2013 Can-Am SPYDER RT problems and owner complaints

SINCE THE PURCHASE OF MY SPYDER THERE HAVE BEEN SEVERAL OCCASIONS WHERE THE FUEL IS BOILING IN THE FUEL TANK AND VERY STRONG SMELL OF GAS COMES FROM THE CYCLE. THE FUMES ARE SO STRONG THAT I FEEL IT IS UNSAFE TO PARK IT IN MY GARAGE UNTIL THE FUMES GO AWAY. I LEAVE THE CYCLE ON THE DRIVEWAY AWAY FROM THE HOUSE ON THE OFF CHANCE SOMETHING IGNITES THE FUMES. TYPICALLY, I HAVE TO LEAVE THE CYCLE OUTSIDE FOR A COUPLE OF HOURS TO TOTALLY CLEAR. THE EVAP CANISTER THAT SHOULD CONTROL THESE FUMES ISN'T DOING THE JOB. *TR

Owner-reported narrative. 100 miles reported. Look up ODI 10544661 at NHTSA ↗

I DROVE THE NEWLY PURCHASED SPYDER RTS FROM THE DEALERSHIP AND PARKED THE VEHICLE IN THE GARAGE. AFTER TURNING OFF THE ENGINE, I HEARD WHAT SOUNDED LIKE BOILING SOUNDS COMING FROM THE GAS TANK AREA. WITHIN MINUTES, THE GARAGE WAS FILLED WITH GASOLINE FUMES. IT WAS SO OVERWHELMING, I HAD OPEN THE GARAGE DOOR AND LEFT IT OPEN FOR AT LEAST 2 HOURS. THIS IS NOW HAPPENING EVERY TIME AFTER THE VEHICLE IS RIDDEN. IT APPEARS TO BE VERY LIKELY THAT THE BOILING SOUNDS AND FUMES ARE ALSO OCCURRING WHILE THE VEHICLE IS IN MOTION. *TR

Owner-reported narrative. 60 miles reported. Look up ODI 10545679 at NHTSA ↗

THE BIKE HAS A VERY BAD HEAT PROBLEM. THE TEMPS ON MY RIGHT FOOT ARE VERY HIGH AND I SMELL GAS WHEN I COME TO A STOP AND SHUT IT DOWN. I REPLACED THE FRONT SHOCKS DUE TO THE BIKE DOING A NOSE DIVE, AND THE FRONT BALL JOINTS ALSO HAD TO BE RECALLED BECAUSE THEY WERE BAD. MY BIKE IS GOING INTO THE DEALER ON TUESDAY THE 15TH OF OCTOBER FOR A COMPLETE WORK OVER TO SEE WHY ALL THE HEAT IS THERE. CAN AM AKA. BRP KNOWS OF THE PROBLEM AND CAN'T SEEM TO FIX IT. A COUPLE OF BIKES HAVE CAUGHT FIRE AND THERE IS A HEAT RECALL WHERE THE BRAKE MASTER CYLINDER…

Owner-reported narrative. 600 miles reported. Look up ODI 10547672 at NHTSA ↗

I RECENTLY HAVE BEEN GETTING A STRONG ODOR OF GAS WHEN I COME HOME AFTER A RIDE. THE RECENT RECALL FOR THE EVAP CANISTER AND BRAKE CYLINDER HAS BEEN DONE BUT I PUT A PAPER TOWEL UNDER THE PURGE LINE TO FIND IT IS DRIPPING GAS. THIS IS ALL TO COMMON ON THIS MOTORCYCLE AND IS A FIRE HAZARD BOTH ON AND OFF THE ROAD IN MY GARAGE. I HAVE HEARD THIS IS HAPPENING TO A LOT OF SPYDER OWNERS WHO SAY THE SOLUTION IS TO PARK OUTSIDE AFTER A RIDE. UNACCEPTABLE. *TR

Owner-reported narrative. 1,500 miles reported. Look up ODI 10547761 at NHTSA ↗

AFTER A FOUR HOUR RIDE, I STOPPED AT A GAS STATION TO REFUEL. WHEN I WAS READY TO LEAVE, MY PARKING BRAKE CABLE WOULD NOT RELEASE. I HAD TO GET UNDER THE MACHINE AND PULL IT FREE IN ORDER TO RIDE HOME. IT TURNED OUT THE CABLE HAD MELTED, ALONG WITH THE MASTER CYLINDER AND THE CHARCOAL CANISTER. ALL THREE WERE REPLACED DURING THE RECALL. IN MARCH, WHILE DRIVING IN HEAVY TRAFFIC ON I-95 SOUTH OF FREDERICKSBURG VA, MY MACHINE STALLED AND I HAD TO CALL FOR A TOW TRUCK. A RUBBER HOSE GOING TO THE THROTTLE BODY HAD CRACKED. AT NUMEROUS TIMES I…

