1999 Bmw 540I problems and owner complaints

ABS WARNING AND DSC LIGHT IS ON INDICATING FAILURE OF ABS ELECTRONIC MODULE. ABS AND DSC IS NO LONGER OPERABLE. THIS IS A SAFETY ISSUE SINCE THE CAR WILL NO LONGER HAVE ABS AND DYNAMIC STABILITY CONTROL SYSTEM IN OPERABLE CONDITION. IT IS UNKNOWN IF BRAKE COULD BE RANDOMLY ACTIVATED BY THE FAILED ABS MODULE WHILE DRIVING. COMMON FAILURE ON 1999 OR PLUS 5-SERIES BMW BASED ON USER DISCUSSION ON INTERNET. THE FAILURE IS TEMPERTURE RELATED. THE HIGHER THE TEMPERTURE, THE QUICKER THE WARNING LIGHT WILL COME ON. *NM

Owner-reported narrative. 66,896 miles reported. Look up ODI 10143834 at NHTSA ↗

I THINK THIS IS RIDICULOUS THAT THE 60,000 DOLLAR BMW 5 SERIES WITH DSC AND ABS CONTINUALLY HAVE ABS CONTROL MODULE FAILURES. THE PART IS OBVIOUSLY A DESIGN FLAW AND THE COMPANY SHOULD BE FORCED TO REPAIR OR REPLACE UNITS FREE OF CHARGE. THIS IS OBVIOUSLY A SAFETY ISSUE SINCE THE MODULE FAILURE CAUSES THE TRACTION CONTROL AND ABS TO FAIL. THIS IS COMMON IN MODEL YEARS 98,99,AND 2000. *NM

Owner-reported narrative. 109,000 miles reported. Look up ODI 10147794 at NHTSA ↗

DURING A DOWN SHIFT, MY CAR SOMETIMES JUMP FORWARD A FOOT OR SO AND MAKES A THUMP DOWN SHIFTING NOISE. THIS FORCES ME TO APPLY THE BREAK QUICKLY. JUST A WEEK AGO, I HIT A CURVE BECAUSE OF THIS DEFECT AND THE BOTTOM BUMPER COVER OF THE CAR GOT HIT AND BECAME CRACKED! LUCKILY THIS PROBLEM IS RARE. THIS IS ABOUT 4TH FAILURE IN A SPAN OF 10 MONTHS. FOR ABOUT 10 MONTHS, MY CAR ALSO STALLS (ENGINE LOSES POWER) DURING A SLOWDOWN. USUALLY THIS HAPPENS WHEN I SLOW TO MAKE A RIGHT TURN. I NEARLY GOT INTO AN ACCIDENT FEW TIMES THIS MONTH BECA…

Owner-reported narrative. 54,000 miles reported. Look up ODI 10066088 at NHTSA ↗

MY TRANSMISSION WOULD NOT ACCELERATE OR MOVE. I HAD THE TRANS REBUILD AND 2 YEARS LATER THE SAME PROBLEM. THE TRANS HAS LOST GEARS 1-3 AND REVERSE, MULTISTATE REPAIRED THE TRANS AGAIN 2013, IFOR THE SECOND TIME, IT NEVER WORKED AFTER REPAIRS. THE ENGINE LIGHT STAYS ON, BMW SAYS I NEED NEW TRANS AND ENGINE. WHEN I LOOKED UP RECALLS FOR 540I, IT STATES THE SAME TRANS PROBLEM AND IT SHOULD BE REPLACED. WHEN I LOOK UP ENGINE THERE ARE KNOWN ENGINE PROBLEMS WITH 540I, NOT MY VIN. I ALSO HAVE ELECTRICAL ISSUES, WHICH HAVE A RECALL ON 540I, BUT…

Owner-reported narrative. 70,000 miles reported. Look up ODI 10588144 at NHTSA ↗

MY SON WAS DRIVING HOME IN RUSH HOUR TRAFFIC ON CONNECTICUT AVE. IT WAS RAINING RATHER HARD AND VISIBILITY WAS LOW. MY SON ALL OF THE SUDDEN SMELLED SMOKE COMING THROUGH THE VENTS AND THE ENGINE SHUT DOWN. IT WOULD NOT RESTART. HE HAD TO PUSH IT OFF THE ROAD INTO A SERVICE STATION DUE TO THE HIGH VOLUME OF TRAFFIC. THE CAR WAS TOWED THAT EVENING TO MY REPAIR SHOP WHERE IT WAS DIAGNOSED THAT THE THERMOSTAT HOUSING SENSOR FAILED WHICH MELTED THE WIRING HARNESS AND DAMAGED OTHER ELECTRICAL SENSORS ON THE ENGINE. *TR

Owner-reported narrative. 60,590 miles reported. Look up ODI 10211543 at NHTSA ↗

STARTED MY CAR AND HEARD A THUMPING NOISE AND FOUND OUT IT WAS MY BELT BEING CHEWED UP BECAUSE THE POWER STEERING PUMP BRACKETS BROKE. *TR

Owner-reported narrative. Look up ODI 10351089 at NHTSA ↗

VEHICLE WAS DRIVEN AT HIGHWAY SPEED (55-60MPH) AND A LOUD METALLIC 'THUNK' NOISE WAS HEARD AS IF SOMETHING STRUCK OR BOUNCED OFF THE UNDERSIDE OF THE CAR. THE SERPENTINE DRIVE BELT WAS DISCOVERED TO HAVE COME OFF THE DRIVE PULLEYS, AND UPON CLOSER INSPECTION THE POWER STEERING PUMP WAS DISCOVERED TO BE LOOSE. THE UPPER MOUNTING EAR WAS BROKEN, AND THE LOWER MOUNTING BOLT WAS MISSING ENTIRELY. IT APPEARS THE BREAK IN THE UPPER MOUNTING EAR CAUSE THE LOWER BOLT TO VIBRATE LOOSE, AND IN TURN THE SERPENTINE DRIVE BELT WAS DISLODGED. THE RESULT …

Owner-reported narrative. 176,009 miles reported. Look up ODI 10392956 at NHTSA ↗