Fleetwood BOUNDER CLASSIC recalls by model year

Reported: 2010-04-23 (April 23, 2010) · Model years: 2010

FLEETWOOD RV IS RECALLING CERTAIN MODEL YEAR 2010-2011 BOUNDER CLASSIC 30T AND MODEL YEAR 2010 ENCOUNTER 28MS, 30SA AND 32BH CLASS A MOTOR HOMES MANUFACTURED FEBRUARY 26, 2010 THROUGH JUNE 17, 2010 FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF PART 567,"CERTIFICATION." THE FEDERAL CERTIFICATION TAG WAS PRINTED WITH AN INCORRECT FRONT AND REAR TIRE PSI.

Consequence: THIS DOES NOT MEET THE REQUIREMENTS OF THE STANDARD.

Remedy: FLEETWOOD WILL MAIL CORRECT FEDERAL CERTIFICATION TAGS TO DEALERS AND OWNERS ALONG WITH INSTALLATION INSTRUCTIONS. IF CUSTOMERS DO NOT FEEL COMFORTABLE INSTALLING THE TAGS THEY MAY TAKE THEIR MOTOR HOME TO ANY FLEETWOOD DEALER AND THEY WILL PERFORM THIS SERVICE FREE OF CHARGE. THE SAFETY RECALL BEGAN ON MAY 3, 2010. OWNERS MAY CONTACT FLEETWOOD AT 800-509-3418.

Reported: 2010-06-09 (June 9, 2010) · Model years: 2010

FLEETWOOD RV IS RECALLING CERTAIN MODEL YEAR 2010 BOUNDER, BOUNDER CLASSIC, FIESTA, SOUTHWIND AND TERRA CLASS A MOTOR HOMES MANUFACTURED FROM MARCH 11, 2010 THROUGH MARCH 30, 2010. THESE MOTOR HOMES WERE BUILT ON WORKHORSE CUSTOM CHASSIS AND WITH GENERAL MOTORS GASOLINE ENGINES AND EQUIPPED WITH REMY ALTERNATOR. A LOW RESISTANCE ELECTRICAL SHORT IN THE ALTERNATOR'S VOLTAGE REGULATOR MAY OCCUR.

Consequence: AN ELECTRICAL SHORT IN THE ALTERNATOR MAY OCCUR WITHOUT WARNING POSSIBLY RESULTING IN A VEHICLE FIRE.

Remedy: DEALERS WILL INSPECT AND REPLACE THE ALTERNATOR IF NECESSARY FREE OF CHARGE. NAVISTAR/WORKHORSE IS HANDING THE OWNER NOTIFICATION AND REMEDY FOR THIS CAMPAIGN PLEASE SEE NAVISTAR/WORKHORSE'S DEFECT REPORT 10V-158. OWNERS MAY CONTACT NAVISTAR/WORKHORSE AT 1-877-246-7731.

Reported: 2011-05-24 (May 24, 2011) · Model years: 2011

FLEETWOOD RV IS RECALLING CERTAIN MODEL YEAR 2011 BOUNDER CLASSIC, STORM AND TERRA CLASS A MOTOR HOMES BUILT ON FORD CHASSIS AND MANUFACTURED FROM MAY 21, 2010, THROUGH FEBRUARY 11, 2011. CERTAIN MODEL YEAR 2011 BOUNDER AND SOUTHWIND CLASS A MOTOR HOMES BUILT ON FORD CHASSIS AND MANUFACTURED FROM MAY 24, 2010 THROUGH MAY 18, 2011; AND CERTAIN MODEL YEAR 2012 BOUNDER AND SOUTHWIND CLASS A MOTOR HOMES BUILT ON FORD CHASSIS AND MANUFACTURED FROM MAY 16, 2011 THROUGH JUNE 15, 2011. A WIRE HARNESS THAT IS ROUTED UNDER THE MOTOR HOME, NEAR THE CHASSIS RAIL, CAN CONTACT A HEAT SHIELD LOCATED NEXT TO THE PASSENGER SIDE ENGINE EXHAUST MANIFOLD. THE CLOSE PROXIMITY CAN CAUSE THE HARNESS TO MELT OR BE OTHERWISE DAMAGED.

