Collins BANTAM recalls by model year

Reported: 1993-09-28 (September 28, 1993) · Model years: 1986, 1987, 1988, 1989, 1990, 1991, 1992, 1993

PASSENGERS CLOTHING CAN UNKNOWINGLY BECOME CAUGHT IN THE HANDRAILS AT BUS DOORS WHEN EXITING THE BUS.

Consequence: WHEN A PASSENGER'S CLOTHING BECOMES CAUGHT IN THEHANDRAIL, AND THE BUS DRIVER CLOSES THE DOOR AND PUTS THE VEHICLE IN MOTION, THEINDIVIDUAL IS SUBJECT TO BEING DRAGGED BY THE BUS. THIS CAN RESULT IN SERIOUSINJURY OR DEATH.

Remedy: REPLACE OR REPOSITION THE HANDRAILS TO STOP CLOTHING FROM BECOMING CAUGHT.

Reported: 1991-07-25 (July 25, 1991) · Model years: 1990, 1991

THE FASTENERS ATTACHING THE SEATS TO THE FLOOR OF THE VEHICLE DO NOT MEET DESIGN SPECIFICATIONS AND MAY FAIL.

Consequence: FASTENER FAILURE WOULD SUBJECT SEAT OCCUPANTS TOINCREASED RISK OF INJURY IN THE EVENT OF A SUDDEN STOP OR ACCIDENT.

Remedy: REPLACE FASTENERS AS NECESSARY.

Reported: 1997-08-18 (August 18, 1997) · Model years: 1993

VEHICLE DESCRIPTION: SCHOOL BUSES BUILT ON A 9,500 LB. GROSS VEHICLE WEIGHT RATIO GMT-600 CHEVY CUTAWAY CHASSIS WITH AN EXTERIOR WIDTH OF 80 INCHES. THERE IS NOT ENOUGH CLEARANCE BETWEEN THE WHEELWELL AND THE REAR TIRE ALLOWING THE INSIDE OF THE REAR TIRE TO RUB ON THE STEEL WHEELWELL.

Consequence: THE TIRE RUBBING CAN CAUSE A PREMATURE TIRE FAILURE INCREASING THE RISK OF A VEHICLE CRASH.

Remedy: DEALERS WILL REPAIR THE WHEELWELL TO PREVENT THE TIRE FROM RUBBING. IF AN OWNER PREFERS, DETAILED INSTRUCTIONS WILL BE PROVIDED SO THE BUS OWNERS CAN REPAIR THEIR VEHICLES.

Reported: 1997-10-02 (October 2, 1997) · Model years: 1997

VEHICLE DESCRIPTION: SCHOOL BUSES EQUIPPED WITH 39" SCHOOL BUS SEATS. THE SEATS IN THESE BUSES HAVE FRAME MATERIAL THAT DOES NOT COMPLY WITH THE ENERGY ABSORPTION REQUIREMENTS OF FMVSS NO. 222, "SCHOOL BUS PASSENGER SEATING AND CRASH PROTECTION."

Consequence: IN THE EVENT OF A VEHICLE CRASH, THE OCCUPANT OF THE SEAT MAY INCUR PERSONAL INJURIES.

Remedy: A GUSSET WILL BE ADDED TO THE SEAT CUSHION FRAME. IN ADDITION, A REINFORCEMENT STRAP WILL BE ADDED TO THE FRONT OF THE SEAT LEG.

Reported: 2000-07-13 (July 13, 2000) · Model years: 1999, 2000

VEHICLE DESCRIPTION: SCHOOL BUSES BUILT ON FORD OR CHEVROLET CUTAWAY VAN CHASSIS EQUIPPED WITH THE ROSCO "EURO-STYLE" OVERHANGING RIGHT HAND REARVIEW MIRROR. THESE MIRRORS HAVE AN INADEQUATE STRENGTH ATTACHMENT AT THE MIRROR BRACE MOUNTING POINT AND COULD PULL LOOSE DURING HIGH WINDS (FROM ONCOMING TRAFFIC) OR SEVERE VIBRATION. THIS DOES NOT COMPLY WITH THE REQUIREMENTS OF FMVSS NO. 111, "REARVIEW MIRRORS."