Owner-reported narrative. 1,700 miles reported. Look up ODI 10621881 at NHTSA ↗

THIS IS MY THIRD COMPLAINT REGARDING THIS VEHICLE. IN ADDITION TO THE SEVERE HEAT AND GASOLINE ODOR PROBLEMS WHICH I DESCRIBED IN EARLIER COMPLAINTS, THE VEHICLE HAS BECOME VERY HARD TO START WHEN THE ENGINE IS WARM. NORMAL IDLE RPM IS 1,300 TO 1,400. WHEN THIS CONDITION OCCURS - AS IT HAS ON MULTIPLE OCCASIONS - THE RPM DOES NOT EXCEED 500, AND THERE IS LIMITED THROTTLE RESPONSE. THE ENGINE STALLS, AND THERE IS AN OVERPOWERING ODOR OF GASOLINE EMANATING FROM THE VEHICLE AS IF THE THROTTLE BODY IS BEING FLOODED WITH GASOLINE. THE DEALER AND BRP…

Owner-reported narrative. 8,500 miles reported. Look up ODI 10650266 at NHTSA ↗

2013 SPYDER RT LIMITED HAS BOILING GAS ISSUES. FUEL CAP IS VERY HOT TO TOUCH WHEN STOPPING TO FILL UP. YOU CAN HEAR THE GAS BOILING WHEN YOU REMOVE THE GAS CAP. HAD THE BIKE IN FOR IT'S 600 MILE OIL CHANGE AND CHECK UP. WE ARE NOT OVERFILLING THE GAS TANK WHEN WE FILL UP. ONCE THE PUMP CUTS OFF THAT IS ALL THE TANK GETS. DEALER SAID NOTHING WAS OUT OF THE ORDINARY. SINCE THE WEATHER HAS STARTED TO WARM UP YOU CAN FEEL THE HEAT ON THE RIGHT SIDE AROUND THE FOOT. TEMP HAS STARTED TO KICK UP QUIET HIGH AND WE ARE NOT EVEN IN THE HOT MONTHS YET…

Owner-reported narrative. 200 miles reported. Look up ODI 10576999 at NHTSA ↗

FROM THE DAY I BOUGHT MY SPYDER, I'VE HAD ISSUES WITH EXTREME HEAT AT THE LOWER RIGHT AND IN THE AREA AHEAD OF THE SEAT. I'VE HAD NUMEROUS INCIDENTS OF FUMES AFTER PARKING, DRIPPING FUEL, AND FUEL BOILING WITH THE GAS CAP HEATED TO THE POINT THAT I COULD ONLY OPEN IT WHILE WEARING GLOVES. DURING ONE OF MY FIRST TIMES REFUELING WHILE LOOSENING THE GAS CAP MY HANDS WERE WASHED WITH FUEL THAT WAS EXPELLED UNDER PRESSURE, SOAKING MY GLOVES. AFTERWARD I WAS CAREFUL TO OPEN THE CAP SLOWLY (LIKE A COKE CAN UNDER PRESSURE) TO RELIEVE THE BUILT …

Owner-reported narrative. 4,500 miles reported. Look up ODI 10617819 at NHTSA ↗

I WAS RIDING ON HIGHWAY 291 IN LEES SUMMIT MO TRAVELING AT 65 MPH. THE DAILY TEMP WAS BETWEEN 92 - 95 DEGREES. THE FAN WAS BLOWING THE HOT AIR OUT FROM THE BIKES RADIATOR AREA AND WITH THE BIKE BEING IN MOTION THE HOT AIR WAS BEING ROUTED ONTO MY RIGHT LEG AND I COULD FEEL MY LEG GETTING HOT TO THE POINT THAT I WAS UNABLE TO KEEP MY FOOT ON THE FOOT PEG FOR LONGER THAN 10-15 SECONDS AFTER WHICH, I NEEDED TO KEEP SHIFTING THE LOCATION OF MY FOOT ON THE FOOT PEG. I ALSO NOTICED THAT THE RIGHT SIDE PANELS AND THE AIR COMING FROM UNDER THE SEAT W…

Owner-reported narrative. 3,300 miles reported. Look up ODI 10650717 at NHTSA ↗