Ford THUNDERBIRD recalls by model year

Reported: 1966-10-06 (October 6, 1966) · Model years: 1967

Reported: 1966-11-15 (November 15, 1966) · Model years: 1967

Reported: 1967-02-23 (February 23, 1967) · Model years: 1967

Reported: 1967-11-15 (November 15, 1967) · Model years: 1967

Reported: 1970-05-12 (May 12, 1970) · Model years: 1970

Reported: 1970-09-25 (September 25, 1970) · Model years: 1971

Reported: 1971-11-22 (November 22, 1971) · Model years: 1972

Reported: 1972-06-19 (June 19, 1972) · Model years: 1972

Reported: 1972-09-29 (September 29, 1972) · Model years: 1972, 1973

Reported: 1972-11-08 (November 8, 1972) · Model years: 1973

Reported: 1973-03-29 (March 29, 1973) · Model years: 1973

Reported: 1973-08-28 (August 28, 1973) · Model years: 1973

Reported: 1974-01-16 (January 16, 1974) · Model years: 1974

Reported: 1974-08-13 (August 13, 1974) · Model years: 1975

Reported: 1975-03-04 (March 4, 1975) · Model years: 1975

Reported: 1975-03-04 (March 4, 1975) · Model years: 1975

Reported: 1975-04-23 (April 23, 1975) · Model years: 1975

Reported: 1976-04-29 (April 29, 1976) · Model years: 1976

Reported: 1977-09-13 (September 13, 1977) · Model years: 1977

THE INVOLVED VEHICLES WERE FITTED WITH TILT STEERING COLUMNS CONTAINING TRANSMISSION CONTROL INSERTS INTENDED FOR TRUCKS RATHER THAN PASSENGER VEHICLES. THIS MAY CAUSE THE TRANSMISSION SELECTOR POINTER TO BE MISALIGNED AND THE POSSIBILITY OF STARTING THE ENGINE WHEN THE SELECTOR IS BETWEEN THE NEUTRAL (N) AND DRIVE (D) DETENTS AND THE TRANSMISSION IS IN DRIVE.

Remedy: DEALER WILL INSPECT AND, IF NECESSARY, REPLACE THE TRANSMISSION SHIFT CONTROL INSERT, WITHOUT CHARGE TO OWNER.

Reported: 1977-09-13 (September 13, 1977) · Model years: 1977

THE INVOLVED VEHICLES MAY EXPERIENCE FUEL LEAKAGE AT THE RUBBER HOSE CONNECTING THE FUEL INLET TUBE TO THE CARBURETOR FILTER. THIS LEAKAGE CONDITION IS DUE TO INSUFFICIENT INSERTION OF THE FUEL TUBE INTO THE HOSE OR IMPROPER POSITIONING OF THE HOSE CLAMP, CAUSING THE CLAMP TO BE CRIMPED DIRECTLY OVER THE FUEL TUBE BEAD.

Remedy: DEALER WILL REPLACE THE EXISTING FUEL HOSE CLAMP WITH A SPRING-TYPE CLAMP AT THE HOSE-TO-FUEL INLET TUBE CONNECTION, AND ADJUST THE CONNECTION WHERE NECESSARY, WITHOUT CHARGE.

Reported: 1980-11-07 (November 7, 1980) · Model years: 1977

SOME OF THE FLEXIBLE FIVE-BLADE ENGINE COOLING FANS MAY BE SUBJECT TO HIGH BLADE STRESSES THAT CAN RESULT FROM RESONANT VIBRATION INPUTS OCCURRING DURING NORMAL VEHICLE OPERATION. THIS CAN LEAD TO FATIGUE CRACKING OF THE BLADES. PORTIONS OF THE BLADE MAY SEPARATE FROM THE FAN ASSEMBLY WITHOUT PRIOR WARNING.

Remedy: DEALER WILL REPLACE FAN WITH AN IMPROVED FIVE-BLADED VERSION WITHOUT CHARGE TO OWNER.

Reported: 1984-06-26 (June 26, 1984) · Model years: 1977

BLADES MAY CRACK AND MAY, OVER A PERIOD OF TIME, LOOSEN FROM FAN ASSEMBLY.

Remedy: FAN ASSEMBLY WILL BE REPLACED WITHOUT CHARGE.

