Itasca CAMBRIA recalls by model year

Reported: 2004-10-20 (October 20, 2004) · Model years: 2005

ON MOTOR HOMES BUILT ON FORD E-SERIES CHASSIS AND EQUIPPED WITH GAS ENGINES, A DIODE IN THE ANTI-LOCK BRAKING SYSTEM (ABS) MODULE MAY EXPERIENCE AN ELECTRICAL SHORT.

Consequence: THE ELECTRICAL SHORT MAY CAUSE AN ABS MALFUNCTION THAT WOULD ILLUMINATE THE ABS WARNING LIGHT, OR THE MODULE MAY OVERHEAT RESULTING IN A BURNING ODOR, SMOKE, AND/OR FIRE. THIS CONDITION MAY OCCUR WHILE THE VEHICLE IS BEING DRIVEN OR UNATTENDED.

Remedy: FORD MOTOR COMPANY IS CONDUCTING THE OWNER NOTIFICATION AND REMEDY FOR THIS CAMPAIGN. DEALERS WILL INSTALL A NEW FUSE IN THE ABS CIRCUIT AND INSTALL A HEAT SHIELD OVER THE ABS MODULE. OWNERS SHOULD CONTACT FORD AT 1-800-392-3673 OR WINNEBAGO AT 641-585-3535.

Reported: 2004-10-20 (October 20, 2004) · Model years: 2005

ON MOTOR HOMES BUILT ON FORD E-SERIES CHASSIS, THE AIR FILTER ELEMENT MATERIAL PROCESS RESULTED IN AN AIR FILTER PAPER ELEMENT THAT CAN SMOLDER OR BURN. THIS CHANGE IN FILTER PAPER COMPOSITION COMBINED WITH THE CONFIGURATION OF THE AIR INDUCTION SYSTEM, MAY ALLOW HOT CARBON PARTICLES TO CONTACT THE AIR FILTER ELEMENT DURING CERTAIN DRIVING CONDITIONS THAT CREATE HOT PARTICLES.

Consequence: THESE HOT PARTICLES MAY IGNITE THE AIR FILTER ELEMENT WITH THE POTENTIAL FOR AIR INDUCTION SYSTEM DAMAGE OR UNDERHOOD FIRE.

Remedy: FORD MOTOR COMPANY IS CONDUCTING THE OWNER NOTIFICATION AND REMEDY FOR THIS CAMPAIGN. DEALERS WILL INSPECT AND REPLACE THE AIR FILTER ELEMENT. OWNERS SHOULD CONTACT FORD AT 1-800-392-3673 OR WINNEBAGO AT 641-585-3535.

Reported: 2005-10-13 (October 13, 2005) · Model years: 2005, 2006

ON CERTAIN MOTOR HOMES BUILT ON FORD CHASSIS, THE FASTENERS HOLDING THE FUEL TANK MOUNTING STRAPS MAY NOT HAVE BEEN PROPERLY TIGHTENED, ALLOWING THE POSSIBILITY FOR THE FUEL TANK TO LOOSEN AND FALL.

Consequence: IF THE FUEL TANK FALLS, THERE IS THE POTENTIAL FOR THE TANK TO IGNITE, RESULTING IN PERSONAL INJURY, VEHICLE AND PROPERTY DAMAGE.

Remedy: DEALERS WILL INSPECT AND PROPERLY TIGHTEN THE FASTENERS TO THE FUEL TANK STRAPS. THE RECALL BEGAN ON OCTOBER 15, 2005. OWNERS MAY CONTACT WINNEBAGO AT 614-585-6939.

Reported: 2005-12-28 (December 28, 2005) · Model years: 2006

ON CERTAIN MOTOR HOMES EQUIPPED WITH KWIKEE BRAND ELECTRIC STEPS, THE STEPS MAY HAVE BEEN MANUFACTURED WITH DEFECTIVE STEP CONTROL UNITS.

Consequence: THE DEFECTIVE CONTROL UNITS COULD DEVELOP AN ELECTRICAL SHORT ALLOWING FOR THE POTENTIAL OF THE PLASTIC CASE TO IGNITE, POSSIBLY RESULTING IN PERSONAL INJURY AND/OR VEHICLE AND PROPERTY DAMAGE.

Remedy: DEALERS WILL INSPECT THE KWIKEE STEP AND REPLACE THE STEP CONTROL UNIT, IF NECESSARY, FREE OF CHARGE. THE RECALL BEGAN ON DECEMBER 23, 2005. OWNERS MAY CONTACT WINNEBAGO AT 1-800-537-1885.

