Blue Bird VISION recalls by model year

Reported: 2003-09-26 (September 26, 2003) · Model years: 2004

ON CERTAIN SCHOOL BUSES, THE POWER CABLES THAT RUN FROM THE STARTER TO THE POWER DISTRIBUTOR UNIT MAY CHAFE AGAINST THE BOTTOM CORNER OF THE FRONT FLOOR PANEL, RESULTING IN AN ELECTRICAL SHORT.

Consequence: AN ELECTRICAL SHORT COULD RESULT IN THE SHUT DOWN OF ENGINE PARTS OR RESULT IN AN UNDERHOOD FIRE.

Remedy: BLUE BIRD WILL PROVIDE OWNERS WITH PARTS AND INSTRUCTIONS TO INSTALL REVISED CABLE MOUNTING BRACKETS. OWNER NOTIFICATION BEGAN OCTOBER 23, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT BLUE BIRD AT 1-478-822-2242.

Reported: 2003-10-15 (October 15, 2003) · Model years: 2004

2004 MY BLUE BIRD VISION CONVENTIONAL TYPE SCHOOL BUSES MANUFACTURED FROM JUNE 12, 2003, THROUGH SEPTEMBER 24, 2003. THE BUS BAR THAT CONNECTS THE AMMETER SHUNT TO THE ENGINE INTAKE GRID HEATER MEGAFUSE WAS INCORRECTLY INSTALLED. THE IMPROPER INSTALLATION OF THIS BUS BAR CREATES EXCESSIVE ELECTRICAL RESISTANCE AND POTENTIAL OVERHEATING IN THE GRID HEATER POWER CIRCUIT.

Consequence: THIS ADDITIONAL RESISTANCE COULD RESULT IN OVERHEATING AT THE MEGAFUSE HOLDER WITH POTENTIAL FOR A FIRE.

Remedy: BLUE BIRD WILL NOTIFY ITS CUSTOMERS AND PROVIDE INSTRUCTIONS AND PARTS TO REPAIR THE BUSES FREE OF CHARGE. OWNER NOTIFICATION BEGAN ON OCTOBER 23, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT BLUE BIRD AT 478-822-2242.

Reported: 2003-12-04 (December 4, 2003) · Model years: 2004

ON CERTAIN CONVENTIONAL STYLE SCHOOL BUSES, ONLY THOSE EQUIPPPED WITH AIR BRAKES, THE UNDERHOOD FIREWALL LOCATION OF THE AIR BRAKE MANIFOLD MAY PERMIT RAINWATER ENTRY INTO THE PARKING BRAKE EXHAUST PORT FITTING OF THE MANIFOLD. IN FREEZING WEATHER, THIS WATER COULD FORM ICE BLOCKING THE EXHAUST PORT. WHEN THIS OCCURS, THE PARKING BRAKE DOES NOT OPERATE AS DESIGNED.

Consequence: IN THE EVENT THAT THIS CONDITION SHOULD OCCUR AND THE PARKING BRAKE FAILED TO APPLY, THE BUS COULD ROLL AWAY, RESULTING IN PROPERTY DAMAGE OR PERSONAL INJURY.

Remedy: DEALERS WILL MODIFY THESE VEHICLES. OWNER NOTIFICATION BEGAN ON DECEMBER 8, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT BLUE BIRD AT 1-478-822-2242.

Reported: 2004-08-30 (August 30, 2004) · Model years: 2004, 2005

CERTAIN BLUE BIRD 1999-2005 ALL AMERICAN, TC/2000, MICRO BIRD, VISION, CONVENTIONAL, AND COMMERCIAL SERIES SCHOOL BUSES EQUIPPED WITH SURE-LOC WHEELCHAIR SECUREMENT SYSTEMS AND MANUFACTURED BETWEEN FEBRUARY 17, 1999, AND AUGUST 13, 2004. CERTAIN SURE-LOK WHEELCHAIR TIE-DOWN SECUREMENT ASSEMBLIES P/N 8625-13. THE SPROCKET TEETH OF THE RETRACTOR ASSEMBLY MAY BE OUT OF ALIGNMENT CAUSING THE LOAD PAWL NOT TO FULLY SEAT IN THE SPROCKET TEETH.

Consequence: IN THE EVENT OF A VEHICLE CRASH, THE WHEELCHAIR MAY NOT BE ADEQUATELY SECURED POSSIBLY RESULTING IN INJURIES.

Remedy: BLUE BIRD WILL NOTIFY ITS CUSTOMERS AND REPLACE THE DEFECTIVE PART FREE OF CHARGE. THE RECALL BEGAN SEPTEMBER 21, 2004. OWNERS WHO TAKE THEIR BUSES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT AT BLUE BIRD AT 478-822-2242.

Reported: 2005-03-03 (March 3, 2005) · Model years: 2004, 2005

CERTAIN 2004-2006 MY BLUE BIRD VISION CONVENTIONAL SCHOOL AND NON SCHOOL BUSES MAUNFACTURED FROM JUNE 12, 2003, THROUGH FEBRUARY 22, 2005. A SHORT CAN OCCUR IN THE CROSSING ARM CIRCUIT OR THE 8-WAY WARNING LIGHT CIRCUIT, CAUSING THE HEAVY DUTY TRANSISTOR W/BUILT IN CIRCUIT PROTECT TO TRIP RESULTING IN AN INADVERTENT ENGINE SHUTDOWN.

Consequence: A VEHICLE CRASH COULD OCCUR SHOULD THE ENGINE SHUTDOWN WHILE THE BUS IS IN USE, POSSIBLY RESULTING IN INJURY OR DEATH.

Remedy: BLUE BIRD WILL NOTIFY ITS CUSTOMERS AND REPAIR THE BUSES BY RELOCATING THE CIRCUITS TO A SEPARATE CIRCUIT PROTECTED BY A CIRCUIT BREAKER FREE OF CHARGE. THE RECALL BEGAN ON MARCH 24, 2005. OWNERS MAY CONTACT BLUE BIRD AT 478-822-2242.

Reported: 2005-05-06 (May 6, 2005) · Model years: 2004, 2005, 2006

CERTAIN BLUE BIRD MY 2004-2006 VISION SCHOOL BUSES EQUIPPED WITH HYDRAULIC BRAKES MANUFACTURED BETWEEN MARCH 24, 2003, AND APRIL 25, 2005. THE HYDRAULIC BRAKE DASH WARNING LIGHT WAS INCORRECTLY LABELED WITH THE CANADIAN VERSION WHICH USES SYMBOLS RATHER THAN WORDS AS REQUIRED BY FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 105, HYDRAULIC AND ELECTRIC BRAKE SYSTEMS.

Consequence: THE ORIGINAL DASH WARNING LIGHT INDICATOR DISPLAYS AN INTERNATIONAL SYMBOL ON THE BRAKE WARNING LIGHT INDICATOR WHEREAS FMVSS 105 REQUIRES THE WORD "BRAKE" TO BE DISPLAYED. THE OPERATOR MAY NOT RECOGNIZE THE INTERNATIONAL SYMBOL AS WARNING INDICATING A PROBLEM IN THE HYDRAULIC BRAKE SYSTEM WHICH COULD RESULT IN A VEHICLE CRASH IF THE WARNING IS NOT HEEDED.

Remedy: BLUE BIRD WILL MAIL REPLACEMENT DECALS WITH CORRECT NOMENCLATURE FOR THE BRAKE DASH WARNING INDICATOR LIGHT. THE RECALL BEGAN JULY 15, 2005. OWNERS MAY CONTACT BLUE BIRD AT 478-822-2242.

Reported: 2005-05-20 (May 20, 2005) · Model years: 2004, 2005, 2006

CERTAIN SCHOOL BUSES ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN THE FOLLOWING STATES: ALASKA, COLORADO, CONNECTICUT, DELAWARE, IDAHO, ILLINOIS, INDIANA, IOWA, KANSAS, KENTUCKY, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, MONTANA, NEBRASKA, NEVADA, NEW HAMPSHIRE, NEW JERSEY, NEW MEXICO, NEW YORK, NORTH DAKOTA, OHIO, OREGON, PENNSYLVANIA, RHODE ISLAND, SOUTH DAKOTA, TENNESSEE, UTAH, VERMONT, VIRGINIA, WASHINGTON, WEST VIRGINIA, WISCONSIN, WYOMING, AND THE DISTRICT OF COLUMBIA. IN EXTREMELY COLD WEATHER, THE MICROSWITCHES USED INTERNALLY TO POSITION THE STOP ARM SIGN IN THE OPEN AND CLOSED POSITIONS MAY MALFUNCTION, CAUSING THE SIGN TO OPEN OR CLOSE IN AN IMPROPER POSITION, OR TO NOT OPEN AT ALL.

Consequence: SHOULD THE STOP ARM NOT PERFORM PROPERLY, A CHILD OR PEDESTRIAN MAY BE ENDANGERED BY PASSING VEHICLES SHOULD THE MOTORIST NOT STOP AT THE CORRECT LOCATION.

Remedy: BLUE BIRD WILL NOTIFY ITS CUSTOMERS AND REPLACE THE ORIGINAL SWITCH WITH A SWITCH PACK THAT IS NOT SENSITIVE TO EXTREME COLD WEATHER AND WILL INSPECT TO ENSURE THE MICROSWITCH HEATER WIRING IS PROPERLY CONNECTED FREE OF CHARGE. THE RECALL BEGAN ON AUGUST 12, 2005. OWNERS MAY CONTACT BLUE BIRD AT 478-822-2242.

Reported: 2005-05-20 (May 20, 2005) · Model years: 2004, 2005, 2006

CERTAIN BLUE BIRD 2002 THROUGH 2006 MY ALL AMERICAN, CONVENTIONAL, MINIBIRD, MICROBIRD, VISION, AND TC2000 SCHOOL BUSES ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN STATES OTHER THAN THE FOLLOWING STATES: ALASKA, COLORADO, CONNECTICUT, DELAWARE, IDAHO, ILLINOIS, INDIANA, IOWA, KANSAS, KENTUCKY, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, MONTANA, NEBRASKA, NEVADA, NEW HAMPSHIRE, NEW JERSEY, NEW MEXICO, NEW YORK, NORTH DAKOTA, OHIO, OREGON, PENNSYLVANIA, RHODE ISLAND, SOUTH DAKOTA, TENNESSEE, UTAH, VERMONT, VIRGINIA, WASHINGTON, WEST VIRGINIA, WISCONSIN, WYOMING, AND THE DISTRICT OF COLUMBIA. IN EXTREMELY COLD WEATHER, THE MICROSWITCHES USED INTERNALLY TO POSITION THE SIGN IN THE OPEN AND CLOSED POSITIONS MAY MALFUNCTION, CAUSING THE SIGN TO OPEN OR CLOSE IN AN IMPROPER POSITION, OR TO NOT OPEN AT ALL.

Consequence: SHOULD THE STOP ARM NOT PERFORM PROPERLY, A CHILD OR PEDESTRIAN MAY BE ENDANGERED BY PASSING MOTORISTS SHOULD THE MOTORIST NOT STOP AT THE CORRECT LOCATION.

Remedy: BLUE BIRD WILL NOTIFY ALL ITS CUSTOMERS OF THIS CAMPAIGN. FOR THOSE BUSES OPERATED IN OR NEAR ANY OF THE STATES LISTED ABOVE, BLUE BIRD IS ENCOURAGING THE BUS OWNERS TO OBTAIN THE REPLACEMENT SWITCH. FOR THOSE BUSES OPERATED IN THE WARMER STATES, BLUE BIRD WILL REPLACE THE SWITCH UPON OWNER REQUEST. FOR THOSE CUSTOMERS WHO REQUEST THE REMEDY, BLUE BIRD WILL REPLACE THE ORIGINAL SWITCH WITH A SWITCH PACK THAT IS NOT SENSITIVE TO EXTREME COLD WEATHER AND WILL INSPECT TO ENSURE THE MICROSWITCH HEATER WIRING IS PROPERLY CONNECTED. THE SAFETY IMPROVEMENT CAMPAIGN BEGAN ON AUGUST 12, 2005. OWNERS MAY CONTACT BLUE BIRD AT 478-822-2242.

Reported: 2005-08-31 (August 31, 2005) · Model years: 2004, 2005, 2006

CERTAIN 2001 THROUGH 2006 MY BLUE BIRD ALL AMERICAN, TC2000, AND VISION TRANSIT SCHOOL BUSES MANUFACTURED BETWEEN JANUARY 5, 2001, AND JULY 15, 2005. THESE BUSES ARE EQUIPPED WITH A BATTERY DISCONNECT SWITCH THAT HAS CONNECTIONS THAT MAY BE LOOSE ON THE BATTERY SWITCH STUDS CREATING THE POTENTIAL FOR THE BUS TO SHUT DOWN WHILE IN OPERATION.

Consequence: SHOULD THE BUS SHUT DOWN WHILE IN OPERATION, A VEHICLE CRASH COULD OCCUR.

Remedy: BLUE BIRD WILL NOTIFY ITS OWNERS AND INSTRUCT THEM ON HOW TO REPAIR THE SWITCH. THE RECALL BEGAN ON OCTOBER 19 , 2005. OWNERS MAY CONTACT BLUE BIRD AT 478-822-2242.

Reported: 2006-07-17 (July 17, 2006) · Model years: 2004, 2005, 2006, 2007

CERTAIN 2004-2007 MY VISION SCHOOL BUSES MANUFACTURED BETWEEN AUGUST 5, 2003, AND JUNE 13, 2006, EQUIPPED WITH OPTION 40280-02 AMMETER SHUNT. THE POWER CABLE ORIGINALLY INSTALLED BETWEEN THE TOE BOARD AND THE SHUNT MAY BE TOO SHORT AND MAY BREAK DUE TO ENGINE VIBRATION.

Consequence: SHOULD THE POWER CABLE BREAK WHILE THE BUS IS IN USE, THE BUS COULD BECOME STRANDED IN AN ACTIVE LANE WHICH COULD POSSIBLY RESULT IN A VEHICLE CRASH.

Remedy: BLUE BIRD WILL NOTIFY OWNERS AND REPLACE THE SHORT POWER CABLE WITH A LONGER ONE FREE OF CHARGE. THE RECALL BEGAN ON AUGUST 31, 2006. OWNERS MAY CONTACT BLUE BIRD AT 478-822-2242.

Reported: 2007-06-22 (June 22, 2007) · Model years: 2004, 2005, 2006, 2007

CERTAIN BLUE BIRD MY 2004 THROUGH 2007 VISION SCHOOL AND TRANSIT BUSES MANUFACTURED BETWEEN OCTOBER 9, 2003, AND SEPTEMBER 21, 2006, EQUIPPED WITH PARKER SINGLE CHECK VAVLES (SCV) PROVIDED BY BENDIX. THE DEFECT EXISTS IN THE PARKER SCV THAT CONNECTS WITH THE SUPPLY PORT OF THE SR-7 SPRING BRAKE MODULATING VALVE. AFTER PROLONGED USE OF THE PARKER SCV, THE VALVE BODY RETAINER MAY BECOME EXCESSIVELY WORN AND EVENTUALLY BREAK APART. PIECES OF THE PARKER SCV CAN BECOME LODGED INSIDE THE SR-7 SPRING BRAKE MODULATING VALVE, POTENTIALLY CAUSING EITHER LEAKAGE OUT OF THE SR-7 VALVE OR PREVENTING AIR FROM PROPERLY EXHAUSTING FROM THE SR-7 VALVE.

Consequence: THIS CONDITION CAN CAUSE A DELAY IN THE APPLICATION OF THE SPRING BRAKES TO PARK THE VEHICLE AFTER THE OPERATOR PULLS THE DASH VALVE BUTTON. THESE CONDITIONS CAN OCCUR WITHOUT WARNING, LEADING TO UNINTENDED VEHICLE ROLLAWAY, BRAKE DRAG, OR IN THE CASE OF LOSS OF PRIMARY CIRCUIT, INABILITY TO MODULATE THE SPRING BRAKES.

Remedy: BLUE BIRD WILL NOTIFY OWNERS AND PROVIDE A FREE REMEDY. THE RECALL BEGAN ON SEPTEMBER 30, 2007. OWNERS CAN CONTACT BLUE BIRD AT 478-822-2242.

Reported: 2008-07-11 (July 11, 2008) · Model years: 2004, 2005, 2006, 2007, 2008, 2009

THE HYDRAULIC BRAKE HOSES FROM THE MASTER CYLINDER TO THE CHASSIS FRAME MAY HAVE BEEN IMPROPERLY ROUTED OR RETAINED ON CERTAIN 2004 THROUGH 2009 MY BLUE BIRD VISION CONVENTIONAL SCHOOL AND TRANSIT BUSES MANUFACTURED FROM JANUARY 11, 2004 THROUGH APRIL 22, 2008.

Consequence: IMPROPER ROUTING OR RETENTION OF THE HYDRAULIC BRAKE HOSES MAY RESULT IN BRAKE HOSES CHAFFING AGAINST THE BUS BODY AND/OR CHASSIS COMPONENTS WHICH COULD CAUSE A LEAK IN THE HYDRAULIC BRAKE SYSTEM RESULTING IN REDUCED BRAKING CAPACITY WHICH COULD RESULT IN A CRASH.

Remedy: BLUE BIRD WILL NOTIFY OWNERS AND INSPECT AND REPAIR THE BUSES FREE OF CHARGE. THE RECALL BEGAN ON AUGUST 8, 2008. OWNERS MAY CONTACT BLUE BIRD AT 1-478-822-2242.

Reported: 2009-08-13 (August 13, 2009) · Model years: 2004, 2005, 2006, 2007, 2008, 2009, 2010

BLUE BIRD IS RECALLING CERTAIN MODEL YEAR 2004 THROUGH 2010 ALL AMERICAN, VISION, MICRO BIRD, AND CONVENTIONAL SCHOOL BUSES MANUFACTURED BETWEEN JANUARY 30, 2003 AND MAY 7, 2009. INCORRECT OFFSET LEG BARRIER PADS OR 2/3 SEAT BACK PADS MAY HAVE BEEN INSTALLED. BUSES WITH INCORRECT PADS INSTALLED FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 222, "SCHOOL BUS PASSENGER SEATING AND CRASH PROTECTION."