Reported: 1977-10-25 (October 25, 1977) · Model years: 1978

ON THE INVOLVED VEHICLES, THE PARK ACTUATION SUPPORT PLATES ARE DEFECTIVE DUE TO THEIR SUSCEPTIBILITY TO CRACKING DUE TO IMPROPER HEAT TREATMENT DURING MANUFACTURE. AS A RESULT, FRAGMENTS FROM A BROKEN PLATE CAN BECOME LODGED IN THE TRANSMISSION PARKING PAWL MECHANISM. THIS COULD PREVENT THE TRANSMISSION PARKING PAWL FROM ENGAGING WHEN THE SELECTOR LEVER IS PLACED IN THE "PARK" POSITION, OR PREVENT THE PAWL FROM BEING DISENGAGED FROM THE PARK GEAR.

Remedy: THE DEALER WILL REPLACE THE PARK ACTUATION CAM SUPPORT PLATES, FREE OF CHARGE, ON ALL AFFECTED VEHICLES.

Reported: 1977-11-15 (November 15, 1977) · Model years: 1978

THE INVOLVED VEHICLES MAY HAVE BEEN EQUIPPED WITH CAST ALUMINUM WHEELS WITH INADEQUATE LUG NUT COUNTERBORE DEPTHS. THIS CONDITION MAY NOT PROVIDE SUFFICIENT LUG NUT THREAD ENGAGEMENT. THE LUG NUTS MAY LOOSEN AND FALL OFF, ALLOWING THE WHEEL TO SEPARATE FROM THE VEHICLE.

Remedy: DEALER WILL INSPECT AND, IF NEESSARY, WILL REPLACE THE WHEELS WITHOUT CHARGE TO OWNER.

Reported: 1978-05-15 (May 15, 1978) · Model years: 1978

THE INVOLVED VEHICLES ARE EQUIPPED WITH SHOULDER HARNESS RETRACTORS THAT MAY NOT LOCK. SHOULD THE VEHICLE EXPERIENCE A SUDDEN DECELERATION OR IMPACT, THE FRONT SEAT OCCUPANT MAY NOT BE RESTRAINED BY THE SHOULDER HARNESS PORTION OF THE THREE-POINT SEAT BELT SYSTEM. FURTHERMORE, THE SHOULDER HARNESS RETRACTORS MAY NOT ALLOW EXTRACTION OF THE SHOULDER BELT WEBBING DUE TO A PRE-LOCKED CONDITION. THIS IS A NON-COMPLIANCE TO THE EMERGENCY LOCKING RETRACTOR PERFORMANCE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 209, "SEAT BELT ASSEMBLIES".

Remedy: THE DEALER WILL REPLACE THE SEAT BELT ASSEMBLIES IF NECESSARY, WITHOUT CHARGE TO OWNER.

Reported: 1978-12-21 (December 21, 1978) · Model years: 1979

THE STEERING GEARS ON THE INVOLVED VEHICLES MAY HAVE BEEN BUILT WITH IMPROPERLY MANUFACTURED SECTOR SHAFTS FROM WHICH THE THREADED PORTIONS OF THE SHAFTS MAY FRACTURE AND SEPARATE. SHOULD THE SECTOR SHAFT FRACTURE, THE PITMAN ARM MAY DISENGAGE FROM THE SPLINED PORTION OF THE SECTOR SHAFT.

Remedy: THE DEALER WILL INSPECT AND, IF NECESSARY, REPLACE THE STEERING GEAR ASSEMBLY OR INSTALL A NEW SECTOR SHAFT IN THE STEERING GEAR ASSEMBLY.

Reported: 1979-01-09 (January 9, 1979) · Model years: 1979

THE INVOLVED VEHICLES MAY HAVE BEEN BUILT WITH INCORRECT WELD NUTS THAT ATTACH THE REAR PORTION OF THE FRONT OUTBOARD SEAT TRACK TO THE FLOOR PAN. THE INCORRECT NUTS HAVE AN OVERSIZE DIAMETER AND THREAD, AND UPON FRONT SEAT TRACK ANCHOR BOLT INSTALLATION, THE THREADS MAY HAVE BEEN STRIPPED.

Remedy: THE DEALER WILL INSPECT AND, IF NECESSARY, REPAIR ANY STRIPPED WELD NUTS AND INSTALL LARGER SIZE BOLTS TO ANCHOR THE SEAT TRACK TO THE FLOOR AT NO COST TO OWNER.