Reported: 2006-08-01 (August 1, 2006) · Model years: 2006, 2007

ON CERTAIN MOTORHOMES,THE FLAME ON THE COOKING RANGE MAY BE FORCED DOWNWARD OVER THE BURNER OR FLAME OUTAGE MAY OCCUR WHEN THE COOKING RANGE AND FURNACE ARE OPERATED AT THE SAME TIME. THIS IS DUE TO THE POSSIBILITY OF A MISSING OR INCOMPLETE CABINET PANEL THAT ISOLATES THE FURNACE RETURN AIR.

Consequence: IF THE FURNACE IS OPERATED AT THE SAME TIME AS THE STOVE AND THE CABINET PANEL IS MISSING OR INCOMPLETE, THE STOVE FLAME MAY GO OUT AND THE PROPANE GAS WILL CONTINUE TO FLOW, WHICH HAS THE POTENTIAL TO IGNITE RESULTING IN PERSONAL INJURY, VEHICLE AND PROPERTY DAMAGE.

Remedy: DEALERS WILL INSPECT THE CABINET ASSEMBLY AND, IF THE CABINENT PANEL IS MISSING OR INCOMPLETE, THE PANEL WILL BE INSTALLED OR REPAIRED. THE RECALL BEGAN ON AUGUST 10, 2006. OWNERS MAY CONTACT WINNEBAGO AT 1-641-585-6939.

Reported: 2008-08-12 (August 12, 2008) · Model years: 2006, 2007, 2008

WINNEBAGO IS RECALLING 31 MY 2006-2008 ITASCA CAMBRIA, HORIZON, WINNEBAGO ACCESS, ADVENTURER, JOURNEY, MINNIE WINNIE, SIGNTSEER, TOUR, VECTRA, AND VOYAGE MOTOR HOMES EQUIPPED WITH RICON PLATFORM STYLE WHEELCHAIR LIFTS. THESE LIFTS FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 403, "PLATFORM LIFT SYSTEMS FOR MOTOR VEHICLES." THE ANTI-STOW INTERLOCK MAY NOT DETECT THE PRESENCE OF A WHEELCHAIR OR MOBILITY AID USER. THE PRESSURE SENSING SWITCH THAT DETECTS THE PRESENCE OF WEIGHT ON THE PLATFORM WAS NOT ADJUSTED TO THE NECESSARY SENSITIVITY LEVEL. THE LIFT COULD STOW EVEN THOUGH SOMEONE OR SOMETHING IS STILL ON THE LIFT.

Consequence: A LIFT OCCUPANT CAN BE INJURED SHOULD THE LIFT BEGIN TO STOW UNINTENTIONALLY.

Remedy: WINNEBAGO IS WORKING WITH RICON TO CORRECT THE WHEELCHAIR LIFTS (PLEASE SEE 07E097). OWNERS MAY CONTACT RICON AT 1-800-322-2884 OR WINNEBAGO AT 1-641-585-3535.

Reported: 2008-03-28 (March 28, 2008) · Model years: 2007

WINNEBAGO IS RECALLING 31 MY 2006-2008 JOURNEY, VOYAGE, MY 2006-2007 SIGHTSEER, MY 2006 ADVENTURER, MINNIE WINNIE, MY 2007 ACCESS, TOUR, VECTRA, ITASCA CAMBRIA, AND MY 2007-2008 ITASCA HORIZON MOTOR HOMES EQUIPPED WITH RICON PLATFORM STYLE WHEELCHAIR LIFTS. THESE MOTOR HOMES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 404, "PLATFORM LIFT INSTALLATIONS IN MOTOR VEHICLES." THE THRESHOLD WARNING SYSTEM MAY NOT DETECT THE PRESENCE OF A WHEELCHAIR OR MOBILITY AID USER IN A CERTAIN SPOT WITHIN THE DEFINED THRESHOLD AREA.

Consequence: THE USER OF THE LIFT COULD BE INJURED SHOULD THE LIFT MOVE UNINTENTIONALLY.

Remedy: WINNEBAGO IS WORKING WITH RICON TO CORRECT THE WHEELCHAIR LIFTS FREE OF CHARGE (PLEASE SEE 07E095). THE RECALL BEGAN ON APRIL 9, 2008. OWNERS MAY CONTACT RICON AT 1-818-267-3000.

Reported: 2008-05-20 (May 20, 2008) · Model years: 2007, 2008

WINNEBAGO IS RECALLING 35 MY 2006-2008 ASPECT, ACCESS, CHALET, OUTLOOK, AND MINNIE WINNIE MOTOR HOMES, AND MY 2007-2008 ITASCA CAMBRIA MOTOR HOMES. A POOR GROUND MAY DEVELOP ON THE DAYTIME RUNNING LIGHT MODULE THAT WOULD ALLOW THE MODULE TO OVERHEAT.

