Dodge DAKOTA recalls by model year

Reported: 1986-08-18 (August 18, 1986) · Model years: 1987

THESE TRUCKS WERE EQUIPPED WITH REAR PARK BRAKE CABLES WHICH CAUSED LIMITED REAR BRAKE SHOE TRAVEL RESULTING IN THE PARKING BRAKE SYSTEM NOT HOLDING THE VEHICLE IN THE REVERSE DIRECTION WHEN PARKED ON A 20% GRADE, AS REQUIRED BY FMVSS 105. CONSEQUENCE OF DEFECT: IF THE TRUCK IS PARKED ON AN INCLINE AND THE PARKING BRAKE SET, IT MAY ROLL BACK CAUSING DAMAGE OR AN ACCIDENT.

Remedy: REPLACE BOTH REAR PARKING BRAKE CABLES.

Reported: 1987-04-14 (April 14, 1987) · Model years: 1987

SPEED CONTROL SYSTEM CABLES MAY PARTIALLY DISENGAGE AND BIND AT THE CARBURETOR THROTTLE LEVER ATTACHMENT.

Consequence: THROTTLE WOULD STAY PARTIALLY OPEN WHEN ACCELERATORPEDAL IS RELEASED.

Remedy: INSTALL A WASHER AT SPEED CONTROL CABLE TO CARBURETOR THROTTLE LEVER ATTACHMENT TO ELIMINATE POTENTIAL FOR THIS CONDITION.

Reported: 1987-12-26 (December 26, 1987) · Model years: 1988

AUTOMATIC TRANSMISSION MAY CONTAIN A PARK SPRAG ROD ASSEMBLY THAT MAY STICK IN THE TOOTH BUTT UNENGAGED POSITION.

Consequence: THIS CONDITION COULD ALLOW THE VEHICLE TO ROLL WITH THEGEAR SHIFT LEVER IN PARK POSITION.

Remedy: ALL INVOLVED VEHICLES WILL HAVE THE PARK SPRAG ROD ASSEMBLIES REPLACED.

Reported: 1988-05-04 (May 4, 1988) · Model years: 1988

MACHINING ERROR IN LOCATING WHEEL STUD HOLES MAY PREVENT FULL SEATING OF BRAKE DRUM TO SHAFT FLANGE.

Consequence: WHEEL STUDS COULD LOOSEN, ALLOWING WHEEL TO SEPARATEFROM THE TRUCK.

Remedy: REPLACE AXLE SHAFTS AS NECESSARY.

Reported: 1996-06-13 (June 13, 1996) · Model years: 1988, 1989, 1990

THE FRAME CAN CRACK AT THE STEERING GEAR ATTACHMENT AND/OR THE STEERING GEAR MOUNTING BOLTS CAN FRACTURE.

Consequence: THE STEERING GEAR CAN SEPARATE FROM THE VEHICLE FRAME RESULTING IN A LOSS OF VEHICLE CONTROL INCREASING THE POTENTIAL FOR A VEHICLE ACCIDENT.

Remedy: DEALERS WILL ADD REINFORCEMENTS TO THE FRAME AND REPLACE THE STEERING GEAR MOUNTING BOLTS. IF THE FRAME IS ALREADY CRACKED, THE STEERING GEAR WELD NUTS WILL ALSO BE REPLACED.

Reported: 2001-07-06 (July 6, 2001) · Model years: 1989, 1990

VEHICLE DESCRIPTION: 4X2 PICKUP TRUCK CONVERTIBLES EQUIPPED WITH V6 ENGINES (BUILT FROM NOVEMBER 1988 - JUNE 1990) AND 4X2 PICKUP TRUCKS EQUIPPED WITH THE SHELBY PACKAGE (BUILT OCTOBER 1988 - JUNE 1989). THE FRAME CAN CRACK AT THE STEERING GEAR ATTACHMENT AND/OR THE STEERING GEAR MOUNTING BOLTS CAN FRACTURE.

Consequence: THE STEERING GEAR CAN SEPARATE FROM THE VEHICLE FRAME RESULTING IN A LOSS OF VEHICLE CONTROL INCREASING THE POTENTIAL FOR A VEHICLE ACCIDENT.

Remedy: DEALERS WILL ADD REINFORCEMENTS TO THE FRAME AND REPLACE THE STEERING GEAR MOUNTING BOLTS. IF THE FRAME IS ALREADY CRACKED, THE STEERING GEAR WELD NUTS WILL ALSO BE REPLACED. OWNER NOTIFICATION BEGAN AUGUST 27, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.

Reported: 1989-12-27 (December 27, 1989) · Model years: 1989, 1990

THE ENGINE VALVE COVER GASKET MAY DISLOCATE AND ALLOW AN ENGINE OIL LEAK AT THE GASKET.

Consequence: THE LEAKAGE OF OIL IN THE ENGINE COMPARTMENT COULD CAUSEA FIRE.

Remedy: REPLACE GASKET COVER WITH REVISED COVER, AND RTV SEALANT WILL BE APPLIED IN PLACE OF A GASKET.

Reported: 2000-04-11 (April 11, 2000) · Model years: 1991, 1992

VEHICLE DESCRIPTION: LIGHT DUTY PICKUP TRUCKS EQUIPPED WITH A500 AUTOMATIC TRANSMISSION. INADVERTENT PLACEMENT OF THE SHIFT LEVER IN REVERSE CAN OCCUR WHEN THE DRIVER BELIEVES THAT THE TRANSMISSION HAS BEEN PLACED IN PARK.

Consequence: THIS CAN CAUSE THE VEHICLE TO ROLL AWAY WITH THE ENGINE ON AFTER THE DRIVER HAS LEFT THE VEHICLE.

Remedy: DEALERS WILL REPLACE THE STEEL MANUAL VALVE IN THE TRANSMISSION WITH AN ALUMINUM VERSION.

Reported: 1990-10-01 (October 1, 1990) · Model years: 1991

STEEL BRAIDED FUEL HOSE ROUTING MAY ALLOW CONTACT BETWEEN THE HOSE AND TRANSMISSION WIRING HARNESS.