Reported: 1979-05-15 (May 15, 1979) · Model years: 1979

THE INVOLVED VEHICLES WERE PRODUCED WITH BRAKE PUSH-ROD TO BRAKE PEDAL RETAINING PINS WHICH WERE NOT HEAT-TREATED AS SPECIFIED. THIS COULD ALLOW THE BRAKE PEDAL TO BECOME DISENGAGED FROM THE PUSH-ROD.

Remedy: DEALER WILL REPLACE THE SUSPECT BRAKE RETAINING PIN.

Reported: 1979-12-18 (December 18, 1979) · Model years: 1980

THE INVOLVED VEHICLES DO NOT CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 105, "HYDRAULIC BRAKE SYSTEMS". REAR AXLE ASSEMBLIES INTENDED FOR OTHER VEHICLES MAY HAVE BEEN INSTALLED IN THE INVOLVED VEHICLES. THE WHEEL CYLINDERS MAY NOT BE THE CORRECT SIZE. THIS COULD AFFECT BRAKING PERFORMANCE.

Remedy: DEALER WILL REPLACE ANY INCORRECT WHEEL CYLINDERS WITHOUT CHARGE TO OWNER.

Reported: 1983-02-08 (February 8, 1983) · Model years: 1983

SOME OF THESE VEHICLES MAY HAVE BEEN BUILT WITH FUEL TANKS THAT HAVE INADEQUATELY WELDED FRONT SEAMS THAT CAN LEAK.

Remedy: THE DEALER WILL DETERMINE IF THE VEHICLE WAS CORRECTED AT THE FACTORY; IF NOT, THE FUEL TANK WILL BE REPLACED AT NO CHARGE TO THE OWNER.

Reported: 1983-03-07 (March 7, 1983) · Model years: 1983

THE PARKING GEAR MAY NOT ENGAGE, EVEN THOUGH THE GEAR SHIFT LEVER IS PLACED IN THE "PARK" POSITION. THIS OCCURS IF THE LINKAGE INSIDE THE TRANSMISSION THAT ACTUATES THE PARK GEAR WAS IMPROPERLY MANUFACTURED. A PIN THAT RETAINS COMPONENTS ON A LINKAGE (ACTUATING) ROD COULD BREAK AND THE LINKAGE MAY NOT ENGAGE THE PARKING GEAR.

Remedy: DEALER WILL INSPECT AND, IF NECESSARY, REPLACE THE PARKING PAWL ACTUATING ROD ASSEMBLY.

Reported: 1983-04-11 (April 11, 1983) · Model years: 1983

FUEL LEAKS COULD DEVELOP IN EITHER OF TWO CONNECTIONS IN A FUEL SUPPLY LINE. ONE CONNECTION UNDER THE VEHICLE MAY HAVE BEEN DAMAGED OR IMPROPERLY INSTALLED. THE OTHER SUSPECT PART IS IN THE ENGINE COMPARTMENT AND CONTAINS A PRESSURE RELIEF VALVE.

Remedy: THE DEALER WILL INSTALL A REVISED DESIGN FUEL LINE VALVE ASSEMBLY WITH NEW HOSE CLAMPS AND REPLACE THE FUEL SUPPLY HOSE CLAMP, IF IT IS DAMAGED OR INCORRECT. NOTIFICATION WAS MADE TO DEALERS PRIOR TO ANY RECORDED VEHICLE SALES, AND VEHICLES SHOULD HAVE BEEN CORRECTED BEFORE FINAL DELIVERY.

Reported: 1983-12-20 (December 20, 1983) · Model years: 1984

THE BOLTS THAT ATTACH THE D-SHAPED RING FOR THE SHOULDER BELT ARE INADEQUATELY SUPPORTED BY THE MATERIAL IN WHICH THEY ARE MOUNTED. THE ATTACHMENT DOES NOT COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 210, "SEAT BELT ASSEMBLY ANCHORAGES".

Remedy: DEALERS WILL INSTALL NEW ATTACHING HARDWARE TO IMPROVE THE STRENGTH OF THE MOUNTING.