Consequence: FAILURE OF THE MIRROR BRACE ATTACHMENT ALLOWS THE MIRROR ARM TO PIVOT LEFT OR RIGHT, POSSIBLY SWINGING FAR TO THE RIGHT PAST THE BUS PERIMETER AND INJURING PEDESTRIANS NEARBY. THIS COULD ALSO RESULT IN A LOSS OF VISIBILITY SURROUNDING THE BUS.

Remedy: DEALERS WILL RELOCATE THE MIRROR BRACE MOUNTING POINT FROM THE FRONT CAP OF THE BUS BODY TO THE ROOF SKIN OF THE BUS CAB, PROVIDING SIGNIFICANTLY INCREASED STRENGTH. OWNERS WILL BE PROVIDED WITH A DESCRIPTION AND DRAWING OF THE NONCOMPLIANCE, A BRIEF DESCRIPTION OF THE REPAIR PROCEDURE, AND WHERE TO TAKE THE VEHICLE TO HAVE IT REPAIRED.

Reported: 1998-12-22 (December 22, 1998) · Model years: 1999

VEHICLE DESCRIPTION: SINGLE REAR-WHEEL AND DUAL REAR-WHEEL SCHOOL BUSES BUILT ON CHEVROLET 3500 VAN CUTAWAY CHASSIS, EXTERIOR BODY WIDTH OF 81" OR 94". THE SCHOOL BUS CERTIFIED SAFETY SEATS DO NOT COMPLY WITH THE REQUIREMENTS OF FMVSS NO. 210, "SEAR BELT ASSEMBLY ANCHORAGES." THE SEAT LEGS MAY HAVE INCOMPLETE OR MISSING WELDS.

Consequence: IN THE EVENT OF A CRASH, THE SEATS MAY NOT WITHSTAND THE FORCES SPECIFIED, POSSIBLY CAUSING INJURY TO THE SEAT OCCUPANT.

Remedy: DEALERS WILL REPLACE THE NONCOMPLYING SEAT LEGS.

Reported: 1999-11-02 (November 2, 1999) · Model years: 1999

VEHICLE DESCRIPTION: SINGLE-REAR-WHEEL AND DUAL-REAR-WHEEL SCHOOL BUSES BUILT ON CHEVROLET 3500 VAN CUTAWAY CHASSIS. CERTAIN BUSES ARE EQUIPPED WITH SCHOOL BUS CERTIFIED SAFETY SEATS WHICH MAY NOT MEET THE REQUIREMENTS OF FMVSS NO. 210, "SEAT BELT ASSEMBLY ANCHORAGES."

Consequence: IN THE EVENT OF A VEHICLE CRASH, THE SEAT OCCUPANT MAY NOT BE PROPERLY RESTRAINED, INCREASING THE RISK OF PERSONAL INJURY.

Remedy: COLLINS WILL PROVIDE REPLACEMENT SEAT LEGS FOR THESE BUSES.

Reported: 2005-01-21 (January 21, 2005) · Model years: 2002, 2003, 2004, 2005

CERTAIN 2002 THRU 2005 COLLINS BANTAM AND SUPER BANTAM SCHOOL BUSES MANUFACTURED BETWEEN SEPTEMBER 18, 2002, AND JANUARY 17, 2005. THE PROTECTIVE RUBBER PARTS THAT COVER THE FUEL LINES TO PREVENT CONTACT WITH METAL EDGES MAY BE MISSING.

Consequence: THE FUEL LINES MAY BE CUT RESULTING IN FUEL SPILLAGE AND IN THE PRESENCE OF AN IGNITION SOURCE, COULD RESULT IN A FIRE.

Remedy: CUSTOMERS WILL BE NOTIFIED TO TAKE THEIR BUSES TO AN AUTHORIZED DEALER FOR FREE REPAIR. DEALERS WILL INSPECT THE FUEL LINES AND INSTALL THE PROTECTIVE RUBBER COVERING SHOULD IT BE MISSING. IF THE FUEL LINES ARE DAMAGED, DEALERS WILL REPLACE THE FUEL LINES FREE OF CHARGE. THE RECALL BEGAN ON JANUARY 21, 2005. OWNERS MAY CONTACT COLLINS AT 1-800-533-1850.