Consequence: IN THE EVENT OF A CRASH, THERE IS AN INCREASED RISK OF INJURY TO THE SEAT OCCUPANT(S).

Remedy: BLUE BIRD WILL NOTIFY OWNERS AND THE BUSES WILL BE REPAIRED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON SEPTEMBER 18, 2009. OWNERS MAY CONTACT BLUE BIRD AT 1-478-822-2242.

Reported: 2010-04-23 (April 23, 2010) · Model years: 2004, 2005, 2006, 2007, 2008, 2009

BLUE BIRD IS RECALLING CERTAIN MODEL YEAR 2004 THROUGH 2009 VISION SCHOOL BUSES MANUFACTURED FROM JANUARY 30, 2003 THROUGH SEPTEMBER 24, 2008. THE POWER CABLES RUNNING TO THE POWER DISTRIBUTION UNIT STUD AND DRIVER'S CONTROL MODULE STUD MAY HAVE BEEN INSTALLED WITH THE LUG (EYELET) FLAT SIDE UP. WHEN THIS CONDITION EXISTS, VIBRATION MAY WEAR THE INSULATION PERMITTING DIRECT CONTACT BETWEEN THE BARE LUG AND THE PDU OR DCM WHICH COULD CAUSE A DIRECT SHORT IN THE ELECTRICAL SYSTEM.

Consequence: THIS CONDITION COULD RESULT IN A FIRE.

Remedy: BLUE BIRD WILL NOTIFY OWNERS AND REPAIR THE BUSES AS NECESSARY FREE OF CHARGE. THE SAFETY RECALL BEGAN MAY 26, 2020. OWNERS MAY CONTACT BLUE BIRD AT 1-478-822-2242.

Reported: 2010-04-23 (April 23, 2010) · Model years: 2004, 2005, 2006, 2007, 2008, 2009

BLUE BIRD IS RECALLING CERTAIN MODEL YEAR 2004 THROUGH 2009 VISION NON-SCHOOL BUSES MANUFACTURED FROM SEPTEMBER 19, 2003 THROUGH JULY 2, 2008. THE POWER CABLES RUNNING TO THE POWER DISTRIBUTION UNIT STUD AND DRIVER'S CONTROL MODULE STUD MAY HAVE BEEN INSTALLED WITH THE LUG (EYELET) FLAT SIDE UP. WHEN THIS CONDITION EXISTS, VIBRATION MAY WEAR THE INSULATION PERMITTING DIRECT CONTACT BETWEEN THE BARE LUG AND THE PDU OR DCM WHICH COULD CAUSE A DIRECT SHORT IN THE ELECTRICAL SYSTEM.

Consequence: THIS CONDITION COULD RESULT IN A FIRE.

Remedy: BLUE BIRD WILL NOTIFY OWNERS AND REPAIR THE BUSES AS NECESSARY FREE OF CHARGE. THE SAFETY RECALL BEGAN ON MAY 26, 2020. OWNERS MAY CONTACT BLUE BIRD AT 1-478-822-2242.

Reported: 2011-04-06 (April 6, 2011) · Model years: 2004, 2005, 2006

BLUE BIRD IS RECALLING CERTAIN MODEL YEAR 2004 THROUGH 2006 VISION CONVENTIONAL STYLE SCHOOL BUSES MANUFACTURED FROM JUNE 26, 2003, THROUGH DECEMBER 9, 2004. THE STARTER CABLE MAY CONTACT AND POTENTIALLY CHAFE AGAINST THE STEEL BRAIDED POWER STEERING HOSE THEREBY CREATING A DIRECT SHORT.

Consequence: A SHORT COULD RESULT IN A FIRE.

Remedy: BLUE BIRD WILL NOTIFY OWNERS AND DEALERS WILL INSPECT THE SUBJECT BUSES FOR PROPER CLEARANCE BETWEEN THE STARTER CABLE AND THE POWER STEERING HOSE. BUSES FOUND TO HAVE INSUFFICIENT CLEARANCE WILL HAVE A CLAMP INSTALLED TO PREVENT FURTHER CONTACT. ANY DAMAGED POWER STEERING HOSES OR STARTER CABLES WILL BE REPLACED FREE OF CHARGE. THE SAFETY RECALL IS EXPECTED TO BEGIN ON OR ABOUT MAY 10, 2011. OWNERS MAY CONTACT BLUE BIRD AT 1-478-822-2242.

Reported: 2011-04-06 (April 6, 2011) · Model years: 2004, 2005, 2006

BLUE BIRD IS RECALLING CERTAIN MODEL YEAR 2004 THROUGH 2006 VISION CONVENTIONAL STYLE NON SCHOOL BUSES MANUFACTURED FROM JUNE 26, 2003, THROUGH DECEMBER 9, 2004. THE STARTER CABLE MAY CONTACT AND POTENTIALLY CHAFE AGAINST THE STEEL BRAIDED POWER STEERING HOSE THEREBY CREATING A DIRECT SHORT.

Consequence: A SHORT COULD RESULT IN A FIRE.

Remedy: BLUE BIRD WILL NOTIFY OWNERS AND DEALERS WILL INSPECT THE SUBJECT BUSES FOR PROPER CLEARANCE BETWEEN THE STARTER CABLE AND THE POWER STEERING HOSE. BUSES FOUND TO HAVE INSUFFICIENT CLEARANCE WILL HAVE A CLAMP INSTALLED TO PREVENT FURTHER CONTACT. ANY DAMAGED POWER STEERING HOSES OR STARTER CABLES WILL BE REPLACED FREE OF CHARGE. THE SAFETY RECALL IS EXPECTED TO BEGIN ON OR ABOUT MAY 10, 2011. OWNERS MAY CONTACT BLUE BIRD AT 1-478-822-2242.

Reported: 2008-05-20 (May 20, 2008) · Model years: 2005, 2006, 2007, 2008, 2009

BLUE BIRD IS RECALLING 23,464 MY 2005 THROUGH 2009 ALL AMERICAN AND VISION SCHOOL AND TRANSIT MODEL BUSES MANUFACTURED FROM JANUARY 22, 2004, AND MARCH 28, 2008, AND MY 2004 THROUGH 2007 ALL AMERICAN SCHOOL BUSES AND CONVENTIONAL MODEL SCHOOL BUSES MANUFACTURED FROM MARCH 6, 2003, THROUGH JUNE 16, 2006. THE RIVET PATTERN MAY BE INCORRECT IN SECTIONS OF THE REAR ROOF SHEET JOINT THAT ATTACHES TO THE REAR ROOF CAP. WITHOUT THE APPROPRIATE AMOUNT OF ROOF RIVETS, THE BUSES FAIL TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO 221, "JOINT STRENGTH."

Consequence: IN THE EVENT OF A CRASH, THESE PANELS MAY SEPARATE EXPOSING THE OCCUPANTS TO INCREASED RISK OF INJURY.

Remedy: BLUE BIRD WILL NOTIFY OWNERS AND INSPECT AND REPAIR THE BUSES BY ADDING ADDITIONAL RIVETS. THE RECALL BEGAN ON SEPTEMBER 18, 2008. OWNERS MAY CONTACT BLUE BIRD AT 478-822-2242.

Reported: 2005-05-09 (May 9, 2005) · Model years: 2006

CERTAIN MY 2006 BLUE BIRD ALL AMERICAN AND VISION SCHOOL BUSES MANUFACTURED BETWEEN FEBRUARY 9 AND APRIL 15, 2005. SEAT SPACING IN FRONT OF THE SIDE EMERGENCY DOOR FLIP UP SEAT EXCEEDS THE MAXIMUM ALLOWED SPACING AS REQUIRED BY FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 222, SCHOOL BUS PASSENGER SEATING AND CRASH PROTECTION.

Remedy: ALL THE AFFECTED BUSES HAVE BEEN REPAIRED BY BLUE BIRD DISTRIBUTORS. THEREFORE, IT WILL NOT BE NECESSARY FOR BLUE BIRD TO MAIL OUT OWNER NOTIFICATION LETTERS TO CUSTOMERS.

Reported: 2006-04-11 (April 11, 2006) · Model years: 2006

CERTAIN MY 2006 ALL AMERICAN SCHOOL AND TRANSIT BUSES AND 2006 CONVENTIONAL VISION SCHOOL BUSES MANUFACTURED BETWEEN JULY 7 AND NOVEMBER 8, 2005, EQUIPPED WITH RICON S AND K SERIES PLATFORM STYLE WHEELCHAIR LIFTS . THE VERTICAL SUPPORT ARMS FOR THE LIFTS WERE IMPROPERLY WELDED ALLOWING THE LIFT TO STOW IMPROPERLY.

Consequence: IN THE EVENT THIS CONDITION OCCURS DURING PASSENGER OPERATIONS IT MAY NOT BE POSSIBLE TO CLOSE THE LIFT DOOR CAUSING THE VEHICLE INTERLOCKS TO REMAIN ENGAGED PREVENTING MOVEMENT OF THE VEHICLE OR THE ABILITY TO LOAD OR UNLOAD PASSENGERS WITH DISABILITIES FROM THE VEHICLE.

Remedy: BLUE BIRD WILL NOTIFY ITS CUSTOMERS AND REPAIR THE BUSES FREE OF CHARGE. THE RECALL BEGAN ON MAY 5, 2006. OWNERS MAY CONTACT BLUE BIRD AT 478-822-2242.

Reported: 2011-10-14 (October 14, 2011) · Model years: 2006, 2007, 2008, 2009, 2010, 2011

BLUE BIRD IS RECALLING CERTAIN MODEL YEAR 2006 THROUGH 2012 ALL AMERICAN, 2006 THROUGH 2011 VISION, AND 2006 CONVENTIONAL SCHOOL BUSES MANUFACTURED BETWEEN SEPTEMBER 19, 2005, AND MAY 3, 2011, EQUIPPED WITH 2-PASSENGER SEATS INSTALLED FORWARD OF THE 39" BARRIER. IN THE EVENT OF A CRASH, THE BARRIER MAY MAKE CONTACT WITH THE 2-PASSENGER SEAT INSTALLED FORWARD OF THE BARRIER. ACCORDINGLY, THESE BUSES FAIL TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 222, "SCHOOL BUS PASSENGER SEATING AND CRASH PROTECTION."

Consequence: THE SEAT OCCUPANTS MAY BE SERIOUSLY INJURED IN THE EVENT OF A CRASH.

Remedy: BLUE BIRD WILL NOTIFY OWNERS, AND DEALERS WILL REPAIR THE BUSES FREE OF CHARGE. THE SAFETY RECALL BEGAN ON JANUARY 18, 2012. OWNERS MAY CONTACT BLUE BIRD AT 1-478-822-2242.

Reported: 2020-04-27 (April 27, 2020) · Model years: 2006, 2007, 2008, 2009, 2010, 2011, 2012, 2013, 2014, 2015, 2016, 2017, 2018, 2019

Blue Bird Body Company (Blue Bird) is recalling certain 2006-2021 Vision and 2007-2013 All American school buses. The floor-mounted parking brake may fail to hold the vehicle stationary on an incline when the vehicle is loaded to its maximum weight, due to an insufficient application force. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 105, "Hydraulic and Electric Brake Systems."

Consequence: A parking brake system that is set to an insufficient application force may result in an increased possibility of unintended vehicle movement, which increases the risk of a crash.

Remedy: Blue Bird will notify owners, and dealers will inspect the floor mounted park brake application force hand lever assembly and correct the application force, as necessary, free of charge. The recall is expected to begin June 24, 2020. Owners may contact Blue Bird customer service at 478-822-2242. Blue Bird's number for this recall is R20AO-SB.

Reported: 2006-06-08 (June 8, 2006) · Model years: 2007

CERTAIN 2007 VISION SCHOOL BUSES EQUIPPED WITH BENDIX AIR BRAKES MANUFACTURED BETWEEN APRIL 7 AND MAY 26, 2006. THE CHECK VALVE INSIDE THE VALVE CAVITY MAY NOT PROPERLY SEAT, CAUSING INTERNAL AIR LEAKAGE. THIS CAN CAUSE A DELAY IN THE APPLICATION OF THE SPRING BRAKE TO PARK THE VEHICLE AFTER THE OPERATOR PULLS THE DASH VALVE BUTTON.

Consequence: THE DELAYED PARKING BRAKE APPLICATION CAN OCCUR WITHOUT WARNING, LEADING TO UNINTENDED VEHICLE ROLLAWAY, POSSIBLY RESULTING IN A VEHICLE CRASH, PERSONAL INJURY, OR DEATH.

Remedy: BLUE BIRD WILL NOTIFY OWNERS AND REPLACE THE BRAKE VALVE FREE OF CHARGE. THE RECALL BEGAN ON AUGUST 31, 2006. OWNERS CAN CONTACT BLUE BIRD AT 478-822-2242.

Reported: 2006-09-13 (September 13, 2006) · Model years: 2007

CERTAIN MY 2007 BLUE BIRD VISION SCHOOL BUSES EQUIPPED WITH AIR BRAKES MANUFACTURED FROM AUGUST 17 THROUGH SEPTEMBER 5, 2006. AN INCORRECT FITTING WAS DESIGNED INTO THE SUBASSEMBLY FOR THE REAR AXLE BRAKE VALVE MODULE. A STANDARD 90 DEGREE ELBOW WAS USED WHERE A 90 DEGREE CHECK VALVE SHOULD HAVE BEEN USED. THESE BUSES FAIL TO CONFORM TO THE BLEED DOWN REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 121, "BRAKE SYSTEMS.

Consequence: IN THE EVENT OF A CATASTROPHIC LINE FAILURE, THE EMERGENCY BRAKES WILL APPLY WITHOUT WARNING, POSSIBLY RESULTING IN A VEHICLE CRASH.

Remedy: BLUE BIRD WILL NOTIFY OWNERS AND REPAIR THE BUSES FREE OF CHARGE. THE RECALL BEGAN ON SEPTEMBER 29, 2006. OWNERS MAY CONTACT BLUE BIRD AT 478-822-2242.

Reported: 2007-01-29 (January 29, 2007) · Model years: 2007, 2008

CERTAIN 2007 AND 2008 MY BLUE BIRD VISION SCHOOL BUSES MANUFACTURED BETWEEN OCTOBER 16, 2006, AND JANUARY 18, 2007. CONTINUOUS RESETTING OF THE CIRCUIT BREAKER WHEN THE WIPER/WASHER IS OPERATING IN THE WASH/WIPE MODE MAY CAUSE FAILURE IN THE WIRING CIRCUIT RESULTING IN POWER BEING APPLIED TO THE GROUND WHICH COULD CAUSE THE CIRCUIT BREAKER TO OVERHEAT AND FAIL RESULTING IN A STALLED WIPER.

Consequence: FAILURE OF THE WIPER IN INCLEMENT WEATHER CONDITIONS MAY CAUSE A VEHICLE CRASH, POSSIBLY RESULTING IN PROPERTY DAMAGE, PERSONAL INJURY OR DEATH.

Remedy: BLUE BIRD WILL NOTIFY OWNERS AND REPAIR THE BUSES FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN ON FEBRUARY 28, 2007. OWNERS CAN CONTACT BLUE BIRD AT 478-822-2242.

Reported: 2007-02-08 (February 8, 2007) · Model years: 2007, 2008

CERTAIN BLUE BIRD 2007 AND 2008 VISION SCHOOL BUSES MANUFACTURED BETWEEN FEBRUARY 9 AND OCTOBER 27, 2006. THE LIFT INNER BARRIER INTERLOCK SWITCH SYSTEM MAY NOT DETECT THE PRESENCE OF A PASSENGER ON THE INNER BARRIER AND ALLOW THE PLATFORM TO MOVE DOWN MORE THAN ONE INCH BELOW FLOOR LEVEL WHILE OCCUPIED WHICH DOES NOT CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 403, PLATFORM LIFT SYSTEMS FOR MOTOR VEHICLES.

Consequence: IN THE EVENT THIS CONDITION OCCURS DURING PASSENGER OPERATIONS IT MAY BE POSSIBLE FOR THE WHEELCHAIR LIFT TO TIP BACKWARDS ONTO THE PLATFORM IF THE USER IS BACKING ONTO THE LIFT FROM INSIDE THE VEHICLE AND HAS THE SMALL FRONT WHEELS FULLY OR PARTIALLY ON THE INNER BARRIER WHEN THE PLATFORM WAS LOWERED. A STANDEE COULD LOOSE HIS OR HER BALANCE IF THEY WERE POSITIONED FULLY OR PARTLY ON THE INNER BARRIER WHEN THE PLATFORM IS LOWERED. EITHER CONDITION COULD CAUSE PERSONAL INJURY.

Remedy: BLUE BIRD IS WORKING WITH RICON TO REPAIR THE BUSES FREE OF CHARGE (PLEASE SEE 06E101). THE RECALL IS EXPECTED TO BEGIN ON OR ABOUT FEBRUARY 26, 2007. OWNERS CAN CONTACT BLUE BIRD AT 478-822-2242.

Reported: 2007-06-26 (June 26, 2007) · Model years: 2007, 2008

CERTAIN MY 2007 AND 2008 BLUE BIRD VISION AND ALL AMERICAN SCHOOL AND TRANSIT BUSES MANUFACTURED BETWEEN DECEMBER 1, 2005, AND MAY 24, 2007, AND EQUIPPED WITH BENDIX SR-7 SPRING BRAKE MODULATING VALVES. THE INTERNAL RUBBER CHECK VALVE MAY LEAK CAUSING A DELAY IN THE APPLICATION OF THE SPRING BRAKES TO PARK THE VEHICLE AFTER THE OPERATOR PULLS THE DASH VALVE BUTTON.

Consequence: THE DELAYED PARKING BRAKE APPLICATION CAN OCCUR WITHOUT WARNING, LEADING TO UNINTENDED VEHICLE ROLLAWAY.

Remedy: BLUE BIRD WILL NOTIFY OWNERS AND PROVIDE A FREE REMEDY. THE RECALL BEGAN ON SEPTEMBER 30, 2007. OWNERS CAN CONTACT BLUE BIRD AT 478-822-2242.

