E-One TYPHOON recalls by model year

Reported: 2006-05-19 (May 19, 2006) · Model years: 2005, 2006

ON CERTAIN EMERGENCY VEHICLES EQUIPPED WITH CUMMINS ISL CM850 DIESEL ENGINES, THE CONNECTING RODS WHICH TRANSFER ENERGY FROM THE PISTON TO THE CRANKSHAFT ARE DEFECTIVE AND CAN RESULT IN SEIZURE OF THE PISTON PIN. A PISTON PIN SEIZURE CAN RESULT IN A MISSION-DISABLING ENGINE FAILURE.

Consequence: THIS CONDITION COULD ULTIMATELY RESULT IN A LOSS OF VEHICLE POWER (ENGINE STALL) INCREASING THE RISK OF A CRASH.

Remedy: DEALERS ARE WORKING WITH CUMMINS TO REPLACE THE CONNECTING RODS FREE OF CHARGE. OWNERS MAY CONTACT E-ONE AT 352-237-1122 OR CUMMINS AT 1-800-DIESELS.

Reported: 2018-01-09 (January 9, 2018) · Model years: 2005, 2006, 2007, 2008, 2009, 2010

E-One Incorporated (E-One) is recalling certain 2005-2010 E-One Typhoon, Cyclone II, X-036, Cyclone III, SPGL, SPBE, FLM2, F550, I440, and I740 emergency vehicles, equipped with an IOTA 50 Amp transfer switch. Electrical connections at the transfer switch may loosen and cause excessive heat.

Consequence: The excessive heat can increase the risk of a fire.

Remedy: E-One will notify owners, and dealers will replace the IOTA transfer switch with a Powermax switch, free of charge. The recall began on February 19, 2018. Owners may contact E-One customer service at 1-352-861-3612.

Reported: 2011-12-01 (December 1, 2011) · Model years: 2008, 2009, 2010, 2011

E-ONE IS RECALLING CERTAIN MODEL YEAR 2008 THROUGH 2011 CYCLONE II, TYPHOON, AND QUEST VEHICLES MANUFACTURED FROM MAY 1, 2008, THROUGH NOVEMBER 28, 2011, AND EQUIPPED WITH MERITOR WABCO ELECTRONIC STABILITY CONTROL (ESC) MODULES. UNDER CERTAIN ROAD AND DRIVING CONDITIONS, VEHICLE BODY ROLL AND ROAD INCLINATION CHARACTERISTICS MAY ADVERSELY AFFECT THE SLIP ANGLE CALCULATION OF THE ELECTRONIC STABILITY CONTROL (ESC) SYSTEM. THIS MIGHT CAUSE THE ESC TO PERCEIVE AN OVER STEERING SITUATION AND THEREFORE APPLY THE OUTER WHEEL BRAKE ON THE FRONT AXLE UNTIL THE VEHICLE IS PERCEIVED TO BE STABLE.

Consequence: IF THE DRIVER IS SLOW TO REACT DURING THIS ESC INTERVENTION, THE VEHICLE MAY DEVIATE FROM THE INTENDED LINE OF TRAVEL, INCREASING THE RISK OF A CRASH.

Remedy: E-ONE WILL NOTIFY OWNERS AND IS WORKING WITH MERITOR WABCO TO REPLACE THE CONTROL MODULE FREE OF CHARGE. THE SAFETY RECALL BEGAN ON DECEMBER 16, 2011. OWNERS MAY CONTACT E-ONE CUSTOMER SERVICE AT 1-800-627-5050 OR MERITOR ON TRACK CUSTOMER SERVICE AT 1-866-668-7221.

Reported: 2018-03-15 (March 15, 2018) · Model years: 2008, 2009, 2010, 2011, 2012, 2013, 2014, 2015

E-One Incorporated (E-One) is recalling certain 2008-2015 E-One Typhoon, Cyclone II, and Quest II vehicles, equipped with Timoney Independent Front Suspensions. Inconsistent machining may result in fatigue cracks developing over time in the front axle spindles, causing failure of the spindle and the possible separation of a front wheel from the vehicle.

Consequence: A wheel separation from the vehicle can increase the risk of a crash.

Remedy: E-One will notify owners, and dealers will replace the front axle spindle, free of charge. The recall began on April 24, 2018. Owners may contact E-One customer service at 1-352-861-3612.