Reported: 2005-05-02 (May 2, 2005) · Model years: 2002, 2003, 2004, 2005

CERTAIN COLLINS MY 2002-2005 BANTAM, SUPER BANTAM, AND GRAND BANTAM MODEL SCHOOL BUSES MANUFACTURED BETWEEN APRIL 22, 2002, AND APRIL 27, 2005. THESE BUSES WERE EQUIPPED WITH A BENCH-STYLE SINGLE PASSENGER SEATS HAVING A LOWER CUSHION SURFACE OF 24 INCHES IN WIDTH. THESE SEATS SHOULD HAVE A SEATING SURFACE OF ONLY 22 INCHES FOR A SIGNAL DESIGNATED SEATING POSITION. THESE SEATS DO NOT CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 222, SCHOOL BUS PASSENGER SEATING AND CRASH PROTECTION.

Consequence: THESE SEATS SHOULD HAVE A SEATING SURFACE OF ONLY 22 INCHES WIDE TO HAVE A SINGLE DESIGNATED SEATING POSITION. BECAUSE THE 24 INCH CUSHION IS WIDER THAN 22 INCHES, THE POTENTIAL EXISTS FOR TWO PASSENGERS TO BE SEATED IN THIS SEAT. A SECOND PASSENGER WOULD NOT HAVE AN AVAILABLE SEAT BELT FOR RESTRAINT AND MAY BE INJURED IN A CRASH.

Remedy: COLLINS WILL NOTIFY ITS CUSTOMERS AND REPLACE THE 24 INCH SEAT CUSHION WITH A 22 INCH SEAT CUSHION FREE OF CHARGE. THE RECALL BEGAN APRIL 29, 2005. OWNERS MAY CONTACT COLLINS CUSTOMER SERVICE AT 1-800-533-1850.

Reported: 2005-08-01 (August 1, 2005) · Model years: 2002, 2003, 2004, 2005

CERTAIN 2002-2005 MY COLLINS BANTAM, SUPER BANTAM, AND GRAND BANTAM SCHOOL BUSES EQUIPPED WITH SPECIALTY MFG "5" SERIES STOP ARMS ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN THE FOLLOWING STATES: ALASKA, COLORADO, CONNECTICUT, DELAWARE, IDAHO, ILLINOIS, INDIANA, IOWA, KANSAS, KENTUCKY, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, MONTANA, NEBRASKA, NEVADA, NEW HAMPSHIRE, NEW JERSEY, NEW MEXICO, NEW YORK, NORTH DAKOTA, OHIO, OREGON, PENNSYLVANIA, RHODE ISLAND, SOUTH DAKOTA, TENNESSEE, UTAH, VERMONT, VIRGINIA, WASHINGTON, WEST VIRGINIA, WISCONSIN, WYOMING, AND THE DISTRICT OF COLUMBIA. IN EXTREMELY COLD WEATHER, THE MICROSWITCHES USED INTERNALLY TO POSITION THE SIGN IN THE OPEN AND CLOSED POSITIONS MAY MALFUNCTION, CAUSING THE SIGN TO OPEN OR CLOSE IN AN IMPROPER POSITION, OR TO NOT OPEN AT ALL.

Consequence: SHOULD THE STOP ARM NOT PERFORM PROPERLY, A CHILD OR PEDESTRIAN MAY BE ENDANGERED BY PASSING VEHICLES SHOULD THE MOTORIST NOT STOP AT THE CORRECT LOCATION.

Remedy: COLLINS BUS WILL NOTIFY ITS CUSTOMERS AND THE ORIGINAL SWITCH WILL BE REPLACED FREE OF CHARGE WITH A SWITCH PACK THAT IS NOT SENSITIVE TO EXTREME COLD WEATHER AND WILL INSPECT TO ENSURE THE MICROSWITCH HEATER WIRING IS PROPERLY CONNECTED FREE OF CHARGE. THE RECALL BEGAN OCTOBER 12, 2005. CUSTOMERS MAY CONTACT COLLINS BUS CUSTOMER SERVICE AT 1-800-533-1850 OR SPECIALTY MANUFACTURING AT 1-800-951-7867.

