Holiday Rambler NAVIGATOR recalls by model year

Reported: 1994-06-10 (June 10, 1994) · Model years: 1994

AN INCOMPLETE SEAL AT THE REAR OF THE MOTORHOME BETWEEN THE LIVING FACILITY AREA AND THE COMPARTMENT WHICH CONTAINS THE HEATING SYSTEM CAN ALLOW CARBON MONOXIDE (CO) TO ENTER THE LIVING AREA.

Consequence: THIS CONDITION CAN LEAD TO ILLNESS AND POSSIBLE DEATH TO VEHICLE OCCUPANTS FROM CARBON MONOXIDE POISONING.

Remedy: DEALERS WILL COMPLETELY SEAL OFF THE LIVING AREA FROM THE HEATING SYSTEM COMPARTMENT, AND WILL INSTALL REDESIGNED DUCTS FOR EXHAUSTING HEATING SYSTEM EMISSIONS TO THE EXTERIOR OF THE MOTORHOME.

Reported: 1995-10-13 (October 13, 1995) · Model years: 1995

WHEN OPERATED AT A HIGH SPEED, THE FRONT WIPER ARM CONNECTION TO THE WIPER DRIVE PIVOT SHAFT CAN LOOSEN CAUSING THE WINDSHIELD WIPER SYSTEM TO FAIL.

Consequence: LOSS OF WIPER FUNCTION RESULTS IN REDUCED VISIBILITY FOR THE DRIVER IN INCLEMENT WEATHER CONDITIONS AND INCREASES THE RISK OF AN ACCIDENT.

Remedy: DEALERS WILL REPLACE THE DEFECTIVE WIPER SYSTEMS WITH A DIFFERENT WIPER SYSTEM DESIGN.

Reported: 1995-11-08 (November 8, 1995) · Model years: 1995, 1996

THE WRONG SAFETY BELT BUCKLE ENDS WERE USED WHICH COULD CAUSE THE BELT NOT TO RELEASE.

Consequence: CONSEQUENCE OF NON-COMPLIANCE: IF THE SAFETY BELT ASSEMBLY WILL NOT RELEASE, SAFETY BELT USE FOR THE SEAT OCCUPANT IS IMPOSSIBLE, INCREASING THE RISK OF INJURY IN AN ACCIDENT.

Remedy: DEALERS WILL INSTALL THE CORRECT BUCKLE ENDS.

Reported: 2008-06-05 (June 5, 2008) · Model years: 1998, 1999, 2000, 2001, 2002

MONACO IS RECALLING CERTAIN MOTOR HOMES EQUIPPED WITH NORCOLD REFRIGERATORS. A FATIGUE FAILURE IN THE SECTION OF THE COOLING UNIT WHICH CONTAINS THE REFRIGERANT COULD ALLOW THE LIQUID SOLUTION TO SLOWLY LEAK.

Consequence: EXTENDED OPERATION OF A LEAKING COOLING UNIT COULD LEAD TO A FIRE FROM GAS WHICH MIGHT ESCAPE.

Remedy: MONACO IS WORKING WITH NORCOLD TO REPAIR THESE REFRIGERATORS. NORCOLD WILL PROVIDE THERMAL SWITCH KITS TO OWNERS ALONG WITH THE NECESSARY FORMS AND INSTRUCTIONS. THE RECALL BEGAN ON AUGUST 29, 2008. OWNERS MAY CONTACT NORCOLD AT 1-800-767-9101 OR MONACO AT 1-800-685-6545.

Reported: 2003-05-08 (May 8, 2003) · Model years: 1999

ON CERTAIN MOTORHOMES, FIFTH WHEELS AND TRAVEL TRAILERS EQUIPPED WITH NORCOLD REFRIGERATOR COOLING UNITS MODEL NUMBERS 1200LR AND 1200RIM, THESE REFRIGERATORS CAN EXPERIENCE LOW CYCLE FATIGUE FAILURE WHICH CAN LEAD TO THE LIQUID SOLUTION SLOWLY LEAKING FROM THE SEALED, PRESSURIZED COOLING UNIT THROUGH A SMALL CRACK.