Reported: 2011-07-13 (July 13, 2011) · Model years: 2010, 2011

E-ONE IS RECALLING CERTAIN MODEL YEAR 2010 AND 2011 TYPHOON, CYCLONE II, AND TRADITION FIRE FIGHTING VEHICLES MANUFACTURED FROM JANUARY 1, 2010, THROUGH JULY 1, 2011, EQUIPPED WITH TRIMARK CAB DOOR MOUNT BRACKET PART NUMBERS 28141-01 AND 28142-01. IF THE MOUNTING FASTENERS ARE NOT AT PROPER TORQUE VALUE, THE OUTSIDE DOOR HANDLE MOUNT BRACKET MAY POTENTIALLY ROTATE OUT OF POSITION. THE DOOR SYSTEM MAY FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 206, "DOOR LOCKS AND DOOR RETENTION COMPONENTS."

Consequence: THE DOOR MAY NOT STAY CLOSED AND COULD OPEN WITHOUT WARNING DURING A CRASH. PERSONS OR OBJECTS COULD FALL FROM THE VEHICLE, POSSIBLY RESULTING IN INJURY.

Remedy: E-ONE IS WORKING WITH TRIMARK AND TRIMARK WILL NOTIFY VEHICLE OWNERS USING E-ONE LETTERHEAD. REPAIRS WILL BE MADE BY E-ONE SERVICE CENTERS OR BY TRIMARK PERSONNEL AS NEEDED. REPAIRS WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON JULY 22, 2011. OWNERS MAY CONTACT TRIMARK AT 1-641-394-1095 OR E-ONE AT 1-352-861-3223.

Reported: 2011-08-17 (August 17, 2011) · Model years: 2010, 2011

E-ONE IS RECALLING CERTAIN MODEL YEAR 2010 AND 2011 TYPHOON AND CYCLONE II AND MODEL YEAR 2011 TRADITION AND QUEST FIRE FIGHTING CHASSIS MANUFACTURED FROM NOVEMBER 24, 2010, THROUGH JULY 13, 2011, EQUIPPED WITH A CUMMINS ISB, ISL, ISC, or ISX DIESEL ENGINE. THE V-BAND CLAMP ASSEMBLY, PART NUMBERS Q187684, Q187685, AND Q187686, USED TO CONNECT THE INLET AND OUTLET CONE SECTIONS TO THE DIESEL OXIDATION CATALYST (DOC)/DIESEL PARTICULATE FILTER (DPF) INCLUDE A T-BOLT WHICH CAN FRACTURE AND FAIL WHEN SUBJECTED TO STRESS OR LOAD. A FRACTURE OR FAILURE OF THE T-BOLT MAY CAUSE THE CLAMP TO LOOSEN AND THE INLET OR OUTLET SECTIONS ATTACHED TO THE DOC/DPF HOUSING TO DISCONNECT.

Consequence: THIS COULD RESULT IN ASPHYXIATION OR CARBON MONOXIDE POISONING. THE HEAT BUILD UP FROM THE EXHAUST CAN ALSO RESULT IN A FIRE. IF BOTH CLAMPS FAIL, THERE IS A RISK IN SOME APPLICATIONS THAT THE DOC/DPF HOUSING MAY DETACH COMPLETELY, CREATING A ROAD HAZARD.

Remedy: E-ONE IS WORKING WITH CUMMINS TO IDENTIFY AND NOTIFY OWNERS OF THE RECALL CAMPAIGN. REPAIRS WILL BE PERFORMED BY AUTHORIZED CUMMINS DEALERS FREE OF CHARGE. THE SAFETY RECALL BEGAN ON OCTOBER 10, 2011. OWNERS MAY CONTACT CUMMINS AT 1-812-377-5000 OR E-ONE AT 1-352-861-3223.

Reported: 2018-10-22 (October 22, 2018) · Model years: 2012, 2013, 2014, 2015

E-One Incorporated (E-One) is recalling certain 2012-2015 E-One Cyclone II, Cyclone III and Typhoon emergency vehicles. High current load in the HVAC system can cause one of the relays to melt.

Consequence: A melting relay can increase the risk of a fire.

Remedy: E-One will notify owners, and dealers will install a new relay assembly, free of charge. The recall began January 10, 2019. Owners may contact E-One customer service at 1-352-861-3612.