Reported: 2005-08-01 (August 1, 2005) · Model years: 2002, 2003, 2004, 2005

CERTAIN 2002-2005 MY COLLINS BANTAM, SUPER BANTAM, AND GRAND BANTAM SCHOOL BUSES EQUIPPED WITH "5" SERIES STOP ARMS. THESE SCHOOL BUSES WERE ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN STATES OTHER THAN THE FOLLOWING: ALASKA, COLORADO, CONNECTICUT, DELAWARE, IDAHO, ILLINOIS, INDIANA, IOWA, KANSAS, KENTUCKY, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, MONTANA, NEBRASKA, NEVADA, NEW HAMPSHIRE, NEW JERSEY, NEW MEXICO, NEW YORK, NORTH DAKOTA, OHIO, OREGON, PENNSYLVANIA, RHODE ISLAND, SOUTH DAKOTA, TENNESSEE, UTAH, VERMONT, VIRGINIA, WASHINGTON, WEST VIRGINIA, WISCONSIN, WYOMING, AND THE DISTRICT OF COLUMBIA. IN EXTREMELY COLD WEATHER, THE MICROSWITCHES USED INTERNALLY TO POSITION THE SIGN IN THE OPEN AND CLOSED POSITIONS MAY MALFUNCTION, CAUSING THE SIGN TO OPEN OR CLOSE IN AN IMPROPER POSITION, OR TO NOT OPEN AT ALL.

Consequence: SHOULD THE STOP ARM NOT PERFORM PROPERLY, A CHILD OR PEDESTRIAN MAY BE ENDANGERED BY PASSING VEHICLES SHOULD THE MOTORIST NOT STOP AT THE CORRECT LOCATION.

Remedy: COLLINS WILL NOTIFY ALL ITS CUSTOMERS OF THIS CAMPAIGN. FOR THOSE BUSES OPERATED IN OR NEAR ANY OF THE STATES LISTED ABOVE, COLLINS IS ENCOURAGING THE BUS OWNERS TO OBTAIN THE REPLACEMENT SWITCH. FOR THOSE BUSES OPERATED IN THE WARMER STATES, COLLINS WILL REPLACE THE SWITCH UPON OWNER REQUEST. FOR THOSE CUSTOMERS WHO REQUEST THE REMEDY, COLLINS WILL REPLACE THE ORIGINAL SWITCH WITH A SWITCH PACK THAT IS NOT SENSITIVE TO EXTREME COLD WEATHER AND WILL INSPECT TO ENSURE THE MICROSWITCH HEATER WIRING IS PROPERLY CONNECTED. THE SAFETY IMPROVEMENT CAMPAIGN BEGAN OCTOBER 12, 2005. OWNERS MAY CONTACT COLLINS AT 800-448-7825 OR SPECIALTY MANUFACTURING AT 1-800-951-7867.

Reported: 2011-05-23 (May 23, 2011) · Model years: 2002, 2003, 2004, 2005, 2006, 2007, 2008, 2009, 2010, 2011

COLLINS IS RECALLING CERTAIN MODEL YEAR 2002-2011 BANTAM, GRAND BANTAM, AND SUPER BANTAM SCHOOL BUSES MANUFACTURED FROM OCTOBER 2002 THROUGH MAY 20, 2011, FOR FAILING TO CONFORM TO THE LEG PROTECTION ZONE IMPACT REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD 222 "SCHOOL BUS PASSENGER SEATING AND CRASH PROTECTION."

Consequence: IN THE EVENT OF A VEHICLE CRASH, THE VEHICLE OCCUPANTS MAY NOT BE ADEQUATELY PROTECTED AND MAY SUSTAIN INJURIES.

Remedy: COLLINS WILL NOTIFY OWNERS AND DEALERS WILL INSTALL ADDITIONAL FOAM PADDING UNDER THE UPHOLSTERY FREE OF CHARGE. THE SAFETY RECALL BEGAN ON JULY 18, 2011. OWNERS MAY CONTACT COLLINS BUS AT 1-800-533-1850.

Reported: 2005-08-15 (August 15, 2005) · Model years: 2004

CERTAIN 2004 MY BANTAM AND SUPER BANTAM SCHOOL BUSES MANUFACTURED BETWEEN JULY 2004 AND NOVEMBER 2004. THE AMOUNT OF ADHESIVE APPLIED TO THE ROOF SEAMS IS INADEQUATE FOR THE TYPE OF ADHESIVE USED WHICH FAILS TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 221, SCHOOL BUS BODY JOINT STRENGTH.

Consequence: IN THE EVENT OF A CRASH, THE JOINTS MAY COME APART AND INDIVIDUAL INTERIOR CEILING SKINS COULD CAUSE HARM TO THE OCCUPANTS OF THE BUS.

Remedy: DEALERS WILL CORRECT THE BUSES BY ADDING TWO ADDITIONAL SCREWS BETWEEN THE CURRENT SCREWS THAT ATTACH THE SEAMS OF THE CEILING SKINS TO THE STRUCTURAL ROOF BOWS. THE RECALL BEGAN ON DECEMBER 14, 2005. OWNERS MAY CONTACT COLLINS AT 1-800-533-1850.