Consequence: THIS CONTACT COULD CAUSE HOSE DAMAGE AND FUEL LEAKAGETHAT, IN THE PRESENCE OF AN IGNITION SOURCE, COULD RESULT IN A FIRE.

Remedy: INSTALL A TIE STRAP TO SECURE THE TRANSMISSION WIRING AWAY FROM THE FUEL HOSE.

Reported: 1991-11-12 (November 12, 1991) · Model years: 1991

THE RIGHT FRONT BRAKE HOSE MAY RUB AGAINST THE TIRE DURING A FULL LOCK LEFT TURN, WHICH MAY EVENTUALLY CAUSE WEAR THROUGH OF THE BRAKE HOSE ON THE RIGHT FRONT SIDE.

Consequence: WEAR THROUGH OF THE RIGHT FRONT BRAKE HOSE WOULD CAUSEFLUID LOSS FROM HALF OF THE SPLIT BRAKE HYDRAULIC SYSTEM AND INCREASE STOPPINGDISTANCE WHICH COULD RESULT IN AN ACCIDENT.

Remedy: IF CLEARANCE BETWEEN THE BRAKE HOSE AND TIRE ON THE RIGHT FRONT IS INADEQUATE, REPLACE BRAKE HOSE WITH A MODIFIED VERSION TO ENSURE ADEQUATE CLEARANCE.

Reported: 1995-05-12 (May 12, 1995) · Model years: 1991

THE STEERING WHEEL ARMATURE STAMPING CAN CRACK DUE TO FATIGUE AND SEPARATE FROM THE CENTER HUB ATTACHMENT TO THE STEERING COLUMN.

Consequence: THIS CONDITION CAN CAUSE SEPARATION OF THE CENTER HUB ATTACHMENT TO THE STEERING COLUMN RESULTING IN A LOSS OF CONTROL AND AN ACCIDENT.

Remedy: DEALERS WILL INSPECT THE STEERING WHEEL FOR ARMATURE CRACKS AND REPLACE ANY WHEELS EXHIBITING CRACKS. ALL OTHER VEHICLES WILL HAVE A REINFORCEMENT PLATE INSTALLED TO PREVENT STEERING WHEEL SEPARATION IF CRACKING OCCURS.

Reported: 1993-05-11 (May 11, 1993) · Model years: 1993

SOME OF THE ABS EQUIPPED VEHICLES WERE BUILT WITH AN UNDERSIZED BRAKE RETURN CHECK VALVE. IN INCIDENTS WHERE HARD BRAKE PEDAL EFFORT IS APPLIED ON LOW FRICTION ROAD SURFACES, LIKE RAIN COVERED STREETS, THE VALVES MAY FAIL, CAUSING THE ABS TO BECOME INOPERATIVE. THIS CREATES EXCESS BRAKE PEDAL TRAVEL AND MAY CAUSE THE ABS WARNING LIGHT TO COME ON.

Consequence: LACK OF FRONT WHEEL ABS COULD CAUSE THE FRONT WHEELBRAKES TO LOCK, INCREASING STOPPING DISTANCE WHICH MAY RESULT IN AN ACCIDENT.

Remedy: REPLACE THE RETURN CHECK VALVE WITH THE CORRECT VALVE.

Reported: 1994-01-12 (January 12, 1994) · Model years: 1994

TWO FUEL TANK SUPPORT STRAP ATTACHING STUDS WERE NOT ADEQUATELY TIGHTENED, WHICH COULD CAUSE ONE OR BOTH OF THE STRAP(S) TO SEPARATE, MISLOCATING THE FUEL TANKS OR ALLOW COMPLETE SEPARATION OF THE FUEL TANK FROM THE VEHICLE.

Consequence: IN EITHER CASE FUEL TANK SUPPORT STRAP(S) FAILURE RESULTS IN FUEL LEAKAGE WHICH COULD RESULT IN A FIRE.

Remedy: THE FUEL TANK SUPPORT STRAP ATTACHING STUDS WILL BE PROPERLY TIGHTENED.

Reported: 1994-03-09 (March 9, 1994) · Model years: 1994

SOME UPPER CONTROL ARM ATTACHING BOLTS CAN FAIL DUE TO IMPROPER HEAT TREATMENT. THE BOLTS ARE TOO SOFT TO WITHSTAND THE STRESSES IN THE STEERING SYSTEM AND CAN BREAK.

Consequence: IF THE ATTACHING BOLTS OF THE UPPER CONTROL ARM BREAK, THE VEHICLE CAN EXPERIENCE LOSS OF STEERING CONTROL WHICH COULD RESULT IN AN ACCIDENT.

Remedy: REPLACE THE UPPER CONTROL ARM ATTACHING BOLTS.

Reported: 1995-05-12 (May 12, 1995) · Model years: 1994

WHILE MAKING A TURN, THE EXTRA KEYS ON A VEHICLE OPERATOR'S KEY RING CAN BECOME TEMPORARILY LODGED IN THE SCREW ACCESS HOLES IN THE BACK COVER OF THE STEERING WHEEL.

Consequence: THIS CONDITION CAN HAMPER THE STEERING WHEEL RETURN ORCAUSE THE IGNITION TO BE TURNED OFF, RESULTING IN LOSS OF VEHICLE CONTROL AND AN ACCIDENT.

Remedy: DEALERS WILL REPLACE THE STEERING WHEEL BACK COVER WITH A REDESIGNED COVER.

Reported: 1995-10-20 (October 20, 1995) · Model years: 1996

THE POWER BRAKE BOOSTER VACUUM HOSE COULD BE IMPROPERLY INSTALLED AND NOT CLAMPED TO THE BRAKE BOOSTER VACUUM NIPPLE.

Consequence: A DISCONNECTED VACUUM HOSE CAN CAUSE AN INCREASE IN ENGINE IDLE SPEED AND LOSS OF BRAKE POWER ASSIST DURING BRAKE APPLICATION WITHOUT PRIOR WARNING.

Remedy: DEALERS WILL INSPECT THE VEHICLES TO INSURE THAT THE BRAKE BOOSTER VACUUM HOSE CONNECTION IS FULLY SEATED AND CLAMPED TO THE VACUUM CHECK VALVE NIPPLE AT THE BRAKE BOOSTER.