Reported: 1985-03-11 (March 11, 1985) · Model years: 1985

BRAKE MASTER CYLINDERS MAY HAVE IMPROPERLY ANODIZED INTERNAL SURFACES CAUSING ACCELERATED WEAR OF A PISTON SEAL. CONSEQUENCE OF DEFECT: ONE PORTION OF THE SPLIT BRAKE SYSTEM WOULD BECOME INEFFECTIVE RESULTING IN INCREASED STOPPING DISTANCE WHICH MAY CAUSE AN ACCIDENT. DRIVER WOULD BE WARNED BY INCREASED PEDAL TRAVEL AND THE BRAKE WARNING LIGHT.

Remedy: MASTER CYLINDERS BUILT ON JANUARY 9, 1985 WILL BE REPLACED.

Reported: 1987-09-04 (September 4, 1987) · Model years: 1986, 1987

SPRING LOCK FUEL LINE COUPLING MAY NOT BE PROPERLY ENGAGED.

Consequence: COUPLING COULD DISENGAGE DUE TO FUEL PRESSURE,VIBRATION, AND ENGINE MOVEMENTS; THIS WOULD CAUSE LOSS OF FUEL WHICH, INPRESENCE OF AN IGNITION SOURCE, CREATES A FIRE RISK.

Remedy: INSTALL RETAINER CLIPS OVER THE COUPLINGS TO PREVENT COUPLING SEPARATION AND FUEL LEAKAGE.

Reported: 1988-03-15 (March 15, 1988) · Model years: 1988

A DESIGN CHANGE TO FACILITATE CHANGEOVER IN REAR AXLE SHAFT FLANGES INADVERTENTLY PRODUCED THE POSSIBILITY FOR INTERFERENCE BETWEEN THE FLANGE AND DISC BRAKE ROTOR.

Consequence: THE INTERFERENCE COULD PREVENT PROPER SEATING OF THEROTOR. ALSO AN IMPROPERLY SEATED ROTOR COULD IN TIME RESULT IN A REDUCTION INTHE CLAMPING FORCES OF THE WHEEL STUDS, POSSIBLY LEADING TO FRACTURED STUDSAND REAR WHEEL SEPARATION.

Remedy: INSPECTION OF VEHICLES AND WHERE NECESSARY REPLACE REAR AXLE SHAFTS AND REAR BRAKE ROTORS.

Reported: 1996-04-25 (April 25, 1996) · Model years: 1988, 1989, 1990, 1991, 1992, 1993

THE IGNITION SWITCH COULD EXPERIENCE AN INTERNAL SHORT CIRCUIT.

Consequence: THIS CONDITION COULD CAUSE OVERHEATING, SMOKE, AND POSSIBLY FIRE IN THE STEERING COLUMN AREA OF THE VEHICLE.

Remedy: DEALERS WILL REPLACE THE IGNITION SWITCH.

Reported: 1988-10-18 (October 18, 1988) · Model years: 1989

PLASTIC ROLLOVER VALVE MOUNTING PLATE MAY NOT BE PROPERLY SEALED TO THE PLASTIC FUEL TANK.

Consequence: FUEL OR VAPOR COULD LEAK, WHICH COULD RESULT IN A VEHICLEFIRE.

Remedy: REPLACE FUEL TANK.

Reported: 1989-05-19 (May 19, 1989) · Model years: 1989

IMPROPERLY HEAT TREATED REAR SUSPENSION KNUCKLES COULD EXPERIENCE HIGH MILEAGE FATIGUE CRACKS AND EVENTUAL FRACTURE.

Consequence: THIS COULD RESULT IN REAR SUSPENSION FAILURE AT THEAFFECTED WHEEL WITH AN ADVERSE AFFECT ON CONTROL OF THE CAR, WHICH COULDCAUSE AN ACCIDENT.

Remedy: REPLACE KNUCKLES THAT HAVE THE AFFECTED LOT CODES.

Reported: 1989-05-19 (May 19, 1989) · Model years: 1989

DUE TO CONTACT BETWEEN THE BRAKE CALIPER OF THE INBOARD FRONT WHEEL AND THE FRONT STABILIZER BAR, THERE MAY BE INCREASED BRAKE PEDAL TRAVEL FOLLOWING LOW SPEED TURNING MANEUVERS.

Consequence: THIS COULD CAUSE A REDUCTION IN BRAKE PERFORMANCETHAT COULD RESULT IN AN ACCIDENT.

