International 7600 recalls by model year

Reported: 2004-06-30 (June 30, 2004) · Model years: 2002, 2003, 2004

ON CERTAIN HEAVY DUTY TRUCKS EQUIPPED WITH INTERNATIONAL DT530, CUMMINS, OR CATERPILLAR I-6 ENGINES, THE POSITIVE BATTERY CABLE BETWEEN THE BATTERIES AND THE STARTER MAY RUB AGAINST AN ELECTRICAL GROUND CABLE BETWEEN THE STARTER AND FRAME RAIL.

Consequence: THIS COULD CAUSE AN ELECTRICAL SHORT AND/OR FIRE.

Remedy: DEALERS WILL INSPECT FOR ANY CHAFING. IF THERE IS NO EVIDENCE OF CHAFING, A SADDLE CLAMP WILL BE INSTALLED. IF THERE IS EVIDENCE OF CHAFING, THE DAMAGED CABLES WILL BE REPLACED AND THE SADDLE CLAMP INSTALLED. THE RECALL BEGAN ON AUGUST 16, 2004. OWNERS SHOULD CONTACT INTERNATIONAL AT 1-800-448-7825.

Reported: 2005-04-28 (April 28, 2005) · Model years: 2002, 2003, 2004, 2005, 2006

ON CERTAIN VEHICLES EQUIPPED WITH AIR OPERATED FIFTH WHEEL SLIDES AND AN MSVA 7-PACK ACCESSORY CONTROLLER, THE 7-PACK CAN ALLOW WATER TO CONTAMINATE ITS CIRCUIT BOARD. THIS COULD RESULT IN INADVERTENT OPERATION OF THE FIFTH WHEEL SLIDE CONTROL.

Consequence: IF THE SLIDE CONTROL ACTUATES WHILE THE VEHICLE IS IN MOTION, MOMENTUM FROM THE TRAILER CAN CAUSE THE FIFTH WHEEL TO SLIDE WITHOUT INPUT FROM THE DRIVER, WHICH COULD RESULT IN A CRASH WITHOUT WARNING.

Remedy: DEALERS WILL RELOCATE THE MSVA 7-PACK TO A LESS WATER INTENSIVE ENVIRONMENT. A NEW MSVA 7-PACK BASE, THAT HAS BEEN IMPROVED TO PREVENT WATER INTRUSION, AND ALL AIR ACCESSORY SOLENOIDS WILL BE INSTALLED FREE OF CHARGE. THE RECALL BEGAN ON AUGUST 5, 2005. OWNERS MAY CONTACT INTERNATIONAL AT 1-800-448-7825.

Reported: 2005-12-21 (December 21, 2005) · Model years: 2002, 2003, 2004, 2005, 2006

ON CERTAIN HEAVY DUTY TRUCKS EQUIPPED WITH CATERPILLAR DIESEL ENGINES, THE ENGINE ELECTRICAL GROUND CABLE THAT CONNECTS THE ENGINE BLOCK WITH THE STARTER MAY BE ROUTED IN A WAY THAT COULD CAUSE CHAFING AGAINST THE STARTER'S POSITIVE BATTERY CABLES.

Consequence: IF CHAFING OCCURS BETWEEN THE POSITIVE AND NEGATIVE CABLES, AN ELECTRICAL SHORT MAY RESULT AND MAY CAUSE A VEHICLE FIRE, POSSIBLY RESULTING IN PROPERTY DAMAGE, PERSONAL INJURY OR DEATH.

Remedy: DEALERS WILL INSPECT THE ENGINE GROUND CABLES FOR PROPER ROUTING. IF ANY CHAFING IS FOUND, THE ENGINE BLOCK GROUND CABLE WILL BE REPLACED WITH A SHORTER (280MM) CABLE AND ANY OTHER DAMAGED CABLES WILL BE REPLACED AND ROUTED CORRECTLY FREE OF CHARGE. THE RECALL BEGAN ON DECEMBER 21, 2005. OWNERS MAY CONTACT INTERNATIONAL AT 1-800-448-7825.