Reported: 2013-11-29 (November 29, 2013) · Model years: 2013

E-One Incorporated (E-One) is recalling certain model year 2013 model Typhoon and Cyclone II fire fighting vehicles equipped with IMMI-brand L9 seat belt buckles. When the button is pressed to release the seat belt, the latch plate can become partially engaged with the buckle, making the seat belt difficult to unlatch. Thus, these vehicles fail to conform to the requirements of Federal Motor Vehicle Safety Standard (FMVSS) No. 209, "Seat Belt Assemblies."

Consequence: If the latch plate remains partially engaged after the button is pressed, egress from the vehicle could be hindered which would increase the risk of injury in the event of an emergency.

Remedy: E-One will notify owners and dealers will inspect the seat belt buckle, and if necessary, replace the seat belt buckles, free of charge. The recall is expected to begin on, or about, January 17, 2014. Customers may contact E-One at 1-800-627-5050.

Reported: 2014-04-18 (April 18, 2014) · Model years: 2013, 2014

E-One Incorporated (E-One) is recalling certain model year 2013-2014 Emergency One Typhoon, Cyclone II, and Quest Fire Fighting Chassis manufactured March 19, 2013, through April 15, 2014, and equipped with Vehicle Input Module (VIM) part number 508875. The VIM, used to supply programming inputs that monitor and control some vehicle functions such as lights, warning indicators and some interlock functions of the vehicle electrical system, has software that may experience a defect that affects the operation of the brake lights and other electrical operations of the vehicle.

Consequence: The VIM software may cause the vehicle's brake lights to be illuminated even when the vehicle is not braking and may prevent the vehicle's ability to raise its idle when auxilliary equipment is being used. If the brake lights are illuminated while the vehicle is moving it could make other motorists think the vehicle is stopping/slowing down and increase the risk of a vehicle crash. If the vehicle cannot raise its idle when auxilliary equipment is being used, equipment such as aerial devices, electrical generators and rescue tools may have reduced performance.

Remedy: E-One will notify owners, and dealers will update the VIM software, free of charge. The recall began on June 12, 2014. Owners may contract E-One customer service at 1-800-627-5050.

Reported: 2015-09-24 (September 24, 2015) · Model years: 2013, 2014

E-One Incorporated (E-One) is recalling certain model year 2013-2014 Typhoon, Cyclone II, and Quest emergency vehicles manufactured August 2, 2013, to December 16, 2014. The affected vehicles have front independent suspension assemblies that may have loose ball joints which could separate causing a loss of steering control.

Consequence: A loss of steering control increases the risk of a crash.

Remedy: E-One will notify owners, and dealers will inspect and repair the suspension assemblies, as necessary, free of charge. The recall began on October 9, 2015. Owners may contact E-One customer service at 1-800-627-5050.

Reported: 2017-04-05 (April 5, 2017) · Model years: 2013, 2014, 2015, 2016

E-One Incorporated (E-One) is recalling certain 2013-2016 Typhoon and Cyclone II and 2014-2016 Quest emergency vehicles. The ball joints on the independent front suspension (IFS) modules can loosen and separate, leading to a partial loss of steering.

Consequence: A separated ball joint can cause a loss of steering control, increasing the risk of a crash.

Remedy: E-One will notify owners, and dealers will inspect, clean and secure the ball joint, free of charge. The recall began on May 5, 2017. Owners may contact E-One customer service at 1-800-627-5050.

Reported: 2017-11-20 (November 20, 2017) · Model years: 2013, 2014, 2015, 2016, 2017

E-One Incorporated (E-One) is recalling certain 2013-2017 E-One Cyclone II, Quest, Typhoon, 2016 Freightliner M2 112, 2013-2015 International 7400, 2014-2017 International 4400, Freightliner M2 106, 2016-2017 Kenworth T370, and 2015 Kenworth T800 vehicles equipped with Hale pressure relief valves in the water pumps used for fire fighting. Rings securing the valves may corrode over time after exposure to water, causing the ring to fail and the pressure relief valve to open, reducing the water pressure available for fire fighting.

Consequence: A reduction in water pressure may hinder fire fighting efforts, increasing the risk of injury.

Remedy: E-One will notify owners, and a certified dealer or technician will install a stainless steel retaining ring, free of charge. The recall began on January 11, 2018. Owners may contact E-One customer service at 1-352-861-3612.