Consequence: THIS COULD HAVE THE POTENTIAL TO IGNITE, POSSIBLY RESULTING IN PERSONAL INJURY AND/OR VEHICLE AND PROPERTY DAMAGE.

Remedy: DEALERS WILL REPLACE THE DAYTIME RUNNING LIGHT MODULE GROUND WIRE. THE RECALL BEGAN ON MAY 30, 2008. OWNERS MAY CONTACT WINNEBAGO AT 1-641-585-3535.

Reported: 2009-09-01 (September 1, 2009) · Model years: 2007, 2008

WINNEBAGO IS RECALLING MODEL YEAR 2007-2008 ACCESS, ASPECT, SIGHTEER AND VISTA, MODEL YEAR 2007-2008 ITASCA IMPULSE, CAMBRIA, SUNOVA, AND SUNSTAR, MODEL YEAR 2009-2010 WINNEBAGO ACCESS, SIGHTSEER AND VISTA, MODEL YEAR 2009-2010 ITASCA IMPULSE, SUNOVA, AND SUNSTAR MOTOR HOMES. THESE MOTOR HOMES MAY HAVE A MISSING STOVE PARTITION THAT ISOLATES THE FURNACE AIR.

Consequence: IF THE FURNACE IS OPERATED AT THE SAME TIME AS THE STOVE AND PARTITION IS MISSING, THE STOVE FLAME MAY GO OUT AND THE PROPANE GAS WILL CONTINUE TO FLOW, WHICH HAS THE POTENTIAL TO IGNITE RESULTING IN PERSONAL INJURY AND/OR VEHICLE AND PROPERTY DAMAGE.

Remedy: DEALERS WILL CORRECT THIS SITUATION BY INSTALLING A STOVE PARTITION THAT ISOLATES THE STOVE FROM THE FURNACE RETURN AIR AT NO CHARGE TO THE OWNER. THE RECALL BEGAN ON SEPTEMBER 30, 2009. OWNERS MAY CONTACT WINNEBAGO AT 1-800-537-1885.

Reported: 2008-07-11 (July 11, 2008) · Model years: 2008

WINNEBAGO IS RECALLING CERTAIN MY 2008-2009 MOTOR HOMES BUILT ON MY 2008 FORD E450 CHASSIS FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 120, "TIRE SELECTION AND RIMS FOR MOTOR VEHICLES OTHER THAN PASSENGER CARS." THE VEHICLE CERTIFICATION LABEL REFLECTS THE INCORRECT TIRE PRESSURE.

Consequence: FAILURE TO FOLLOW PROPER VEHICLE LOADING SPECIFICATIONS AND TIRE INFLATION RECOMMENDATIONS CAN RESULT IN TIRE DAMAGE AND VEHICLE INSTABILITY, INCREASING THE RISK OF A CRASH.

Remedy: OWNERS WILL BE PROVIDED WITH CORRECT VEHICLE CERTIFICATION LABELS AND INSTALLATION INSTRUCTIONS. A DEALER CAN INSTALL THIS LABEL FOR OWNERS IF THEY SO DESIRE. THE RECALL BEGAN ON JUNE 27, 2008. OWNERS MAY CONTACT WINNEBAGO AT 1-641-585-6939.

Reported: 2012-08-08 (August 8, 2012) · Model years: 2012

Winnebago is recalling certain model year 2012-2013 Winnebago and Itasca motor homes. A cutting machine may have scored the copper propane tubing resulting in unknown long-term reliability.

Consequence: If the copper tubing fails, propane can escape leading to a fire or explosion which can result in property damage, personal injury, or death.

Remedy: Winnebago will notify owners, and dealers will replace the copper tubing, free of charge. The recall began on September 6, 2012. Owners may contact Winnebago Industries Owner Relations at 1-641-585-6939.

Reported: 2013-04-24 (April 24, 2013) · Model years: 2012, 2013, 2014

Winnebago Industries is recalling certain model year 2012-2014 Minnie Winnie, Aspect, Sightseer, Adventurer, and Journey motorhomes; and model year 2012-2014 Itasca Spirit, Cambria, Sunova, Suncruiser, and Meridian motorhomes. The affected vehicles were manufactured January 10, 2012, through April 5, 2013 and may be missing a range enclosure.