Reported: 2004-04-19 (April 19, 2004) · Model years: 2004

CERTAIN TRUCKS FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 121, "AIR BRAKE SYSTEMS." A STANDARD FITTING WAS INSTALLED IN PLACE OF A SINGLE CHECK VALVE ON THE PARK BRAKE RELAY VALVE.

Consequence: THIS COULD RESULT IN THE PARKING BRAKE NOT RELEASING AND STOPPING THE VEHICLE INCREASING THE RISK OF A CRASH.

Remedy: DEALERS WILL INSTALL THE CHECK VALVE. OWNER NOTIFICATION BEGAN ON MAY 3, 2004. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT INTERNATIONAL AT 1-800-448-7825.

Reported: 2004-04-22 (April 22, 2004) · Model years: 2004

CERTAIN TRUCKS FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 209, "SEAT BELT ASSEMBLIES." THE SEAT BELT LATCH FAILED A QUALITY REVIEW.

Consequence: THIS COULD CAUSE THE SEAT BELT LATCH TO BECOME DISENGAGED WITHOUT WARNING IN A VEHICLE CRASH OR DURING EPISODES OF HIGH SEAT BELT LOADING.

Remedy: DEALERS WILL REPLACE THE SEAT BELT ASSEMBLIES. OWNER NOTIFICATION IS BEGAN ON JUNE 11, 2004. OWNERS SHOULD CONTACT INTERNATIONAL AT 1-800-445-7825.

Reported: 2004-12-03 (December 3, 2004) · Model years: 2004, 2005

ON CERTAIN TRUCKS, THE BOLTS THAT MOUNT THE FRONT OF THE CAB TO THE MOUNTING BRACKETS WERE NOT PROPERLY TORQUED AT THE MANUFACTURING PLANT.

Consequence: THESE BOLTS CAN LOOSEN DURING NORMAL VEHICLE USE AND FALL OUT. THIS MAY LEAD TO THE CAB SEPARATING FROM THE VEHICLE'S CHASSIS DURING A VEHICLE CRASH THAT MAY RESULT IN PROPERTY DAMAGE, PERSONAL INJURY OR DEATH.

Remedy: AS AN INTERIM ACTION, DEALERS WILL PROPERLY TIGHTEN THE EXISTING CAB MOUNTING BOLTS AND REPLACE ANY MISSING BOLTS. AS SOON AS PARTS ARE AVAILABLE, DEALERS WILL REPLACE ALL SIXTEEN BOLTS AND TIGHTEN THEM PROPERLY. AN INTERIM LETTER WAS SENT TO OWNERS ON FEBRUARY 11, 2005. ANOTHER LETTER WAS SENT TO OWNERS ON APRIL 8, 2005, AS SOON AS PARTS ARE AVAILABLE. OWNERS SHOULD CONTACT INTERNATIONAL AT 1-800-448-7825.

Reported: 2005-10-04 (October 4, 2005) · Model years: 2006

ON CERTAIN HEAVY DUTY TRUCK/TRACTORS EQUIPPED WITH ARVINMERITOR SERIES 145 AND 160 REAR DRIVE AXLES. THE SUSPECT REAR DRIVE AXLE'S SPINDLES MAY HAVE BEEN INCORRECTLY HEAT TREATED. SUCH A CONDITION LESSENS THE OVERALL STRUCTURAL INTEGRITY OF THE SPINDLES AND COULD RESULT IN ITS FRACTURE.

Consequence: IF A SPINDLE FRACTURES WHILE THE VEHICLE IS IN MOTION, IT MAY CAUSE WHEEL SEPARATION, WHICH COULD, WITHOUT WARNING RESULT IN A VEHICLE CRASH.