Reported: 2005-09-29 (September 29, 2005) · Model years: 2005

CERTAIN 2005 COLLINS BANTAM, SUPER BANTAM, AND GRAND BANTAM SCHOOL BUSES AND SUPER OMNI BUSES BUILT BETWEEN AUGUST 1 AND SEPTEMBER 15, 2005. THE FASTENERS SECURING THE SEATS AND THE BARRIERS TO THE WALL TRACK MAY BE INADEQUATELY TIGHTENED WHICH FAILS TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 210, SEAT BELT ASSEMBLY ANCHORAGES AND FMVSS NO. 222, SCHOOL BUS PASSENGER SEATING AND CRASH PROTECTION.

Consequence: IN THE EVENT OF A CRASH, THE SEAT OCCUPANTS MAY NOT BE ADEQUATELY PROTECTED, POSSIBLY RESULTING IN SERIOUS INJURIES.

Remedy: COLLINS WILL NOTIFY THE BUS OWNERS AND REPAIR THE VEHICLES FREE OF CHARGE. THE RECALL BEGAN ON SEPTEMBER 23, 2005. OWNERS MAY CONTACT COLLINS AT 620-662-9000 OR 800-533-1850 X430.

Reported: 2006-06-01 (June 1, 2006) · Model years: 2005

CERTAIN 2005 BANTAM, SUPER BANTAM, AND GRAND BANTAM SCHOOL BUSES MANUFACTURED BETWEEN JUNE 10 AND SEPTEMBER 28, 2005, EQUIPPED WITH RICON MODEL S20005 WHEELCHAIR LIFTS. THE PLATFORM LIFTS MAY HAVE A DEFECT IN THE WELD WHICH WILL ALLOW A JOINT ON THE VERTICAL LIFT TO CRACK.

Consequence: IN THE EVENT THIS CONDITION OCCURS DURING PASSENGER OPERATIONS IT MAY NOT BE POSSIBLE TO CLOSE THE LIFT DOOR CAUSING THE VEHICLE INTERLOCKS TO REMAIN ENGAGED PREVENTING MOVEMENT OF THE VEHICLE OR THE ABILITY TO LOAD OR UNLOAD PASSENGERS WITH DISABILITIES FROM THE VEHICLE. THIS MAY RESULT IN INJURY OR DEATH.

Remedy: RICON IS CONDUCTING THIS RECALL (PLEASE SEE 06E008000) AND WILL REPLACE THE TWO VERTICAL ARMS EVEN IF ONLY ONE ARM IS CRACKED FREE OF CHARGE. THE RECALL BEGAN ON JUNE 22, 2006. OWNERS MAY CONTACT RICON CUSTOMER SUPPORT DEPT. AT 800-322-2884 OR OWNERS MAY CONTACT COLLINS BUS CUSTOMER SERVICE AT 1-800-533-1850.

Reported: 2008-01-14 (January 14, 2008) · Model years: 2005, 2006

CERTAIN MY 2005 AND 2006 COLLINS BANTAM, GRAND BANTAM, SUPER BANTAM, AND OMNI SCHOOL BUSES MANUFACTURED BETWEEN NOVEMBER 2005 AND JUNE 2006, FOR FAILING TO COMPLY WITH ALL THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 209, "SEAT BELT ASSEMBLIES", AND NO. 210, "SEAT BELT ASSEMBLY ANCHORAGES." THE WEB OF THE BELT RUBS UP AGAINST THE RETRACTOR'S METAL SLEEVE CAUSING FRICTION AND ABRASION, AND OVER TIME, MAY FRAY THE BELT.

Consequence: IN THE EVENT OF A VEHICLE CRASH, THE SEAT OCCUPANT MAY NOT BE PROPERLY RESTRAINED POSSIBLY RESULTING IN INJURY.

Remedy: COLLINS WILL NOTIFY OWNERS AND REPLACE THE SEAT BELT FREE OF CHARGE. THE RECALL BEGAN ON JANUARY 7, 2008. OWNERS MAY CONTACT COLLINS AT 1-800-533-1850.