Reported: 2000-07-17 (July 17, 2000) · Model years: 1997, 1998, 1999, 2000

VEHICLE DESCRIPTION: PICKUP TRUCKS BUILT WITH 2.5L ENGINES. SOME VEHICLES MAY HAVE BEEN BUILT WITH INADEQUATE CLEARANCE BETWEEN THE LEFT FRONT BRAKE TUBE AND THE POWER STEERING HOSE.

Consequence: A PUNCTURE OF THE LEFT FRONT BRAKE TUBE CAN RESULT IN A LOSS OF BRAKING FORCE AT THE FRONT WHEELS, INCREASING THE RISK OF A CRASH.

Remedy: DEALERS WILL INSPECT THE BRAKE TUBE AND POWER STEERING HOSE FOR WEAR. IF WEAR IS EVIDENT, THE BRAKE TUBE AND/OR POWER STEERING HOSE WILL BE REPLACED. A POWER STEERING STANDOFF BRACKET WILL BE INSTALLED ON ALL VEHICLES TO ENSURE THAT ADEQUATE CLEARANCE BETWEEN THE BRAKE TUBE AND POWER STEERING HOSE IS MAINTAINED.

Reported: 2000-07-17 (July 17, 2000) · Model years: 1997, 1998, 1999, 2000

VEHICLE DESCRIPTION: PICKUP TRUCKS. SOME VEHICLES MAY HAVE BEEN BUILT WITH INADEQUATE CLEARANCE BETWEEN THE REAR AXLE VENT HOSE AND THE BRAKE HOSE.

Consequence: A PUNCTURE IN THE REAR BRAKE HOSE WILL RESULT IN A LOSS OF BRAKING FORCE AT THE REAR WHEELS.

Remedy: DEALERS WILL INSPECT THE REAR BRAKE HOSE FOR EVIDENCE OF WEAR. WORN BRAKE HOSES WILL BE REPLACED. THE REAR VENT HOSE WILL BE SHORTENED BY 3 INCHES AND A CLIP WILL BE INSTALLED TO ASSURE CLEARANCE BETWEEN THE AXLE VENT LINE AND BRAKE HOSE IS MAINTAINED.

Reported: 2000-07-17 (July 17, 2000) · Model years: 1997

VEHICLE DESCRIPTION: PICKUP TRUCKS WITH A 131 INCH WHEELBASE. SOME OF THESE VEHICLES MAY HAVE BEEN BUILT WITH INADEQUATE CLEARANCE BETWEEN THE FUEL LINE AND THE CAB UNDERBODY.

Consequence: THIS CONTACT CAN RESULT IN WEAR, AND AFTER EXTENDED CONTACT, COULD CAUSE A PERFORATION IN THE FUEL LINE, RESULTING IN LEAKAGE. FUEL LEAKAGE IN THE PRESENCE OF AN IGNITION SOURCE COULD RESULT IN A FIRE.

Remedy: DEALERS WILL INSPECT THE VEHICLES FOR PROPER CLEARANCE. FUEL LINES THAT EXHIBIT INADEQUATE CLEARANCE WILL BE REPLACED WITH A REDESIGNED FUEL LINE THAT WILL ASSURE PROPER CLEARANCE.

Reported: 2001-05-08 (May 8, 2001) · Model years: 1997, 1998, 1999, 2000

VEHICLE DESCRIPTION: PICKUP TRUCKS. SOUND DEADENER MATERIAL INSIDE THE STEERING WHEEL COULD BECOME DETACHED FROM THE COVER AND HOUSING. NOTE: THE RAM PICKUP TRUCKS WERE BUILT AT THE WARREN ASSEMBLY PLANT ("S" IN THE 11TH VIN POSITION) FROM MAY 16, 2000 THROUGH OCTOBER 23, 2000; ST. LOUIS NORTH ASSEMBLY PLANT ("J" IN THE 11TH VIN POSITION) FROM MAY 19, 2000 THROUGH OCTOBER 23, 2000; LAGO ALBERTO ASSEMBLY PLANT ("M" IN THE 11TH VIN POSITION) FROM MAY 23, 2000 THROUGH OCTOBER 23, 2000; AND SALTILLO ASSEMBLY PLANT ("G" IN THE 11TH VIN POSITION) FROM MAY 23, 2000 THROUGH OCTOBER 23, 2000. IMPORTANT: VEHICLES THAT HAVE ALREADY HAD THE PROPER CLOCKSPRING INSTALLED, ACCORDING TO WARRANTY RECORDS, HAVE BEEN EXCLUDED FROM THIS RECALL. IN ADDITION, 1997-2000 MODEL YEAR VEHICLES THAT HAVE HAD A SUSPECT REPLACEMENT CLOCKSPRING INSTALLED, ACCORDING TO WARRANTY RECORDS, HAVE BEEN ADDED TO THIS RECALL.

Consequence: WHEN THIS OCCURS, THE MATERIAL COULD INTERFERE WITH THE CLOCKSPRING RIBBON AND CAUSE AN OPEN CIRCUIT. THE DRIVER AIR BAG SYSTEM WILL BECOME DISABLED, AND THE AIR BAG WARNING LAMP WILL ILLUMINATE ON THE INSTRUMENT PANEL.

Remedy: DEALERS WILL REPLACE THE CLOCKSPRING ASSEMBLY. OWNER NOTIFICATION BEGAN JUNE 18, 2001. ALSO SOME 1997-200 MODEL YEAR VEHICLES THAT, ACCORDING TO WARRANTY RECORDS, HAVE HAD A SUSPECT REPLACEMENT CLOCKSPRING INSTALLED, WILL ALSO BE INCLUDED IN THIS CAMPAIGN. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.

Reported: 1997-05-16 (May 16, 1997) · Model years: 1997

THE ELECTRICAL CIRCUIT DESIGN ALLOWS THE POTENTIAL FOR AN INADVERTENT AIR BAG DEPLOYMENT UPON VEHICLE IGNITION SHUT DOWN.

Consequence: UNEXPECTED AIR BAG DEPLOYMENT CAN RESULT IN OCCUPANT INJURY.