Remedy: DEALERS WILL INSPECT THE SUSPECT VEHICLES AND IF THE SPINDLES ARE FOUND TO HAVE CERTAIN DATE CODES, THE AXLE WILL BE REPLACED. THE RECALL BEGAN ON OCTOBER 7, 2005. OWNERS MAY CONTACT INTERNATIONAL AT 1-800-448-7825.

Reported: 2007-07-24 (July 24, 2007) · Model years: 2006, 2007, 2008

ON CERTAIN 6X4 OR 6X6 TRUCKS WITH AIR BRAKES OR TRACTORS WITH AIR BRAKES AND EQUIPPED WITH BENDIX SR-7 SPRING BRAKE MODULATING VALVES, THE INTERNAL RUBBER CHECK VALVE MAY LEAK CAUSING A DELAY IN THE APPLICATION OF THE SPRING BRAKES TO PARK THE VEHICLE AFTER THE OPERATOR PULLS THE DASH VALVE BUTTON.

Consequence: THIS COULD DELAY OR FAILURE IN APPLYING THE PARKING BRAKES WHICH COULD RESULT IN A VEHICLE ROLL AWAY, INCREASING THE RISK OF A CRASH.

Remedy: INTERNATIONAL IS WORKING WITH BENDIX TO REPAIR THESE VEHICLES (PLEASE SEE 07E-037). BENDIX WILL INSTALL A CHECK VALVE REPAIR KIT FOR THE AFFECTED SR-7 SPRING BRAKE MODULATING VALVE FREE OF CHARGE. THE RECALL BEGAN ON SEPTEMBER 28, 2007. OWNERS MAY CONTACT BENDIX AT 440-329-9000 AND INTERNATIONAL AT 1-800-448-7825.

Reported: 2006-06-28 (June 28, 2006) · Model years: 2007

ON CERTAIN TRUCKS EQUIPPED WITH SR-7 BENDIX BRAKE VALVES, THE CHECK VALVE INSIDE THE VALVE CAVITY MAY NOT PROPERLY SET, CAUSING INTERNAL AIR LEAKAGE. IF THE CHECK VALVE DOES NOT PROPERLY SEAT, THE RESULTING LEAKAGE CAN CAUSE A DELAY IN THE APPLICATION OF THE SPRING BRAKES TO PARK THE VEHICLE AFTER OPERATOR PULLS THE DASH VALVE BUTTON.

Consequence: THE DELAYED PARKING BRAKE APPLICATION CAN OCCUR WITHOUT WARNING, LEADING TO UNINTENDED VEHICLE ROLLAWAY INCREASING THE RISK OF A CRASH.

Remedy: DEALERS WILL INSPECT THE VALVES AND REPLACE IT FREE OF CHARGE. THE RECALL BEGAN ON JULY 21, 2006. OWNERS MAY CONTACT INTERNATIONAL AT 1-800-448-7825.

Reported: 2006-10-11 (October 11, 2006) · Model years: 2007

ON CERTAIN TRUCKS EQUIPPED WITH CHALMERS REAR SUSPENSIONS, THE ADJUSTABLE TORQUE ROD END CASTINGS MAY BE BRITTLE. A BRITTLE ROD END CASTING MAY FRACTURE WITHOUT WARNING, CAUSING THE VEHICLES' REAR AXLES TO BECOME MISALIGNED.

Consequence: THIS MISALIGNMENT CAN CAUSE THE VEHICLE TO LOSE DIRECTIONAL STABILITY AT SPEEDS THAT MAY RESULT IN A VEHICLE CRASH.

Remedy: DEALERS WILL INSPECT THE VEHICLES TO DETERMINE IF THEY WERE MANUFACTURED WITH A SUSPECT TORQUE ROD END. IF A SUSPECT TORQUE ROD END IS FOUND, THE ENTIRE TORQUE ROD WILL BE REPLACED. THE RECALL BEGAN ON OCTOBER 6, 2006. OWNERS MAY CONTACT INTERNATIONAL AT 1-800-448-7825.