Reported: 2011-10-14 (October 14, 2011) · Model years: 2006, 2007, 2008

COLLINS IS RECALLING CERTAIN MODEL YEAR 2006 THROUGH 2008 BANTAM, GRAND BANTAM, AND SUPER BANTAM SCHOOL BUSES MANUFACTURED FROM AUGUST 23, 2006, THROUGH FEBRUARY 1, 2008, EQUIPPED WITH CARRIER GENV EM-1 EVAPORATOR UNITS. DUE TO TIME, TEMPERATURE, AND/OR VIBRATION, THE FUSE MAY LOOSEN IN THE FUSE HOLDER RESULTING IN HIGH RESISTANCE AND ARCING.

Consequence: IF SUFFICIENT ARCING OCCURS, THE FUSE HOLDER MAY MELT, AND A VEHICLE FIRE MAY OCCUR.

Remedy: COLLINS WILL NOTIFY OWNERS AND PROVIDE INFORMATION ON HOW TO OBTAIN THE RETROFIT KIT FROM CARRIER ALONG WITH REPAIR INSTRUCTIONS. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON NOVEMBER 11, 2011. (SEE CARRIER'S RECALL CAMPAIGN 11E-003.) OWNERS MAY CONTACT CARRIER AT 1-800-793-4741 OR COLLINS AT 1- 1-620-662-9000.

Reported: 2008-09-26 (September 26, 2008) · Model years: 2007

COLLINS IS RECALLING 8 MY 2007 BANTAM, SUPER BANTAM, OR GRAND BANTAM SCHOOL BUSES EQUIPPED WITH MODULE LOCK601-GD WHEELCHAIR LIFT INTERLOCK MODULE MANUFACTURED BY INTERMOTIVE, INC. IF THE VEHICLE'S BATTERY VOLTAGE DROPS TO 7.5 VOLTS, THE MODULE MAY GO INTO FAULT MODE AND MAY NOT LOCK THE SHIFTER IN PARK WHEN THE LIFT DOOR IS OPENED WHICH FAILS TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 403, "PLATFORM LIFT SYSTEMS FOR MOTOR VEHICLES."

Consequence: THE VEHICLE MAY BE MOVED WITH THE LIFT DEPLOYED AND COULD RESULT IN INJURY TO THE LIFT OCCUPANT.

Remedy: COLLINS WILL NOTIFY OWNERS AND REPAIR THE BUSES FREE OF CHARGE. THE RECALL BEGAN ON OCTOBER 17, 2008. OWNERS MAY CONTACT COLLINS TOLL-FREE AT 1-800-533-1850 EXT. 430.

Reported: 2009-02-23 (February 23, 2009) · Model years: 2007, 2008, 2009

COLLINS IS RECALLING 559 MY 2007 THROUGH 2009 SCHOOL BUSES BUILT ON FORD E-350 AND E-450 CHASSIS FROM NOVEMBER 3, 2006 TO OCTOBER 1, 2009. THESE BUSES MAY HAVE BEEN PRODUCED WITH THE ABSENCE OF TWO BODY MOUNT BOLTS AND ASSOCIATED HARDWARE IN 2 OF THE BODY/CHASSIS MOUNTING LOCATIONS IMMEDIATELY BEHIND THE REAR AXLE.

Consequence: IF ANY OF THE BODY MOUNT BOLTS ARE MISSING THIS CONDITION WOULD NOT PROVIDE A STABLE CONNECTION OF THE BUS BODY TO THE BUS CHASSIS. IN THE EVENT OF A VEHICLE CRASH, THERE MAY BE AN INCREASED RISK OF PERSONAL INJURY TO THE VEHICLE OCCUPANTS.

Remedy: COLLINS WILL NOTIFY OWNERS AND INSPECT AND REPAIR THE BUSES IF NECESSARY FREE OF CHARGE. THE SAFETY RECALL BEGAN ON FEBRUARY 26, 2009. OWNERS MAY CONTACT COLLINS TOLL-FREE AT 1-800-533-1850.

Reported: 2009-03-06 (March 6, 2009) · Model years: 2008

COLLINS IS RECALLING 2,741 MY 2008 SCHOOL BUSES MANUFACTURED BETWEEN JANUARY 1, 2008 AND JANUARY 1, 2009. THE BOLTS USED TO MOUNT THE BODY TO THE CHASSIS FRAME RAIL MAY HAVE BEEN IMPROPERLY INSTALLED WHICH COULD LEAD TO FAILURE OF THE BOLTS.