Remedy: DEALERS WILL REPLACE THE AIR BAG ELECTRONIC CONTROL MODULE WITH A NEWLY DESIGNED MODULE.

Reported: 1997-10-07 (October 7, 1997) · Model years: 1998

VEHICLE DESCRIPTION: LIGHT DUTY PICKUP TRUCKS (2 WHEEL DRIVE ONLY). THE FRONT BRAKE HOSES OR ANTI-LOCK BRAKE SYSTEM (ABS) SENSOR WIRE MAY BE ABRADED AT THE FRONT WHEELS BY CONTACT WITH A FRONT WHEELHOUSE SPLASH SHIELD.

Consequence: PROLONGED BRAKE HOSE CONTACT CAN CAUSE A PARTIAL LOSS OF THE BRAKING SYSTEM. PROLONGED ABS SENSOR WIRE CONTACT CAN CAUSE A LOSS OF ABS FUNCTION.

Remedy: DEALERS WILL TRIM THE FRONT WHEELHOUSE SPLASH SHIELDS AND THE BRAKE HOSES AND ABS SENSOR WIRES WILL BE INSPECTED. IF EVIDENCE OF ABRASION IS FOUND ON ANY HOSE OR ABS WIRE, THEY WILL BE REPLACED.

Reported: 1998-09-08 (September 8, 1998) · Model years: 1998

VEHICLE DESCRIPTION: LIGHT DUTY PICKUP TRUCKS. THESE VEHICLES MAY HAVE BEEN BUILT WITH BOLTS THAT WERE NOT PROPERLY HARDENED. THE BOLTS WERE USED TO ATTACH THE CAB AND THE CORE SUPPORT TO THE FRAME.

Consequence: THIS CONDITION CAN ALLOW THE CAB TO SEPARATE FROM THE FRAME INCREASING THE RISK OF A CRASH.

Remedy: DEALERS WILL REPLACE THESE BOLTS WITH PROPERLY HARDENED BOLTS.

Reported: 2001-04-11 (April 11, 2001) · Model years: 1999

VEHICLE DESCRIPTION: CERTAIN VAN, WAGON, PICKUP TRUCKS, PASSENGER AND SPORT UTILITY VEHICLES, FAIL TO COMPLY WITH REQUIREMENTS OF FMVSS NO. 209, "SEAT BELT ASSEMBLIES." THE FRONT SEAT BELT RETRACTOR MAY NOT COMPLY WITH THE REQUIREMENTS OF THE STANDARD.

Consequence: IF THE RETRACTOR DOES NOT WORK PROPERLY, IT WILL NOT ADEQUATELY PROTECT OCCUPANTS IN THE EVENT OF A CRASH.

Remedy: DEALERS WILL REPLACE THE SEAT BELT RETRACTOR. OWNER NOTIFICATION BEGAN AUGUST 20, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.

Reported: 2000-07-17 (July 17, 2000) · Model years: 2000

VEHICLE DESCRIPTION: PICKUP TRUCKS EQUIPPED WITH 4.7L ENGINE AND AUTOMATIC TRANSMISSIONS. THE AUTOMATIC TRANSMISSION MAY EXPEL FLUID FROM THE FILL TUBE DURING NORMAL TEMPERATURE OPERATION.

Consequence: THE TRANSMISSION FLUID COULD COME INTO CONTACT WITH THE HOT EXHAUST SYSTEM AND IGNITION OF THE TRANSMISSION FLUID COULD RESULT.

Remedy: DEALERS WILL SHORTEN THE VENT HOSE AND ASSURE ADEQUATE CLEARANCE.

Reported: 2004-12-21 (December 21, 2004) · Model years: 2000, 2001, 2002, 2003

ON CERTAIN SPORT UTILITY VEHICLES AND PICKUP TRUCKS EQUIPPED WITH FOUR-WHEEL DRIVE (4X4), IF MOISTURE LEAKS INTO THE FRONT SUSPENSION UPPER BALL JOINT, EVACUATION OF THE LUBRICANT AND CORROSION OF THE JOINT MAY CAUSE THE JOINT TO WEAR OVER AN EXTENDED PERIOD OF TIME. THIS COULD CAUSE A CLUNKING NOISE IN THE FRONT SUSPENSION, WHICH MAY NOT ALWAYS BE HEARD BY THE VEHICLE OCCUPANTS.

Consequence: EXCESSIVE WEAR IN THE UPPER BALL JOINT MAY ALLOW IT TO SEPARATE, WHICH COULD RESULT IN LOSS OF CONTROL OF THE VEHICLE.

Remedy: DEALERS WILL REPLACE THE FRONT SUSPENSION UPPER BALL JOINTS. THIS SAFETY IMPROVEMENT CAMPAIGN BEGAN ON DECEMBER 21, 2004. OWNERS CAN CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.

Reported: 2000-11-09 (November 9, 2000) · Model years: 2001

VEHICLE DESCRIPTION: CERTAIN PASSENGER VEHICLES, PICKUP TRUCKS AND SPORT UTILITY VEHICLES FAIL TO COMPLY WITH THE REQUIREMENTS OF FMVSS NO. 225, "CHILD RESTRAINT ANCHORAGE SYSTEMS." SOME OF THE OWNER'S MANUALS FOR THESE VEHICLES ARE MISSING INSTRUCTIONS THAT PROVIDE A STEP-BY-STEP PROCEDURE, INCLUDING DIAGRAMS, FOR PROPERLY ATTACHING A CHILD RESTRAINT SYSTEM'S TETHER STRAP TO THE TETHER ANCHORAGE.

Consequence: IN THE EVENT OF A CRASH, THE CHILD SEAT MAY NOT BE PROPERLY ATTACHED INCREASING THE RISK OF INJURY TO THE CHILD.

Remedy: OWNERS WILL BE PROVIDED WITH AN ADDENDUM TO THE OWNER'S MANUALS.

Reported: 2001-03-07 (March 7, 2001) · Model years: 2001

VEHICLE DESCRIPTION: LIGHT DUTY TRUCKS AND SPORT UTILITY VEHICLES EQUIPPED WITH 4-WHEEL DRIVE. THE ELECTRIC SHIFT TRANSFER CASE MAY NOT FULLY ENGAGE INTO GEAR WHEN THE OPERATOR MOVES THE TRANSFER CASE SELECTOR SWITCH.