Consequence: IF A LEAK OCCURS AND THE UNIT IS CONTINUALLY OPERATED, HYDROGEN GAS MAY BE EXPELLED AND CAN BE IGNITED, RESULTING IN A FIRE, POSSIBLY CAUSING SERIOUS INJURY OR DEATH.

Remedy: NORCOLD WILL NOTIFY ITS CUSTOMERS AND PROVIDE A REPLACEMENT COOLING UNIT FREE OF CHARGE. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT NORCOLD SERVICE CENTER AT 1-800-667-3005 OR MONACO AT 574-862-7211.

Reported: 2000-08-16 (August 16, 2000) · Model years: 2000

VEHICLE DESCRIPTION: CLASS A MOTOR HOMES PRODUCED ON ROADMASTER CHASSIS. AS THE RESULT OF INCORRECT CRIMPING OF HYDRAULIC LINE FITTINGS, IT IS POSSIBLE THAT ONE OR MORE OF THE HYDRAULIC HOSES ON THE ENGINE-COOLING UNIT COULD BECOME DETACHED. THIS COULD ALLOW HYDRAULIC FLUID TO BE SPRAYED IN THE ENGINE COMPARTMENT AREA.

Consequence: THIS COULD RESULT IN A FIRE.

Remedy: DEALERS WILL REPLACE THE HYDRAULIC HOSES AND THEIR FITTINGS.

Reported: 2001-04-30 (April 30, 2001) · Model years: 2000, 2001

VEHICLE DESCRIPTION: CLASS A MOTOR HOMES EQUIPPED WITH SAFETY BELT ASSEMBLIES BUILT BY AM-SAFE. ON SOME SEAT BELTS, THE BUCKLE AND CONNECTOR MAY UNLATCH DURING A COLLISION.

Consequence: SERIOUS INJURY OR DEATH COULD OCCUR IF THE VEHICLE OCCUPANT IS NOT PROPERLY RESTRAINED.

Remedy: DEALERS WILL INSPECT THE LAP BELTS AND, IF NECESSARY, REPLACE IT WITH A NEW BELT ASSEMBLY. AM-SAFE IS CONDUCTING THE OWNER NOTIFICATION. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT AM-SAFE AT 219-266-8330 OR MONACO AT 219-862-7211.

Reported: 2001-09-10 (September 10, 2001) · Model years: 2000

VEHICLE DESCRIPTION: MOTOR HOMES BUILT ON ROADMASTER CHASSIS. AS THE RESULT OF THE CLOSE PROXIMITY OF THE ENGINE SYSTEM IN RESPECT TO THE ROUTING OF THE 12-VOLT DC BATTERY CABLES, IT IS POSSIBLE FOR THE INSULATION ON THE BATTERY CABLE TO MELT AND CREATE A SHORT.

Consequence: THIS COULD RESULT IN THE LOSS OF THE 12-VOLT DC SYSTEM AND ENGINE OPERATION, INCREASING THE RISK OF A CRASH.

Remedy: DEALERS WILL ADD TWO HEAT SHIELDS TO THE EXHAUST SYSTEM TO DEFLECT HEAT, AND ADD HEAT SHIELDING SLEEVE MATERIAL OVER THE BATTERY CABLES IN THE AREA OF EXPOSURE TO EXHAUST HEAT. OWNER NOTIFICATION BEGAN JULY 22, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT MONACO AT 1-800-685-6545.

Reported: 2001-01-23 (January 23, 2001) · Model years: 2001

VEHICLE DESCRIPTION: MOTOR HOMES PRODUCED ON ROADMASTER CHASSIS. THE WATER PUMP CONTROLLER CANNOT ADEQUATELY HANDLE CURRENT LOAD WHICH CAN RESULT IN OVERHEATING OF THE PUMP CONTROLLER.

