Alfa Romeo STELVIO fuel problems
33 complaint narratives mention fuel terms.
Key facts
205 owner complaints analyzed
18 distinct recall campaigns
44,500 mi median reported failure mileage
Scope: 2018 to 2025 model years. Data snapshot: . 70 complaints include usable failure mileage.
Fuel system concerns evidence
33 of 205 complaints match this topic (16.1%). The keyword filter can include complaints that mention a transmission without reporting its failure. View matching rules.
Owner report 11131138 · 2018-09-25 (September 25, 2018)
AFTER FUELING UP THE FUEL TANK, THE VEHICLE WAS DRIVEN ON THE HIGHWAY AND SMOKE BEGAN TO EMIT OUT FROM THE VEHICLE'S HOOD. THE DRIVER WAS NOT ALERTED THERE WAS ANY ISSUE FROM THE VEHICLE'S DASHBOARD INDICATOR/WARNING LIGHTS. THE DRIVER PULLED OVER ON THE HIGHWAY SHOULDER AND THE VEHICLE WAS ON FIRE UNTIL THE FIRE/POLICE DEPARTMENT ARRIVED ON SCENE. *DT UPDATED 10/22/18*JB
Owner-reported narrative. 150 miles reported. Look up ODI 11131138 at NHTSA ↗
Owner report 11566380 · 2024-01-18 (January 18, 2024)
While I was driving the car suddenly stopped sending gas when pressing the gas pedal and put the can a neutral mode. This was the second time this happened. Luckily the first time I was in my neighborhood going slow. The second time was in the middle of the night pitch black on a busy road. I was stranding the middle of the road and almost got hit. I was so fortunate a cop was driving by an helped. This has been extremely unsettling as I have a 1 year old. Luckily he was in the car but I can’t imagine if I was driving with him on a highway. The…
Owner-reported narrative. Look up ODI 11566380 at NHTSA ↗
Owner report 11596454 · 2024-06-25 (June 25, 2024)
The contact owns a 2018 Alfa Romeo Stelvio. The contact stated while driving 30 MPH, the vehicle stalled and hesitated to restart. The check engine warning light was illuminated. The contact stated that after a while the vehicle restarted but drove with reduced motive power. The battery was replaced but the failure persisted. The contact scanned the vehicle with an OBD II scanner and determined that the fuel pump had failed. The local dealer was not contacted. The vehicle was not repaired. The manufacturer was made aware of the failure. The fai…
Owner-reported narrative. 60,000 miles reported. Look up ODI 11596454 at NHTSA ↗
Owner report 11615884 · 2024-09-23 (September 23, 2024)
The engine has shut down in traffic on the following occasions: 1) July 2023 in The Woodlands, Texas. 2) Later that same day on [XXX] in Plantersville, Texas. 3) In August 2024, on [XXX] and 4) on [XXX] . My vehicle is available to the NHTSA upon request. On each occasion, except one, I was fortunate to be in the right hand lane and was able to pull over onto the shoulder before any could hit me. On [XXX] , near Richards, there was no shoulder and I was stopped within the single lane of westbound traffic. I was fortunate that traffic …
Owner-reported narrative. Look up ODI 11615884 at NHTSA ↗
Owner report 11672398 · 2025-07-10 (July 10, 2025)
The contact owns a 2018 Alfa Romeo Stelvio. The contact stated that while driving at an undisclosed speed, the vehicle lost motive power. The message "Electronic Acceleration Control Disabled" was displayed. The contact pulled over and waited a while before restarting the vehicle. The vehicle was taken to the dealer, where it was determined that the low-pressure fuel pump had failed. The contact was informed that the low-pressure fuel pump and module needed to be replaced. The vehicle was not yet repaired and remained with the dealer. The manuf…
Owner-reported narrative. 13,500 miles reported. Look up ODI 11672398 at NHTSA ↗