Reported: 2018-01-09 (January 9, 2018) · Model years: 2013, 2014, 2015, 2016, 2017

E-One Incorporated (E-One) is recalling certain 2013-2017 Cyclone II, Typhoon, and Quest II emergency vehicles equipped with a Cummins ISL, L9, ISX15, or X15 engine. The affected engines do not have a diode in the starter solenoid circuit to improve the longevity of the lock-out relay, resulting in accumulated damage over time.

Consequence: The damaged starter lock-out relay may prevent the vehicle from starting, hindering personnel from responding to emergencies.

Remedy: E-One will notify owners, and dealers will install a diode in the starter solenoid circuit and install a new starter lock-out relay, free of charge. The recall began on February 19, 2018. Owners may contact E-One customer service at 1-352-861-3612.

Reported: 2019-08-14 (August 14, 2019) · Model years: 2013, 2014, 2016, 2017, 2018, 2019

E-One Incorporated (E-One) is recalling certain 2014-2019 Cyclone II, 2013-2014 and 2016-2019 Typhoon, 2015-2017 Quest fire trucks. The front shocks may separate from their upper mount on the front suspension. The loose shock may contact and damage the steering gear housing, possibly causing a steering fluid leak and a loss of power steering assist.

Consequence: A loss of hydraulic steering assist can increase the risk of a crash.

Remedy: E-One has notified owners, and dealers will install a new shock mount bolt and nut, hardened washer, and shims to keep the shocks secured, free of charge. The recall began August 28, 2019. Owners may contact E-One customer service at 1-352-861-3612.

Reported: 2019-10-14 (October 14, 2019) · Model years: 2013, 2014, 2015, 2016, 2017, 2018, 2019

E-One Incorporated (E-One) is recalling certain 2013-2019 Typhoon and Cyclone 2, 2013-2014 Cyclone 3, 2014-2019 Quest 2 and 2017 CHSH emergency vehicles equipped with a Cummins ISL, L9, ISX12, X12, ISX15, or X15 engine. The engines do not have a diode in the starter solenoid circuit to improve the longevity of the lock-out relay, resulting in accumulated damage over time.

Consequence: The damaged starter lock-out relay may prevent the vehicle from starting, hindering personnel from responding to emergencies, increasing the risk of an injury.

Remedy: E-One will notify owners, and dealers will install a diode in the starter solenoid circuit and install a new starter lock-out relay, free of charge. The recall began November 15, 2019. Owners may contact E-One customer service at 1-352-861-3612. Note: Vehicles previously repaired under recall 18V-019 also need this recall remedy.

Reported: 2015-10-13 (October 13, 2015) · Model years: 2014, 2015

E-One Incorporated (E-One) is recalling certain model year 2014-2015 Typhoon, Cyclone II, and Quest emergency vehicles manufactured October 28, 2014, to August 29, 2015. The affected vehicles may have left the production facility with a harness for the front air bag system disconnected.

Consequence: If the air bag harness is not connected to the air bag control system, the front air bag will not deploy in the event of a crash, increasing the risk of injury.

Remedy: E-One will notify owners, and dealers will inspect the air bag harness, connecting it as necessary, and test the system for proper operation, free of charge. All affected vehicles have been repaired. Therefore an owner notification letter will not be issued for this recall campaign. The recall is expected to begin during November 2015. Owners may contact E-One customer service at 1-800-627-5050.

Reported: 2016-06-16 (June 16, 2016) · Model years: 2014, 2015, 2016

E-One Incorporated (E-One) is recalling certain model year 2014-2016 E-One Cyclone II and Typhoon vehicles manufactured January 1, 2014, to May 31, 2016, equipped with certain Class 1 Es-Key power control modules manufactured by Hale Products. The affected power control modules may not provide sufficient circuit protection depending on their combination of software and installation, possibly resulting in a short circuit.

Consequence: A short circuit may result in damage to components of the vehicle's electrical system, affecting their function such as causing a loss of headlights, increasing the risk of a crash. A short circuit may also increase the risk of a fire.

Remedy: E-One will notify owners, and dealers will upgrade the software or retrofit fuses, free of charge. The recall began on July 25, 2016. Owners may contact E-One customer service at 1-904-237-1122, or Hale customer service at 1-800-533-3569.