Consequence: THIS CREATES A POTENTIAL FOR A FIRE, INCREASING THE RISK OF INJURY TO A VEHICLE OCCUPANT.

Remedy: DEALERS WILL ADD A WIRE HARNESS AND RELAYS TO RELIEVE THE OVERLOAD POTENTIAL FROM THE WATER PUMP CONTROLLER. OWNER NOTIFICATION BEGAN MARCH 29, 2001. OWNERS WHO DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT MONACO AT 1-800-685-6545.

Reported: 2001-10-11 (October 11, 2001) · Model years: 2001, 2002

VEHICLE DESCRIPTION: MOTOR HOMES EQUIPPED WITH TAG AXLES. WELDS USED TO SECURE THE TAG AXLE TO THE TAG AXLE DRIVE SHAFT LOOP COULD FAIL.

Consequence: AS A RESULT, THE TAG AXLE TUBE COULD SEPARATE FROM THE DRIVE SHAFT LOOP, MOVE OUT OF ALIGNMENT, AND CONTACT CHASSIS COMPONENTS RESULTING IN DAMAGE TO THE TIRE AND CHASSIS COMPONENTS. IT MAY BE POSSIBLE FOR THE TAG AXLE TO BE TORN FROM THE CONTROL TOWER AND SEPARATE FROM THE MOTOR HOME.

Remedy: DEALERS WILL INSPECT THE WELDS, RE-WELD AND ADD SUPPORT GUSSETS. OWNER NOTIFICATION BEGAN OCTOBER 18, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT MONACO AT 1-800-685-6545.

Reported: 2002-01-07 (January 7, 2002) · Model years: 2001, 2002

ON CLASS A MOTOR HOMES BUILT WITH A STEERABLE AUXILIARY AXLE AND EQUIPPED WITH CERTAIN MERITOR-WABCO BRAKE SYSTEM TWO AND FOUR PORT RELAY VALVES, THE VALVE MAY STICK OPEN WHEN A HIGH-PRESSURE BRAKE APPLICATION IS RELEASED.

Consequence: WHEN THE VALVE STICKS OPEN, IT CAN RESULT IN A TOTAL LOSS OF AIR FROM EITHER THE SERVICE OR THE PARK BRAKE SYSTEM. THE DRIVER MAY LOSE BRAKING ABILITY UNDER A SERVICE APPLICATION, POSSIBLY RESULTING IN A VEHICLE CRASH.

Remedy: DEALERS WILL REPLACE THESE VALVES. MERITOR WABCO IS CONDUCTING THE OWNER NOTIFICATION AND REMEDY FOR THIS CAMPAIGN. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT MERITOR WABCO AT 800-535-5560 OR MONACO AT 1-877-466-6226.

Reported: 2004-06-02 (June 2, 2004) · Model years: 2003

ON CERTAIN MOTOR HOMES, THE WATER HEATER WAS INSTALLED UNDER THE SLIDE-OUT, WHICH MADE IT POSSIBLE FOR FUMES TO ENTER THE COACH WHEN THE WATER HEATER IS LIT AND THE COACH IS PARKED WITH THE SLIDE-OUT EXTENDED.

Consequence: THIS CAN CAUSE FUMES TO COME UP INSIDE THE COACH, INCREASING THE RISK OF INJURY TO THE VEHICLE OCCUPANTS.

Remedy: DEALERS WILL RELOCATE THE WATER HEATER TO THE OPPOSITE SIDE OF THE MOTOR HOME. OWNER NOTIFICATION BEGAN ON JUNE 30, 2004. OWNERS SHOULD CONTACT MONACO AT 1-800-685-6545.