Consequence: A DAMAGED WIRE HARNESS CAN RESULT IN AN ELECTRICAL SHORT, RESULT IN INTERMITTENT OPERATION OF ELECTRICAL SYSTEMS VEHICLE "SHUT DOWN", AND/OR LEAD TO A FIRE, AND MAY RESULT IN LOSS OF VEHICLE CONTROL, INJURY, OR DEATH.

Remedy: DEALERS WILL INSPECT AND REROUTE THE WIRE HARNESS AWAY FROM THE HEAT SHIELD. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL IS EXPECTED TO BEGIN DURING JUNE 2011. OWNERS MAY CONTACT FLEETWOOD OWNER RELATIONS AT 1-800-509-3418.

Reported: 2011-08-03 (August 3, 2011) · Model years: 2011

FLEETWOOD RV IS RECALLING CERTAIN MODEL YEAR 2010 AMERICAN EAGLE, AMERICAN TRADITION, DISCOVERY, REVOLUTION LE, AND MODEL YEAR 2011 AMERICAN EAGLE, AMERICAN HERITAGE, AMERICAN TRADITION, BOUNDER, BOUNDER CLASSIC, DISCOVERY, EXPEDITION, PROVIDENCE, REVOLUTION LE, AND SOUTHWIND CLASS A MOTOR HOMES EQUIPPED WITH MURRAY OR SIEMENS BRAND CIRCUIT BREAKERS. THESE CIRCUIT BREAKERS HAVE A NON-CONFORMING "SPRING CLIP" PLUG-IN ASSEMBLY THAT BREAKS OR FAILS TO PROVIDE SUFFICIENT FORCE TO MAINTAIN A PROPER ELECTRICAL CONNECTION IN THE PANEL BOARD.

Consequence: THIS CONDITION COULD LEAD TO EXCESSIVE TEMPERATURE, ARCING OR THERMAL DAMAGE AT THE CONNECTION POINT, AND POTENTIAL DAMAGE TO THE PANEL BOARD'S ELECTRICAL INSULATION. THIS COULD LEAD TO FIRE, PROPERTY DAMAGE, OR PERSONAL INJURY.

Remedy: DEALERS WILL INSPECT AND REPLACE THE CIRCUIT BREAKERS IF NECESSARY, FREE OF CHARGE. THE SAFETY RECALL BEGAN ON AUGUST 25, 2011. OWNERS MAY CONTACT FLEETWOOD OWNER RELATIONS AT 1-800-509-3418.

Reported: 2013-01-09 (January 9, 2013) · Model years: 2012, 2013

Fleetwood RV is recalling certain model year 2012 and 2013 Bounder Classic model 30T motorhomes manufactured from February 17, 2012, through November 30, 2012. The Federal Certification Tag information relating to front and rear tires is incorrect. Due to the inaccurate label, these vehicles fail to comply with the requirements of Part 567, "Certification."

Consequence: Owners relying on the information provided on the label may incorrectly inflate their tires, which could contribute to a tire failure that could cause a crash.

Remedy: Fleetwood RV will mail new federal certification tags to owners. Owners who are not comfortable installing these labels may have them replaced at a dealer, free of charge. The safety recall began on January 31, 2013. Owners may contact Fleetwood RV Owner Relations at 1-800-509-3418.

Reported: 2013-05-10 (May 10, 2013) · Model years: 2013, 2014

Fleetwood RV, Inc. is recalling certain model year 2013 Jamboree Sport Diesel, Providence, Tioga DSL and Tioga Ranger DSL; 2014 Excursion, Expedition, Jamboree Sport, Montara Commercial, Searcher Commercial, Southwind, Storm, Terra, and Tioga Ranger; and 2013-2014 Bounder, Bounder Classic, and Discovery recreational vehicles. The vehicles are equipped with Weatherpro and 9100 series power awnings. Due to a design change in the power awning motor assembly, the motor assembly screws may unknowingly shear.

Consequence: If the motor assembly screws shear, it is possible that the awning can unfurl unexpectedly, either while the vehicle is at rest or while in transit, increasing the risk of personal injury or a vehicle crash.