Reported: 2016-11-03 (November 3, 2016) · Model years: 2014, 2015, 2016

E-One Incorporated (E-One) is recalling certain model year 2014-2016 Typhoon, Quest, and Cyclone fire trucks manufactured January 1, 2014, to October 11, 2016, and equipped with aerial ladders. Due to a design change, the filter for the aerial ladder may leak hydraulic fluid.

Consequence: A hydraulic fluid leak can cause a loss of aerial device function, increasing the risk of injury.

Remedy: E-One will notify owners, and dealers will inspect and replace the filter and head assembly, as necessary, free of charge. The recall began on November 29, 2016. Owners may contact E-One customer service at 1-800-627-5050.

Reported: 2016-05-12 (May 12, 2016) · Model years: 2015, 2016

E-One Incorporated (E-One) is recalling certain model year 2015-2016 Cyclone II, Quest II and Typhoon emergency vehicles manufactured May 1, 2015, to March 31, 2016, equipped with pumps to provide pressurized water to aid in fighting fires. These pumps have 6" intake strainers that may have been improperly soldered during production and, as a result, the strainers may come apart during use, allowing parts of the strainer and debris to enter the pump, possibly damaging the pump.

Consequence: If the strainer and/or debris enters the pump, and the operator is forced to shut down the pump, reducing firefighting effectiveness, there could be an increased risk of injury.

Remedy: E-One will notify owners to check the strainer for missing solder at the joints. Any strainers missing solder will be replaced, free of charge. The recall began on June 6, 2016. Owners may contact E-One customer service at 1-352-861-3612 or Hale customer service at 1-800-533-3569.

Reported: 2016-08-01 (August 1, 2016) · Model years: 2015, 2016

E-One Incorporated (E-One) is recalling certain model year 2015-2016 Cyclone II vehicles manufactured July 31, 2015, to June 12, 2016, 2015-2016 Typhoon vehicles manufactured September 21, 2015, to July 27, 2016, 2015 Freightliner M2 vehicles manufactured November 3, 2015, and 2015 International 7400 vehicles manufactured November 3, 2015. The affected vehicles may be equipped with certain C20 and C21 split-shaft transmissions from Waterous. This transmission sends power to the wheels of an emergency response vehicle or powers an add-on unit such as a water pump used for fighting fires. A component within the shift unit may be damaged and as a result, the operator may not be able to switch the power output.

Consequence: If the power output cannot be changed, once the fire truck arrives at the scene, it may not be able to pump water to aid in extinguishing the fire, increasing the risk of injury.

Remedy: E-One will notify owners and will supply a remedy kit that replaces the clevis pin and retaining rings, free of charge. The recall began on September 8, 2016. Owners may contact E-One customer service at 1-352-861-3612.

Reported: 2016-08-03 (August 3, 2016) · Model years: 2015

E-One Incorporated (E-One) is recalling one model year 2015 Typhoon emergency vehicle manufactured March 16, 2015, to October 30, 2015, equipped with a Class 1 Ultraview Touchscreen manufactured by Hale Products. The touchscreen may experience false switch activations that can happen without the operator's knowledge causing accessories to turn on or off.

Consequence: Uintended turning on or off of any or multiple accessories such as emergency beacons or automatic snow chains can increase the risk of a crash.

Remedy: E-One has notified the owner and updated touchscreen software has been installed, free of charge. The recall began on August 4, 2016. Owners may contact E-One customer service at 1-904-237-1122.

Reported: 2017-10-09 (October 9, 2017) · Model years: 2016, 2017

E-One Incorporated (E-One) is recalling certain 2016-2017 Quest, Cyclone II, and Typhoon emergency vehicles. The power steering assist cylinder may not have been properly tightened to the steering arm.

Consequence: If the steering assist cylinder detaches there would be a loss of power steering assist, increasing the risk of a crash.

Remedy: E-One will notify owners, and dealers will inspect and retighten the steering assist cylinder mounting bolts, free of charge. The recall began on November 27, 2017. Owners may contact E-One customer service at 1-352-861-3612.

Reported: 2018-10-22 (October 22, 2018) · Model years: 2016, 2017, 2018

E-One Incorporated (E-One) is recalling certain 2016-2018 E-One Cyclone II and Typhoon aerial devices. The torque rod tower may crack causing failure of the tower, possibly affecting vehicle handling.