Reported: 2006-05-25 (May 25, 2006) · Model years: 2004, 2005, 2006, 2007

ON CERTAIN CLASS A MOTOR HOMES EQUIPPED WITH DETROIT DIESEL SERIES C-60 ENGINES, THE ELECTRONIC CONTROL MODULE (ECM) WILL REQUIRE TO BE REPROGRAMMED TO CURRENT MAINFRAME CALIBRATIONS.

Consequence: REPROGRAMMING THE ECM WILL PREVENT THE POTENTIAL OF A TURBOCHARGER FAILURE FROM PROGRESSING TO AN ENGINE COMPARTMENT FIRE.

Remedy: DETROIT DIESEL IS CONDUCTING THIS RECALL (PLEASE SEE 06E019000) AND WILL REPROGRAM THE ECM TO CURRENT MAINFRAME CALIBRATIONS FREE OF CHARGE. OWNERS MAY CONTACT DETROIT DIESEL AT 313-592-3708 OR MONACO AT 1-800-685-6545.

Reported: 2007-12-20 (December 20, 2007) · Model years: 2008

ON CERTAIN CLASS A MOTOR HOMES EQUIPPED WITH TRW STEERING GEARS, MODELS TAS85 AND RCS85, THESE STEERING GEARS CONTAIN POTENTIALLY DEFECTIVE SECTOR SHAFTS WITH AN INCORRECT GEAR TOOTH WHICH MAY INTERFERE WITH THE RACK-PISTON TEETH, RESULTING IN A STICK OR BIND CONDITION.

Consequence: THIS CONDITION HAS THE POTENTIAL TO CAUSE THE STEERING GEAR TO STALL AND RESTRICT THE STEERING TURNING ANGLE OF THE VEHICLE WHICH COULD RESULT IN A VEHICLE CRASH.

Remedy: MONACO IS WORKING WITH TRW TO REPLACE THE DEFECTIVE STEERING GEAR (PLEASE SEE 07E101). THE RECALL BEGAN ON JANUARY 24, 2008. OWNERS MAY CONTACT MONACO AT 1-800-685-6545 OR TRW AT 1-765-429-1768.

Reported: 2010-06-25 (June 25, 2010) · Model years: 2008, 2009, 2010

KONGSBERG POWER PRODUCTS SYSTEMS I, INC., (KPPS) IS RECALLING ON BEHALF OF MONACO COACH CERTAIN MODEL YEAR 2008-2010 MOTOR HOMES MANUFACTURED AFTER APRIL 2007 AND EQUIPPED WITH PNEUMATIC AND HYDRAULIC ADJUSTABLE BRAKE PEDAL ASSEMBLIES SUPPLIED BY KPPS. THE DRIVE PIN WHICH SECURES THE BRAKE PEDAL ARM TO THE BALANCE OF THE ASSEMBLY MAY BECOME DISENGAGED, THIS MAY CAUSE A REDUCTION IN VEHICLE BRAKING AND/OR CAUSE THE BRAKE PEDAL TO MOVE OUT OF POSITION AND INTERFERE WITH THROTTLE PEDAL FUNCTION.

Consequence: A REDUCTION IN BRAKING OR INTERFERENCE WITH THE THROTTLE PEDAL COULD RESULT IN A CRASH.

Remedy: KPPS WILL PROVIDE A CLAMP ASSEMBLY KIT ALONG WITH INSTALLATION INSTRUCTIONS FREE OF CHARGE. THE SAFETY RECALL BEGAN ON JULY 16, 2010. OWNERS MAY CONTACT KPPS AT 1-877-485-6647.