Reported: 2009-02-17 (February 17, 2009) · Model years: 2007, 2008

BLUE BIRD IS RECALLING 4,591 MY 2007 AND 2008 VISION CONVENTIONAL SCHOOL BUSES MANUFACTURED FROM MARCH 29, 2006 THROUGH DECEMBER 3, 2007, EQUIPPED WITH CATERPILLAR C7 ENGINES. THE MAIN BATTERY POWER CABLE MAY CHAFE AGAINST THE ENGINE COMPONENTS AT THE REAR OF THE ENGINE.

Consequence: CHAFING OF THE CABLE CAN RESULT IN A DIRECT SHORT WITH POTENTIAL FOR FIRE.

Remedy: BLUE BIRD WILL NOTIFY OWNERS AND INSPECT AND CORRECT THE BUSES FREE OF CHARGE. THE RECALL BEGAN ON APRIL 2, 2009. OWNERS MAY CONTACT BLUE BIRD AT 1-478-822-2242.

Reported: 2011-03-15 (March 15, 2011) · Model years: 2007, 2008, 2009, 2010, 2011

BLUE BIRD IS RECALLING CERTAIN MODEL YEAR 2007 THROUGH 2011 VISION SCHOOL BUSES. THE DASH INSTRUMENT PANEL ABS INDICATOR LIGHT DOES NOT ILLUMINATE WHEN THE ABS CIRCUIT IS DISCONNECTED AT THE MAIN ABS MODULE. ACCORDINGLY, THESE BUSES FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 105, "HYDRAULIC AND ELECTRIC BRAKE SYSTEMS," AND FMVSS NO. 121, "AIR BRAKE SYSTEMS."

Consequence: IN THE EVENT THE ABS CIRCUIT DISCONNECTS FROM THE MAIN ABS MODULE, THE BUS OPERATOR WOULD BE UNAWARE OF THE FAILURE OF THE ABS SYSTEM AND THE ASSOCIATED REDUCED BRAKING FUNCTION, INCREASING THE RISK OF A CRASH.

Remedy: BLUE BIRD IS CURRENTLY WORKING WITH STONERIDGE TO PRODUCE SOFTWARE THAT DEALERS CAN USE TO REPROGRAM THE DASH INSTRUMENT PANEL. BLUE BIRD WILL NOTIFY OWNERS ONCE THE SOFTWARE UPDATE BECOMES AVAILABLE. THE AFFECTED BUSES WILL BE REPAIRED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON JUNE 23, 2011. OWNERS MAY CONTACT BLUE BIRD AT 1-478-822-2242.

Reported: 2013-07-31 (July 31, 2013) · Model years: 2007, 2008, 2009, 2010, 2011, 2012, 2013, 2014

Blue Bird Body Company is recalling certain model year 2007-2014 All American and Vision school buses manufactured March 10, 2006, through June 18, 2013; and equipped with optional transit sliding windows. Joint adhesive may not have been applied at the interior and exterior body window panel joints. Without the adhesive, these vehicles fail to conform to the standards of Federal Motor Vehicle Safety Standard (FMVSS) No. 221, "School Bus Body Joint Strength."

Consequence: In the event of a vehicle crash, there is an increased risk that the window panels may separate and fall onto occupants causing injury.

Remedy: Blue Bird will notify owners, and dealers will install additional rivets at the window panel joints, free of charge. The recall began on August 28, 2013. Owners may contact Blue Bird at 1-478-825-2021. Blue Bird's recall number is R13WM.

Reported: 2014-08-19 (August 19, 2014) · Model years: 2007, 2008, 2009, 2010, 2011, 2012, 2013, 2014, 2015

Blue Bird Body Company (Blue Bird) is recalling certain model year 2007-2015 All American and Vision, 2007-2011 Micro Bird, and 2007-2008 Conventional school buses equipped with certain model S2005, S2010, S5005, S5010, S5505, and S5510 wheelchair lifts manufactured by Ricon Corporation. The platform side plate of the affected wheelchair lifts may crack.

Consequence: If the platform side plates crack, the lift platform can separate from the lift and come to rest against the vehicle's lift door. When the doors are opened, the platform may fall out, increasing the risk of injury to the lift operator.

Remedy: Blue Bird will notify owners to take buses to a Ricon dealer or service center who will install supplemental platform support bumpers. Any platform that has already started cracking will be replaced, free of charge. The recall began on October 1, 2014. Owners may contact Blue Bird customer service at 1-478-822-2242 or Ricon customer service at 1-800-322-2884. Blue Bird's number for this recall is R14XN.

Reported: 2014-08-19 (August 19, 2014) · Model years: 2007, 2008, 2009, 2010, 2011, 2012, 2013, 2014

Blue Bird Body Company (Blue Bird) is recalling certain model year 2007-2015 All American, 2007-2010 Micro Bird, and 2007-2014 Vision non-school buses equipped with certain model S2005, S2010, S5005, S5010, S5505, and S5510 wheelchair lifts manufactured by Ricon Corporation. The platform side plate of the affected wheelchair lifts may crack.

Consequence: If the platform side plates crack, the lift platform can separate from the lift and come to rest against the vehicle's lift door. When the doors are opened, the platform may fall out, increasing the risk of injury to the lift operator.

Remedy: Blue Bird will notify owners to take buses to a Ricon dealer or service center who will install supplemental platform support bumpers. Any platform that has already started cracking will be replaced, free of charge. The recall began on October 1, 2014. Owners may contact Blue Bird customer service at 1-478-822-2242 or Ricon customer service at 1-800-322-2884. Blue Bird's number for this recall is R14XN.

Reported: 2015-11-04 (November 4, 2015) · Model years: 2007, 2008, 2009, 2010, 2011, 2012, 2013, 2014, 2015

Blue Bird Body Company (Blue Bird) is recalling certain model year 2007-2015 All American, Vision, 2007-2011 Micro Bird, and 2007-2008 Conventional school buses, equipped with certain model S2005, S2010, S5005, S5010, S5505, and S5510 wheelchair lifts manufactured January 1, 2006, to August 25, 2014 by the Ricon Corporation. The affected lifts are equipped with folding link arms that may have pivot holes that are too big, allowing the bearings to move out of position.

Consequence: If the bearings move out of position, the stowed platform may have excessive movement resulting in failure of the platform mounting. This failure could cause the wheel chair lift platform to fall out of the vehicle when the doors are opened, increasing the risk of injury for the lift operator.

Remedy: Blue Bird will notify owners, and Ricon dealers will inspect the link arms for damage or for displaced bearings. The platform will be inspected for cracks. Any damaged parts will be replaced, free of charge. The recall began on December 1, 2015. Owners may contact Blue Bird customer service at 1-478-822-2242, or Ricon Customer Service at 1-800-322-2884.

Reported: 2015-11-04 (November 4, 2015) · Model years: 2007, 2008, 2009, 2010, 2011, 2012, 2013, 2014, 2015

Blue Bird Body Company (Blue Bird) is recalling certain model year 2007-2015 All American and Vision and 2007-2011 Micro Bird transit buses equipped with certain model S2005, S2010, S5005, S5010, S5505, and S5510 wheelchair lifts manufactured January 1, 2006, to August 25, 2014 by the Ricon Corporation. The affected lifts are equipped with folding link arms that may have pivot holes that are too big, allowing the bearings to move out of position.

Consequence: If the bearings move out of position, the stowed platform may have excessive movement resulting in failure of the platform mounting. This failure could cause the wheel chair lift platform to fall out of the vehicle when the doors are opened, increasing the risk of injury for the lift operator.

Remedy: Blue Bird will notify owners, and Ricon dealers will inspect the link arms for damage or for displaced bearings. The platform will be inspected for cracks. Any damaged parts will be replaced, free of charge. The recall began on December 1, 2015. Owners may contact Blue Bird customer service at 1-478-822-2242, or Ricon Customer Service at 1-800-322-2884.

Reported: 2006-12-06 (December 6, 2006) · Model years: 2008

CERTAIN 2008 BLUE BIRD VISION SCHOOL BUSES BUILT FROM OCTOBER 23 THROUGH NOVEMBER 21, 2006. A TEMPORARY BOLT WAS USED TO SECURE THE STEERING WHEEL DURING THE MANUFACTURING PROCESS. THE TEMPORARY BOLT WAS TO BE REMOVED AND REPLACED WITH A PERMANENT BOLT WITH A LOCK COATING DURING THE FINAL ASSEMBLY STAGE. THE TEMPORARY BOLT WAS NOT REMOVED AND REPLACED ON THE SUBJECT UNITS, BUT INSTEAD THE BOLT WAS REUSED.

Consequence: REUSE OF THE ATTACHING SCREW COULD ALLOW THE STEERING WHEEL TO LOOSEN DURING OPERATION WHICH COULD RESULT IN A VEHICLE CRASH CAUSING INJURY OR DEATH TO OCCUPANTS.

Remedy: BLUE BIRD WILL NOTIFY OWNERS AND REPAIR THE BUSES BY REPLACING THE SCREW WITH A NEW ATTACHING SCREW FREE OF CHARGE. THE RECALL BEGAN ON DECEMBER 11, 2006. OWNERS MAY CONTACT BLUE BIRD AT 478-822-2242.

Reported: 2007-08-03 (August 3, 2007) · Model years: 2008

CERTAIN BLUE BIRD MY 2008 ALL AMERICAN AND VISION SCHOOL BUSES MANUFACTURED BETWEEN JUNE 6 AND JULY 27, 2007. A FUEL PUMP FAILURE WILL DILUTE THE ENGINE OIL WITH FUEL AND CAUSE LOSS OF THROTTLE CONTROL AND EXCESSIVE SMOKE.

Consequence: EITHER CONDITION COULD RESULT IN A VEHICLE CRASH.

Remedy: BLUE BIRD IS WORKING IN CONJUNCTION WITH CATERPILLAR TO NOTIFY OWNERS TO CONTACT THEIR LOCAL CATERPILLAR DEALER FOR A FREE REMEDY. THE RECALL IS EXPECTED TO BEGIN DURING AUGUST 2007. OWNERS CAN CONTACT CATERPILLAR AT 1-800-447-4986 OR BLUE BIRD AT 478-822-2242.

Reported: 2007-09-07 (September 7, 2007) · Model years: 2008

CERTAIN 2008 BLUE BIRD VISION SCHOOL BUSES MANUFACTURED FROM JUNE 6 THROUGH SEPTEMBER 4, 2007. THE OIL FILL CAP MAY SEPARATE FROM THE OIL FILL TUBE ALLOWING ENGINE OIL TO BE EMITTED FROM THE TUBE. OIL COULD WET THE LEFT FRONT BRAKE SHOES/PADS RESULTING IN REDUCED BRAKING CAPACITY.

Consequence: A VEHICLE CRASH COULD OCCUR.

Remedy: BLUE BIRD IS ADVISING THE OWNERS TO REMOVE THEIR BUSES FROM SERVICE UNTIL THEY HAVE THE BUSES REPAIRED AND TO CONTACT A CATERPILLAR DEALER FOR AN INTERIM REPAIR. THE INTERIM REPAIR CONSISTS OF INSTALLING TWO SCREWS THROUGH THE OIL FILL TUBE TO RETAIN THE OIL FILL CAP IN PLACE. CATERPILLAR WILL ISSUE A SEPARATE RECALL NOTIFICATION LETTER TO OWNERS ON OR ABOUT SEPTEMBER 17, 2007 THAT WILL INSTRUCT OWNERS TO CONTACT A CATERPILLAR DEALER TO SCHEDULE AN APPOINTMENT TO HAVE A NEW OIL FILL TUBE INSTALLED AS A PERMANENT REMEDY. THE RECALL BEGAN ON SEPTEMBER 7, 2007. OWNERS CAN CONTACT BLUE BIRD AT 478-822-2242 OR CATERPILLAR AT 800-447-4986.

Reported: 2008-07-10 (July 10, 2008) · Model years: 2008, 2009

A PLUG ON THE OUTLET SIDE OF THE FUEL PUMP CAN CRACK ON CERTAIN 2008 AND 2009 MY BLUE BIRD ALL AMERICAN AND VISION SCHOOL BUSES MANUFACTURED FROM MAY 23, 2007 THROUGH JULY 4, 2008, EQUIPPED WITH CATERPILLAR C7 ENGINES.

Consequence: A CRACK IN THIS PLUG CAN RESULT IN A HIGH PRESSURE FUEL SPRAY OR LEAK WHICH, IN THE PRESENCE OF AN IGNITION SOURCE, COULD RESULT IN A FIRE.

Remedy: BLUE BIRD IS WORKING IN CONJUNCTION WITH CATERPILLAR TO NOTIFY OWNERS TO CONTACT THEIR LOCAL CATERPILLAR DEALER FOR A FREE REMEDY. THE RECALL IS EXPECTED TO BEGIN DURING JULY 2008. OWNERS CAN CONTACT CATERPILLAR AT 1-800-447-4986 OR BLUE BIRD AT 1-478-822-2242.

Reported: 2009-03-09 (March 9, 2009) · Model years: 2008, 2009

BLUE BIRD IS RECALLING 3,419 MY 2008 AND 2009 VISION CONVENTIONAL SCHOOL BUSES MANUFACTURED FROM JANUARY 18, 2007 THROUGH OCTOBER 29, 2008, EQUIPPED WITH CATERPILLAR C7 AND C7 07 ENGINES. INCORRECT BOLTS AND/OR SPACERS MAY HAVE BEEN INSTALLED TO ATTACH THE FAN BLADE TO THE FAN CLUTCH.

Consequence: AS A RESULT, THE FAN BLADE MAY SEPARATE FROM THE CLUTCH AND POTENTIALLY CAUSE PROPERTY DAMAGE OR PERSONAL INJURY TO PERSONS IN OR NEAR THE FRONT OF THE BUS. THE VEHICLE SHOULD NOT BE SERVICED WITH THE HOOD OPEN AND THE ENGINE RUNNING UNTIL THE BOLTS/SPACERS HAVE BEEN INSPECTED AND, IF NEEDED, REPLACED.

Remedy: BLUE BIRD WILL NOTIFY OWNERS AND DEALERS WILL REPAIR THE BUSES FREE OF CHARGE. THE SAFETY RECALL BEGAN ON APRIL 7, 2009. OWNERS MAY CONTACT BLUE BIRD AT 1-478-822-2242.

Reported: 2009-07-06 (July 6, 2009) · Model years: 2008, 2009, 2010

BLUE BIRD IS RECALLING 69 MODEL YEAR 2008 THROUGH 2010 MICRO BIRD AND VISION SCHOOL BUSES MANUFACTURED FROM SEPTEMBER 29, 2007 THROUGH MAY 2, 2009, EQUIPPED WITH OPTIONAL 34 INCH OFFSET BARRIER. THE OFFSET LEG OF THE BARRIER FRAME MAY HAVE BEEN LOCATED INCORRECTLY AND INCORRECT PADDING MAY HAVE BEEN INSTALLED ON THE 34 INCH OFFSET BARRIERS WHICH FAILS TO COMPLY WITH THE LEG PROTECTION ZONE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 222, "SCHOOL BUS PASSENGER SEATING AND CRASH PROTECTION."

Consequence: VEHICLE OCCUPANTS MAY SUFFER INJURIES IN THE EVENT OF A VEHICLE CRASH.

Remedy: BLUE BIRD WILL NOTIFY OWNERS AND REPLACE THE BARRIER PADS WITH A NEW DESIGNED PAD FREE OF CHARGE. THE SAFETY RECALL BEGAN ON AUGUST 12, 2009. OWNERS MAY CONTACT BLUE BIRD AT 1-478-822-2242.

Reported: 2009-07-23 (July 23, 2009) · Model years: 2008, 2009, 2010

BLUE BIRD IS RECALLING 7,772 MODEL YEAR 2008 THROUGH 2010 VISION SCHOOL BUSES MANUFACTURED FROM MARCH 27, 2007 THROUGH JUNE 10, 2009. THE LID GASKET ON THE POWER STEERING RESERVOIR MAY DETERIORATE AND CONTAMINATE THE POWER STEERING FLUID WHICH COULD RESULT IN A LOSS OF POWER STEERING ASSIST.

Consequence: LOSS OF POWER STEERING ASSIST COULD RESULT IN A VEHICLE CRASH.

Remedy: BLUE BIRD WILL NOTIFY OWNERS AND REPAIR THE BUSES FREE OF CHARGE. THE SAFETY RECALL CAMPAIGN BEGAN ON AUGUST 11, 2009. OWNERS MAY CONTACT BLUE BIRD AT 1-478-822-2242.

Reported: 2009-08-25 (August 25, 2009) · Model years: 2008, 2009

BLUE BIRD IS RECALLING CERTAIN MODEL YEAR 2008 AND 2009 ALL AMERICAN, VISION, AND MICRO BIRD SCHOOL BUSES MANUFACTURED BETWEEN APRIL 18, 2008 AND FEBRUARY 11, 2009, EQUIPPED WITH SPECIALTY MANUFACTURING, INC. (SMI) 000290 LED LIGHT KITS. A CHANGE TO THE WIRE USED IN THE LED LIGHT KITS MAY REDUCE THE EFFECTIVE LIFE OF THE LIGHTS USED ON THE STOP ARMS. THE LIGHTS MAY STOP FUNCTIONING WITHOUT WARNING.

Consequence: SHOULD THE LED LIGHTS STOP FUNCTIONING, VISIBILITY OF A STOPPED BUS WOULD BE DECREASED, POSSIBLY ENDANGERING A CHILD OR PEDESTRIAN TO INJURY BY PASSING VEHICLES.

Remedy: BLUE BIRD WILL NOTIFY OWNERS AND THE BUSES WILL BE REPAIRED FREE OF CHARGE. REPAIRS WILL BE PERFORMED BY SMI. THE SAFETY RECALL BEGAN ON SEPTEMBER 24, 2009. OWNERS MAY CONTACT SMI WARRANTY SERVICE AT 1-800-951-7867 OR BLUE BIRD AT 1-478-822-2242.