Consequence: If the torque rod tower fails and affects vehicle handling, it can increase the risk of a crash.

Remedy: E-One will notify owners, and direct owners to contact the manufacturer of the Atlas suspension for replacement parts, free of charge. The recall began January 10, 2019. Owners may contact E-One customer service at 1-352-861-3612.

Reported: 2018-09-11 (September 11, 2018) · Model years: 2017, 2018, 2019

E-One Incorporated (E-One) is recalling certain 2017-2019 Cyclone II, Typhoon and Quest II emergency vehicles, equipped with Whelen accessory brake lights. Depending on the specific wiring of the vehicle, these brake lights may illuminate when the brake pedal has not been pressed. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 108, "Lamps, Reflective Devices, and Associated Equipment."

Consequence: If the brake lights incorrectly illuminate, it can confuse other drivers, possibly increasing the risk of a crash.

Remedy: E-One will notify owners, and dealers will replace the brake lights, free of charge. The recall began October 26, 2018. Owners may contact E-One customer service at 1-352-861-3612.

Reported: 2021-05-11 (May 11, 2021) · Model years: 2017, 2018, 2019, 2020, 2021

E-One Incorporated (E-One) is recalling certain 2017-2021 Cyclone 2, Cyclone N, Quest 2, Typhoon, and Typhoon N vehicles. The sealing washer may not seat correctly in the pilot bore holes, allowing the high pressure fuel rail assembly to leak.

Consequence: A fuel leak in the presence of an ignition source increases the risk of a fire.

Remedy: Dealers will inspect and replace the rail as necessary, free of charge. Owner notification letters were mailed out on May 28, 2021. Owners may contact E-One customer service at 1-352-237-1122.

Reported: 2019-09-10 (September 10, 2019) · Model years: 2018

E-One Incorporated (E-One) is recalling one 2018 Typhoon emergency vehicle equipped with a Hale SmartFoam 6.5 foam pump system with a 12 volt power supply. The foam pump system can overheat and fail, causing fire fighting foam chemical to be unavailable to fight a fire.

Consequence: If the fire fighting foam chemical injection is unavailable, it can impact the fire fighting and/or vapor mitigation efforts, which increases the risk of injury to bystanders and emergency personnel.

Remedy: E-One will notify owners, and a Hale dealer will replace the SmartFoam 6.5 12 volt system with SmartFoam 6.5 24 volt system and a voltage converter, free of charge. The recall began October 15, 2019. Owners may contact E-One customer service at 1-352-861-3612 or Hale at 1-800-533-3569.

Reported: 2020-09-09 (September 9, 2020) · Model years: 2018, 2019, 2020

E-One Incorporated (E-One) is recalling certain 2018-2020 Cyclone 2 and Typhoon ambulances. The lower shock mount bracket may cause the U-bolts to bind and break, possibly preventing the rear axle from remaining secured.

Consequence: The unsecured rear axle may shift sideways, resulting in loss of control of the vehicle, thereby increasing the risk of crash.

Remedy: E-One has notified owners, and dealers replace any of the affected lower shock mount brackets, free of charge. The recall began September 21, 2020. Owners may contact E-One customer service at 1-888-237-1751.

Reported: 2019-08-13 (August 13, 2019) · Model years: 2019

E-One Incorporated (E-One) is recalling certain 2019 Typhoon and Cyclone II fire trucks. Due to improper manufacturing, the cushion of the Inflatable Head Cushion (IHC) and Knee Air Bag (KAB) may detach during a deployment event and not inflate.

Consequence: In the event of a crash, if the cushions do not inflate properly, they may not provide the intended protection to the occupant, increasing the risk of injury.

Remedy: E-One will notify owners, and dealers will replace the air bags, free of charge. The recall began November 12, 2019. Owners may contact E-One customer service at 1-352-861-3612.

Reported: 2020-12-04 (December 4, 2020) · Model years: 2020

E-One Incorporated (E-One) is recalling certain 2020-2021 Commercial, 2019-2020 Cyclone 2 and 2020 Cyclone N, Quest 2, Typhoon and Typhoon N vehicles, equipped with Weldon V-Mux Vista IV Standard LCD displays used for controlling emergency vehicle lighting and HVAC functions. These displays may experience low voltage spikes, causing the LCD display to lock up or become nonfunctional.