Reported: 2010-01-20 (January 20, 2010) · Model years: 2010

NAVISTAR IS RECALLING CERTAIN MODEL YEAR 2008-2009 BEAVER CONTESSA, MODEL YEAR 2009 BEAVER MARQUIS, PATRIOT, MONTEREY, MODEL YEAR 2009-2010 HOLIDAY RAMBLER AMBASSADOR, MODEL YEAR 2010-2011 HOLIDAY RAMBLER ENDEAVOR, MODEL YEAR 2009-2010 HOLIDAY RAMBLER IMPERIAL, MODEL YEAR 2010 HOLIDAY RAMBLER NAVIGATOR, AND SCEPTOR, MODEL YEAR 2010 MONACO CAMELOT MODEL YEAR 2010-2011 MONACO DIPLOMAT, MODEL YEAR 2010 MONACO DYNASTY, MODEL YEAR 2009-2010 MONACO KNIGHT AND MODEL YEAR 2010 MONACO SIGNATURE MANUFACTURED FROM JANUARY 22, 2008 THROUGH OCTOBER 27, 2009 ON BEHALF OF MONACO RV WITH KONGSBERG POWER PRODUCTS SYSTEMS ADJUSTABLE BRAKE PEDALS. THE DRIVE PIN WHICH SECURES THE BRAKE PEDAL ARM TO THE BALANCE OF THE ASSEMBLY MAY BECOME DISENGAGED, THIS MAY CAUSE A REDUCTION IN VEHICLE BRAKING AND/OR CAUSE THE BRAKE PEDAL TO MOVE OUT OF POSITION AND INTERFERE WITH THROTTLE PEDAL FUNCTION.

Consequence: A REDUCTION IN BRAKING OR INTERFERENCE WITH THE THROTTLE PEDAL COULD RESULT IN A VEHICLE CRASH.

Remedy: NAVISTAR IS WORKING WITH KONGSBERG PLEASE SEE KONGSBERG DEFECT REPORT 09E-064. NAVISTAR WILL RECEIVE KITS AND WILL INSPECT AND INSTALL A C-CLAMP ON THE ADJUSTABLE BRAKE PEDAL. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. THE RECALL BEGAN ON FEBRUARY 4, 2010. OWNERS MAY CONTACT NAVISTAR AT 1-800-685-6545.

Reported: 2011-11-17 (November 17, 2011) · Model years: 2010, 2011

NAVISTAR IS RECALLING CERTAIN MODEL YEAR 2009-2011 BEAVER, HOLIDAY RAMBLER AND MONACO COACH BRAND RECREATIONAL VEHICLES MANUFACTURED FROM JANUARY 11, 2008, THROUGH APRIL 15, 2011. SEE THE ABOVE LIST FOR MODELS. THE FRONT WINDSHIELD SHADE MAY SEPARATE FROM THE CABIN BODY WITHOUT WARNING, POSSIBLY IMPAIRING THE DRIVER'S ABILITY TO SEE THE ROADWAY.

Consequence: AN IMPAIRMENT TO A DRIVER'S ABILITY TO SEE THE ROADWAY COULD CAUSE A VEHICLE CRASH POTENTIALLY RESULTING IN PROPERTY DAMAGE, PERSONAL INJURY, OR DEATH.

Remedy: NAVISTAR WILL NOTIFY OWNERS, AND DEALERS WILL INSPECT THE SHADE MOUNTING CLIPS AND REPAIR THE VEHICLES AS NECESSARY FREE OF CHARGE. THE SAFETY RECALL IS EXPECTED TO BEGIN DECEMBER 10, 2011.OWNERS MAY CONTACT NAVISTAR AT 1-877-466-6226.

Reported: 2018-03-28 (March 28, 2018) · Model years: 2017, 2018

REV Recreation Group (REV) is recalling certain 2018 Fleetwood Axon and Pulse, Holiday Rambler Reno and Prodigy, Monaco Marquis and American Coach American Dream motorhomes, 2017-2018 Fleetwood Bounder, Discovery, Discovery LXE, Flair, Jamboree, Southwind, Pace Arrow, Pace Arrow LXE and Storm motorhomes, Holiday Rambler Admiral XE, Endeavor, Endeavor XE, Navigator XE, Navigator, Vacationer, Vacationer XE and Vesta and American Coach American Eagle motorhomes and 2017 Holiday Rambler Scepter, Monaco Diplomat, and American Coach American Revolution motorhomes. The mounting screws for the satellite dish may not have been fastened through the sheet steel reinforcement, possibly allowing the satellite dish to detach from the roof while driving.