Consequence: FAILURE OF THESE BOLTS WILL RESULT IN INADEQUATE CONNECTION OF THE BUS BODY TO THE BUS CHASSIS. IN THE EVENT OF A VEHICLE CRASH, THERE MAY BE AN INCREASED RISK OF PERSONAL INJURY TO THE VEHICLE OCCUPANTS.

Remedy: COLLINS WILL NOTIFY OWNERS AND INSPECT AND REPAIR THE BUSES IF NECESSARY FREE OF CHARGE. THE SAFETY RECALL BEGAN ON MARCH 19, 2009. OWNERS MAY CONTACT COLLINS TOLL-FREE AT 1-800-533-1850.

Reported: 2010-08-02 (August 2, 2010) · Model years: 2008

COLLINS IS RECALLING CERTAIN MODEL YEAR 2008 BANTAM, GRAND BANTAM, AND SUPER BANTAM MODEL SCHOOL BUSES. THE 39 INCH THREE PASSENGER SEATS FAIL TO MEET THE MINIMUM PERFORMANCE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 222, "SCHOOL BUS PASSENGER AND CRASH PROTECTION."

Consequence: SEAT OCCUPANTS ARE AT AN INCREASED RISK OF INJURY IN THE EVENT OF A CRASH.

Remedy: COLLINS WILL NOTIFY OWNERS AND DEALERS WILL REPAIR THE BUSES FREE OF CHARGE. THE SAFETY RECALL BEGAN ON JANUARY 3, 2011. OWNERS MAY CONTACT COLLINS AT 1-800-533-1850.

Reported: 2010-02-18 (February 18, 2010) · Model years: 2009

COLLINS IS RECALLING CERTAIN MODEL YEAR 2009 BANTAM, SUPER BANTAM, AND GRAND BANTAM SCHOOL BUSES MANUFACTURED BETWEEN APRIL 1 AND OCTOBER 1, 2009, BUILT ON FORD CUTAWAY CHASSIS. THE BRAKE-TURN SEPARATOR MODULE WHICH IS USED TO CONTROL THE BRAKE LIGHTS AND TURN SIGNALS LIGHTS IN THE REAR MAY NOT ALWAYS DISTINGUISH CORRECTLY BETWEEN A BRAKE SIGNAL INPUT AND A TURN SIGNAL INPUT FROM THE FORD CHASSIS OEM WIRING. FOR TYPICAL BRAKE AND TURN SIGNAL OPERATION, THE STOP/TAIL/TURN LIGHTS AT THE REAR OF THE BUS WILL FUNCTION PROPERLY. HOWEVER, IF THE BRAKES ARE PUMPED/APPLIED IN A FREQUENCY MATCHING THAT OF THE BLINKING TURN SIGNAL WHILE THE TURN INDICATOR IS ON, THERE IS THE POTENTIAL THAT THE BRAKE SIGNAL THROUGH THE MODULE MAY CANCEL OUT THE TURN SIGNAL TEMPORARILY OR CAUSE IT TO FLASH INTERMITTENTLY.

Consequence: THIS CAN CAUSE CONFUSION TO VEHICLES BEHIND THE BUS AS TO WHETHER THE BUS IS TURNING OR STOPPING INCREASING THE RISK OF A CRASH.

Remedy: COLLINS WILL NOTIFY OWNERS AND DEALERS WILL REPLACE THE BRAKE-TURN SIGNAL SEPARATOR MODULE, IF THE BUS IS EQUIPPED WITH ONE, FREE OF CHARGE. THE SAFETY RECALL BEGAN ON MARCH 2, 2010. OWNERS MAY CONTACT COLLINS TOLL-FREE AT 1-800-533-1850 EXT. 424.

Reported: 2013-09-25 (September 25, 2013) · Model years: 2009, 2010

Collins Bus Corporation (Collins) is recalling certain model year 2009-2010 Bantam, Super Bantam, Grand Bantam, Mid Bus Guide, Super Guide, and Grand Guide school buses manufactured September 2009 through April 2010, and equipped with A&M Systems-brand electric door actuators. Voltage spikes may damage electrical components and electrical circuits, causing the circuit board to develop high resistance.

Consequence: High resistance may cause the board to overheat, increasing the risk of a fire.

Remedy: Collins will notify owners, and dealers will inspect and, if necessary, replace the circuit board free of charge. The recall began on December 4, 2013. Owners may contact Collins at 1-800-533-1850.