Consequence: THIS COULD CAUSE THE TRANSFER CASE TO END UP IN THE NEUTRAL POSITION UNEXPECTEDLY AND ALLOW THE VEHICLE TO ROLL AWAY IF THE PARKING BRAKE IS NOT APPLIED.

Remedy: DEALERS WILL REPROGRAM THE TRANSFER CASE CONTROL MODULE. OWNER NOTIFICATION BEGAN APRIL 9, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.

Reported: 2001-07-05 (July 5, 2001) · Model years: 2001

VEHICLE DESCRIPTION: QUAD CAB PICKUP TRUCKS. THE FRONT OUTBOARD LOWER SEAT BELT ANCHOR BOLTS MAY NOT BE TIGHTENED CORRECTLY.

Consequence: AN IMPROPERLY TIGHTENED SEAT BELT ANCHOR MAY NOT PROVIDE THE ANTICIPATED LEVEL OF OCCUPANT RESTRAINT IN A CRASH.

Remedy: DEALERS WILL INSPECT THE DRIVER AND PASSENGER SIDE LOWER SEAT BELT ANCHOR BOLTS AND TIGHTEN TO SPECIFICATION. OWNER NOTIFICATION BEGAN JULY 19, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.

Reported: 2003-10-10 (October 10, 2003) · Model years: 2001, 2002, 2003

ON CERTAIN PICKUP TRUCKS EQUIPPED WITH MANUAL TRANSMISSIONS, THE HEADLAMP AND DASH WIRING HARNESS MAY BE CHAFED BY THE ACTUATION OF THE CLUTCH PEDAL. THIS COULD RESULT IN ABNORMAL OPERATION OF THE WIPERS, TURN SIGNALS, HORN OR LIGHTING SYSTEMS.

Consequence: THIS COULD AFFECT DRIVER VISIBILITY, COULD PREVENT A DRIVER FROM SOUNDING A WARNING BY USING THE HORN, AND, WHEN THE TURN SIGNALS ARE INOPERATIVE, THE DRIVER CANNOT USE THEM TO SIGNAL INTENT TO TURN, INCREASING THE RISK OF A CRASH.

Remedy: DEALERS WILL REROUTE THE WIRE HARNESS AND REPAIR THE HARNESS IF NECESSARY. OWNER NOTIFICATION BEGAN NOVEMBER 3, 2003. OWNERS SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-992-1997.

Reported: 2003-12-10 (December 10, 2003) · Model years: 2001, 2002

ON CERTAIN MINIVANS AND 4X2 PICKUP TRUCKS, THE VEHICLE CERTIFICATION LABEL MAY HAVE GROSS AXLE WEIGHT RATINGS (GAWR) THAT EXCEED THE MAXIMUM TIRE LOAD CAPACITY AS DEFINED IN FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 120, "TIRE SELECTION AND RIMS FOR MOTOR VEHICLES OTHER THAN PASSENGER CARS."

Consequence: IMPROPERLY LOADING YOUR VEHICLE CAN CAUSE TIRE FAILURE AND RESULT IN A CRASH.

Remedy: OWNERS WILL BE PROVIDED WITH VEHICLE CERTIFICATION LABEL OVERLAYS CONTAINING CORRECTED INFORMATION RELATIVE TO VEHICLE GAWR AND TIRE SIZE. OWNER NOTIFICATION BEGAN MARCH 1, 2004. OWNERS SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-992-1997.

Reported: 2007-12-04 (December 4, 2007) · Model years: 2001, 2002

ON CERTAIN VAN AND PICKUP TRUCKS EQUIPPED WITH AUTOMATIC TRANSMISSIONS, THE IGNITION/PARK SHIFT INTERLOCK SYSTEM MAY BECOME INOPERATIVE. THIS CAN ALLOW THE SHIFTER TO BE MOVED OUT OF THE "PARK" POSITION WITH THE IGNITION KEY REMOVED (OR IN THE "LOCK" POSITION). THIS CAN ALSO ALLOW THE IGNITION KEY TO BE REMOVED WHEN THE SHIFTER HAS NOT BEEN PLACED IN THE "PARK" POSITION.

Consequence: EITHER OF THESE CONDITIONS COULD ALLOW THE VEHICLE TO ROLL AWAY CAUSING A CRASH WITHOUT WARNING.

Remedy: DEALERS WILL REPLACE THE GEARSHIFT BLOCKER AND BRACKET ASSEMBLY FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN DURING JANUARY 2008. OWNERS MAY CONTACT CHRYSLER AT 1-800-853-1403.

Reported: 2004-05-05 (May 5, 2004) · Model years: 2002, 2003, 2004

ON CERTAIN PICKUP TRUCKS AND SPORT UTILITY VEHICLES, THE WINDSHIELD WIPER MODULE MOTOR MAY BE SUSCEPTIBLE TO WATER INTRUSION THAT COULD CAUSE INTERNAL CORROSION AND RESULT IN PARTIAL OR COMPLETE LOSS OF FRONT WINDSHIELD WIPING CAPABILITY.

Consequence: DRIVER VISIBILITY COULD BE REDUCED, WHICH COULD RESULT IN A CRASH.

Remedy: DEALERS WILL REPLACE THE FRONT WINDSHIELD WIPER MODULE. OWNER NOTIFICATION BEGAN ON JULY 12, 2004. OWNERS SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.

Reported: 2002-12-02 (December 2, 2002) · Model years: 2003

ON CERTAIN PICKUP TRUCKS, THE CENTRAL TIMER MODULE (CTM) HAS AN IMPROPERLY SIZED CIRCUIT BOARD TRACE THAT COULD POTENTIALLY CAUSE THE RIGHT HEADLAMP LOW BEAM TO BECOME INOPERATIVE.

Consequence: IF THE LIGHTS FAIL, A VISIBILITY PROBLEM COULD OCCUR, INCREASING THE RISK OF A VEHICLE CRASH.

