF THE VEHICLE, AND THE MAT THAT COMES WITH THE VEHICLE DOES NOT SUFFICIENTLY COVER THESE METAL POLES, LEAVING THEM VULNERABLE TO CATCH FLAME WHEN METAL ITEMS ARE IN THE BACK OF THE VEHICLE. THE REAR BATTERY CAUGHT FLAME, WHILE STATIONARY, DUE TO A METAL ROD USED FOR FURNITURE ASSEMBLY TOUCHING THE EXPOSED PORTION OF THE BATTERY.

Owner-reported narrative. 110,000 miles reported. Look up ODI 11047153 at NHTSA ↗