Reported: 2007-04-24 (April 24, 2007) · Model years: 2007, 2008

ON CERTAIN TRUCKS EQUIPPED WITH DAVCO FUEL PRO 382 HEATED FUEL FILTERS, WHEN THE KEY IS IN THE 'ON' POSITION, THE PRE-HEATER, LOCATED IN THE FUEL FILTER BASE, IS ENERGIZED.

Consequence: IF THIS PRE-HEATER IS ENERGIZED WHILE MAINTENANCE IS BEING PERFORMED ON THE FUEL FILTER, DIESEL FUEL COULD IGNITE WITHIN THE FILTER HOUSING. A FIRE WITHIN THE FUEL FILTER HOUSING MAY SPREAD POSSIBLY RESULTING IN PROPERTY DAMAGE OR PERSONAL INJURY.

Remedy: DEALERS WILL INSPECT THE FUEL FILTERS AND FUEL HEATERS AND, IF NECESSARY, WILL REPLACE THE FUEL HEATER. THE RECALL BEGAN ON MAY 11, 2007. OWNERS MAY CONTACT INTERNATIONAL AT 1-800-448-7825.

Reported: 2007-08-22 (August 22, 2007) · Model years: 2007, 2008

ON CERTAIN HEAVY DUTY CLASS 8 TRUCKS BUILT WITH CUMMINS ISM C876 ENGINES, THE ELECTRONIC CONTROL MODULE FAILS TO RECOGNIZE INPUTS OF THE VEHICLE ELECTRONIC CONTROL UNIT OR FROM A DRIVER ACTUATED DASH SWITCH THEREBY INCREASING THE RISK OF UNINTENDED (OR UNEXPECTED) ELEVATED EXHAUST TEMPERATURES.

Consequence: WHILE THIS CONDITION DOES NOT INVOLVE A RISK OF FIRE IN THE VEHICLE ITSELF, IT COULD PRESENT A FIRE HAZARD IN A SITUATION WHERE THE VEHICLE'S EXHAUST IS IN CLOSE PROXIMITY TO MATERIALS OR SUBSTANCES THAT CAN MELT, BURN, OR EXPLODE.

Remedy: CUMMINS, IN CONJUNCTION WITH INTERNATIONAL, WILL CONDUCT THE REMEDY CAMPAIGN. CUMMINS WILL INSTALL NEW ECM SOFTWARE. OWNERS CAN CONTACT CUMMINS AT 1-800-343-7357 OR INTERNATIONAL AT 1-800-448-7825.

Reported: 2007-10-24 (October 24, 2007) · Model years: 2007, 2008

ON CERTAIN TRUCKS EQUIPPED WITH SPLIT SHAFT STYLE POWER TAKE OFF (PTO), THE BOLTS THAT ATTACH THE DRIVE SHAFT FLANGES TO THE SPLIT SHAFT PTO MAY LOOSEN AND ALLOW THE DRIVE SHAFT TO SEPARATE FROM THE VEHICLE.

Consequence: DRIVE SHAFT SEPARATION MAY HAPPEN WITHOUT WARNING AND COULD POSSIBLY GET INTO THE PATH OF OTHER VEHICLES ON THE HIGHWAY, CAUSING PROPERTY DAMAGE, PERSONAL INJURY OR DEATH.

Remedy: DEALERS WILL REPLACE AND PROPERLY TIGHTEN THE SPLIT SHAFT PTO FLANGE MOUNTING BOLTS FREE OF CHARGE. THE RECALL BEGAN ON OCTOBER 30, 2007. OWNERS MAY CONTACT INTERNATIONAL AT 1-800-448-7825.