Remedy: DEALERS WILL REPLACE THE CTM. OWNER NOTIFICATION BEGAN DECEMBER 23, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.

Reported: 2005-01-05 (January 5, 2005) · Model years: 2005

ON CERTAIN PICKUP TRUCKS EQUIPPED WITH THE OPTIONAL SIDE CURTAIN AIR BAG, THE CURTAIN FASTENERS MAY NOT HAVE BEEN PROPERLY TIGHTENED.

Consequence: THIS COULD RESULT IN AN IMPROPER SIDE AIR BAG CURTAIN DEPLOYMENT IN CERTAIN SIDE CRASH CONDITIONS, WHICH CAN INCREASE THE RISK OF INJURY TO VEHICLE OCCUPANTS.

Remedy: DEALERS WILL TIGHTEN THE SIDE AIR BAG CURTAIN FASTENERS TO THE PROPER SPECIFICATION. THE RECALL BEGAN ON JANUARY 17, 2005. OWNERS MAY CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.

Reported: 2005-10-06 (October 6, 2005) · Model years: 2005

ON CERTAIN PICKUP TRUCKS, SPORT UTILITY AND PASSENGER VEHICLES EQUIPPED WITH 42RLE AUTOMATIC TRANSMISSIONS, THE CUP PLUG THAT RETAINS THE PARK PAWL ANCHOR SHAFT MAY BE IMPROPERLY INSTALLED. IF THE SHAFT MOVES OUT OF POSITION, THE VEHICLE MAY NOT BE ABLE TO ACHIEVE 'PARK' POSITION.

Consequence: IF THIS OCCURS AND THE PARKING BRAKE IS NOT APPLIED, THE VEHICLE MAY ROLL AWAY AND CAUSE A CRASH WITHOUT WARNING.

Remedy: DEALERS WILL INSPECT THE TRANSMISSIONS AND INSTALL A BRACKET TO ENSURE THE PARK PAWL ANCHOR SHAFT IS RETAINED IN THE PROPER POSITION. THE RECALL BEGAN ON NOVEMBER 28, 2005. OWNERS MAY CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.

Reported: 2014-12-03 (December 3, 2014) · Model years: 2005

Chrysler Group LLC (Chrysler) is recalling certain model year 2004-2005 Dodge Ram 1500, 2500, and 3500, 2004-2005 Dodge Durango, 2005 Dodge Dakota, 2005 Dodge Magnum and 2005 Chrysler 300, 300C and 300 SRT8 vehicles originally sold, or ever registered, in geographic locations associated with high absolute humidity. Specifically, vehicles sold, or ever registered, in Alabama, Florida, Georgia, Hawaii, Louisiana, Mississippi, Texas, Puerto Rico, U.S. Virgin Islands, Saipan, Guam, and American Samoa are addressed by this recall. Upon deployment of the passenger side frontal air bag, excessive internal pressure may cause the inflator to rupture.

Consequence: In the event of a crash necessitating deployment of the passenger’s frontal air bag, the inflator could rupture with metal fragments striking the vehicle occupants potentially resulting in serious injury or death.

Remedy: Chrysler will notify owners, and dealers will replace the front passenger air bag inflator, free of charge. For vehicles that were sold, or are currently registered, in Florida, Puerto Rico, Hawaii, and the U.S. Virgin Islands, owners were notified and the recall began on December 5, 2014. For all other vehicles, Chrysler notified owners and the recall began on February 3, 2015. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is P40 Expanded. Note: This recall has been superseded by recall 16V-352. This recall superseded the passenger air bag portion of recall 14V-354.

Reported: 2015-05-26 (May 26, 2015) · Model years: 2005, 2006, 2007, 2008, 2009, 2010, 2011

Chrysler (FCA US LLC) is recalling certain model year 2005-2009 Dodge Ram 2500, 2004-2008 Dodge Ram 1500 and Durango, 2006-2009 Dodge Ram 3500, 2008-2010 Dodge Ram 4500 and 5500, 2007-2008 Chrysler Aspen, 2005-2010 Chrysler 300, 300C, 300S, and SRT8, 2006-2010 Dodge Charger, 2005-2008 Magnum, 2005-2011 Dodge Dakota, and 2006-2009 Mitsubishi Raider vehicles. The affected vehicles are equipped with a dual-stage driver frontal air bag that may be susceptible to moisture intrusion which, over time, could cause the inflator to rupture.

Consequence: In the event of a crash necessitating deployment of the driver's frontal air bag, the inflator could rupture with metal fragments striking the driver or other occupants resulting in serious injury or death.

Remedy: Owners are advised not to drive their vehicle until the recall repair is complete. Chrysler will notify the affected Chrysler and Dodge owners and Mitsubishi will notify the affected Raider owners. Dealers will replace the driver's frontal air bag inflator, free of charge. The recall began for Chrylser on June 8, 2015. The recall for Mitsubishi started on June 24, 2015. Chrysler and Dodge owners may contact Chrysler customer service at 1-800-853-1403. Mitsubishi owners may call 1-888-648-7820. Chrysler's number for this recall is R25. Note: This recall supersedes recall 14V817 in its entirety. Vehicles that have had their driver side frontal air bag replaced previously need to have their air bag replaced under this recall as well.

Reported: 2016-05-24 (May 24, 2016) · Model years: 2005, 2006, 2007, 2008, 2009, 2010, 2011