Consequence: A locked up or non-functional LCD display can delay emergency efforts, increasing the risk of injury.

Remedy: E-One will notify owners, and dealers will replace the display or apply a retrofit remedy, free of charge. E-One issued owners an interim notification on December 15, 2020. The recall began January 26, 2021. Owners may contact E-One customer service at 1-352-237-1122.

Reported: 2021-02-19 (February 19, 2021) · Model years: 2020

E-One Incorporated (E-One) is recalling certain 2020 Cyclone 2, Typhoon, and Typhoon N vehicles. The steering gear mounting bolts may become loose and back out, resulting in difficulty steering.

Consequence: Difficulty steering, or the inability to steer in both directions, can increase the risk of a crash.

Remedy: E-One will notify owners, and dealers will replace the steering gear mounting bolts and washers, free of charge. The recall is expected to begin March 2021. Owners may contact E-One customer service at 1-352-237-1122.

Reported: 2021-12-09 (December 9, 2021) · Model years: 2020

E-One Incorporated (E-One) is recalling certain 2019-2021 Cyclone 2, Quest 2, 2020-2021 Typhoon N, 2020 Typhoon, and 2021 Cyclone N vehicles. The fuel tubes between the fuel rail and the injectors for cylinders four, five, and six may fatigue and crack, which can result in a high pressure fuel leak.

Consequence: A high pressure fuel leak in the presence of an ignition source can increase the risk of a fire.

Remedy: Dealers will replace the fuel tubes and install vibration isolators, free of charge. Owner notification letters were mailed February 14, 2022. Owners may contact E-One customer service at 1-352-237-1122.

Reported: 2022-07-26 (July 26, 2022) · Model years: 2020, 2021

E-One Incorporated (E-One) is recalling certain 2019-2021 Cyclone 2, 2020 Commercial, Quest 2, 2020-2021 Typhoon, 2021 Cyclone N, and 2020-2022 Typhoon N fire trucks. The neutral screw connection within the QO Plug-On Neutral Load Center may be loose. If that connection is loose, the affected load center can overheat.

Consequence: An overheated load center can increase the risk of a fire.

Remedy: Dealers will inspect and repair, or replace the load center, free of charge. Owner notification letters were mailed October 24, 2022. Owners may contact E-One's customer service at 1-352-237-1122.

Reported: 2021-11-19 (November 19, 2021) · Model years: 2021

E-One Incorporated (E-One) is recalling certain 2022 Cyclone 2, Cyclone N, Typhoon, and Typhoon N vehicles. The rear axle drive pinion may fracture.

Consequence: A fractured drive pinion may contact the brake drop hose and unintentionally engage the parking brake, increasing the risk of a crash.

Remedy: Meritor will inspect and replace the drive pinion, as necessary, free of charge. Owner notification letters were mailed on January 05, 2022. Owners may contact E-One customer service at 1-352-237-1122.

Reported: 2024-01-08 (January 8, 2024) · Model years: 2022

E-One Incorporated (E-One) is recalling certain 2021-2023 ARFF, Cyclone N, 2020-2024 Commercial, 2020, 2022-2023 Cyclone 2, 2023 Cyclone E, 2022 Typhoon, and 2020-2023 Typhoon N vehicles. In the event of a short circuit or wiring failure, the firmware in the vehicle multiplex system may fail to shut off the output pin, resulting in overloaded electrical circuits.

Consequence: Overloaded electrical circuits can overheat, increasing the risk of fire.

Remedy: The equipment manufacturer, Weldon, will update the firmware, free of charge. Owner notification letters were mailed January 24, 2024. Owners may contact E-One customer service at 1-352-237-1122.

Reported: 2024-03-12 (March 12, 2024) · Model years: 2024

E-One Incorporated (E-One) is recalling certain 2024 Commercial, Cyclone N, Typhoon N, and Typhoon EV vehicles equipped with Hercules HC 1.7 multiplex nodes. In the event of a short circuit or wiring failure, the firmware in the node may fail to shut off the output pin, resulting in overloaded electrical circuits.

Consequence: Overloaded electrical circuits can overheat, increasing the risk of fire.

Remedy: Weldon will update the firmware, free of charge. Owner notification letters were mailed April 5, 2024. Owners may contact E-One customer service at 1-352-237-1122.