Reported: 2010-06-28 (June 28, 2010) · Model years: 2008, 2009, 2010

BLUE BIRD IS RECALLING CERTAIN MODEL YEAR 2008 THROUGH 2010 ALL AMERICAN AND VISION MODEL SCHOOL BUSES MANUFACTURED FROM MAY 23, 2007 THROUGH MARCH 9, 2010, EQUIPPED WITH CATERPILLAR C7 ENGINES. THE #5 AND #6 FUEL LINES MAY CRACK AT THE FASTENING POINT TO THE COMMON FUEL RAIL AND CAUSE A FUEL LEAK.

Consequence: A FUEL LEAK, IN THE PRESENCE OF AN IGNITION SOURCE, CAN RESULT IN A VEHICLE FIRE.

Remedy: BLUE BIRD IS WORKING WITH CATERPILLER TO NOTIFY OWNERS AND REPAIRS WILL BE PERFORMED BY AUTHORIZED CATERPILLAR DEALERS FREE OF CHARGE. OWNERS MAY CONTACT CATERPILLAR TOLL-FREE AT 1-800-447-4986 OR BLUE BIRD AT 1-478-822-2242.

Reported: 2010-06-28 (June 28, 2010) · Model years: 2008, 2009, 2010

BLUE BIRD IS RECALLING CERTAIN MODEL YEAR 2008 THROUGH 2010 ALL AMERICAN, VISION, AND EXCEL 102 MODEL NON SCHOOL BUSES MANUFACTURED FROM MAY 17, 2007 THROUGH NOVEMBER 13, 2008, EQUIPPED WITH CATERPILLAR C7 ENGINES. THE #5 AND #6 FUEL LINES MAY CRACK AT THE FASTENING POINT TO THE COMMON FUEL RAIL AND CAUSE A FUEL LEAK.

Consequence: A FUEL LEAK, IN THE PRESENCE OF AN IGNITION SOURCE, CAN RESULT IN A VEHICLE FIRE.

Remedy: BLUE BIRD IS WORKING WITH CATERPILLAR TO NOTIFY OWNERS AND REPAIRS WILL BE PERFORMED BY AUTHORIZED CATERPILLAR DEALERS FREE OF CHARGE. THE SAFETY RECALL BEGAN ON SEPTEMBER 9, 2010. OWNERS MAY CONTACT CATERPILLAR TOLL-FREE AT 1-800-447-4986 OR BLUE BIRD AT 1-478-822-2242.

Reported: 2011-03-15 (March 15, 2011) · Model years: 2008, 2009, 2010

BLUE BIRD IS RECALLING CERTAIN MODEL YEAR 2008 THROUGH 2010 VISION NON SCHOOL BUSES. THE DASH INSTRUMENT PANEL ABS INDICATOR LIGHT DOES NOT ILLUMINATE WHEN THE ABS CIRCUIT IS DISCONNECTED AT THE MAIN ABS MODULE. ACCORDINGLY, THESE BUSES FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 105, "HYDRAULIC AND ELECTRIC BRAKE SYSTEMS," AND FMVSS NO. 121, "AIR BRAKE SYSTEMS."

Consequence: IN THE EVENT THE ABS CIRCUIT DISCONNECTS FROM THE MAIN ABS MODULE, THE BUS OPERATOR WOULD BE UNAWARE OF THE FAILURE OF THE ABS SYSTEM AND THE ASSOCIATED REDUCED BRAKING FUNCTION, INCREASING THE RISK OF A CRASH.

Remedy: BLUE BIRD IS CURRENTLY WORKING WITH STONERIDGE TO PRODUCE SOFTWARE THAT DEALERS CAN USE TO REPROGRAM THE DASH INSTRUMENT PANEL. BLUE BIRD WILL NOTIFY OWNERS ONCE THE SOFTWARE UPDATE BECOMES AVAILABLE. THE AFFECTED BUSES WILL BE REPAIRED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON JUNE 23, 2011. OWNERS MAY CONTACT BLUE BIRD AT 1-478-822-2242.

Reported: 2016-02-23 (February 23, 2016) · Model years: 2008, 2009

Blue Bird Body Company (Blue Bird) is recalling certain model year 2008-2009 Vision school buses manufactured from May 10, 2007, through March 5, 2008 and equipped with Caterpillar C707 engines. In the affected buses, the positive starter cable may be incorrectly attached to the same Power Distribution Unit (PDU) stud as the battery cable, exposing the smaller battery cable to a higher current draw during cranking.

Consequence: Exposure to high current draw may cause the battery cable to overheat, melt the wire insulation and increase the risk of a short circuit and a fire.

Remedy: Blue Bird will notify owners, and dealers will relocate the starter cable to the chassis power stud. Any damaged battery cables will be replaced. These repairs will be made free of charge. The recall began on March 10, 2016. Owners may contact Blue Bird customer service at 1-478-822-2242. Blue Bird's recall number for this campaign is R16YL-SB.

Reported: 2020-03-03 (March 3, 2020) · Model years: 2008, 2009, 2010, 2011, 2012, 2013, 2014, 2015, 2016, 2017, 2018, 2019

Blue Bird Body Company (Blue Bird) is recalling certain 2008-2021 Vision and All American school buses. The seat barrier behind the driver seat with an integrated 3-point seat belt may have been installed incorrectly and may be missing the reinforcing bracket. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 222, "School Bus Passenger Seating and Crash Protection."

Consequence: In the event of a crash, the seat barrier may not adequately protect the occupant seated behind the seat barrier separating them from the driver seat with integrated 3-point seat belt, increasing the risk of injury.

Remedy: Blue Bird will notify owners, and dealers will inspect and properly install the seat barrier including adding reinforcing bracket, as necessary, free of charge. The recall is expected to begin April 23, 2020. Owners may contact Blue Bird customer service at 1-478-822-2242. Blue Bird's number for this recall is R20AM-SB.

Reported: 2009-06-11 (June 11, 2009) · Model years: 2009, 2010

BLUE BIRD IS RECALLING 377 MODEL YEAR 2009 AND 2010 VISION CONVENTIONAL SCHOOL BUSES MANUFACTURED FROM MAY 13, 2008 THROUGH MAY 17, 2009, EQUIPPED WITH PROPANE ENGINES. THE POWER STEERING RETURN HOSE MAY LEAK AND/OR FAIL RESULTING IN LOSS OF HYDRAULIC STEERING ASSIST.

Consequence: LOSS OF POWER STEERING ASSIST COULD RESULT IN A VEHICLE CRASH.

Remedy: BLUE BIRD WILL NOTIFY OWNERS AND REPAIR THE BUSES FREE OF CHARGE. THE SAFETY RECALL BEGAN ON JULY 30, 2009. OWNERS MAY CONTACT BLUE BIRD AT 1-478-422-2242.

Reported: 2011-04-22 (April 22, 2011) · Model years: 2009, 2010, 2011, 2012

BLUE BIRD IS RECALLING CERTAIN MODEL YEAR 2009 THROUGH 2012 VISION SCHOOL BUSES MANUFACTURED FROM OCTOBER 7, 2008, THROUGH JANUARY 19, 2011, EQUIPPED WITH AN OPTIONAL FUEL FILTER LOCATED ON THE DRIVER'S CONTROL MODULE. DUE TO ROUTING AND CLAMPING VARIATIONS, THE FUEL LINE ON UNITS EQUIPPED WITH AN OPTIONAL RELOCATED FUEL FILTER MAY CONTACT THE BODY MOUNTED TRANSMISSION COVER AND CHAFE AGAINST THE COVER.

Consequence: THIS CONDITION COULD POTENTIALLY RESULT IN A FUEL LEAK AND POSSIBLY RESULT IN A FIRE.

Remedy: BLUE BIRD WILL NOTIFY OWNERS AND DEALERS WILL INSPECT FOR CONTACT/RUBBING WITH THE TRANSMISSION COVER. FUEL LINES FOUND TO BE CONTACTING OR RUBBING WILL BE REPOSITIONED. ANY DAMAGED FUEL FILTER HOSES FOUND WILL BE REPLACED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON MAY 25, 2011. OWNERS MAY CONTACT BLUE BIRD AT 1-478-822-2242.

Reported: 2012-04-05 (April 5, 2012) · Model years: 2009, 2010, 2011

BLUE BIRD IS RECALLING CERTAIN MODEL YEAR 2009 THROUGH 2011 ALL AMERICAN, VISION, AND MICRO BIRD SCHOOL BUSES EQUIPPED WITH BRAUN VISTA-2 WHEELCHAIR LIFTS. OVER TIME AND WITH FREQUENT USE, THE ROLL STOP LATCHES ON THE OUTER BARRIER MAY BECOME BENT OR MISALIGNED.

Consequence: A WHEELCHAIR OCCUPANT MAY DEFEAT OR RIDE OVER THE INSUFFICIENTLY LATCHED ROLL STOP. IF THIS OCCURS WHEN THE LIFT PLATFORM IS IN AN ELEVATED POSITION, THE WHEELCHAIR’S OCCUPANT COULD FALL AND SUSTAIN INJURY.

Remedy: BLUE BIRD WILL NOTIFY OWNERS, AND THE REPAIRS WILL BE PERFORMED BY AUTHORIZED BRAUN DEALERS FREE OF CHARGE. THE SAFETY RECALL BEGAN ON APRIL 26, 2012. OWNERS MAY CONTACT BLUE BIRD AT 1-478-822-2242.

Reported: 2016-02-23 (February 23, 2016) · Model years: 2009

Blue Bird Body Company (Blue Bird) is recalling certain model year 2009 Vision transit buses manufactured from November 27, 2007, through February 18, 2008, and equipped with Caterpillar C707 engines. In the affected buses, the positive starter cable may be incorrectly attached to the same Power Distribution Unit (PDU) stud as the battery cable, exposing the smaller battery cable to a higher current draw during cranking.

Consequence: Exposure to high current draw may cause the battery cable to overheat, melt the wire insulation and increase the risk of a short circuit and a fire.

Remedy: Blue Bird will notify owners, and dealers will relocate the starter cable to the chassis power stud. Any damaged battery cables will be replaced. These repairs will be made free of charge. The recall began on March 10, 2016. Owners may contact Blue Bird customer service at 1-478-822-2242. Blue Bird's recall number for this campaign is R16YL-NSB.

Reported: 2020-04-27 (April 27, 2020) · Model years: 2009, 2010, 2011, 2012, 2013, 2014, 2015, 2016, 2017, 2018, 2019

Blue Bird Body Company (Blue Bird) is recalling certain 2009-2019 Vision transit buses. The floor-mounted parking brake may fail to hold the vehicle stationary on an incline when the vehicle is loaded to its maximum weight, due to an insufficient application force. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 105 "Hydraulic and Electric Brake Systems."

Consequence: A parking brake system that is set to an insufficient application force may result in an increased possibility of unintended vehicle movement, which increases the risk of injury to bystanders.

Remedy: Blue Bird will notify owners, and dealers will inspect the floor mounted park brake application force hand lever assembly and adjust the application force, as necessary, free of charge. The recall is expected to begin June 24, 2020. Owners may contact Blue Bird customer service at 478-822-2242. Blue Bird's number for this recall is R20AO-SB.

Reported: 2009-11-17 (November 17, 2009) · Model years: 2010

BLUE BIRD IS RECALLING CERTAIN MODEL YEAR 2010 VISION SCHOOL BUSES MANUFACTURED BETWEEN MAY 12 AND SEPTEMBER 10, 2009 THAT WERE EQUIPPED WITH AN OPTIONAL WHEELCHAIR LIFT. THE WHEELCHAIR LIFT POWER CABLE MAY COME IN CONTACT WITH THE ENGINE EXHAUST MANIFOLD.

Consequence: SHOULD THE CABLE CONTACT THE MANIFOLD, ITS INSULATION WOULD MELT CAUSING A POTENTIAL FOR A DIRECT SHORT WHICH COULD RESULTIN A VEHICLE FIRE.

Remedy: BLUE BIRD WILL NOTIFY OWNERS AND DEALERS WILL INSPECT THE WHEELCHAIR LIFT POWER CABLE AND REPAIR IF NECESSARY. THE SAFETY RECALL BEGAN ON DECEMBER 17, 2009. OWNERS MAY CONTACT BLUE BIRD AT 1-478-822-2242.

Reported: 2010-06-29 (June 29, 2010) · Model years: 2010, 2011

BLUE BIRD IS RECALLING CERTAIN MODEL YEAR 2010 AND 2011 ALL AMERICAN AND VISION MODEL SCHOOL BUSES MANUFACTURED FROM MARCH 25, 2009 THROUGH JANUARY 12, 2010. THE DRIVER'S SEAT SHOCK DAMPER MAY BREAK ALLOWING THE DRIVER'S SEAT TO UNEXPECTEDLY DROP TO THE FLOOR WITHOUT WARNING.

Consequence: IN THE EVENT THIS SHOULD OCCUR WHILE THE BUS IS IN OPERATION, THE DRIVER MAY LOSE CONTROL OF THE VEHICLE, POSSIBLY RESULTING IN A CRASH.

Remedy: BLUE BIRD WILL NOTIFY OWNERS AND REPLACE THE SEAT SHOCK AS NECESSARY. THE SAFETY RECALL BEGAN ON AUGUST 20, 2010. OWNERS MAY CONTACT BLUE BIRD AT 1-478-822-2242.

Reported: 2010-12-16 (December 16, 2010) · Model years: 2010, 2011

BLUE BIRD IS RECALLING CERTAIN MODEL YEAR 2010 AND 2011 MODEL VISION SCHOOL BUSES MANUFACTURED FROM NOVEMBER 13, 2009, THROUGH DECEMBER 15, 2010. ON SOME BUSES, THE HYDRAULIC BRAKE PEDAL MAY DEFORM UPON APPLICATION WHICH MAY PREVENT THE PARKING BRAKE FROM FULLY APPLYING.

Consequence: THIS CONDITION MAY PERMIT THE BUS TO ROLL UNEXPECTEDLY WHEN PARKED WHICH COULD RESULT IN PROPERTY DAMAGE, PERSONAL INJURY, OR DEATH TO AN INDIVIDUAL WITHIN THE PATH OF THE ROLLING BUS.

Remedy: BLUE BIRD WILL NOTIFY OWNERS AND DEALERS WILL REPAIR THE BUSES FREE OF CHARGE. THE SAFETY RECALL BEGAN ON FEBRUARY 14, 2011. OWNERS MAY CONTACT BLUE BIRD AT 1-478-822-2242.

Reported: 2012-05-15 (May 15, 2012) · Model years: 2010, 2011, 2012, 2013

BLUE BIRD CORPORATION (BLUE BIRD) IS RECALLING CERTAIN MODEL YEAR 2010 THROUGH 2013 ALL AMERICAN AND VISION SCHOOL BUSES MANUFACTURED FROM MAY 30, 2009, THROUGH APRIL 4, 2012 AND EQUIPPED WITH AIR BRAKES. THE PRIMARY AND SECONDARY AIR BRAKE LINES MAY HAVE BEEN CROSSED AT THE BRAKE TREADLE VALVE. INCORRECT INSTALLATION OF THE AIR BRAKE LINES AT THE AIR BRAKE TREADLE VALVE FAILS TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 121, "AIR BRAKE SYSTEMS."

Consequence: IN THE EVENT OF A BRAKE SYSTEM PROBLEM, INCORRECT INSTALLATION OF THE AIR BRAKE LINES COULD RESULT IN A REDUCTION OR COMPLETE LOSS OF BRAKE ACTION, INCREASING THE RISK OF A CRASH.

Remedy: BLUE BIRD WILL NOTIFY OWNERS, AND DEALERS WILL REPAIR THE BUSES FREE OF CHARGE. THE RECALL BEGAN ON MAY 23, 2012. OWNERS MAY CONTACT BLUE BIRD AT 1-478-822-2242.

Reported: 2012-05-15 (May 15, 2012) · Model years: 2010, 2011, 2012, 2013

BLUE BIRD CORPORATION (BLUE BIRD) IS RECALLING CERTAIN MODEL YEAR 2010 THROUGH 2013 ALL AMERICAN AND VISION NON SCHOOL BUSES MANUFACTURED FROM MAY 30, 2009, THROUGH APRIL 4, 2012 AND EQUIPPED WITH AIR BRAKES. THE PRIMARY AND SECONDARY AIR BRAKE LINES MAY HAVE BEEN CROSSED AT THE BRAKE TREADLE VALVE. INCORRECT INSTALLATION OF THE AIR BRAKE LINES AT THE AIR BRAKE TREADLE VALVE FAILS TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 121, "AIR BRAKE SYSTEMS."

Consequence: IN THE EVENT OF A BRAKE SYSTEM PROBLEM, INCORRECT INSTALLATION OF THE AIR BRAKE LINES COULD RESULT IN A REDUCTION OR COMPLETE LOSS OF BRAKE ACTION, INCREASING THE RISK OF A CRASH.

Remedy: BLUE BIRD WILL NOTIFY OWNERS, AND DEALERS WILL REPAIR THE BUSES FREE OF CHARGE. THE RECALL BEGAN ON MAY 23, , 2012. OWNERS MAY CONTACT BLUE BIRD AT 1-478-822-2242.

Reported: 2013-05-15 (May 15, 2013) · Model years: 2010, 2011, 2012, 2013, 2014

Blue Bird is recalling certain model year 2010 through 2014 All American and Vision model school buses manufactured from August 25, 2009, through March 19, 2013, and equipped with C. E. White Inc. Flip Seats models Quasi Static "QSJ11" (30", 36", 39" and 45"), Student Safety Seat "SSSJ" (30", 36", 39" and 45"), or School Bus Seat "SBJ" (30", 36", 39" and 45").

Consequence: When a Flip Seat is installed in front of another passenger seat, it is possible for the occupant of the rearward passenger seat to insert their toes and/or foot into the lower frame area of the Flip Seat. When a vehicle passenger occupies the Flip Seat, pushing the seat bottom downward to the horizontal position to sit in the seat, the occupant of the rearward seat could suffer a pinch point injury to their toes and/or foot.

Remedy: Blue Bird will notify owners, and dealers will install a safety guard to prevent passengers from placing their toes or feet in the opening on the back of the subject Flip Seats, free of charge. The recall began on June 14, 2013. Owners may contact Blue Bird at 1-478-822-2242 for more information. Blue Bird's number for this campaign is R13WF.