Chrysler (FCA US LLC) expanded the affected population to include 73,712 2005-2009 RAM 2500 trucks produced at the St. Louis North Assembly Plant. With this change, Chrysler is recalling certain model year 2004-2008 RAM 1500, 2005-2009 RAM 2500, 2006-2009 RAM 3500, 2007-2010 RAM 3500 Cab Chassis, 2008-2010 RAM 4500 and 5500 Cab Chassis, 2004-2009 Dodge Durango, 2007-2009 Chrysler Aspen, 2007-2012 Jeep Wrangler, 2008-2012 Dodge Challenger, 2005-2008 Dodge Magnum, 2005-2012 Chrysler 300, 2006-2012 Dodge Charger, 2005-2011 Dodge Dakota, and 2006-2009 Mitsubishi Raider vehicles originally sold, or ever registered, in AL, CA, FL, GA, HI, LA, MS, SC, TX, Puerto Rico, American Samoa, Guam, the Northern Mariana Islands (Saipan), and the U.S. Virgin Islands, or "Zone A." Additionally, unless included in "Zone A" above, Chrysler is also recalling 2004-2008 RAM 1500, 2005-2009 RAM 2500, 2006-2009 RAM 3500, 2007-2009 RAM 3500 Cab Chassis, 2008-2009 RAM 4500 and 5500 Cab Chassis, 2004-2009 Dodge Durango, 2007-2009 Chrysler Aspen, 2007-2009 Jeep Wrangler, 2008-2009 Dodge Challenger, 2005-2008 Dodge Magnum, 2005-2009 Chrysler 300, 2006-2009 Dodge Charger, 2005-2009 Dodge Dakota and 2006-2009 Mitsubishi Raider vehicles originally sold, or ever registered, in AZ, AR, DE, Washington D.C., IL, IN, KS, KY, MD, MO, NE, NV, NJ, NM, NC, OH, OK, PA, TN, VA, and WV, or "Zone B." Lastly, unless included in "Zone A" or "Zone B" above, Chrysler is recalling certain 2005-2008 RAM 2500, 2006-2008 RAM 3500, 2007-2008 RAM 3500 Cab Chassis, 2008 RAM 4500 and 5500 Cab Chassis, 2004-2008 Dodge Durango, 2007-2008 Chrysler Aspen, 2007-2008 Jeep Wrangler, 2008 Dodge Challenger, 2005-2008 Dodge Magnum, 2005-2008 Chrysler 300, 2006-2008 Dodge Charger, 2005-2008 Dodge Dakota, and 2006-2008 Mitsubishi Raider vehicles originally sold, or registered, in AK, CO, CT, ID, IA, ME, MA, MI, MN, MT, NH, NY, ND, OR, RI, SD, UT, VT, WA, WI, and WY.

Consequence: These vehicles are equipped with certain air bag inflators assembled as part of the passenger frontal air bag modules, and used as original equipment or replacement equipment. These inflators may rupture due to propellant degradation occurring after long-term exposure to absolute humidity and temperature cycling. An inflator rupture may result in metal fragments striking the vehicle occupants resulting in serious injury or death.

Remedy: Owners are advised not to drive their vehicle until the recall repair is complete. Chrysler will notify the Chrysler, Dodge, Jeep and RAM owners. Mitsubishi owners will be notified by their company. Dealers will replace the passenger frontal air bag inflator, free of charge. The recall began on March 27, 2017. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is S43. Note: This recall supersedes recall 14V-7700.

Reported: 2017-12-20 (December 20, 2017) · Model years: 2005

Fiat Chrysler Automobiles US LLC (Chrysler) is recalling certain 2005 Dodge Dakota pickup trucks equipped with heated seats. These driver and passenger seats may develop hot spots that can result in the seat cushion or seat back having burn holes.

Consequence: The hot spots and burn holes can injure the seat occupant and can increase the risk of a fire.

Remedy: Chrysler will notify owners and dealers will update the seat heating system control features, free of charge. The recall began December 27, 2018. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is T80.

Reported: 2006-02-09 (February 9, 2006) · Model years: 2006

ON CERTAIN PICKUP TRUCKS EQUIPPED WITH FOUR-WHEEL ANTILOCK BRAKE SYSTEMS (ABS), THE ABS ELECTRONIC CONTROL UNIT (ECU) MAY CAUSE A LOSS OF FRONT TO REAR BRAKE BALANCE, AND THE REAR BRAKES COULD LOCK UP PREMATURELY DURING CERTAIN BRAKING CONDITIONS.

Consequence: THIS COULD RESULT IN A LOSS OF VEHICLE CONTROL AND CAUSE A CRASH WITHOUT WARNING.

Remedy: DEALERS WILL REPLACE THE ABS ECU. THE RECALL IS EXPECTED TO BEGIN DURING THE WEEK OF JULY 17, 2006. OWNERS MAY CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.

Reported: 2006-02-09 (February 9, 2006) · Model years: 2006

ON CERTAIN PICKUP TRUCKS AND SPORT UTILITY VEHICLES, A STATIC ELECTRICITY SPARK BETWEEN THE OPERATOR AND THE VEHICLE CAN CAUSE THE TURN SIGNAL, HEADLAMPS OR WINDSHIELD WIPERS TO MALFUNCTION WITHOUT WARNING.

Consequence: THIS CAN IMPAIR THE DRIVER'S VISION AND RESULT IN A CRASH.

Remedy: DEALERS WILL RE-FLASH THE INSTRUMENT CLUSTER. THE RECALL BEGAN ON MARCH 6, 2006. OWNERS MAY CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.

Reported: 2014-12-16 (December 16, 2014) · Model years: 2006, 2007

Chrysler Group LLC (Chrysler) is recalling certain model year 2006-2007 Dodge Ram 1500, 2500, 3500, Dakota, and 2006 Mitsubishi Raider vehicles manufactured July 1, 2005, to July 31, 2006 with manual transmissions. The return springs in the clutch ignition interlock switch may break.

Consequence: Broken springs can result in a no-start condition, or cause unintended movement when the ignition is cranked, increasing the risk of a vehicle crash.

Remedy: Chrysler will notify owners, and dealers will replace the clutch ignition interlock switch, free of charge. The recall began on March 27, 2015. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is P80.

Reported: 2006-09-07 (September 7, 2006) · Model years: 2007

ON CERTAIN PASSENGER AND SPORT UTILITY VEHICLES AND PICKUP TRUCKS EQUIPPED WITH AUTOMATIC TRANSMISSIONS, THE SOFTWARE PROGRAMMED INTO THE POWERTRAIN CONTROL MODULE CAN CAUSE A MOMENTARY LOCK UP OF THE DRIVE WHEELS IF THE VEHICLE IS TRAVELING OVER 40 MPH AND THE OPERATOR SHIFTS FROM DRIVE TO NEUTRAL AND BACK TO DRIVE.

Consequence: IF THE DRIVE WHEELS LOCKED UP, LOSS OF VEHICLE CONTROL COULD OCCUR INCREASING THE RISK OF A CRASH.