Reported: 2009-10-30 (October 30, 2009) · Model years: 2008, 2009, 2010

NAVISTAR IS RECALLING CERTAIN MODEL YEAR 2008 AND 2010 EMERGENCY VEHICLES MANUFACTURED BETWEEN JUNE 12, 2007 AND JUNE 24, 2009, EQUIPPED WITH CUMMINS ISB CM2150, ISC CM2150, ISL CM2150, ISM CM876, AND ISX CM871 MODEL DIESEL ENGINES. THE VEHICLES MAY BE DESIGNED WITH A HARD WIRED, DASH-MOUNTED SWITCH THAT ENABLES THE VEHICLE OPERATOR TO INHIBIT AFTERTREATMENT DIESEL PARTICULATE FILTER REGENERATION IN ENVIRONMENTS WHERE THE OPERATOR BELIEVES IT MAY BE UNSAFE FOR ELEVATED EXHAUST TEMPERATURES. DUE TO AN ISSUE WITH THE LOGIC IN THE ECM SOFTWARE IN THESE ENGINES, THE SWITCH MAY NOT FUNCTION CORRECTLY, LEADING THE OPERATOR TO BELIEVE THAT THE SWITCH IS IN "INHIBIT" MODE WHEN IT IS NOT.

Consequence: THIS CONDITION WILL PERMIT HOT EXHAUST GASES TO EXIT THE VEHICLE TAILPIPE, INCREASING THE RISK OF MELTING OR BURNING OF NEARBY SURFACES, OR A FIRE.

Remedy: CUMMINS IS CONDUCTING THIS CAMPAIGN AND WILL PROVIDE THE REMEDY FREE OF CHARGE. PLEASE SEE CUMMINS DEFECT REPORT 09E-046. OWNERS MAY CONTACT CUMMINS AT 1-800-343-7357.

Reported: 2010-03-18 (March 18, 2010) · Model years: 2009, 2010, 2011

NAVISTAR HAS NOTIFIED NHTSA OF A DEFECT ON CERTAIN MODEL YEAR 2008-2011 INTERNATIONAL TRUCKS EQUIPPED WITH AN OPTIONAL JUMP START STUD. CORROSION AT THE BASE OF THE STUD MAY CAUSE AN ELECTRICAL SHORT BETWEEN THE STUD AND BATTERY BOX.

Consequence: AN ELECTRICAL SHORT MAY CAUSE A VEHICLE FIRE.

Remedy: A FINAL REMEDY HAS BEEN ESTABLISHED. NAVISTAR WILL NOTIFY OWNERS, AND DEALERS WILL REPAIR THE VEHICLES BY INSTALLING A NEW JUMP START STUD. REPAIRS WILL BE PREFORMED FREE OF CHARGE. AN INTERIM ACTION WILL INVOLVE THE REMOVAL OF THE JUMP START STUD AND THE CONNECTING CABLE. THE SAFETY RECALL BEGAN ON SEPTEMBER 10, 2010. OWNERS MAY CONTACT INTERNATIONAL DEALERS AT 1-800-448-7825.

Reported: 2025-11-25 (November 25, 2025) · Model years: 2016

International Motors, LLC (International) is recalling certain 2016 7600, 2016-2023 Lonestar, 2018 8600, 2018-2023 LT, 2021-2026 MV, 2022-2023 RH, 2023-2026 HX, and 2025-2026 HV vehicles. Electrical noise and low signal to the power line carrier may cause the ECU to incorrectly process commands or stop working.

Consequence: Safety systems that depend on the ECU, such as Automatic Traction Control, ABS, Electronic Stability Control, Active Cruise Control, and Collison Mitigation System, may have diminished or lost functionality, increasing the risk of a crash.

Remedy: International will work with Bendix to reprogram the ECU, free of charge. Owner notification letters were mailed January 19, 2026. Owners may contact International's customer service at 1-800-448-7825. International's number for this recall is 25525. Vehicle Identification Numbers (VINs) involved in this recall will be searchable on NHTSA.gov beginning January 12, 2026.