Consequence: A missing range enclosure may allow the gas range flame to be extinguished due to air flow. In such a case, propane gas will continue to flow without a flame. If propane continues to flow, in the presence of an ignition source, it may suddenly combust resulting in a fire and/or personal injury.

Remedy: Winnebago notify owners and dealers will install a range enclosure, free of charge. The safety recall began on May 20, 2013. Owners may contact Winnebago at 1-641-585-3535. Winnebago's recall campaign number is 128.

Reported: 2013-04-26 (April 26, 2013) · Model years: 2013, 2014

Winnebago Industries, Inc. (Winnebago) is recalling certain model year 2013-2014 Winnebago Access, Aspect, Sightseer, Vista, Adventurer, Forza and Itasca Impulse, Cambria, Sunova, Sunstar, Suncruiser motorhomes manufactured February 20, 2013, through April 25, 2013. If the awning installation sequence was not completely followed, the awning motor may unknowningly become damaged. A damaged motor may lead to an unfurling of the awning.

Consequence: If motor damage occurs, it is possible that the awning can unfurl unexpectedly, either while the motorhome is at rest or while in transit, increasing the risk of personal injury or a vehicle crash.

Remedy: Winnebago will notify owners and Dometic staff will replace the affected motors with a design that is not subject to an out-of-sequence installation error. The recall began on July 17, 2013. Owners may contact Winnebago at 1-800-537-1885 or Dometic at 1-888-447-0003 for more information. Owners are being instructed not to drive their vehicle until repairs can be performed.

Reported: 2013-09-04 (September 4, 2013) · Model years: 2013, 2014

Winnebago Industries Inc. (Winnebago) is recalling certain model year 2013-2014 Aspect and Itasca Cambria (models 730C and 730J) motorhomes, manufactured March 12, 2012, through May 31, 2013. The child seat tether is mounted in an improper position.

Consequence: This improper position does not allow the child seat to be used properly and in the event of a crash, it will not allow the child seat to properly protect the occupant which increases the risk of injury.

Remedy: Winnebago will notify owners and dealers will remove the child tether, free of charge. The recall began on September 27, 2013. Owners may contact Winnebago at 1-800-537-1885 or or@winnebagoind.com. Winnebago's campaign number is 130.

Reported: 2017-12-07 (December 7, 2017) · Model years: 2013, 2014, 2015, 2016, 2017, 2018

Winnebago Industries, Inc. (Winnebago) is recalling certain 2013-2018 Winnebago Era, Travato, Minnie Winnie, Fuse, View, Trend, Aspect, Brave, Vista, Sightseer, Adventurer, Forza, Journey, Tour, Revel, Paseo, Chalet, Access, and Intent motorhomes and Commercial vehicles, and 2013-2018 Itasca Spirit, Navion, Cambria, Tribute, Sunstar, Sunova, Suncruiser, Solei, Meridian, Elipse, Horizon, Reyo, and Via motorhomes. These vehicles are equipped with Kidde Plastic-Handle or Push Button 'Pindicator' fire extinguishers that may become clogged, preventing the extinguisher from discharging as expected or excessive force may be needed to activate the extinguisher. Additionally, in certain models, the nozzle may detach from the valve assembly with enough force that it could cause injury and also render the product inoperable. For a full list of the affected fire extinguisher models visit: https://static.nhtsa.gov/odi/rcl/2017/RMISC-17E062-5427.pdf

Consequence: In the event of a fire, if the fire extinguisher does not function properly, it can increase the risk of injury.

Remedy: Winnebago will notify owners, instructing them to contact Kidde for replacement or aftermarket fire extinguishers, free of charge. The recall began on January 19, 2018. Owners may contact Winnebago customer service at 1-641-585-3535, or Kidde customer service toll-free at 1-855-262-3540, or online at www.kidde.com and click on "Product Safety Recall" for more information.

Reported: 2016-08-12 (August 12, 2016) · Model years: 2015, 2016, 2017

Winnebago Industries, Inc (Winnebago) is recalling certain model year 2015-2017 Itasca Cambria, 2015-2017 Winnebago ERA, Travato, Fuse, Aspect, and Vista recreational vehicles, and 2015-2017 Itasca Sunstar recreational vehicles manufactured May 6, 2014, to April 22, 2016. The affected vehicles may have a electrical connection to the automatic transfer switch (ATS) that may not be properly tightened.

Consequence: A loose power connection may cause a build up of heat at the connection, increasing the risk of a fire.

Remedy: Winnebago will notify owners, and dealers will tighten the electrical connection, replacing the ATS box and switch, as necessary. These repairs will be performed free of charge. The recall began on September 22, 2016. Owners may contact Winnebago customer service at 1-800-537-1885.