Remedy: INSTALL ACORN TYPE FRONT SUSPENSION STRUT NUTS TO ELIMINATE STABILIZER BAR TO BRAKE CALIPER CONTACT.

Reported: 1990-02-12 (February 12, 1990) · Model years: 1990

BATTERY TO STARTER CABLES ARE LONGER THAN SPECIFIED; EXCESSIVE CABLE LENGTH COULD CONTACT ENGINE DAMPER PULLEY.

Consequence: CABLE PROTECTIVE COVERING AND INSULATION COULD WEAR THROUGH AND CAUSE A DIRECT SHORT TO GROUND, RESULTING IN OVERHEATING OF THE CABLE INSULATION AND POSSIBLY A UNDERHOOD FIRE.

Remedy: REPLACE BATTERY TO STARTER CABLE WITH CORRECT LENGTH CABLE.

Reported: 1991-05-06 (May 6, 1991) · Model years: 1990, 1991

THE NUTS WHICH HOLD WINDSHIELD WIPER MOTOR TO THE WIPER MODULE MAY NOT HAVE BEEN SUFFICIENTLY TIGHTENED AND MAY LOOSEN OR COME OFF. THIS CAUSES CHANGED WIPER PATTERNS, OR THE WIPERS MAY JAM IF TWO OF THE THREE NUTS COME OFF.

Consequence: CHANGES IN THE WIPER PATTERN OR JAMMING OF THE WIPERSWOULD RESULT IN REDUCED DRIVER VISIBILTY IN INCLEMENT WEATHER CONDITIONS.

Remedy: APPLY TORQUE RETENTION MATERIAL TO WIPER MOTOR STUDS AND NUTS AND RETORQUE.

Reported: 1991-03-18 (March 18, 1991) · Model years: 1991

THE PARK ROD ASSEMBLY CONTAINS A PARK CAM WITH INADEQUATE SURFACE HARDNESS, WHICH COULD LEAD TO PARK DISENGAGEMENT OR NO PARK ENGAGEMENT WHEN THE LEVER IS PLACED IN PARK.

Consequence: IF PARK IS NOT ENGAGED AND THE PARKING BRAKE IS OFF, AVEHICLE ROLL-AWAY COULD RESULT.

Remedy: REPLACE PARK ROD ASSEMBLY ON AUTOMATIC TRANSMISSIONS.

Reported: 1997-09-22 (September 22, 1997) · Model years: 1992, 1993

VEHICLE DESCRIPTION: PASSENGER VEHICLES ORIGINALLY SOLD OR CURRENTLY REGISTERED IN THE STATES OF CONNECTICUT, DISTRICT OF COLUMBIA, DELAWARE, IOWA, ILLINOIS, INDIANA, KENTUCKY, MASSACHUSETTS, MARYLAND, MAINE, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, WISCONSIN, AND WEST VIRGINIA. MOVEMENT OF THE FUEL LINES CAUSES THE NYLON FUEL LINE JUMPER TO CHAFE AGAINST THE FLOOR PAN. THIS WEAR CAN CAUSE A PIN HOLE IN THE FUEL LINE RESULTING IN FUEL LEAKAGE.

Consequence: THIS FUEL LEAKAGE RESULTS IN DAMPNESS AND FUEL ODOR, AND IF AN IGNITION SOURCE WAS PRESENT, A FIRE COULD RESULT.

Remedy: DEALERS WILL INSTALL A PLASTIC CONVOLUTE COVERING AROUND THE FUEL LINES. IF THE LINES SHOW A LEAK, THE LINES WILL BE REPLACED FIRST.

Reported: 1999-10-12 (October 12, 1999) · Model years: 1992, 1993

VEHICLE DESCRIPTION: PASSENGER VEHICLES EQUIPPED WITH FOG LIGHTS, IN WHICH THE HEADLIGHTS MAY GO OUT FOR VARIOUS INTERVALS AND WHICH MAY BE PRECEDED BY FLICKERING OR BLINKING AS A RESULT OF THE CIRCUIT BREAKER OPENING.

Consequence: DRIVER'S COULD EXPERIENCE A LOSS OF VISIBILITY, INCREASING THE RISK OF A CRASH.

Remedy: DEALERS WILL INSTALL A HEADLIGHT SWITCH WHICH INCORPORATES A CIRCUIT BREAKER OF REVISED DESIGN, AND INSTALL A WIRING HARNESS CONNECTOR, IF NEEDED.