Reported: 2010-07-01 (July 1, 2010) · Model years: 2011

BLUE BIRD IS RECALLING CERTAIN MODEL YEAR 2010 AND 2011 D3 ALL AMERICAN SCHOOL BUSES MANUFACTURED FROM MAY 13, 2009 THROUGH JUNE 25, 2010 AND 2011 MODEL YEAR VISION SCHOOL BUSES MANUFACTURED FROM NOVEMBER 9, 2009 THROUGH JUNE 24, 2010. THESE BUSES ARE EQUIPPED WITH A CRUISE CONTROL FEATURE WHICH ONCE ACTIVATED MAY NOT DE-ACTIVATE WHEN THE SERVICE BRAKES ARE APPLIED.

Consequence: IN THE EVENT THE CRUISE CONTROL FAILS TO DE-ACTIVATE WHEN THE SERVICE BRAKES ARE APPLIED, THE POTENTIAL FOR A VEHICLE CRASH COULD OCCUR.

Remedy: BLUE BIRD SENT AN INTERIM LETTER TO DEALERS AND OWNERS ON JULY 1, 2010 INSTRUCTING DEALERS TO DISABLE THE CRUISE CONTROL MECHANISM UNTIL A PERMANENT REMEDY IS AVAILABLE. A DECAL WASL PROVIDED TO AFFIX TO THE DASH ADVISING OPERATORS THAT THE CRUISE CONTROL HAS BEEN DISABLED. A PERMANENT REPAIR HAS NOW BEEN ESTABLISHED. DEALERS WILL REPAIR THE BUSES BY INSTALLING A FAILSAFE CURCUIT IN THE CRUISE CONTROL SYSTEM FREE OF CHARGE. ALL OWNERS, REGARDLESS OF WHETHER THEY RECEIVED THE INTERIM FIX OR NOT, WILL BE NOTIFIED AND OFFERED THE PERMANENT REMEDY. THE SAFETY RECALL BEGAN ON AUGUST 5, 2010. OWNERS MAY CONTACT BLUE BIRD AT 1-478-822-2242.

Reported: 2010-07-02 (July 2, 2010) · Model years: 2011

BLUE BIRD IS RECALLING CERTAIN MODEL YEAR 2010 AND 2011 D3 ALL AMERICAN NON SCHOOL BUSES MANUFACTURED FROM MAY 19, 2009 THROUGH JUNE 15, 2010 AND 2011 MODEL YEAR VISION NON SCHOOL BUSES MANUFACTURED FROM APRIL 9, 2009 THROUGH APRIL 10, 2010. THESE BUSES ARE EQUIPPED WITH A CRUISE CONTROL FEATURE WHICH ONCE ACTIVATED MAY NOT DE-ACTIVATE WHEN THE SERVICE BRAKES ARE APPLIED.

Consequence: IN THE EVENT THE CRUISE CONTROL FAILS TO DE-ACTIVATE WHEN THE SERVICE BRAKES ARE APPLIED, THE POTENTIAL FOR A VEHICLE CRASH COULD OCCUR.

Remedy: BLUE BIRD SENT AN INTERIM LETTER TO DEALERS AND OWNERS ON JULY 1, 2010 INSTRUCTING DEALERS TO DISABLE THE CRUISE CONTROL MECHANISM UNTIL A PERMANENT REMEDY IS AVAILABLE. A DECAL WASL PROVIDED TO AFFIX TO THE DASH ADVISING OPERATORS THAT THE CRUISE CONTROL HAS BEEN DISABLED. A PERMANENT REPAIR HAS NOW BEEN ESTABLISHED. DEALERS WILL REPAIR THE BUSES BY INSTALLING A FAILSAFE CURCUIT IN THE CRUISE CONTROL SYSTEM FREE OF CHARGE. ALL OWNERS, REGARDLESS OF WHETHER THEY RECEIVED THE INTERIM FIX OR NOT, WILL BE NOTIFIED AND OFFERED THE PERMANENT REMEDY. THE SAFETY RECALL BEGAN ON AUGUST 5, 2010. OWNERS MAY CONTACT BLUE BIRD AT 1-478-822-2242.

Reported: 2011-02-10 (February 10, 2011) · Model years: 2011, 2012

BLUE BIRD IS RECALLING CERTAIN MODEL YEAR 2011 AND 2012 VISION AND ALL AMERICAN MODEL SCHOOL BUSES MANUFACTURED FROM OCTOBER 18, 2010, THROUGH JANUARY 6, 2011. THE SHEET METAL RAIN VISORS OVER THE PUSHOUT SIDE WINDOW ON THE LEFT SIDE OF THE BUS MAY PROHIBIT THE EMERGENCY EXIT WINDOW FROM OPENING SUFFICIENTLY WHICH FAILS TO CONFORM TO THE EMERGENCY EGRESS REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 217, "BUS EMERGENCY EXISTS AND WINDOW RETENTION AND RELEASE."

Consequence: IN THE EVENT OF AN EMERGENCY, PASSENGERS COULD BE INJURED IF THEY ARE UNABLE TO QUICKLY EXIT THE BUS.

Remedy: BLUE BIRD WILL NOTIFY OWNERS AND DEALERS WILL REPAIR THE BUSES FREE OF CHARGE. THE SAFETY RECALL BEHAN ON MARCH 15, 2011. OWNERS MAY CONTACT BLUE BIRD AT 1-478-822-2242.

Reported: 2011-08-17 (August 17, 2011) · Model years: 2011, 2012

BLUE BIRD IS RECALLING CERTAIN MODEL YEAR 2011 AND 2012 ALL AMERICAN SCHOOL BUSES MANUFACTURED FROM OCTOBER 13, 2010, THROUGH MARCH 8, 2011, AND VISION SCHOOL BUSES MANUFACTURED FROM OCTOBER 2, 2010, THROUGH FEBRUARY 2, 2011, EQUIPPED WITH A CUMMINS DIESEL ENGINE. THE V-BAND CLAMP ASSEMBLY, PART NUMBERS Q187684, Q187685, AND Q187686, USED TO CONNECT THE INLET AND OUTLET CONE SECTIONS TO THE DIESEL OXIDATION CATALYST (DOC)/DIESEL PARTICULATE FILTER (DPF) INCLUDE A T-BOLT WHICH CAN FRACTURE AND FAIL WHEN SUBJECTED TO STRESS OR LOAD. A FRACTURE OR FAILURE OF THE T-BOLT MAY CAUSE THE CLAMP TO LOOSEN AND THE INLET OR OUTLET SECTIONS ATTACHED TO THE DOC/DPF HOUSING TO DISCONNECT.

Consequence: IF THE INLET OR OUTLET SECTIONS DISCONNECT, HOT EXHAUST GASES CAN VENT PRIOR TO EXITING THE TAILPIPE, CREATING THE RISK OF COMBUSTION AND A FIRE. IF BOTH CLAMPS FAIL, THERE IS A RISK IN SOME APPLICATIONS THAT THE DOC/DPF HOUSING MAY DETACH COMPLETELY, CREATING A ROAD HAZARD.

Remedy: BLUE BIRD IS WORKING WITH CUMMINS TO IDENTIFY AND NOTIFY OWNERS OF THE RECALL CAMPAIGN. REPAIRS WILL BE PERFORMED BY AUTHORIZED CUMMINS DEALERS FREE OF CHARGE. THE SAFETY RECALL BEGAN ON OCTOBER 10, 2011. OWNERS MAY CONTACT CUMMINS AT 1-812-377-5000 OR BLUE BIRD AT 1-478-822-2242.

Reported: 2011-08-17 (August 17, 2011) · Model years: 2011, 2012

BLUE BIRD IS RECALLING CERTAIN MODEL YEAR 2011 AND 2012 ALL AMERICAN NON-SCHOOL BUSES MANUFACTURED FROM NOVEMBER 2, 2010, THROUGH MARCH 17, 2011, AND VISION CONVENTIONAL NON-NOVEMBER 2, 2010, THROUGH MARCH 17, 2011, EQUIPPED WITH A CUMMINS DIESEL ENGINE. THE V-BAND CLAMP ASSEMBLY, PART NUMBERS Q187684, Q187685, AND Q187686, USED TO CONNECT THE INLET AND OUTLET CONE SECTIONS TO THE DIESEL OXIDATION CATALYST (DOC)/DIESEL PARTICULATE FILTER (DPF) INCLUDE A T-BOLT WHICH CAN FRACTURE AND FAIL WHEN SUBJECTED TO STRESS OR LOAD. A FRACTURE OR FAILURE OF THE T-BOLT MAY CAUSE THE CLAMP TO LOOSEN AND THE INLET OR OUTLET SECTIONS ATTACHED TO THE DOC/DPF HOUSING TO DISCONNECT.

Consequence: IF THE INLET OR OUTLET SECTIONS DISCONNECT, HOT EXHAUST GASES CAN VENT PRIOR TO EXITING THE TAILPIPE, CREATING THE RISK OF COMBUSTION AND A FIRE. IF BOTH CLAMPS FAIL, THERE IS A RISK IN SOME APPLICATIONS THAT THE DOC/DPF HOUSING MAY DETACH COMPLETELY, CREATING A ROAD HAZARD.

Remedy: BLUE BIRD IS WORKING WITH CUMMINS TO IDENTIFY AND NOTIFY OWNERS OF THE RECALL CAMPAIGN. REPAIRS WILL BE PERFORMED BY AUTHORIZED CUMMINS DEALERS FREE OF CHARGE. THE SAFETY RECALL BEGAN ON OCTOBER 10, 2011. OWNERS MAY CONTACT CUMMINS AT 1-812-377-5000 OR BLUE BIRD AT 1-478-822-2242.

Reported: 2011-10-18 (October 18, 2011) · Model years: 2012

BLUE BIRD IS RECALLING CERTAIN MODEL YEAR 2012 ALL AMERICAN AND VISION SCHOOL BUSES MANUFACTURED FROM AUGUST 2, 2011, THROUGH SEPTEMBER 14, 2011, EQUIPPED WITH SPECTAL INDUSTRIES VERTICAL EMERGENCY EXIT WINDOWS. INCORRECT RIVETS MAY HAVE BEEN USED TO ATTACH THE HANDLES THAT AN OCCUPANT WOULD USE TO OPEN THE WINDOW IN THE EVENT OF AN EMERGENCY. THE PART NUMBERS FOR THE BLUE BIRD BUSES ARE AS FOLLOWS: 129185, 129195, 129197, 129199, 129201, 129202, 129203, 129205, 129207, 129209, 129210, 129228, 129230, 129232, 129234, 129236, 129238, 129240, 129242, AND 129243.

Consequence: IF THE HANDLE IS ACTUATED DURING A NON-EMERGENCY SITUATION AND DETACHES, THE EMERGENCY WINDOW CANNOT BE RE-SECURED, POSING A RISK THAT CHILDREN MAY FALL OR CLIMB OUT. HOWEVER, IF THE HANDLE WERE TO DETACH DURING AN EMERGENCY, THE EXIT WINDOW WILL OPEN AND EGRESS THROUGH THE WINDOW WILL NOT BE HINDERED.

Remedy: BLUE BIRD WILL NOTIFY OWNERS, AND PROVIDE REPAIR KITS, FREE OF CHARGE. THE SAFETY RECALL IS EXPECTED TO BEGIN ON OR ABOUT NOVEMBER 14, 2011. OWNERS MAY CONTACT BLUE BIRD AT 1-478-822-2242.

Reported: 2012-06-08 (June 8, 2012) · Model years: 2012, 2013

BLUE BIRD CORPORATION (BLUE BIRD) IS RECALLING CERTAIN MODEL YEAR 2012 THROUGH 2013 ALL AMERICAN AND VISION SCHOOL BUSES MANUFACTURED FROM APRIL 7, 2011, THROUGH MARCH 21, 2012, EQUIPPED WITH SPECIALTY MANUFACTURING INC. (SMI) PROLO ROOF HATCHES. INCREASED FRICTION BETWEEN THE REAR PLATE ASSEMBLIES, P/NO. 009327, AND THE NYLON REAR POP-UP SUPPORT, P/NO. 008956, MAY RESULT IN AN OPENING FORCE OF THE PROLO ROOF HATCHES THAT EXCEEDS FEDERAL STANDARD REQUIREMENTS. THUS, THESE HATCHES FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 217, "BUS EMERGENCY EXITS AND WINDOW RETENTION AND RELEASE."

Consequence: IN THE EVENT OF AN EMERGENCY, EGRESS OF THE BUS MAY BE HINDERED POSSIBLY RESULTING IN INJURY TO THE VEHICLE OCCUPANTS.

Remedy: BLUE BIRD WILL NOTIFY OWNERS. SMI WILL PROVIDE SERVICE KITS ALONG WITH REPAIR INSTRUCTIONS TO DEALERS AND OWNERS, FREE OF CHARGE. THE SAFETY RECALL BEGAN ON JUNE 21, 2012. OWNERS MAY CONTACT BLUE BIRD AT 1-478-822-2242 OR SMI AT 1-800-951-7867.

Reported: 2012-06-08 (June 8, 2012) · Model years: 2012

BLUE BIRD CORPORATION (BLUE BIRD) IS RECALLING CERTAIN MODEL YEAR 2012 ALL AMERICAN AND VISION NON-SCHOOL BUSES MANUFACTURED FROM MAY 20, 2011, THROUGH OCTOBER 20, 2012, EQUIPPED WITH SPECIALTY MANUFACTURING INC. (SMI) PROLO ROOF HATCHES. INCREASED FRICTION BETWEEN THE REAR PLATE ASSEMBLIES, P/NO. 009327, AND THE NYLON REAR POP-UP SUPPORT, P/NO. 008956, MAY RESULT IN AN OPENING FORCE OF THE PROLO ROOF HATCHES THAT EXCEEDS FEDERAL STANDARD REQUIREMENTS. THUS, THESE HATCHES FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 217, "BUS EMERGENCY EXITS AND WINDOW RETENTION AND RELEASE."

Consequence: IN THE EVENT OF AN EMERGENCY, EGRESS OF THE BUS MAY BE HINDERED POSSIBLY RESULTING IN INJURY TO THE VEHICLE OCCUPANTS.

Remedy: BLUE BIRD WILL NOTIFY OWNERS. SMI WILL PROVIDE SERVICE KITS ALONG WITH REPAIR INSTRUCTIONS TO DEALERS AND OWNERS, FREE OF CHARGE. THE SAFETY RECALL BEGAN ON JUNE 21, 2012. OWNERS MAY CONTACT BLUE BIRD AT 1-478-822-2242 OR SMI AT 1-800-951-7867.

Reported: 2014-06-04 (June 4, 2014) · Model years: 2012, 2013

Blue Bird Body Company (Blue Bird) is recalling certain model year 2012-2013 Vision school buses manufactured January 10, 2012, to April 24, 2013, and equipped with a Roush CleanTech LLC propane fuel system. Due to a reaction between the different metals, the affected vehicles may develop a propane leak where the aluminum fuel line fitting contacts the brass supply valve housing.

Consequence: A propane leak in the presence of an ignition source increases the risk of a fire.

Remedy: Blue Bird will notify owners, and dealers will replace the aluminum fuel line fitting with a new stainless steel fitting, free of charge. The recall began on July 3, 2014. Owners may contact Blue Bird customer service at 1-478-822-2242. Blue Bird's number for this recall is R14XD.

Reported: 2012-07-24 (July 24, 2012) · Model years: 2013

Blue Bird is recalling certain model year 2013 Vision school buses manufactured from May 10, 2012, through June 7, 2012. The electronic module that activates the hydraulic brake pressure indicator light on the dash instrument panel when there is little, or no, pressure in the hydraulic brake system may have been omitted during manufacturing. Therefore, these buses fail to conform to the requirements of Federal Motor Vehicle Safety Standard No. 105, "Hydraulic and Electric Brake Systems," Section 5.3 "Brake System Indicator Lamps".

Consequence: In the event that a loss of pressure occurs in the hydraulic brake system and the brake pressure monitor does not activate, the operator of the bus may not be aware of the subsequent reduced braking capacity which could result in a vehicle crash with potential for personal injury and/or property damage.

Remedy: Blue Bird will notify owners, and dealers will repair the buses free of charge. The safety recall began on August 9, 2012. Owners may contact Blue Bird at 1-478-822-2242.

Reported: 2012-07-25 (July 25, 2012) · Model years: 2013

Blue Bird is recalling model year 2013 All American and Vision school buses manufactured from April 30, 2012, through June 23, 2012. Driver's seat belts may have been inadvertently installed with mismatched buckles which fails to conform to the requirements of Federal Motor Vehicle Safety Standard No. 209, "Seat Belt Assemblies." The latch plate (tongue) on one style buckle may mate up to another style buckle receiver, but the latch plate may not be properly engaged.

Consequence: Should this condition occur, the seat occupant may not be properly restrained and could be injured in an accident or sudden stop.

Remedy: Blue Bird will notify owners, and dealers will repair the buses free of charge. The safety recall began on August 23, 2012. Owners may contact Blue Bird at 1-478-822-2242.

Reported: 2012-07-25 (July 25, 2012) · Model years: 2013

Blue Bird is recalling model year 2013 All American and Vision non-school buses manufactured from April 30, 2012, through June 23, 2012. Driver's seat belts may have been inadvertently installed with mismatched buckles. The latch plate (tongue) on one style buckle may mate up to another style buckle receiver but the latch plate may not be properly engaged. Therefore, they fail to conform to the requirements of Federal Motor Vehicle Safety Standard No. 209, "Seat Belt Assemblies."

Consequence: Should this condition occur, the seat occupant may not be properly restrained and could be injured in an accident or sudden stop.

Remedy: Blue Bird will notify owners, and dealers will repair the buses free of charge. The safety recall began on August 23, 2012. Owners may contact Blue Bird at 1-478-822-2242.