Consequence: If the satellite dish detaches from the roof while driving, it can increase the risk of a crash or injury.

Remedy: REV will notify owners, and dealers will resecure the satellite dish to the roof with a metal reinforcement, free of charge. The recall began on May 14, 2018. Owners may contact REV customer service at 1-800-509-3417. REV's number for this recall is 180322REV. Note: This recall supersedes recall 17V-802. Any vehicle repaired under that campaigned is not included in this one as the remedy for both recalls is the same.

Reported: 2017-07-27 (July 27, 2017) · Model years: 2018

REV Recreation Group (REV) is recalling certain 2017-2018 Fleetwood Discovery and Discovery LXE, and Holiday Rambler Endeavor, Endeavor XE, and Admiral XE motorhomes, as well as 2018 Monaco Diplomat, Fleetwood Pace Arrow, Bounder, Flair, and Storm motorhomes, and Holiday Rambler Navigator and Vacationer XE motorhomes. The affected vehicles may have been manufactured with headlights that do not have tempered glass lenses.

Consequence: If the headlamp lens is not tempered, it may crack or break, which may cause decreased illumination and/or premature failure of the headlight bulb, increasing the risk of a crash.

Remedy: REV Recreation Group will notify owners, and authorized REV dealers will inspect, and if necessary, replace non-tempered, defective headlamp lenses with new headlamp lenses, free of charge. The recall began on September 8, 2017. Owners may contact REV customer service at 1-800-509-3417. REVs number for the recall is 170720REV.

Reported: 2017-12-14 (December 14, 2017) · Model years: 2018

REV Recreation Group (REV) is recalling certain 2018 Fleetwood Axon, Bounder, Flair, Southwind, Pace Arrow and Pace Arrow LXE motorhomes, and 2018 Holiday Rambler Navigator, Navigator XE, Reno, Vacationer, and Vacationer XE motorhomes. The satellite dish on these vehicles may detach from the roof while driving and become a road hazard.

Consequence: If the satellite dish detaches from the roof while driving it can increase the risk of a crash or injury.

Remedy: REV will notify owners, and dealers will resecure the satellite dish to the roof with a metal reinforcement, free of charge. The recall began on February 9, 2018. Owners may contact REV customer service at 1-800-509-3417. REV's number for this recall is 171208REV.

Reported: 2018-03-19 (March 19, 2018) · Model years: 2018

REV Recreation Group (REV) is recalling certain 2018 American Coach American Dream and American Revolution motorhomes, Fleetwood Discovery, Discovery LXE, Pace Arrow and Pace Arrow LXE motorhomes, Holiday Rambler Endeavor, Endeavor XE, Navigator and Navigator XE motorhomes and Monaco Marquis and Signature motorhomes equipped with an Aurora heating, ventilation and air conditioning (HVAC) system. The wires for the HVAC system potentiometer may become disconnected from the quick connect terminals.

Consequence: If the potentiometer wires detach and are reconnected incorrectly, there is an increased risk of a fire.

Remedy: REV will notify owners, and dealers will inspect the potentiometer and solder the wires or replace the control panel, if necessary, free of charge. The recall began on May 14, 2018. Owners may contact REV customer service at 1-800-509-3417. REV's number for this recall is 180315REV.

Reported: 2019-12-04 (December 4, 2019) · Model years: 2020

REV Recreation Group (REV) is recalling certain 2020 Fleetwood Pace Arrow LXE, Discovery and Discovery LXE, and Holiday Rambler Navigator and Endeavor motorhomes. The wire harness/plumbing bundle within the slideout raceway may have been improperly wrapped and secured.