Reported: 1996-01-16 (January 16, 1996) · Model years: 1996

UNDER CERTAIN CONDITIONS, THE CLIMATE CONTROL BLOWER DOES NOT OPERATE AS INTENDED. THE BLOWER COULD (1) STICK ON "HIGH;" (2) OPERATE ERRATICALLY WITH BLOWER OUTPUT VARYING BETWEEN NO BLOWER AND MAXIMUM BLOWER; OR (3) NOT OPERATE AT ALL DUE TO MALFUNCTION OF THE TEMPERATURE CONTROL MODULE.

Consequence: BLOWER MALFUNCTIONS LIMITING OR STOPPING OUTPUT CAN ADVERSELY AFFECT WINDSHIELD DEFROSTING AND DEFOGGING PERFORMANCE INCREASING THE POTENTIAL FOR A VEHICLE ACCIDENT.

Remedy: DEALERS WILL REPLACE THE SEMI-AUTOMATIC TEMPERATURE CONTROL MODULES WITH MODULES CONTAINING REVISED SOFTWARE.

Reported: 1996-04-22 (April 22, 1996) · Model years: 1996

WHEN IN THE SECONDARY LATCHED POSITION, THE DRIVER DOOR LATCHES MAY OPEN WHEN SUBJECTED TO TRANSVERSE LOADS LESS THAN THAT SPECIFIED IN FMVSS NO. 206, "DOOR LOCKS AND DOOR RETENTION COMPONENTS."

Consequence: THE DRIVER'S DOOR, WHEN CLOSED ONLY TO THE SECONDARY LATCHED POSITION, MAY NOT SUSTAIN A 1,000 POUND TRANSVERSE LOAD.

Remedy: DEALERS WILL INSPECT AND, IF NECESSARY, REPLACE THE DRIVER DOOR LATCH.

Reported: 2002-06-14 (June 14, 2002) · Model years: 2002

ON CERTAIN PASSENGER VEHICLES, THE DRIVER'S SIDE SEAT BELT CONTACTED THE SEAT RECLINER DURING A 35 MPH NCAP FULL-FRONTAL BARRIER IMPACT TEST.

Consequence: THE EDGE OF THE RECLINER MECHANISM CAUSED A PARTIAL CUT IN THE LAP PORTION OF THE WEBBING. IF THE WEBBING IS CUT, IT INCREASES THE RISK OF INJURY IN A CRASH.

Remedy: DEALERS WILL INSTALL AN INSERT BEHIND THE DRIVER SIDE SEAT LOWER TRIM PANEL. OWNER NOTIFICATION BEGAN JUNE 21, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-866-436-7332.

Reported: 2004-07-08 (July 8, 2004) · Model years: 2004

CERTAIN PASSENGER VEHICLES EQUIPPED WITH POWER ADJUSTABLE SEATS MAY HAVE BEEN INADEQUATELY WELDED.

Consequence: THE SEAT MAY NOT PERFORM AS INTENDED DURING A CRASH WHICH COULD INCREASE THE RISK OF INJURY.

Remedy: DEALERS WILL REPLACE THE UPPER SUPPORT ASSEMBLY ON THE POWER SEATS. THE RECALL BEGAN ON JULY 20, 2004. OWNERS SHOULD CONTACT FORD AT 1-800-392-3673.

Reported: 2005-03-18 (March 18, 2005) · Model years: 2005

ON CERTAIN PASSENGER VEHICLES, THE FUEL TANK MAY HAVE A LOCALIZED THIN WALL SECTION IN THE LOWER HALF OF THE TANK. THE FUEL TANK MAY CRACK CREATING A POTENTIAL FOR A FUEL LEAK AND FUEL ODOR. THE "SERVICE ENGINE SOON" INDICATOR MAY ILLUMINATE.

Consequence: A FUEL LEAK IN THE PRESENCE OF AN IGNITION SOURCE COULD RESULT IN A FIRE.

Remedy: DEALERS WILL REPLACE THE FUEL TANK FREE OF CHARGE. THE RECALL BEGAN ON APRIL 4, 2005. OWNERS MAY CONTACT FORD AT 1-800-392-3673, LINCOLN AT 1-800-521-4140.