Reported: 2012-11-15 (November 15, 2012) · Model years: 2013, 2014

Blue Bird is recalling certain model year 2013 and 2014 Vision school buses manufactured from January 10, 2012, through November 01, 2012, and equipped with Ford 6.8L propane engines. The brake light switch mounting bracket may have caused the brake light switch to be incorrectly adjusted at installation and/or the brake light switch mounting bracket may deform when the driver allows the brake pedal to return forcibly. An incorrectly adjusted brake light switch or deformed brake light switch mounting bracket may cause the brake lights to illuminate continuously.

Consequence: Improperly functioning brake lights could confuse following motorists and fail to warn them that the bus may be stopping, increasing the risk of a crash.

Remedy: Blue Bird will notify owners, and dealers will install a new, redesigned brake light switch mounting bracket along with a new brake light switch, free of charge. The safety recall began on December 5, 2012. Owners may contact Blue Bird at 1-478-822-2242.

Reported: 2012-12-13 (December 13, 2012) · Model years: 2013

Blue Bird is recalling certain 2013 model year Vision conventional school buses manufactured from August 27, 2012, to November 06, 2012. The castle nut that attaches the drag link to the steering arm may not have been torqued to the proper specifications.

Consequence: Improperly torqued drag link castle nuts could cause excessive movement at the drag link to steering arm connection which could lead to potential separation of the drag link from the steering arm and loss of steering control, which may increase the risk of a crash.

Remedy: Blue Bird will notify owners, and dealers will check the torque on the drag link castle nuts. Any vehicle where the castle nuts are found to be loose will also have its steering arm inspected for wear. The recall began on December 28, 2012. Owners may contact Blue Bird at 1-478-822-2242.

Reported: 2014-07-22 (July 22, 2014) · Model years: 2013, 2014, 2015

Blue Bird Body Company (Blue Bird) is recalling certain model year 2013-2015 Vision school buses manufactured December 5, 2011, to July 2, 2014, and equipped with the optional Roush CleanTech propane fuel system. In the affected vehicles, the return fuel line may crack near the support bracket.

Consequence: A propane leak in the presence of an ignition source increases the risk of a fire.

Remedy: Blue Bird will notify owners, and dealers will replace the existing fuel return line with a new line and support clamps, free of charge. The recall began on September 29, 2014. Owners may contact Blue Bird customer service at 1-478-822-2242. Blue Bird's number for this recall is R14XJ.

Reported: 2014-07-22 (July 22, 2014) · Model years: 2013, 2014, 2015

Blue Bird Body Company (Blue Bird) is recalling certain model year 2013-2015 Vision nonschool buses manufactured December 5, 2011, to July 2, 2014, and equipped with the optional Roush CleanTech propane fuel system. In the affected vehicles, the return fuel line may crack near the support bracket.

Consequence: A propane leak in the presence of an ignition source increases the risk of a fire.

Remedy: Blue Bird will notify owners, and dealers will replace the existing fuel return line with a new line and support clamps, free of charge. The recall began on September 29, 2014. Owners may contact Blue Bird customer service at 1-478-822-2242. Blue Bird's number for this recall is R14XJ.

Reported: 2015-03-10 (March 10, 2015) · Model years: 2013, 2014, 2015, 2016

Blue Bird Body Company (Blue Bird) is recalling certain model year 2013-2016 All American A3FE, A3RE, T3FE, T3RE, and D3RE school buses manufactured June 28, 2012, to September 25, 2014, and 2013-2016 Vision BBCV school buses manufactured June 9, 2012, to September 30, 2014. Incorrect fasteners may have been used to secure the seat gusset reinforcement to the side wall resulting in the seat belts being improperly anchored. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) No. 210, "Seat Belt Assembly Anchorages."

Consequence: If the seat belts are improperly anchored, there is an increased risk of occupant injury in the event of a crash.

Remedy: Blue Bird will notify owners, and dealers will inspect the the seat gusset reinforcement mounting fasteners, and will install an additional gusset reinforcement bracket, as necessary, free of charge. The recall began on April 2, 2015. Owners may contact Blue Bird customer service at 1-478-822-2242. Blue Birds number for this recall is R15YC-SB.

Reported: 2018-12-12 (December 12, 2018) · Model years: 2013, 2014, 2015, 2016, 2017, 2018, 2019

Blue Bird Body Company (Blue Bird) is recalling certain 2013-2020 Blue Bird Vision school buses equipped with the Ford 6.8L V10 engines. The hydraulic brake lines or transmission shifter cable may have been improperly routed, causing the brake line to be exposed to excessive heat, and leak hydraulic brake fluid. Additionally, the transmission shifter cable could contact the gasoline fuel supply line to the engine which may result in a fuel leak.

Consequence: A hydraulic brake fluid leak or a fuel line failure can increase the risk of a fire.

Remedy: Blue Bird will notify owners, and dealers will install a bracket which will insulate the brake lines from excessive heat, control routing of the brake lines, and secure the transmission shifter cable away from the fuel line, free of charge. The recall began February 7, 2019. Owners may contact Blue Bird customer service at 1-478-822-2242. Blue Bird's number for this recall is R19ZV-SB.

Reported: 2019-11-06 (November 6, 2019) · Model years: 2013, 2014, 2015, 2016, 2017, 2018, 2019

Blue Bird Body Company (Blue Bird) is recalling certain 2013-2020 Vision school buses equipped with Ford engines. The brake light switch mounting bracket may have caused the brake light switch to be incorrectly adjusted at installation and/or the brake light switch mounting bracket may deform when the driver allows the brake pedal to return forcibly. An incorrectly adjusted brake light switch or deformed brake light switch mounting bracket may cause the brake lights to illuminate continuously.

Consequence: Improperly functioning brake lights could confuse following motorists and fail to warn them that the bus may be stopping, increasing the risk of a crash.

Remedy: Blue Bird distributed owners an interim notification on December 10, 2019. Dealers will install a new, redesigned brake light switch mounting bracket along with a new brake light switch, free of charge. The recall began March 6, 2020. Owners may contact Blue Bird customer service at 1-478-822-2242. Blue Bird's number for this recall is S19AI-SB.

Reported: 2019-11-06 (November 6, 2019) · Model years: 2013, 2014, 2015, 2016, 2017, 2018, 2019

Blue Bird Body Company (Blue Bird) is recalling certain 2013-2020 Vision transit buses equipped with Ford engines. The brake light switch mounting bracket may have caused the brake light switch to be incorrectly adjusted at installation and/or the brake light switch mounting bracket may deform when the driver allows the brake pedal to return forcibly. An incorrectly adjusted brake light switch or deformed brake light switch mounting bracket may cause the brake lights to illuminate continuously.

Consequence: Improperly functioning brake lights could confuse following motorists and fail to warn them that the bus may be stopping, increasing the risk of a crash.

Remedy: Blue Bird issued owners an interim notification December 10, 2019. Dealers will install a new, redesigned brake light switch mounting bracket along with a new brake light switch, free of charge. The recall began March 6, 2020. Owners may contact Blue Bird customer service at 1-478-822-2242. Blue Bird's number for this recall is R19AI-NSB.

Reported: 2022-10-04 (October 4, 2022) · Model years: 2013, 2014, 2015, 2016, 2017, 2018, 2019

Blue Bird Body Company (Blue Bird) is recalling certain 2013-2021 Vision school buses equipped with Ford 6.8L LPG engines. The LPG supply line may be damaged from contact with the RH park brake cable, which can result in a fuel leak.

Consequence: A fuel leak in the presence of an ignition source increases the risk of a fire.

Remedy: Dealers will inspect and repair the fuel lines and the park brake cable, free of charge. Owner notification letters were mailed on November 18, 2022. Owners may contact Blue Bird's customer service at 1-478-822-2242. Blue Bird's number for this recall is R22CA-SB.

Reported: 2013-05-29 (May 29, 2013) · Model years: 2014

Blue Bird is recalling certain 2014 model year Blue Bird conventional (Vision) model school buses manufactured from March 11, 2013 through April 29, 2013 and equipped with Ford propane engines. On the subject buses, the brake light switches may not have been adjusted properly.

Consequence: Misadjusted brake light switches may result in one of the following occurrences: the brake lights may remain illuminated after the brake pedal has been released; the brake lights may be delayed in illumination after the brake pedal has been depressed. Either condition may increase the risk of a crash.

Remedy: Blue Bird will notify owners, and dealers will inspect the adjustment of the brake light switch. Any brake light switch found not properly adjusted will be replaced. This work will be performed free of charge. The recall began on June 20, 2013. Owners may contact Blue Bird at 1-478-822-2242. Blue Bird's number for this recall is R13WG.

Reported: 2013-11-20 (November 20, 2013) · Model years: 2014

Blue Bird Body Company (Blue Bird) is recalling certain model year 2014 Vision and All American model non-school buses manufactured August 23, 2013, through November 6, 2013 and equipped with IMMI-brand L9 driver's seat belts. When the button is pressed to release the seat belt, the latch plate can become partially engaged with the buckle, making the seat belt difficult to unlatch. Thus, this equipment fails to conform to the requirements of Federal Motor Vehicle Safety Standard (FMVSS) No. 209, "Seat Belt Assemblies."

Consequence: If the latch plate remains partially engaged after the button is pressed, egress from the vehicle could be hindered which would increase the risk of injury in the event of an emergency.

Remedy: Blue Bird will notify owners, and dealers will inspect the seat belt buckle, and if necessary, replace the seat belt buckle, free of charge. The recall began on December 17, 2013. Owners may contact Blue Bird at 1-478-822-2242. Blue Bird recall number R13WS.

Reported: 2013-11-20 (November 20, 2013) · Model years: 2014, 2015

Blue Bird Body Company (Blue Bird) is recalling certain model year 2014 and 2015 Vision and All American model school buses manufactured August 23, 2013, through November 6, 2013 and equipped with IMMI-brand L9 driver's seat belts. When the button is pressed to release the seat belt, the latch plate can become partially engaged with the buckle, making the seat belt difficult to unlatch. Thus, this equipment fails to conform to the requirements of Federal Motor Vehicle Safety Standard (FMVSS) No. 209, "Seat Belt Assemblies."

Consequence: If the latch plate remains partially engaged after the button is pressed, egress from the vehicle could be hindered which would increase the risk of injury in the event of an emergency.

Remedy: Blue Bird will notify owners, and dealers will inspect the seat belt buckle, and if necessary, replace the seat belt buckle, free of charge. The recall began on December 17, 2013. Owners may contact Blue Bird at 1-478-822-2242. Blue Bird's recall number R13WS.

Reported: 2013-12-24 (December 24, 2013) · Model years: 2014, 2015

Blue Bird Corporation is recalling certain 2014-2015 model year All American and Vision school buses manufactured from September 24, 2013, through December 6, 2013. In the affected vehicles, a component within the hydraulic park brake pedal arm may not have been properly heat treated and may fracture causing the parking brake to release without warning.

Consequence: If the park brake pedal arm fractures, the bus may unexpectedly roll increasing the risk of personal injury or a vehicle crash.

Remedy: Blue Bird has notified owners and dealers will install a new parking brake assembly, free of charge. The recall began on December 31, 2013. Owners may contact Blue Bird at 1-478-822-2242. Blue Bird's number for this recall is R13WT.

Reported: 2014-03-11 (March 11, 2014) · Model years: 2014

Blue Bird Body Company (Blue Bird) is recalling certain model year 2014 Vision and All American school buses manufactured January 21, 2013, through February 28, 2013. In the affected vehicles, the joint between the rear wheelhousing and body gusset panel may have partially separated during manufacturing. Thus, these vehicles do not conform to Federal Motor Vehicle Safety Standard (FMVSS) number 221, "School Bus Body Joint Strength."

Consequence: A joint separation between the rear wheelhousing and body gusset panel may increase the risk the injury to bus occupants in the event of a crash.

Remedy: Blue Bird will notify owners, and dealers will inspect the joint connections and install a two part adhesive and mechanical fasteners, as necessary, free of charge. The recall began on April 24, 2014. Owners may contact Blue Bird at 1-478-822-2242. Blue Bird's number for this recall is R14XC.

Reported: 2014-08-12 (August 12, 2014) · Model years: 2015

Blue Bird Body Company (Blue Bird) is recalling certain model year 2015 All American and Vision school buses manufactured from May 22, 2014, to August 2, 2014. The Cummins ISB or ISL engines in these vehicles may have been equipped with Fleetguard UFF-XT fuel filters, part number FF63009, whose filter shell may separate from the fuel filter nut plate causing the engine to stall without warning.

Consequence: If the engine stalls unexpectedly there is an increased risk of a crash.

Remedy: Cummins will notify owners and dealers will replace the fuel filter with a non-defective one, free of charge. The recall began on during September 2014. Owners may contact Cummins customer service at 1-800-223-4583. Cummins' number for this recall is C1545. Owners may contact Blue Bird customer service at 1-478-822-2242. Blue Bird's number for this recall is R14XM.

Reported: 2014-11-05 (November 5, 2014) · Model years: 2015

Blue Bird Body Company (Blue Bird) is recalling certain model year 2015 All American and Vision transit buses manufactured from May 22, 2014, to August 2, 2014. The Cummins ISB or ISL engines in these vehicles may have been equipped with Fleetguard UFF-XT fuel filters, part number FF63009, whose filter shell may separate from the fuel filter nut plate causing the engine to stall without warning.

Consequence: If the engine stalls unexpectedly there is an increased risk of a crash.

Remedy: Cummins will notify owners and dealers will replace the fuel filter with a non-defective one, free of charge. The recall began during September 2014. Owners may contact Cummins customer service at 1-800-223-4583. Cummins' number for this recall is C1545. Owners may contact Blue Bird customer service at 1-478-822-2242. Blue Bird's number for this recall is R14XM.

Reported: 2014-12-17 (December 17, 2014) · Model years: 2015

Blue Bird Body Company (Blue Bird) is recalling certain model year 2015 Vision non-school buses manufactured July 8, 2015, and All American non-school buses manufactured September 12, 2014. These buses, equipped with hydraulic brakes, may have an incorrectly manufactured parking brake pedal assembly which could separate and bend causing the parking brake not to engage properly.

Consequence: If the parking brake does not engage properly, the vehicle may unexpectedly move, increasing the risk of a vehicle crash.

Remedy: Blue Bird will notify owners, and dealers will inspect the date code on the parking brake pedal assembly and will replace the assembly if it is within that date range, free of charge. The recall began on January 29, 2015. Owners may contact Blue Bird customer service at 1-478-822-2242. blue Bird's recall number is R14XR.

Reported: 2014-12-17 (December 17, 2014) · Model years: 2015, 2016

Blue Bird Body Company (Blue Bird) is recalling certain model year 2015-2016 Vision and All American school buses manufactured July 8, 2014, to September 22, 2014. These buses, equipped with hydraulic brakes, may have an incorrectly manufactured parking brake pedal assembly which could separate and bend causing the parking brake not to engage properly.

Consequence: If the parking brake does not engage properly, the vehicle may unexpectedly move, increasing the risk of a vehicle crash.

Remedy: Blue Bird will notify owners, and dealers will inspect the date code on the parking brake pedal assembly and will replace the assembly if it is within that date range, free of charge. The recall began on January 29, 2015. Owners may contact Blue Bird customer service at 1-478-822-2242. Blue Bird's number for this recall is R14XR.

Reported: 2015-03-27 (March 27, 2015) · Model years: 2015, 2016

Blue Bird Body Company (Blue Bird) is recalling certain model year 2015-2016 Vision non-school transit buses manufactured June 19, 2014, to December 11, 2014. In the affected vehicles, the voltage inverter for the illumination of the driver's heater control panel may fail.

Consequence: An inverter failure may produce smoke and increase the risk of a fire.

Remedy: Blue Bird will notify owners, and dealers will replace the inverter with an inverter from an alternate vendor, free of charge. The recall began on April 23, 2015. Owners may contact Blue Bird customer service at 1-478-822-2242. Blue Bird's number for this recall is R15YA-NSB.

Reported: 2015-03-27 (March 27, 2015) · Model years: 2015, 2016

Blue Bird Body Company (Blue Bird) is recalling certain model year 2015-2016 Vision school buses manufactured June 19, 2014, to December 11, 2014. In the affected vehicles, the voltage inverter for the illumination of the driver's heater control panel may fail.

Consequence: An inverter failure may produce smoke and increase the risk of a fire.

Remedy: Blue Bird will notify owners, and dealers will replace the inverter with an inverter from an alternate vendor, free of charge. The recall began on April 23, 2015. Owners may contact Blue Bird customer service at 1-478-822-2242. Blue Bird's number for this recall is R15YA-SB.

Reported: 2016-07-19 (July 19, 2016) · Model years: 2015, 2016, 2017

Blue Bird Body Company (Blue Bird) is recalling certain model year 2015-2017 Vision school buses manufactured July 3, 2014, to June 24, 2016, equipped with 6.8L Ford engines and Gen 3 propane units. The affected vehicles have propane fuel lines that may rub or are crossed and secured together, possibly resulting in line damage and a propane fuel leak.

Consequence: A propane leak in the presence of an ignition source may increase the risk of a fire.

Remedy: Blue Bird will notify owners, and dealers will inspect and reroute any Gen 3 propane lines that are not parallel. If damaged, the fuel line(s) will be replaced. These repairs will be performed free of charge. The recall began on August 15, 2016. Owners may contact Blue Bird customer service at 1-478-822-2242. Blue Bird's number for this recall is R16YT-SB.

Reported: 2017-02-15 (February 15, 2017) · Model years: 2015, 2016, 2017, 2018

Blue Bird Body Company (Blue Bird) is recalling certain 2015-2018 Vision school buses manufactured February 19, 2014, through March 3, 2017, equipped with a frame mounted battery box. The support brackets for these battery boxes may crack causing the battery box to separate from the chassis.

Consequence: If the battery box detaches, it can become a road hazard, increasing the risk of a crash.

Remedy: Blue Bird will notify owners, and dealers will inspect and repair the buses, as necessary, free of charge. The recall began on March 20, 2017. Owners may contact Blue Bird customer service at 1-478-822-2242. Blue Bird's number for this recall is R17YY-SB.

Reported: 2017-02-15 (February 15, 2017) · Model years: 2015, 2016, 2017, 2018

Blue Bird Body Company (Blue Bird) is recalling certain 2015-2018 Vision transit buses equipped with frame mounted battery boxes. The support brackets for these battery boxes may crack causing the battery box to separate from the chassis.

