Lincoln MARK VII recalls by model year

Reported: 1983-12-20 (December 20, 1983) · Model years: 1984

THE BOLTS THAT ATTACH THE D-SHAPED RING FOR THE SHOULDER BELT ARE INADEQUATELY SUPPORTED BY THE MATERIAL IN WHICH THEY ARE MOUNTED. THE ATTACHMENT DOES NOT COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 210, "SEAT BELT ASSEMBLY ANCHORAGES".

Remedy: DEALERS WILL INSTALL NEW ATTACHING HARDWARE TO IMPROVE THE STRENGTH OF THE MOUNTING.

Reported: 1984-01-13 (January 13, 1984) · Model years: 1984

THE STEERING WHEEL MAY BE LOCKED WHEN THE IGNITION KEY IS IN THE OFF POSITION AND THE GEAR SHIFT LEVER IS NOT IN PARK. THIS CONDITION CONSTITUTES A NON COMPLIANCE WITH FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 114, THEFT PROTECTION.

Remedy: KEY RELEASE CONTROL CABLE WILL BE INSPECTED AND MODIFIED IF NECESSARY.

Reported: 1984-01-13 (January 13, 1984) · Model years: 1984

LABELS SPECIFYING VEHICLE CAPACITY WEIGHT AND DESIGNATED SEATING CAPACITY OVERSTATE THE MAXIMUM LOAD PERMISSIBLE FOR BOTH OCCUPANTS AND LUGGAGE. THE LABEL IS IN NON COMPLIANCE WITH FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, TIRE SELECTION AND RIMS.

Remedy: THE INCORRECT LABEL WILL BE REPLACED.

Reported: 1985-04-09 (April 9, 1985) · Model years: 1985

A MALFUNCTION MAY OCCUR IN THE AIR SUSPENSION ELECTRICAL CIRCUITRY.

Consequence: A WIRE TO THE AIR SUSPENSION COMPRESSOR COULD OVERHEAT CREATING A POTENTIAL FOR A FIRE, PRIMARILY WHEN PARKED AND KEY IS REMOVED.

Remedy: REPLACE CONTROL MODULE WITH A NEWLY DESIGNED MODULE.

Reported: 1986-08-08 (August 8, 1986) · Model years: 1985, 1986

UNDER CERTAIN CONDITIONS, CONTACTS IN BRAKE SYSTEM RELAY COULD REMAIN CLOSED, CAUSING THE BRAKE PUMP MOTOR TO RUN CONTINUOUSLY, CAUSING IT TO OVERHEAT AND EVENTUALLY FAIL. CONSEQUENCE OF DEFECT: SHOULD THE BRAKE SUPPLY MOTOR FAIL, THE POWER ASSIST TO THE FRONT BRAKES WILL BE LOST, AND AFTER ABOUT 10 TO 15 NORMAL BRAKE STOPS, LOSS OF REAR BRAKE FUNCTION WILL RESULT, CAUSING INCREASED STOPPING DISTANCE. HOWEVER, THE INSTRUMENT BRAKE WARNING LIGHT WILL ILLUMINATE PRIOR TO REDUCED BRAKING CAPABILITY AND IF WARNING IS NOT HEEDED, AN ACCIDENT MAY OCCUR.

Remedy: REPLACE PUMP MOTOR RELAYS.

Reported: 1985-09-19 (September 19, 1985) · Model years: 1986

AN ALUMINUM CASTING FLASH ON THE FACE OF THE THROTTLE BODY MAY BREAK OFF AND BECOME TRAPPED BETWEEN THE THROTTLE PLATE AND THE BORE IN THE THROTTLE BODY. CONSEQUENCES OF DEFECT: THROTTLE MAY FAIL TO RETURN TO IDLE POSITION WHEN RELEASED AND COULD RESULT IN LOSS OF VEHICLE CONTROL WHICH MAY CAUSE AN ACCIDENT.

Remedy: REMOVE EXCESS CASTING FLASH.

Reported: 1986-02-10 (February 10, 1986) · Model years: 1986

WIRING CONNECTIONS IN AN ELECTRICAL CONNECTOR TO THE MASTER CYLINDER RESERVOIR FLUID LEVEL SENSORS WERE REVERSED AND FAIL TO INDICATE LOW FLUID LEVELS AS SPECIFIED BY FMVSS 105, HYDRAULIC BRAKE SYSTEMS. CONSEQUENCE OF DEFECT: SENSOR WILL NOT TRANSMIT SIGNAL TO BRAKE WARNING LIGHT WHEN THE FLUID LEVEL IS LESS THAN ONE FOURTH FULL. WITHOUT THIS WARNING SIGNAL THE FLUID LEVEL MAY DECREASE TO THE POINT WHERE PARTIAL OR COMPLETE LOSS OF BRAKE WOULD BE EXPERIENCED AND MAY LEAD TO AN ACCIDENT.

Remedy: RE-CONFIGURE WIRING TO THE FLUID LEVEL SENSOR CONNECTOR.

Reported: 1986-08-08 (August 8, 1986) · Model years: 1986

THE IGNITION LOCK CYLINDER MAY HANG UP AND NOT FULLY RETURN TO THE "ON" POSITION FROM THE "START" POSITION AFTER STARTING THE ENGINE. IF THIS OCCURS, THE ENGINE WILL REMAIN RUNNING, BUT THE BATTERY CURRENT TO THE BRAKE SYSTEM SUPPLY MOTOR WILL BE INTERRUPTED. CONSEQUENCE OF DEFECT: WITH POWER TO MOST ACCESSORIES AND THE BRAKE SYSTEM SUPPLY MOTOR INTERRUPTED, THE POWER ASSIST TO THE FRONT BRAKE WILL BE LOST AND AFTER ABOUT 10 TO 15 NORMAL BRAKE STOPS, LOSS OF REAR BRAKE FUNCTION WILL RESULT, CAUSING INCREASED STOPPING DISTANCE. HOWEVER, THE INSTRUMENT BRAKE WARNING LIGHT WILL ILLUMINATE PRIOR TO REDUCED BRAKING CAPABILITY AND IF WARNING IS NOT HEEDED, AN ACCIDENT MAY OCCUR.

Remedy: REPLACE IGNITION LOCK CYLINDERS WITH REVISED DESIGN CYLINDERS.

Reported: 1987-09-04 (September 4, 1987) · Model years: 1986, 1987, 1988

SPRING LOCK FUEL LINE COUPLING MAY NOT BE PROPERLY ENGAGED.

Consequence: COUPLING COULD DISENGAGE DUE TO FUEL PRESSURE,VIBRATION, AND ENGINE MOVEMENTS; THIS WOULD CAUSE LOSS OF FUEL WHICH, INPRESENCE OF AN IGNITION SOURCE, CREATES A FIRE RISK.

Remedy: INSTALL RETAINER CLIPS OVER THE COUPLINGS TO PREVENT COUPLING SEPARATION AND FUEL LEAKAGE.