Remedy: Fleetwood RV will notify owners and Dometic staff will replace the affected motors with motors of a different design. The recall began during June 2013. Owners may contact Fleetwood RV Owner Relations at 1-800-509-3418 or Dometic at 1-888-447-0003 for more information. Owners are being instructed not to drive their vehicle until repairs can be performed.

Reported: 2013-05-23 (May 23, 2013) · Model years: 2013

Fleetwood RV is recalling certain model year 2013 Bounder Classic and Terra motorhomes manufactured between July 9, 2012 and January 16, 2013. The tire load index letter printed on the Federal Certification Tag is incorrect. Due to the inaccurate label, these vehicles fail to comply with the requirements of Part 567, "Certification."

Consequence: The vehicle may be inadvertently fitted with incorrect replacement tires, which could lead tire failure, increasing the risk of a crash.

Remedy: Fleetwood will mail the corrected tags to dealers and owners. Owners who are not comfortable installing these labels may get them installed at a dealer, free of charge. The recall began on June 20, 2013. Owners may contact Fleetwood Owner Relations at 1-800-509-3418. Fleetwood's recall number is 130417FRV.

Reported: 2013-11-20 (November 20, 2013) · Model years: 2014

Fleetwood RV, Inc. (Fleetwood) is recalling certain model year 2014 model American Eagle, American Heritage, American Revolution, American Tradition, Bounder, Bounder Classic, Discovery, Excursion, Expedition, Providence, South Wind, Storm, Terra, Terra SE, Jamboree Searcher, Jamboree Sport, Tioga Montara, and Tioga Ranger recreational vehicles equipped with IMMI-brand L9 seat belt assemblies. When the button is pressed to release the seat belt, the latch plate can become partially engaged with the buckle, making the seat belt difficult to unlatch. Thus, these vehicles fail to conform to the requirements of Federal Motor Vehicle Safety Standard (FMVSS) No. 209, "Seat Belt Assemblies."

Consequence: If the latch plate remains partially engaged after the button is pressed, egress from the vehicle could be hindered which would increase the risk of injury in the event of an emergency.

Remedy: Fleetwood will notify owners and dealers will inspect and replace the seat belt buckle, as necessary, free of charge. The recall began on January 17, 2014. Owners may contact Fleetwood at 1-800-322-8216. Fleetwood's recall number 131112FRV.

Reported: 2014-11-17 (November 17, 2014) · Model years: 2014, 2015

Allied Recreational Group, Inc. (ARG) is recalling certain model year 2014-2015 Fleetwood Bounder Classic recreational vehicles manufactured April 10, 2013, to August 7, 2014. Due to insufficient structural reinforcement at the installation area, a grab bar can be pulled loose in the affected vehicles.

Consequence: If the grab bar is pulled loose during use, it could increase the risk of personal injury.

Remedy: ARG will notify owners, and dealers will remove and reinstall the grab bar onto a reinforcement steel plate, free of charge. The recall began on December 29, 2014. Owners may contact ARG customer service at 1-800-509-3417. ARG's number for this recall is 141107ARG.

Reported: 2017-03-03 (March 3, 2017) · Model years: 2015

REV Recreation Group (REV) is recalling certain 2015 Fleetwood Bounder Classic motorhomes, 2015-2016 Fleetwood Terra motorhomes, 2016-2017 Fleetwood Storm, Holiday Rambler Admiral XE and Fleetwood Flair motorhomes, and 2017 Holiday Rambler Vacationer XE motorhomes. The affected vehicles, equipped with an Onan 5.5 Kilowatt Generator, have an external fuel pump and in-line fuel filter that may be improperly secured to the chassis.

Consequence: If the fuel pump or filter detach or become loose, a fuel leak may result, which in the presence of an ignition source, can increase the risk of a fire or explosion.

Remedy: REV will notify owners, and dealers will inspect the mounting of the generator's external fuel pump and in-line fuel filter, securing them as necessary, free of charge. The recall began on April 28, 2017. Owners may contact REV customer service at 1-800-509-3417. REVs number for the recall is 170301REV.