Consequence: If the battery box detaches, it can become a road hazard, increasing the risk of a crash.

Remedy: Blue Bird will notify owners, and dealers will inspect and repair the buses, as necessary, free of charge. The recall began on March 20, 2017. Owners may contact Blue Bird customer service at 1-478-822-2242. Blue Bird's number for this recall is R17YY-NSB.

Reported: 2017-08-17 (August 17, 2017) · Model years: 2015, 2016, 2017, 2018, 2019

Blue Bird Body Company (Blue Bird) is recalling certain model year 2015-2019 Vision and model year 2016 All American school buses equipped with certain QS11 series convertible school bus seats supplied by CE White/HSM Solutions. The integral D-Ring mounting stud located in the upper area of the seat back frame does not provide an adequate padding surface between the seat occupant and the D-Ring mounting stud.

Consequence: In a rear crash event, the occupant's head may contact the D-Ring mounting stud, resulting in a head injury or even death.

Remedy: Blue Bird will notify owners, and dealers will equip the Integra D-Ring mounting studs with the proper padding, free of charge. The recall began on September 15, 2017. Owners may contact Blue Bird customer service at 1-478-822-2242. Blue Bird's number for this recall is R17ZB-SB.

Reported: 2019-02-11 (February 11, 2019) · Model years: 2015, 2016, 2017, 2018, 2019

Blue Bird Body Company (Blue Bird) is recalling certain 2015-2019 Vision and All American school buses equipped with Ricon S-Series Titanium Wheelchair lifts. The wheelchair lift positioning input cam may fail while the lift is in use, allowing the platform to travel higher than the vehicle's floor height. As such, this vehicle fails to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 403, "Platform Lift Systems."

Consequence: If the wheelchair lift platform raises above the height of the vehicle floor, the wheelchair user could fall inwards toward the vehicle, increasing their risk of injury.

Remedy: Blue Bird will notify owners, and Ricon dealers will replace the wheelchair lift positioning input cam, free of charge. The recall began March 4, 2019. Owners may contact Ricon customer service at 1-800-322-2884. Blue Bird's number for this recall is R19ZP-SB.

Reported: 2019-05-24 (May 24, 2019) · Model years: 2015, 2016, 2017, 2018, 2019

Blue Bird Body Company (Blue Bird) is recalling certain 2015-2020 Vision and All American school buses equipped with Bendix ADB22X air brakes. The driver side rear brakes may drag.

Consequence: A dragging brake may cause damage to the brake components, which may activate the ABS warning light. The warning light may cause the driver to immediately stop the vehicle and transfer occupants. Additionally, the high temperatures at the wheel end can increase the risk of a fire. Either condition increases the risk of injury.

Remedy: Blue Bird will notify owners, and dealers will install a new caliper with an updated clearance adjustment mechanism, free of charge. Blue Bird issued owners interim notification on July 18, 2019. The recall began August 28, 2019. Owners may contact Blue Bird customer service at 1-478-822-2242. Blue Bird's number for this recall is R19AA - SB.

Reported: 2015-05-12 (May 12, 2015) · Model years: 2016

Blue Bird Body Company (Blue Bird) is recalling certain model year 2016 Vision and All American rear engine school buses manufactured February 11, 2015, to April 2, 2015. The affected vehicles have seat bottoms whose foam core may not meet the flammability requirements of Federal Motor Vehicle Safety Standard (FMVSS) No. 302, "Flammability of Interior Materials."

Consequence: If the seats are built with this seat bottom foam core, the seats may not resist catching fire in the presence of an ignition source, increasing the risk that a fire may start or spread.

Remedy: Blue Bird will notify owners, and dealers will replace the school bus seat bottoms with foam that is compliant to the safety standard, free of charge. The recall began on June 9, 2015. Owners may contact Blue Bird customer service at 1-478-822-2242. Blue Bird's number for this recall is R15YD-SB.

Reported: 2015-09-23 (September 23, 2015) · Model years: 2016

Blue Bird Body Company (Blue Bird) is recalling certain model year 2016 Vision school buses manufactured on August 16, 2015. In the affected vehicles, the Engine Control Module (ECM) may short circuit, causing the engine to stall without warning.

Consequence: An engine that stalls without warning increases the risk of a crash.

Remedy: The affected buses have been corrected. Therefore, an owner notification letter will not be issued for this campaign. Owners may contact Blue Bird's customer service number at 1-478-822-2242. Blue Bird's recall number is R15YG-SB.

Reported: 2015-10-23 (October 23, 2015) · Model years: 2016, 2017

Blue Bird Body Company (Blue Bird) is recalling certain model year 2016-2017 Vision school buses manufactured September 3, 2015, to September 18, 2015. In the affected vehicles, the windshield wiper motor harness connector may have been installed incorrectly, causing the wiper system to stop without warning.

Consequence: An inoperative windshield wiper may reduce the driver's visibility during inclement weather, increasing the risk of a crash.

Remedy: Blue Bird will notify owners, and dealers will inspect and correct the wiper motor connection, free of charge. The recall began on November 18, 2015. Owners may contact Blue Bird customer service at 1-478-822-2242. Blue Bird's number for this recall is R15YH-SB.

Reported: 2015-10-23 (October 23, 2015) · Model years: 2016, 2017

Blue Bird Body Company (Blue Bird) is recalling one 2017 Vision transit bus. In the affected vehicle, the windshield wiper motor harness connector may have been installed incorrectly, causing the wiper system to stop without warning.

Consequence: Inoperative windshield wipers may decrease the driver's visibility during inclement weather, increasing the risk of a crash.

Remedy: Blue Bird will notify the owner, and a dealer will inspect and repair the wiper motor connection, free of charge. The recall began on November 18, 2015. Owners may contact Blue Bird customer service at 1-478-822-2242. Blue Bird's number for this recall is R15YH-NSB.

Reported: 2016-01-08 (January 8, 2016) · Model years: 2016, 2017

Blue Bird Body Company (Blue Bird) is recalling certain model year 2016-2017 All American school buses manufactured May 18, 2015, to November 9, 2015, and Vision school buses manufactured May 8, 2015, to October 27, 2015, equipped with certain Transpec T6000, T6100, and T7000 series school bus stop arms. The affected stop arms have a reflective decal that may peel loose from the stop arm. As such, these stop arms fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 131, "School Bus Pedestrian Safety Devices."

Consequence: Without a reflective decal, the stop arms would have reduced visibility to other drivers, increasing the risk of a crash.

Remedy: Blue Bird will notify owners, and dealers will replace the stop arm blade assembly, free of charge. The recall began on January 28, 2016. Owners may contact Blue Bird customer service at 1-478-822-2242 or the manufacturer of the stop arms at 1-800-951-7867. Blue Birds number for this recall is R16YK-SB.

Reported: 2016-06-06 (June 6, 2016) · Model years: 2016, 2017

Blue Bird Body Company (Blue Bird) is recalling certain model year 2015-2017 All American transit buses manufactured from November 13, 2014, through May 4, 2016, and 2016-2017 Vision transit buses manufactured from May 30, 2015, through February 2, 2016, equipped with Ricon S-Series (S2005 and S5510) wheelchair lifts. In the affected vehicles the platform side plate on the wheelchair lifts may crack. Additionally, the lifts are equipped with folding link arms that may have pivot holes that are too big, allowing the bearings to move out of position.

Consequence: If the platform side plates crack or the platform mounting fails from out-of-position bearings, the lift platform can separate from the lift and come to rest against the vehicle's lift door. When the vehicle's doors are opened, the platform may fall onto the lift operator, increasing their risk of injury.

Remedy: Blue Bird will notify owners, and Ricon dealers will inspect the link arms for damage or for displaced bearings. The platform will be inspected for cracks. Any damaged parts will be replaced, free of charge. The recall began on June 27, 2016. Owners may contact Blue Bird customer service at 1-478-822-2242 or Ricon Customer Service at 1-800-322-2884. The recall number for Blue Bird is R16YR-NSB.

Reported: 2016-07-19 (July 19, 2016) · Model years: 2016, 2017

Blue Bird Body Company (Blue Bird) is recalling certain model year 2016-2017 Vision transit buses manufactured September 24, 2015, to May 21, 2016, equipped with 6.8L Ford engines and Gen 3 propane units. The affected vehicles have propane fuel lines that may rub or are crossed and secured together, possibly resulting in line damage and a propane fuel leak.

Consequence: A propane leak In the presence of an ignition source may increase the risk of a fire.

Remedy: Blue Bird will notify owners, and dealers will inspect and reroute any Gen 3 propane lines that are not parallel. If damaged, the fuel line(s) will be replaced. These repairs will be performed free of charge. The recall began on August 15, 2016. Owners may contact Blue Bird customer service at 1-478-822-2242. Blue Bird's number for this recall is R16YT-NSB.

Reported: 2017-03-23 (March 23, 2017) · Model years: 2016

Blue Bird Body Company (Blue Bird) is recalling certain 2016 Vision and All American school buses, equipped with certain QS11, QSCR11, QSJ11, and Davenport school bus seats that include three-point lap/shoulder seat belts. These seats may have a loose or missing D-ring mounting nut, allowing the shoulder belt D-ring to detach in a crash.

Consequence: A loose or missing shoulder belt D-ring may prevent the seat belt from adequately restraining the seat occupant in the event of a crash, increasing their risk of injury.

Remedy: Blue Bird will notify owners, and personnel from the school bus seat manufacturer will inspect and repair the affected seats, free of charge. The recall began on April 12, 2017. Owners may contact Blue Bird Campaigns Administration at 1-478-822-2242. Blue Bird's number for this recall is R17YZ (SB).

Reported: 2018-12-12 (December 12, 2018) · Model years: 2016, 2017, 2018, 2019

Blue Bird Body Company (Blue Bird) is recalling certain 2016-2020 Blue Bird Vision transit buses equipped with the Ford 6.8L V10 engines. The hydraulic brake lines or transmission shifter cable may have been improperly routed, causing the brake line to be exposed to excessive heat, and leak hydraulic brake fluid. Additionally, the transmission shifter cable could contact the gasoline fuel supply line to the engine which may result in a fuel leak.

Consequence: A hydraulic brake fluid leak or a fuel line failure can increase the risk of a fire.

Remedy: Blue Bird will notify owners, and dealers will install a bracket which will insulate the brake lines from excessive heat, control routing of the brake lines, and secure the transmission shifter cable away from the fuel line, free of charge. The recall began February 7, 2019. Owners may contact Blue Bird customer service at 1-478-822-2242. Blue Bird's number for this recall is R19ZV-NSB.

Reported: 2019-05-24 (May 24, 2019) · Model years: 2016, 2017, 2018, 2019

Blue Bird Body Company (Blue Bird) is recalling certain 2016-2020 Vision and 2015-2020 All American non-school buses equipped with ADB22X disc brakes. The driver side rear brakes may drag.

Consequence: A dragging brake may cause damage to the brake components, which may activate the ABS warning light. The warning light may cause the driver to immediately stop the vehicle and transfer occupants. Additionally, the high temperatures at the wheel end can increasing the risk of a fire. Either condition increases the risk of injury.

Remedy: Blue Bird will notify owners, and dealers will install a new caliper with an updated clearance adjustment mechanism, free of charge. Blue Bird issued owners interim notification on July 18, 2019. The recall began August 28, 2019. Owners may contact Blue Bird customer service at 1-478-822-2242. Blue Bird's number for this recall is R19AA - NSB.

Reported: 2016-05-03 (May 3, 2016) · Model years: 2017

Blue Bird Body Company (Blue Bird) is recalling certain model year 2017 All American Forward Engine transit buses manufactured February 9, 2016, to February 19, 2016 and one Vision transit bus manufactured on February 1, 2016, equipped with Freedman Integrated Child Seats (ICS) Passenger Seats. These vehicles are equipped with seats that may separate from the base frame due to bolt failure. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 213, "Child Restraint Systems."

Consequence: In the event of a crash, the seat can separate from the base frame, increasing the risk of injury to the seat occupant.

Remedy: Blue Bird has notified owners, and dealers will replace the seats, free of charge. The recall began on May 23, 2016. Owners may contact Blue Bird customer service at 1-478-822-2242. Blue Bird's number for this recall is R16YP-NSB.

Reported: 2017-03-23 (March 23, 2017) · Model years: 2017, 2018

Blue Bird Body Company (Blue Bird) is recalling certain 2017-2018 Vision school buses, designed to run on propane. The fuel control valve solenoid may short circuit, shutting off the flow of propane to the engine, causing the engine to shut off.

Consequence: An engine stall while driving increases the risk of a crash.

Remedy: Blue Bird will notify owners, and dealers for Roush CleanTech, the supplier of the propane fuel kit, will replace the defective fuel control valve solenoids, free of charge. The recall began on April 21, 2017. Owners may contact Blue Bird at 1-478-822-2242. Blue Bird's number for recall is R17ZA (SB).

Reported: 2017-03-23 (March 23, 2017) · Model years: 2017, 2018

Blue Bird Body Company (Blue Bird) is recalling certain 2017-2018 Vision transit buses, designed to run on propane. The fuel control valve solenoid may short circuit, shutting off the flow of propane to the engine, causing the engine to shut off.

Consequence: An engine stall while driving increases the risk of a crash.

Remedy: Blue Bird will notify owners, and dealers for Roush CleanTech, the supplier of the propane fuel kit, will replace the defective fuel control valve solenoids, free of charge. The recall began on April 21, 2017. Owners may contact Blue Bird at 1-478-822-2242. Blue Bird's number for recall is R17ZA (NSB).

Reported: 2018-04-24 (April 24, 2018) · Model years: 2017, 2018

Blue Bird Body Company (Blue Bird) is recalling certain 2017-2018 Blue Bird Vision transit buses equipped with Gen4 Ford engines with an optional brake and throttle interlock. The brake and throttle interlock is supposed to apply the service brakes and prevent accelerator pedal input when activated, however the throttle input is not being blocked.

Consequence: If throttle input is allowed, the bus may be able to overpower the applied brake, causing the bus to move unexpectedly, increasing the risk of a crash or an injury.

Remedy: Blue Bird will notify owners, and dealers will update the Smart Relay Module software, free of charge. The recall began on May 24, 2018. Owners may contact Blue Bird customer service at 1-478-822-2242. Blue Bird's number for this recall is R18ZF - NSB.

Reported: 2018-04-24 (April 24, 2018) · Model years: 2017, 2018

Blue Bird Body Company (Blue Bird) is recalling certain 2017-2018 Blue Bird Vision school buses equipped with Gen4 Ford engines with an optional brake and throttle interlock. The brake and throttle interlock is supposed to apply the service brakes and prevent accelerator pedal input when activated, however the throttle input is not being blocked.

Consequence: If throttle input is allowed, the bus may be able to overpower the applied brake, causing the bus to move unexpectedly, increasing the risk of a crash or an injury.

Remedy: Blue Bird will notify owners, and dealers will update the Smart Relay Module software. The recall began on May 24, 2018. Owners may contact Blue Bird customer service at 1-478-822-2242. Blue Bird's number for this recall is R18ZF - SB.

Reported: 2018-11-06 (November 6, 2018) · Model years: 2017, 2018, 2019

Blue Bird Body Company (Blue Bird) is recalling certain 2017-2019 Vision school buses with Ford 6.8L Gen IV LPG, Gasoline, or CNG engines. The alternator cables may not be routed correctly and may contact and chafe against the air conditioning support bracket or a firewall reinforcement.

Consequence: A damaged alternator cable could cause result in an electrical short, increasing the risk of a fire.

Remedy: Blue Bird will notify owners, and dealers will verify that the air conditioning bracket and the alternator cables are properly installed, repairing them as necessary, free of charge. The recall is expected to begin December 06, 2018. Owners may contact Blue Bird customer service at 1-478-822-2242. Blue Birds recall number is R18ZO-SB.

Reported: 2018-12-17 (December 17, 2018) · Model years: 2017, 2018, 2019

Blue Bird Body Company (Blue Bird) is recalling certain 2017-2019 Vision school buses equipped with Cummins ISV5.0 diesel engines with optional CP80009 air compressors. The air compressor belt may slip, reducing air output, which may result in the parking brake automatically applying.

Consequence: If the parking brake applies while the vehicle is being driven, it can increase the risk of a crash.

Remedy: Blue Bird has notified owners, and dealers will replace the existing air compressor belt with a new shorter air compressor belt, free of charge. The recall began February 1, 2019. Owners may contact Blue Bird customer service at 1-478-822-2242. Blue Bird's number for this recall is R19ZW-SB.

Reported: 2022-08-04 (August 4, 2022) · Model years: 2017, 2018, 2019

Blue Bird Body Company (Blue Bird) is recalling certain 2017-2023 Blue Bird Vision school buses equipped with Roush fuel return lines included in GEN 4 and GEN 5 LPG Conversion Systems that were installed on vehicles sold or registered in Connecticut, Delaware, Illinois, Indiana, Iowa, Kentucky, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, Virginia, Washington D.C., West Virginia, and Wisconsin. The zinc-plating on the fuel return line may break away when contacted by road debris, causing two dissimilar metals on the fuel line to contact each other and corrode.

Consequence: A corroded fuel line can leak fuel, increasing the risk of a fire.

Remedy: Dealers will replace the fuel return lines, free of charge. Owner notification letters were mailed May 24, 2023. Owners may contact Blue Bird's customer service at 1-478-822-2242. Blue Bird's number for this recall is R22BX-SB.

Reported: 2018-04-25 (April 25, 2018) · Model years: 2018, 2019

Blue Bird Body Company (Blue Bird) is recalling certain 2018-2019 Blue Bird All American and Vision school buses. The primary and secondary air brake gauges on the instrument cluster may intermittently indicate "0 PSI" instead of the correct air pressure in the tanks. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 121, "Air Brake Systems."

Consequence: If the gauges do not correctly display the air pressure that is in the tanks, the operator will not be able to know when the air pressure is actually dropping, increasing the risk of a crash.