Remedy: DEALERS WILL REPROGRAM THE POWERTRAIN CONTROL MODULE FREE OF CHARGE. THE RECALL BEGAN ON OCTOBER 2, 2006. OWNERS MAY CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.

Reported: 2012-10-02 (October 2, 2012) · Model years: 2009, 2010

Chrysler is recalling certain model year 2009-2010, Ram 1500 and Dodge Dakota trucks, manufactured from July 1, 2009, through November 30, 2009, because the rear axle pinion nut may loosen due to a lack of adhesive.

Consequence: If the rear axle pinion nut loosens, the axle can lock up and cause a loss of vehicle control and/or a vehicle crash with little warning.

Remedy: Chrysler will notify owners, and dealers will install a pinion nut retainer, free of charge. The recall began on June 17, 2013. Owners may contact Chrysler at 1-800-247-9753.

Reported: 2013-02-06 (February 6, 2013) · Model years: 2009, 2010, 2011

Chrysler is recalling certain model year 2009-2012 Ram 1500 trucks manufactured from February 27, 2008, through June 30, 2009, and from December 1, 2009, through October 20, 2011; model year 2009-2011 Dodge Dakota trucks manufactured from February 27, 2007, through June 30, 2009, and from December 1, 2009, through September 30, 2011; model year 2009 Chrysler Aspen trucks manufactured from January 3, 2008, through December 18, 2008; and model year 2009 Dodge Durango trucks manufactured from January 3, 2008, through December 18, 2008. The rear axle pinion nut may loosen due to an undersized pinion spline that can allow relative motion between the nut and companion flange.

Consequence: If the rear axle pinion nut loosens, the axle can lock up and cause a loss of vehicle control and/or a vehicle crash with little warning.

Remedy: On November 7, 2013 Chrysler notified owners that dealers would install a pinion nut retainer, free of charge. In July 2015, and under a consent order with NHTSA, the company agreed to offer owners three options for remedying their vehicles: perform the original remedy, offer to repurchase the vehicle at the fair market value plus 10%, or offer an additional incentive offer towards the purchase of a new Dodge, Jeep, Chrysler, or Fiat vehicle. Chrysler will notify owners of the new recall options in a letter expected to be mailed on August 31, 2015. Owners may contact Chrysler at 1-800-247-9753. Chrysler's recall campaign number is N08.

Reported: 2018-01-09 (January 9, 2018) · Model years: 2009, 2010, 2011

Chrysler (FCA US LLC) is recalling certain 2009-2013 Jeep Wrangler, Chrysler 300, Dodge Challenger and Dodge Charger vehicles, and 2009-2011 Dodge Dakota vehicles sold, or ever registered, in the states of Alabama, California, Florida, Georgia, Hawaii, Louisiana, Mississippi, South Carolina, Texas, Puerto Rico, American Samoa, Guam, the Northern Mariana Islands (Saipan), and the U.S. Virgin Islands or "Zone A." Additionally, Chrysler is recalling certain 2009-2010 RAM 4500 Cab Chassis, RAM 5500 Cab Chassis, RAM 3500 Cab Chassis, Jeep Wrangler, Chrysler 300, Dodge Dakota, Dodge Challenger, and Dodge Charger vehicles ever registered in the states of Arizona, Arkansas, Delaware, District of Columbia, Illinois, Indiana, Kansas, Kentucky, Maryland, Missouri, Nebraska, Nevada, New Jersey, New Mexico, North Carolina, Ohio, Oklahoma, Pennsylvania, Tennessee, Virginia, and West Virginia or "Zone B." Chrysler is also recalling certain 2009 RAM 3500, RAM 2500, RAM 4500 Cab Chassis, RAM 5500 Cab Chassis, Dodge Durango, Chrysler Aspen, RAM 3500 Cab Chassis, Jeep Wrangler, Chrysler 300, Dodge Dakota, Dodge Challenger, and Dodge Charger vehicles ever registered in the states of Alaska, Colorado, Connecticut, Idaho, Iowa, Maine, Massachusetts, Michigan, Minnesota, Montana, New Hampshire, New York, North Dakota, Oregon, Rhode Island, South Dakota, Utah, Vermont, Washington, Wisconsin, and Wyoming. In the event of a crash necessitating deployment of the passenger frontal air bag, these passenger air bag inflator may explode due to propellant degradation occurring after long-term exposure to absolute humidity and temperature cycling.

Consequence: An inflator explosion may result in sharp metal fragments striking the driver or other occupants resulting in serious injury or death.

Remedy: Owners are advised not to drive their vehicle until the recall repair is complete. Chrysler will notify owners, and dealers will replace the passenger frontal air bag inflator, free of charge. The recall began February 28, 2018. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is U03.

Reported: 2012-08-28 (August 28, 2012) · Model years: 2010, 2011

NBC Truck Equipment, Inc. (NBC) is recalling certain model year 2007-2008 and model year 2010-2011 trucks equipped with Sure Power battery separator devices, due to overheating.

Consequence: Overheating of the battery separator can result in smoke and possible fire.

Remedy: NBC will notify owners, and Sure Power will replace the battery separators free of charge. The safety recall began November 26, 2012. Owners may contact NBC Truck Equipment, Inc. at 1-586-774-4900.

Reported: 2019-01-15 (January 15, 2019) · Model years: 2010, 2011

Chrysler (FCA US LLC) is recalling certain 2010 Dodge Ram 3500, Ram 4500/5500, 2010-2011 Dodge Dakota, 2010-2014 Dodge Challenger, 2010-2015 Dodge Challenger, Chrysler 300, and 2010-2016 Jeep Wrangler vehicles. Upon deployment of the driver's frontal air bag, excessive internal pressure may cause the inflator to explode.

Consequence: In the event of a crash necessitating deployment of the passenger's frontal air bag, the inflator could explode with metal fragments striking the vehicle occupants potentially resulting in serious injury or death.

Remedy: Owners are advised not to drive their vehicle until the recall repair is complete. Chrysler will notify owners, and dealers will replace the passenger frontal air bag inflator, free of charge. The recall began February 4, 2019. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is V01.