Consequence: Without the proper securement, the wire harness/plumbing bundle can become damaged, increasing the risk of a fire.

Remedy: REV will notify owners, and dealers will inspect, repair, reroute and resecure the wire harness/plumbing bundle, free of charge. The recall began January 31, 2020. Owners may contact REV customer service at 1-800-509-3417. REV's number for this recall is 191126REV.

Reported: 2020-11-16 (November 16, 2020) · Model years: 2021

REV Recreation Group (REV) is recalling certain 2021 Fleetwood Discovery, Discovery LXE, Pace Arrow, Pace Arrow LXE, Bounder, and Southwind and Holiday Rambler Armada, Endeavor, Nautica, Navigator, and Vacationer motorhomes. The primary gear of the bed lift motor may fail, allowing the bed frame to drop.

Consequence: A bed frame that drops can increase the risk of an injury.

Remedy: REV will notify owners, and dealers will inspect, and if necessary, replace the bed lift motor, free of charge. The recall is expected to begin January 12, 2021. Owners may contact REV customer service at 1-800-509-3417. REV's number for this recall is 201109REV.

Reported: 2022-08-30 (August 30, 2022) · Model years: 2021, 2022, 2023

REV Recreation Group (REV) is recalling certain 2018-2019 Fleetwood Jamboree, 2020-2023 Fleetwood Southwind, Bounder, Flair, Fortis, Holiday Rambler Admiral, Invicta, Vacationer, 2021-2023 Fleetwood Discovery, Discovery LXE, Holiday Rambler Navigator, Armada, Nautica, 2023 Fleetwood Flex, Holiday Rambler Eclipse, 2021 Fleetwood Pace Arrow LXE, 2018 Holiday Rambler Vesta, 2022-2023 Fleetwood Frontier, 2021-2022 Fleetwood Pace Arrow, Holiday Rambler Endeavor, and 2019 Holiday Rambler Augusta motorhomes. The hydraulic lines may have been improperly routed, secured, or protected, which can result in a hydraulic fluid leak.

Consequence: A hydraulic fluid leak in the presence of an ignition source can increase the risk of a fire.

Remedy: Dealers will inspect the hydraulic hoses for chafing or heat damage, and install hose protection, or replace them as necessary, free of charge. Owner notification letters were mailed October 28, 2022. Owners may contact REV customer service at 1-800-509-3417.

Reported: 2022-12-22 (December 22, 2022) · Model years: 2021, 2022, 2023

REV Recreation Group (REV) is recalling certain 2021-2023 Holiday Rambler Vacationer, Invicta, Navigator, Admiral, Fleetwood Southwind, Bounder, Pace Arrow, 2021-2022 Fleetwood Fortis, Flair, 2023 Fleetwood Flex and Holiday Rambler Eclipse motorhomes. The service valves on the LPG tanks may have improper thread depth, which can cause a propane leak.

Consequence: A propane leak in the presence of an ignition source can increase the risk of a fire.

Remedy: Dealers will inspect and if necessary replace the service valves, free of charge. Owner notification letters were mailed February 20, 2023. Owners may contact REV customer service at 1-800-509-3417.

Reported: 2023-03-14 (March 14, 2023) · Model years: 2023

REV Recreation Group (REV) is recalling certain 2023 Fleetwood Bounder, Flair, Flex, Fortis, Southwind, Discovery, Discovery LXE, Frontier, Frontier GTX, Pace Arrow, Holiday Rambler Admiral, Eclipse, Invicta, Vacationer, Armada, Endeavor, Navigator, Nautica, and American Coach American Tradition motorhomes. The entry door latch may fail and not allow entry or exit.

Consequence: The inability to enter or exit the vehicle in an emergency increases the risk of injury.

Remedy: Dealers will inspect and if necessary, replace the door latch, free of charge. Owner notification letters were mailed May 12, 2023. Owners may contact Rev Customer Service at 1-800-509-3417. Rev's number for this recall is 230224REV.