Remedy: Blue Bird will notify owners, and dealers will update the display software, free of charge. The recall began on August 1, 2018. Owners may contact Blue Bird customer service at 1-478-822-2242. Blue Bird's number for this recall is R18ZE-SB.

Reported: 2018-04-25 (April 25, 2018) · Model years: 2018, 2019

Blue Bird Body Company (Blue Bird) is recalling certain 2018-2019 Blue Bird All American and Vision transit buses. The primary and secondary air brake gauges on the instrument cluster may intermittently indicate "0 PSI" instead of the correct air pressure in the tanks. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 121, "Air Brake Systems."

Consequence: If the gauges do not correctly display the air pressure that is in the tanks, the operator will not be able to know when the air pressure is actually dropping, increasing the risk of a crash.

Remedy: Blue Bird will notify owners, and dealers will update the display software, free of charge. Owners may contact Blue Bird customer service at 1-478-822-2242. Blue Bird's number for this recall is R18ZE-NSB.

Reported: 2019-06-19 (June 19, 2019) · Model years: 2018, 2019

Blue Bird Body Company (Blue Bird) is recalling certain 2018-2019 Vision and All American school buses equipped with PowerDrive 7000 EV electric drivetrains. The Vehicle Control Unit (VCU) may unexpectedly shut down the high voltage contactors, resulting in loss of all systems powered by high voltage, including the traction drive system and power steering.

Consequence: An unexpected loss of drive and power steering may increase the risk of a crash.

Remedy: Cummins will notify Blue Bird owners and will update the VCU software with a revised version, free of charge. The recall began July 24, 2019. Owners may contact Cummins customer service at 1-800-286-6467 or Blue Bird at 1-478-822-2242. Blue Bird's number for this recall is R19AE (SB).

Reported: 2019-07-12 (July 12, 2019) · Model years: 2018, 2019

Blue Bird Body Company (Blue Bird) is recalling certain 2018-2020 Vision and All American school buses equipped with Specialty Manufacturing Prolo roof emergency exit hatches. Due to a manufacturing issue, the roof hatch external handle may unexpectedly break under reasonable use. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 217, "Bus Emergency Exits and Window Retention and Release."

Consequence: If the roof hatch external handle breaks, in the event of an emergency, the hatch cannot be easily opened from outside the vehicle, increasing the risk of injury.

Remedy: Blue Bird will notify owners, and Specialty dealers will replace the outer handle, free of charge. The recall began August 21, 2019. Owners may contact Blue Bird customer service at 1-478-822-2242. Blue Bird's number for this recall is R19AF - SB.

Reported: 2019-10-25 (October 25, 2019) · Model years: 2018, 2019

Blue Bird Body Company (Blue Bird) is recalling certain 2018-2019 Vision and All American school buses equipped with Cummins PowerDrive 7000 EV electric drivetrain units. Due to a software error, the VCU may activate the anti-roll back feature during slow moving or stop and go conditions, which can cause unexpected vehicle movement.

Consequence: Unexpected vehicle movement can increase the risk of a crash.

Remedy: Blue Bird has notified owners, and Cummins dealers will update the VCU software, free of charge. The recall began October 30, 2019. Owners may contact Cummins customer service at 1-800-286-6467 or Blue Bird customer service at 1-478-822-2242. Blue Bird's number for this recall is R19AJ-SB.

Reported: 2020-02-11 (February 11, 2020) · Model years: 2018, 2019

Blue Bird Body Company (Blue Bird) is recalling certain 2018-2019 Vision and All American school buses equipped with 7000 EV electric drivetrain units. A connector within the wire harnesses may become unplugged causing loss of communication between control modules, resulting in sudden loss of drive power and power steering.

Consequence: A sudden loss of drive power and loss of power steering increases the risk of a crash.

Remedy: Blue Bird will notify owners, and Cummins dealers will install a cable tie on the connector to maintain the connector locking tab in the locked position, free of charge. The recall began March 12, 2020. Owners may contact Blue Bird customer service at 1-478-822-2242 or Cummins customer service at 1-800-286-6467. Blue Bird's number for this recall is R20AL-SB.

Reported: 2020-05-05 (May 5, 2020) · Model years: 2018, 2019

Blue Bird Body Company (Blue Bird) is recalling certain 2018-2021 Vision school buses equipped with Ford 6.8L gasoline engines with an optional right-hand mounted parking brake lever. Due to improper routing of the parking brake cables, the parking brake cable may contact and chafe the gasoline fuel line, potentially causing a fuel leak.

Consequence: A fuel leak increases the risk of a fire.

Remedy: Blue Bird will notify owners, and dealers will inspect and secure the parking brake cable, as necessary, free of charge. The recall began May 28, 2020. Owners may contact Blue Bird customer service at 1-478-822-2242. Blue Bird's number for this recall is R20AQ-SB.

Reported: 2021-04-12 (April 12, 2021) · Model years: 2018, 2019

Blue Bird Body Company (Blue Bird) is recalling certain 2018-2021 Vision and All American school buses. The electric drive train cannot detect isolation faults when the high voltage contactors are closed.

Consequence: An undetected high voltage isolation can expose service personnel to high voltage, increasing the risk of injury.

Remedy: Blue Bird will notify owners, and dealers will update the Vehicle Control Unit software or install a different combination of High Voltage Power Distribution Unit hardware, free of charge. The recall began on May 22, 2021. Owners may contact Blue Bird customer service at 1-478-822-2242. Blue Bird's number for this recall is R21BD-SB.

Reported: 2021-04-28 (April 28, 2021) · Model years: 2018, 2019

Blue Bird Body Company (Blue Bird) is recalling certain 2018-2021 Vision and All American school buses. The drivetrain may experience an electromagnetic noise on the Control Area Network (CAN) bus, which may cause a loss of electrical power to the power steering pump.

Consequence: A loss of assisted power steering increases the risk of a crash.

Remedy: Cummins will replace the High Voltage Low Power Inverter Harness, and install an overlay harness, free of charge. Interim owner notification letters were mailed on May 22, 2021. Owner notification letters were mailed on October 25, 2021. Owners may contact Blue Bird customer service at 1-478-822-2242.

Reported: 2022-07-14 (July 14, 2022) · Model years: 2018, 2019

Blue Bird Body Company (Blue Bird) is recalling certain 2018-2022 All American and Vision school buses equipped with Cummins PD7000 Electric Drivetrains containing an electric air compressor. The air compressor housing is improperly grounded, causing electrical voltage greater than 50V AC during operation.

Consequence: An improperly grounded air compressor can cause electric shock, increasing the risk of injury.

Remedy: Dealers will install an electrical ground strap between the compressor motor housing and vehicle chassis, free of charge. Owner notification letters were mailed February 6, 2023. Owners may contact Blue Bird's customer service at 1-478-822-2242. Blue Bird's number for this recall is R22BY-SB.

Reported: 2022-08-04 (August 4, 2022) · Model years: 2018, 2019

Blue Bird Body Company (Blue Bird) is recalling certain 2018-2023 Blue Bird Vision transit buses equipped with Roush fuel return lines included in GEN 4 and GEN 5 LPG Conversion Systems that were installed on vehicles sold or registered in Connecticut, Delaware, Illinois, Indiana, Iowa, Kentucky, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, Virginia, Washington D.C., West Virginia, and Wisconsin. The zinc-plating on the fuel return line may break away when contacted by road debris, causing two dissimilar metals on the fuel line to contact each other and corrode.

Consequence: A corroded fuel line can leak fuel, increasing the risk of a fire.

Remedy: Dealers will replace the fuel return lines, free of charge. Owner notification letters were mailed May 24, 2023. Owners may contact Blue Bird's customer service at 1-478-822-2242. Blue Bird's number for this recall is R22BX-NSB.

Reported: 2023-04-18 (April 18, 2023) · Model years: 2018, 2019

Blue Bird Body Company (Blue Bird) is recalling certain 2018-2021 All American and Vision School Buses, equipped with PowerDrive 7000 electric drive systems. The System Control Module (SCM) may activate the anti-rollback feature, causing the vehicle to reverse faster than expected when the vehicle is in reverse and pointing downhill with the brake pedal not applied.

Consequence: A vehicle reversing faster than expected can increase the risk of a crash.

Remedy: Dealers will update the SCM software calibration, free of charge. Owner notification letters were mailed May 10, 2023. Owners may contact Blue Bird customer service at 1-478-822-2242. Blue Bird's number for this recall is R23CG (SB)

Reported: 2024-08-12 (August 12, 2024) · Model years: 2018, 2019

Blue Bird Bus Company (Blue Bird) is recalling certain 2018-2021 Vision school buses equipped with 6.8L gasoline engines. The coating on the fuel lines may have been improperly applied, which can result in a fuel leak.

Consequence: A fuel leak in the presence of an ignition source increases the risk of a fire.

Remedy: Dealers will inspect and replace the fuel lines as necessary, free of charge. Owner notification letters were mailed October 10, 2024. Owners may contact Blue Bird customer service at 1-478-822-2242.

Reported: 2024-08-12 (August 12, 2024) · Model years: 2018, 2019

Blue Bird Bus Company (Blue Bird) is recalling certain 2018-2021 Vision transit buses equipped with 6.8L gasoline engines. The coating on the fuel lines may have been improperly applied, which can result in a fuel leak.

Consequence: A fuel leak in the presence of an ignition source increases the risk of a fire.

Remedy: Dealers will inspect and replace the fuel lines as necessary, free of charge. Owner notification letters were mailed October 10, 2024. Owners may contact Blue Bird customer service at 1-478-822-2242.

Reported: 2018-08-28 (August 28, 2018) · Model years: 2019

Blue Bird Body Company (Blue Bird) is recalling certain 2019 Blue Bird All American and 2019-2020 Blue Bird Vision school buses, equipped with certain NextGen School Bus seats with Integrated Child Restraint Systems. These seats may be missing a warning label on the lower restraint strap. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 213, "Child Restraint Systems."

Consequence: Without a warning label, the seat may be used improperly, increasing the risk of injury.

Remedy: Blue Bird will notify owners, and dealers will install a warning label to the lower restraint strap portion of the Restraint Belt System, free of charge. The recall began September 26, 2018. Owners may contact Blue Bird customer service at 1-478-822-2242. Blue Bird's number for this recall is R18ZN-SB.

Reported: 2018-11-28 (November 28, 2018) · Model years: 2019

Blue Bird Body Company (Blue Bird) is recalling certain 2020 Blue Bird All American and 2019-2020 Blue Bird Vision school buses, equipped with certain HSM NextGen 45" 3PT school bus seats, part number GenQ3-45 LH. There may be an insufficient number of bolts attaching the seat to the bus floor, allowing the seat to detach from the bus floor in the event of a crash. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 210, "Seat Belt Assembly Anchorages."

Consequence: In the event of a crash, if the bus seat detaches from the floor, it can increase the risk of injury.

Remedy: Blue Bird will notify owners, and dealers will install a secondary floor mounting brace, free of charge. The recall began December 12, 2018. Owners may contact Blue Bird customer service at 1-478-822-2242. Blue Bird's number for this recall is R18ZT-SB.

Reported: 2018-12-11 (December 11, 2018) · Model years: 2019

Blue Bird Body Company (Blue Bird) is recalling certain 2019 Blue Bird All American and Vision school buses. The parking brake cable may disengage from the foot pedal assembly, possibly allowing the bus to unintentionally move. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 105, "Hydraulic and Electric Brake Systems."

Consequence: Unintended movement can increase the risk of a crash.

Remedy: Blue Bird will notify owners and dealers will install a clevis cable retention clip and cable-end return spring, free of charge. The recall began February 6, 2019. Owners may contact Blue Bird customer service at 1-478-822-2242. Blue Bird's number for this recall is R19ZU-SB.

Reported: 2018-12-11 (December 11, 2018) · Model years: 2019

Blue Bird Body Company (Blue Bird) is recalling certain 2019 Blue Bird All American and Vision transit buses. The parking brake cable may disengage from the foot pedal assembly, possibly allowing the bus to unintentionally move. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 105, "Hydraulic and Electric Brake Systems."

Consequence: Unintended movement can increase the risk of a crash.

Remedy: Blue Bird will notify owners and dealers will install a clevis cable retention clip and cable-end return spring, free of charge. The recall began February 6, 2019. Owners may contact Blue Bird customer service at 1-478-822-2242. Blue Bird's number for this recall is R19ZU-NSB.

Reported: 2019-02-11 (February 11, 2019) · Model years: 2019

Blue Bird Body Company (Blue Bird) is recalling one 2019 Blue Bird Vision bus equipped with a Ricon S-Series Titanium Wheelchair lift. The wheelchair lift positioning input cam may fail while the lift is in use, allowing the platform to travel higher than the vehicle's floor height. As such, this vehicle fails to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 403, "Platform Lift Systems."

Consequence: If the wheelchair lift platform raises above the height of the vehicle floor, the wheelchair user could fall inwards toward the vehicle, increasing their risk of injury.

Remedy: Blue Bird has notified the owner and Ricon will replace the wheelchair lift positioning input cam, free of charge. The recall began March 4, 2019. Owners may contact Blue Bird customer service at 1-478-822-2242. Blue Bird's number for this recall is R19ZP-NSB.

Reported: 2019-10-04 (October 4, 2019) · Model years: 2019

Blue Bird Body Company (Blue Bird) is recalling certain 2019-2021 All American and Vision school buses. An insufficient number of rivets were installed in the roof sheets, allowing the roof sheets to separate in the event of a severe impact. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 221, "School Bus Body Joint Strength."

Consequence: In the event of a crash, if the roof sheets separate, there is an increased risk of injury.

Remedy: Blue Bird will notify owners, and dealers will inspect the roof joints and add the sufficient number of rivets, as necessary, free of charge. The recall began October 22, 2019. Owners may contact Blue Bird customer service at 1-478-822-2242. Blue Bird's number for this recall is R19AH.

Reported: 2020-06-15 (June 15, 2020) · Model years: 2019

Blue Bird Body Company (Blue Bird) is recalling certain 2019-2021 Blue Bird Vision school buses powered by Compressed Natural Gas (CNG) or Liquefied Petroleum Gas (LPG). The castle nuts used to connect the steering drag link to the steering arm may have not been correctly tightened, potentially causing separation of the drag link.

Consequence: If the drag link separates, loss of steering control my occur, increasing the risk of a crash.

Remedy: Blue Bird will notify owners, and will inspect the drag link assembly connection points, tightening them as necessary, free of charge. This recall began July 27, 2020. Owners may contact Blue Bird customer service at 1-478-822-2242. Blue Bird's number for this recall is R20AW-SB.

Reported: 2020-07-15 (July 15, 2020) · Model years: 2019

Blue Bird Body Company (Blue Bird) is recalling certain 2019-2021 Vision and All-American transit buses. The three-point seatbelt assembly may have been installed without reinforcing washers under the floor at the anchorage point, possibly preventing the assembly from remaining anchored in the event of a crash. As such, these vehicles fail to comply with Federal Motor Vehicle Safety Standard number 210, "Seat Belt Assembly Anchorages."

Consequence: In the event of a crash, seat belt anchorages that do not remain secured increase the risk of injury to those seat occupants.

Remedy: Blue Bird will notify owners, and dealers will inspect the seat belt anchorage point hardware and install any missing hardware as needed, free of charge. The recall began August 11, 2020. Owners may contact Blue Bird customer service at 1-478-822-2242. Blue Bird's number for this recall is R20AX-NSB.

Reported: 2020-07-15 (July 15, 2020) · Model years: 2019

Blue Bird Body Company (Blue Bird) is recalling certain 2018-2021 All-American and 2019-2021 Vision school buses. The three-point seatbelt assembly may have been installed without reinforcing washers under the floor at the anchorage point, possibly preventing the assembly from remaining anchored in the event of a crash. As such, these vehicles fail to comply with Federal Motor Vehicle Safety Standard number 210, "Seat Belt Assembly Anchorages."

Consequence: In the event of a crash, seat belt anchorages that do not remain secured increase the risk of injury to those seat occupants.

Remedy: Blue Bird will notify owners, and dealers will inspect the seat belt anchorage point hardware and install any missing hardware as needed, free of charge. This recall began August 11, 2020. Owners may contact Blue Bird customer service at 1-478-822-2242. Blue Bird's number for this recall is R20AX.

Reported: 2021-02-12 (February 12, 2021) · Model years: 2019

Blue Bird Body Company (Blue Bird) is recalling certain 2020-2022 Vision and All American buses. The seats with integrated 3-point seat belts may have been installed incorrectly. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 210, "Seat Belt Assembly Anchorages."

Consequence: An incorrectly installed seat can increase the risk of injury in the event of a crash.

Remedy: Blue Bird will notify owners, and dealers will inspect the seats and install any missing hardware, as necessary, free of charge. The recall is expected to begin April 9, 2021. Owner notification letters were mailed February 03, 2022. Owners may contact Blue Bird customer service at 1-478-822-2242. Blue Bird's number for this recall is R21BB-SB.

Reported: 2024-07-19 (July 19, 2024) · Model years: 2019

Blue Bird Bus Company (Blue Bird) is recalling certain 2019-2023 Vision, All American Front Engine, and All American Rear Engine school buses. An exterior roof joint may have been manufactured with insufficient strength that can allow the roof panels to separate in a crash. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 221, "School Bus Body Joint Strength."

Consequence: Roof panels that separate during a crash can increase the risk of injury.

Remedy: Dealers will inspect the roof panel joints and install additional rivets as necessary, free of charge. Owner notification letters were mailed September 17, 2024. Owners may contact Blue Bird customer service at 1-478-822-2242.

Reported: 2024-10-11 (October 11, 2024) · Model years: 2019

Blue Bird Body Company (Blue Bird) is recalling certain 2019-2024 Vision and All American school buses. The emergency exit label operating instructions lettering is too small and may be difficult to read. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 217, "Bus Emergency Exits and Window Retention and Release."

Consequence: An emergency exit label that is difficult to read can prevent or delay the use of the emergency exit, increasing the risk of injury.

Remedy: Dealers will replace the emergency exit label, free of charge. Owner notification letters were mailed December 9, 2024. Owners may contact Blue Bird Customer Service at 478-822-2242. Blue Bird's number for this recall is R23CK (SB).