Ford LN7000 recalls by model year

Reported: 1971-02-19 (February 19, 1971) · Model years: 1970, 1971

Reported: 1971-02-19 (February 19, 1971) · Model years: 1971

Reported: 1977-03-14 (March 14, 1977) · Model years: 1976

THE INVOLVED VEHICLES MAY HAVE BEEN ASSEMBLED WITH IMPROPERLY MANUFACTURED FRONT SPRING U-BOLTS USED TO SECURE THE FRONT AXLE ASSEMBLY TO THE SPRING. THE FOUR U-BOLTS MAY EXPERIENCE CRACKS AND COULD ULTIMATELY BREAK. SHOULD TWO U-BOLTS ON THE SAME SIDE OF THE VEHICLE BREAK, THE FRONT AXLE WOULD NOT BE RETAINED SECURELY.

Remedy: ALL SUSPECT U-BOLTS WILL BE REPLACED BY THE DEALER, FREE OF CHARGE.

Reported: 1982-03-15 (March 15, 1982) · Model years: 1982

SOME OF THE SUSPECT VEHICLES MAY HAVE BEEN PRODUCED WITH THE POSITIVE BATTERY CABLE INCORRECTLY INDEXED AT THE ATTACHMENT TO THE STARTER SOLENOID. CABLE INSULATION DAMAGE COULD OCCUR DUE TO METAL ON METAL CONTACT DURING MAXIMUM ENGINE ROLL CONDITIONS. AN ELECTRICAL SHORT MAY DEVELOP BETWEEN THE BATTERY CABLE AND A BRAKE TUBE. A HOLE COULD BE FORMED IN THE BRAKE TUBE, RESULTING IN LOSS OF BRAKE FLUID AND REDUCED BRAKING CAPABILITY.

Remedy: DEALER WILL INSPECT AND, IF NECESSARY, RE-INDEX THE STARTER POSITIVE BATTERY CABLE ATTACHMENT AT NO COST TO OWNER.

Reported: 1990-06-25 (June 25, 1990) · Model years: 1989, 1990

SECONDARY SERVICE RESERVOIR AIR CHECK VALVES MAY NOT SEAT PROPERLY DUE TO A MECHANICAL INTERFERENCE CONDITION BETWEEN A CIRCULAR BRASS GUIDE AND THE WALL OF A CYLINDRICAL FERRULE IN WHICH THE BRASS GUIDE IS INTENDED TO MOVE FREELY.

Consequence: IN THE EVENT OF PRESSURE LOSS IN THE SUPPLY RESERVOIR,A DEFECTIVE CHECK VALVE WOULD ALLOW PRESSURE EQUALIZATION BETWEEN PRIMARY ANDSECONDARY SERVICE RESERVOIRS, PRESENTING THE POTENTIAL FOR LOSS OR ABSENCE OFFRONT BRAKING ABILITY, WHICH COULD CAUSE LOSS OF CONTROL AND AN ACCIDENT.

Remedy: INSTALL REVISED DESIGN SECONDARY SERVICE RESERVOIR CHECK VALVE COMPONENTS.

Reported: 1993-09-27 (September 27, 1993) · Model years: 1992, 1993

AS A RESULT OF INHERENT VIBRATION IN THESE ENGINES, THE THROTTLE RETURN SPRINGS CAN FRACTURE.

Consequence: IF ONE OF THE TWO RETURN SPRINGS FRACTURES WHILE THEVEHICLE IS BEING DRIVEN, A SUBSTANTIAL REDUCTION IN ACCELERATOR PEDAL EFFORTWOULD BE FELT. IF THE SECOND SPRING ALSO FRACTURES, THE THROTTLE WOULD NOTRETURN TO IDLE POSITION AND CAN RESULT IN INCREASED ENGINE SPEED AND THEPOSSIBILITY OF LOSS OF VEHICLE CONTROL AND AN ACCIDENT.

Remedy: THE THROTTLE RETURN CONTROL SYSTEM WITH THE COIL TORSION SPRING DESIGN WILL BE REPLACED.

Reported: 1995-08-02 (August 2, 1995) · Model years: 1993, 1994, 1995

THE HAND THROTTLE CABLE CAN WEAR THE BRASS SWIVEL BLOCK ON THE GOVERNOR LEVER THROUGH WHICH IT PASSES.

Consequence: THIS WEAR CAN RESULT IN THE GOVERNOR JAMMING IN THEDAMAGED SWIVEL AND COULD PREVENT THE GOVERNOR LEVER FROM RETURNING TO THE IDLE POSITION.

Remedy: DEALERS WILL INSTALL A REVISED GOVERNOR LEVER WITH A STAINLESS STEEL SWIVEL. ALSO LETTERS WILL BE SENT TO VEHICLE OWNERS THAT HAVE THE SAME VEHICLES BUT DO NOT HAVE A FORD INSTALLED HAND THROTTLE ADVISING THEM THAT THEY MAY REQUIRE SERVICE IF THEY HAVE HAD AN AFTER MARKET HAND THROTTLE INSTALLED.